Dodge Journey - 2018 Fuse Box Diagram

Dodge Journey - 2018 Fuse Box Diagram

A second 12 Volt (13 Amp) power outlet is located inside
the center console storage area. Power is available with the
ignition is in the ON/RUN, ACC or LOCK position.
A third fused 12 Volt power outlet is located on the back of
the center console. This power outlet has power available
when the ignition is in the LOCK, ON or ACC position.
Center Console 12 Volt Power Outlet
Rear Seat 12 Volt Power Outlet
3
GETTING TO KNOW YOUR VEHICLE
127
A fourth fused 12 Volt power outlet is located on the left
quarter trim panel in the cargo area. This power outlet has
power available when the ignition is in the ON or ACC
position.
NOTE:
To ensure proper operation a Mopar knob and
element must be used.
CAUTION!
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system will
need to be replaced.
The power outlet on the bottom of the center console
shares the fuse with the power outlet on the back of
the console. The combined usage must not exceed
160 Watts (13 Amps) at 12 Volts.
Power outlets are designed for accessory plugs only.
Do not insert any other object in the power outlets as
this
will
damage
the
outlet
and
blow
the
fuse.
Improper use of the power outlet can cause damage
not covered by your New Vehicle Limited Warranty.
Rear Cargo Area Power Outlet
128
GETTING TO KNOW YOUR VEHICLE
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of outlet
should be inserted into any 12 Volt outlet.
Do not touch with wet hands.
(Continued)
WARNING!
(Continued)
Close the lid when not in use and while driving the
vehicle.
If this outlet is mishandled, it may cause an electric
shock and failure.
CAUTION!
Many accessories that can be plugged in draw power
from the vehicle’s battery, even when not in use (i.e.,
cellular phones, etc.). Eventually, if plugged in long
enough, the vehicle’s battery will discharge suffi-
ciently to degrade battery life and/or prevent the
engine from starting.
Accessories that draw higher power (i.e., coolers,
vacuum cleaners, lights, etc.) will degrade the battery
even more quickly. Only use these intermittently and
with greater caution.
After the use of high power draw accessories, or long
periods of the vehicle not being started (with acces-
sories still plugged in), the vehicle must be driven a
sufficient length of time to allow the alternator to
recharge the vehicle’s battery.
(Continued)
Power Outlet Fuses
1 — F103 20 A Yellow Power Outlet Console Bin And Power Outlet
Console Rear
2 — F102 20 A Yellow Cigar Lighter Instrument Panel And Power
Outlet Left Rear Cargo Area
3
GETTING TO KNOW YOUR VEHICLE
129
Cold Weather Operation (Below –22°F Or -30°C)
To ensure reliable starting at these temperatures, use of an
externally powered electric engine block heater (available
from your authorized dealer) is recommended.
If Engine Fails To Start
WARNING!
Never pour fuel or other flammable liquid into the
throttle body air inlet opening in an attempt to start
the vehicle. This could result in flash fire causing
serious personal injury.
Do not attempt to push or tow your vehicle to get it
started. Vehicles equipped with an automatic trans-
mission cannot be started this way. Unburned fuel
could enter the catalytic converter and once the
engine has started, ignite and damage the converter
and vehicle.
If the vehicle has a discharged battery, booster cables
may be used to obtain a start from a booster battery
or the battery in another vehicle. This type of start
can
be
dangerous
if
done
improperly.
Refer
to
“Jump-Starting Procedure” in “In Case Of Emer-
gency” for further information.
After Starting
The idle speed is controlled automatically, and it will
decrease as the engine warms up.
ENGINE BLOCK HEATER — IF EQUIPPED
The engine block heater warms the engine, and permits
quicker starts in cold weather. Connect the cord to a
standard 110-115 Volt AC electrical outlet with a grounded,
three-wire extension cord.
The engine block heater must be plugged in at least one
hour to have an adequate effect on the engine.
The engine block heater cord is bundled under the hood
between the headlight assembly and the Totally Integrated
Power Module (Fuse Box) on the driver’s side of the
vehicle.
WARNING!
Remember to disconnect the engine block heater cord
before driving. Damage to the 110-115 Volt electrical
cord could cause electrocution.
236
STARTING AND OPERATING
2. Insert a small flat-blade tool between the end of the lens
with the locking tab and the surrounding housing and
then pivot the tool to separate the lens from the housing.
3. Hold the lens with one hand and rotate the bulb’s
electrical connector ¼ turn counterclockwise with the
other hand and then separate the bulb and connector
assembly from the lens.
4. Remove the bulb from the connector socket and install
the replacement bulb.
5. Install the bulb and connector assembly into the lens
and rotate the connector ¼ turn clockwise to lock it in
place.
6. Insert the end of the lens without the locking tab into the
housing on the liftgate and then push the opposite end
of the lens into the housing, making sure it locks in the
housing.
FUSES
WARNING!
When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as
the original fuse. Never replace a fuse with another
fuse of higher amp rating. Never replace a blown
fuse with metal wires or any other material. Do not
place a fuse inside a circuit breaker cavity or vice
versa. Failure to use proper fuses may result in
serious personal injury, fire and/or property damage.
Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine
system,
transmission
system)
or
steering
system blows, contact an authorized dealer.
7
IN CASE OF EMERGENCY
285
Interior Fuses
The interior fuse panel is located on the passenger side
under the instrument panel.
Cavity
Cartridge Fuse
Mini-Fuse
Description
F100
30 Amp Pink
110V AC Inverter – If Equipped
F101
10 Amp Red
Interior Lights
F102
20 Amp Yellow
Cigar Lighter in Instrument Panel/Left Rear
Power Outlet
F103
20 Amp Yellow
Power Outlet in Console Bin/Power Outlet
in Rear of Console
F105
20 Amp Yellow
Heated Seats – If Equipped
F106
20 Amp Yellow
Rear Power Outlet
F107
10 Amp Red
Rear Camera – If Equipped
F108
15 Amp Blue
Instrument Panel
F109
10 Amp Red
Climate Control/HVAC
F110
10 Amp Red
Occupant Restraint Controller
F112
10 Amp Red
Spare
F114
20 Amp Yellow
Rear HVAC Blower/Motor
F115
20 Amp Yellow
Rear Wiper Motor
F116
30 Amp Pink
Rear Defroster (EBL)
286
IN CASE OF EMERGENCY
Cavity
Cartridge Fuse
Mini-Fuse
Description
F117
10 Amp Red
Heated Mirrors
F118
10 Amp Red
Occupant Restraint Controller
F119
10 Amp Red
Steering Column Control Module
F120
10 Amp Red
All Wheel Drive – If Equipped
F121
15 Amp Blue
Wireless Ignition Node
F122
25 Amp Clear
Driver Door Module
F123
25 Amp Clear
Passenger Door Module
F124
10 Amp Red
Mirrors
F125
10 Amp Red
Steering Column Control Module
F126
25 Amp Clear
Audio Amplifier
F127
20 Amp Yellow
Trailer Tow – If Equipped
F128
15 Amp Blue
Radio
F129
15 Amp Blue
Video/DVD – If Equipped
F130
15 Amp Blue
Climate Control/Instrument Panel
F131
10 Amp Red
Passenger Assistance/Hands Free System –
If Equipped
F132
10 Amp Red
Tire Pressure Module
F133
10 Amp Red
Cyber Security Gateway
7
IN CASE OF EMERGENCY
287
Underhood Fuses (Power Distribution Center)
The power distribution center is located in the engine
compartment.
Cavity
Cartridge Fuse
Mini-Fuse
Description
F101
60 Amp Yellow
Interior Power Distribution Center Rail
F102
60 Amp Yellow
Interior Power Distribution Center Rail
F103
60 Amp Yellow
Interior Power Distribution Center Rail
F105
60 Amp Yellow
Interior Power Distribution Center Rail Igni-
tion Run Relay
Power Distribution Center
288
IN CASE OF EMERGENCY
Cavity
Cartridge Fuse
Mini-Fuse
Description
F106
60 Amp Yellow
Interior Power Distribution Center Rail Run/
Accessory Relays
F139
40 Amp Green
Climate Control System Blower
F140
30 Amp Pink
Power Locks
F141
40 Amp Green
Anti-Lock Brake System
F142
40 Amp Green
Glow Plugs – If Equipped
F143
40 Amp Green
Exterior Lights 1
F144
40 Amp Green
Exterior Lights 2
F145
30 Amp Pink
To Body Computer – Lamp
F146
30 Amp Pink
Spare
F147
30 Amp Pink
Spare
F148
40 Amp Green
Radiator Fan Motor
F149
30 Amp Pink
Starter Solenoid
F150
25 Amp Clear
Powertrain Control Modules
F151
30 Amp Pink
Headlamp Washer Motor – If Equipped
F152
25 Amp Clear
Diesel Fuel Heater – If Equipped
F153
20 Amp Yellow
Fuel Pump
F156
10 Amp Red
Brake/Electronic Stability Control Module
F157
10 Amp Red
Power Transfer Unit Module – If Equipped
F158
10 Amp Red
Active Hood Module – If Equipped
7
IN CASE OF EMERGENCY
289
Cavity
Cartridge Fuse
Mini-Fuse
Description
F159
10 Amp Red
Spare
F160
20 Amp Yellow
Interior Lights
F161
20 Amp Yellow
Horn
F162
40 Amp Red/20
Amp Lt. Blue
Cabin Heater #1/Vacuum Pump – If
Equipped
F163
50 Amp Red
Cabin Heater #2 – If Equipped
F164
25 Amp Clear
Powertrain Auto Shutdown
F165
20 Amp Yellow
Powertrain Shutdown
F166
20 Amp Yellow
Spare
F167
30 Amp Green
Powertrain Shutdown
F168
10 Amp Red
Air Conditioner Clutch
F169
40 Amp Green
Emissions – Partial Zero Emissions Vehicle
Motor
F170
15 Amp Blue
Emissions – Partial Zero Emissions Vehicle
Actuators
F172
20 Amp Yellow
Spare
F173
25 Amp Clear
Anti Lock Brake Valves
F174
20 Amp Yellow
Siren – If Equipped
F175
30 Amp Green
Spare
F176
10 Amp Red
Powertrain Control Modules
290
IN CASE OF EMERGENCY
Cavity
Cartridge Fuse
Mini-Fuse
Description
F177
20 Amp Yellow
All Wheel Drive Module – If Equipped
F178
25 Amp Clear
Sunroof – If Equipped
F179
10 Amp Red
Battery Sensor
F181
100 Amp Blue
Electrohydraulic Steering (EHPS) – If
Equipped
F182
50 Amp Red
Cabin Heater #3 – If Equipped
F184
30 Amp Pink
Front Wiper Motor
JACKING AND TIRE CHANGING
WARNING!
Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel.
Being under a jacked-up vehicle is dangerous. The
vehicle could slip off the jack and fall on you. You
could be crushed. Never put any part of your body
(Continued)
WARNING!
(Continued)
under a vehicle that is on a jack. If you need to get
under a raised vehicle, take it to a service center
where it can be raised on a lift.
Never start or run the engine while the vehicle is on
a jack.
The jack is designed to be used as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes. The vehicle should be
jacked on a firm level surface only. Avoid ice or
slippery areas.
7
IN CASE OF EMERGENCY
291
ENGINE COMPARTMENT
2.4L Engine
1 — Engine Coolant Reservoir
7 — Power Distribution Center (Fuses)
2 — Power Steering Fluid Reservoir
8 — Air Cleaner Filter
3 — Engine Oil Fill
9 — Automatic Transmission Dipstick (4–Speed Only – If Equipped)
4 — Brake Fluid Reservoir
10 — Washer Fluid Reservoir
5 — Remote Jump Start (Positive Battery Post)
11 — Coolant Pressure Cap
6 — Remote Jump Start (Negative Battery Post)
12 — Engine Oil Dipstick
318
SERVICING AND MAINTENANCE
3.6L Engine
1 — Engine Coolant Reservoir Pressure Cap
7 — Power Distribution Center (Fuses)
2 — Power Steering Fluid Reservoir
8 — Air Cleaner Filter
3 — Oil Filter Access
9 — Washer Fluid Reservoir
4 — Brake Fluid Reservoir
10 — Engine Oil Dipstick
5 — Remote Jump Start (Positive Battery Post)
11 — Engine Oil Fill
6 — Remote Jump Start (Negative Battery Post)
12 — Engine Coolant Reservoir
8
SERVICING AND MAINTENANCE
319
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect
the
accuracy
or
operation
of
the
compass
on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
This power outlet will also operate a conven-
tional cigar lighter unit.
To preserve the heating
element, do not hold the lighter in the heating
position.
A second 12 Volt (13 Amp) power outlet is
located inside the center console storage area.
Power is available with the ignition is in the
ON/RUN, ACC or LOCK position.
A third fused 12 Volt power outlet is located on
the back of the center console. This power
outlet has power available when the ignition is
in the LOCK, ON or ACC position.
A fourth fused 12 Volt power outlet is located on
the left quarter trim panel in the cargo area. This
power outlet has power available when the igni-
tion is in the ON or ACC position.
NOTE:
To ensure proper operation a Mopar knob and
element must be used.
CAUTION!
• Do not exceed the maximum power of
160 Watts (13 Amps) at 12 Volts. If the
160 Watt (13 Amp) power rating is ex-
ceeded the fuse protecting the system will
need to be replaced.
• The power outlet on the bottom of the
center console shares the fuse with the
power outlet on the back of the console.
The combined usage must not exceed
160 Watts (13 Amps) at 12 Volts.
• Power outlets are designed for accessory
plugs only. Do not insert any other object in
the power outlets as this will damage the
outlet and blow the fuse. Improper use of
the power outlet can cause damage not
covered by your New Vehicle Limited War-
ranty.
Center Console 12 Volt Power Outlet
Rear Seat 12 Volt Power Outlet
Rear Cargo Area Power Outlet
GETTING TO KNOW YOUR VEHICLE
48
Power Outlet Fuses
1 — F103 20 Amp Yellow — Power Outlet Console Bin And Power Outlet Console Rear
2 — F102 20 Amp Yellow — Cigar Lighter Instrument Panel And Power Outlet Left Rear Cargo Area
49
FUSES
WARNING!
• When replacing a blown fuse, always use
an appropriate replacement fuse with the
same amp rating as the original fuse.
Never replace a fuse with another fuse of
higher amp rating. Never replace a blown
fuse with metal wires or any other material.
WARNING!
Do not place a fuse inside a circuit breaker
cavity or vice versa. Failure to use proper
fuses may result in serious personal injury,
fire and/or property damage.
• Before replacing a fuse, make sure that the
ignition is off and that all the other services
are switched off and/or disengaged.
WARNING!
• If the replaced fuse blows again, contact
an authorized dealer.
• If a general protection fuse for safety sys-
tems (air bag system, braking system),
power unit systems (engine system, trans-
mission system) or steering system blows,
contact an authorized dealer.
Interior Fuses
The interior fuse panel is located on the passenger side under the instrument panel.
Cavity
Cartridge Fuse
Mini-Fuse
Description
F100
30 Amp Pink
110V AC Inverter – If Equipped
F101
10 Amp Red
Interior Lights
F102
20 Amp Yellow
Cigar Lighter in Instrument Panel/Left Rear Power Outlet
F103
20 Amp Yellow
Power Outlet in Console Bin/Power Outlet in Rear of Console
F105
20 Amp Yellow
Heated Seats – If Equipped
F106
20 Amp Yellow
Rear Power Outlet
F107
10 Amp Red
Rear Camera – If Equipped
F108
15 Amp Blue
Instrument Panel
F109
10 Amp Red
Climate Control/HVAC
F110
10 Amp Red
Occupant Restraint Controller
IN CASE OF EMERGENCY
126
Cavity
Cartridge Fuse
Mini-Fuse
Description
F112
10 Amp Red
Spare
F114
20 Amp Yellow
Rear HVAC Blower/Motor
F115
20 Amp Yellow
Rear Wiper Motor
F116
30 Amp Pink
Rear Defroster (EBL)
F117
10 Amp Red
Heated Mirrors
F118
10 Amp Red
Occupant Restraint Controller
F119
10 Amp Red
Steering Column Control Module
F120
10 Amp Red
All Wheel Drive – If Equipped
F121
15 Amp Blue
Wireless Ignition Node
F122
25 Amp Clear
Driver Door Module
F123
25 Amp Clear
Passenger Door Module
F124
10 Amp Red
Mirrors
F125
10 Amp Red
Steering Column Control Module
F126
25 Amp Clear
Audio Amplifier
F127
20 Amp Yellow
Trailer Tow – If Equipped
F128
15 Amp Blue
Radio
F129
15 Amp Blue
Video/DVD – If Equipped
F130
15 Amp Blue
Climate Control/Instrument Panel
F131
10 Amp Red
Passenger Assistance/Hands Free System – If Equipped
F132
10 Amp Red
Tire Pressure Module
F133
10 Amp Red
Cyber Security Gateway
127
Underhood Fuses (Power Distribution Center)
The power distribution center is located in the engine compartment.
Cavity
Cartridge Fuse
Mini-Fuse
Description
F101
60 Amp Yellow
Interior Power Distribution Center Rail
F102
60 Amp Yellow
Interior Power Distribution Center Rail
F103
60 Amp Yellow
Interior Power Distribution Center Rail
F105
60 Amp Yellow
Interior Power Distribution Center Rail Ignition Run Relay
F106
60 Amp Yellow
Interior Power Distribution Center Rail Run/Accessory Re-
lays
F139
40 Amp Green
Climate Control System Blower
F140
30 Amp Pink
Power Locks
F141
40 Amp Green
Anti-Lock Brake System
F142
40 Amp Green
Glow Plugs – If Equipped
F143
40 Amp Green
Exterior Lights 1
F144
40 Amp Green
Exterior Lights 2
F145
30 Amp Pink
To Body Computer – Lamp
F146
30 Amp Pink
Spare
F147
30 Amp Pink
Spare
F148
40 Amp Green
Radiator Fan Motor
F149
30 Amp Pink
Starter Solenoid
F150
25 Amp Clear
Powertrain Control Modules
F151
30 Amp Pink
Headlamp Washer Motor – If Equipped
F152
25 Amp Clear
Diesel Fuel Heater – If Equipped
F153
20 Amp Yellow
Fuel Pump
IN CASE OF EMERGENCY
128
Cavity
Cartridge Fuse
Mini-Fuse
Description
F156
10 Amp Red
Brake/Electronic Stability Control Module
F157
10 Amp Red
Power Transfer Unit Module – If Equipped
F158
10 Amp Red
Active Hood Module – If Equipped
F159
10 Amp Red
Spare
F160
20 Amp Yellow
Interior Lights
F161
20 Amp Yellow
Horn
F162
40 Amp Red/20 Amp Lt.
Blue
Cabin Heater #1/Vacuum Pump – If Equipped
F163
50 Amp Red
Cabin Heater #2 – If Equipped
F164
25 Amp Clear
Powertrain Auto Shutdown
F165
20 Amp Yellow
Powertrain Shutdown
F166
20 Amp Yellow
Spare
F167
30 Amp Green
Powertrain Shutdown
F168
10 Amp Red
Air Conditioner Clutch
F169
40 Amp Green
Emissions – Partial Zero Emissions Vehicle Motor
F170
15 Amp Blue
Emissions – Partial Zero Emissions Vehicle Actuators
F172
20 Amp Yellow
Spare
F173
25 Amp Clear
Anti Lock Brake Valves
F174
20 Amp Yellow
Siren – If Equipped
F175
30 Amp Green
Spare
F176
10 Amp Red
Powertrain Control Modules
F177
20 Amp Yellow
All Wheel Drive Module – If Equipped
F178
25 Amp Clear
Sunroof – If Equipped
129
Cavity
Cartridge Fuse
Mini-Fuse
Description
F179
10 Amp Red
Battery Sensor
F181
100 Amp Blue
Electrohydraulic Steering (EHPS) – If Equipped
F182
50 Amp Red
Cabin Heater #3 – If Equipped
F184
30 Amp Pink
Front Wiper Motor
JUMP STARTING
If your vehicle has a discharged battery, it can
be jump started using a set of jumper cables
and a battery in another vehicle, or by using a
portable battery booster pack. Jump starting
can be dangerous if done improperly, so please
follow the procedures in this section carefully.
WARNING!
Do not attempt jump starting if the battery is
frozen. It could rupture or explode and cause
personal injury.
CAUTION!
Do not use a portable battery booster pack or
any other booster source with a system volt-
age greater than 12 Volts or damage to the
CAUTION!
battery, starter motor, alternator or electrical
system may occur.
NOTE:
When using a portable battery booster pack,
follow the manufacturer's operating instructions
and precautions.
Preparations For Jump Start
The battery in your vehicle is located between
the left front headlight assembly and the left
front wheel splash shield. To allow jump start-
ing, there are remote battery posts located on
the left side of the engine compartment.
Remote Battery Post Locations
1 — Remote Positive (+) Battery Post
2 — Remote Negative (-) Battery Post
IN CASE OF EMERGENCY
130
ENGINE COMPARTMENT
2.4L Engine
1 — Engine Coolant Reservoir
7 — Power Distribution Center (Fuses)
2 — Power Steering Fluid Reservoir
8 — Air Cleaner Filter
3 — Engine Oil Fill
9 — Automatic Transmission Dipstick (4–Speed Only – If Equipped)
4 — Brake Fluid Reservoir
10 — Washer Fluid Reservoir
5 — Remote Jump Start (Positive Battery Post)
11 — Coolant Pressure Cap
6 — Remote Jump Start (Negative Battery Post)
12 — Engine Oil Dipstick
143
3.6L Engine
1 — Engine Coolant Reservoir Pressure Cap
7 — Power Distribution Center (Fuses)
2 — Power Steering Fluid Reservoir
8 — Air Cleaner Filter
3 — Oil Filter Access
9 — Washer Fluid Reservoir
4 — Brake Fluid Reservoir
10 — Engine Oil Dipstick
5 — Remote Jump Start (Positive Battery Post)
11 — Engine Oil Fill
6 — Remote Jump Start (Negative Battery Post)
12 — Engine Coolant Reservoir
SERVICING AND MAINTENANCE
144