Smart Pure - 2014 Fuse Box Diagram

Smart Pure - 2014 Fuse Box Diagram

result in data loss in the vehicle’s
control units.
R
Not disconnecting the battery and
leaving the key in starter switch posi-
tion
1
(ignition on) may result in
-
the vehicle locking. The vehicle will
lock if the wheels are turning at
vehicle speeds of approximately
8 mph (14 km/h) or more.
-
the ESP
®
being activated. Active
braking action through the ESP
®
may
seriously damage the brake system
which is not covered by the smart
Limited Warranty.
R
Not moving the gear selector lever to
neutral position
N
may result in sig-
nificant transmission damage.
R
in a discharged battery.
Fuses
The electrical fuses in your vehicle serve
to switch off malfunctioning power cir-
cuits.
If a fuse is blown, the components and sys-
tems secured by that fuse will stop operat-
ing.
G
WARNING
Only use fuses approved by smart with the
specified amperage for the system in ques-
tion and do not attempt to repair or bridge
a blown fuse this may cause an overload
leading to a fire, and/or cause damage to
electrical components and/or systems.
Contact a smart center if you encounter any
electrical problems.
!
A blown fuse must be replaced by an
appropriate spare fuse (recognizable by
its color or the fuse rating given on the
fuse) of the amperage recommended in
the fuse chart. Any smart center will be
glad to advise you on this subject.
If a newly inserted fuse blows again, have
the cause determined and rectified at an
authorized smart center.
Before replacing fuses:
R
Engage the parking brake.
R
Make sure the gear selector lever is in
park position
P
.
R
Turn off all electrical accessories.
R
Turn off the engine.
R
Remove the key from the starter switch.
Replacing a fuse
The fuse box is located on the driver’s side
below the dashboard.
X
From the fuse chart (
Y
page 207), deter-
mine which fuse belongs to the malfunc-
tioning accessory or component.
X
Remove the respective fuse.
X
Replace the defective fuse with a new one
of the same amperage.
Fuses
205
>> Practical hints.
Z
Fuse box
Front side
:
-
\
Fuse
y
-
¥
Backup fuse slots
206
Fuses
>> Practical hints.
Rear side
^
-
©
Fuse
Fuse chart
No.
Accessory/Component
Amperage
Color
:
Engine
25 A
Neutral
;
Windshield wipers
25 A
Neutral
=
Power window (left and right)
20 A
Yellow
?
Passenger compartment blower (HVAC)
25 A
Neutral
A
Front fog lamps, LED daytime running lamps
10 A
Red
B
Right parking lamp, right tail lamp, license
plate lamps
7.5 A
Brown
C
Left parking lamp, left tail lamp
7.5 A
Brown
D
Engine, tank ventilation
25 A
Neutral
E
Engine
7.5 A
Brown
Fuses
207
>> Practical hints.
Z
No.
Accessory/Component
Amperage
Color
F
Engine, transmission, shifter
15 A
Blue
G
ESP
®
control unit
25 A
Neutral
H
Exterior lamp switch, turn signal lamp
switch, cockpit switch module, on-board
diagnostics socket, transmission control
unit, exterior rear view mirror heating,
anti-theft warning system, rain-light sen-
sor, auxiliary instruments, central locking
system, instrument cluster, Tire Pressure
Monitoring System (TPMS), brake and turn
signal lamps (left and right)
10 A
Red
I
J
Air conditioning compressor
15 A
Blue
K
Audio, subwoofer, sound system, soft top
(cabriolet only), interior light
15 A
Blue
L
Fuel pump with fuel level sensor
15 A
Blue
M
Rear window wiper (coupé only)
15 A
Blue
N
ESP
®
control unit, EPS control unit, restraint
system
10 A
Red
O
Engine control unit, transmission control
unit, Tire Pressure Monitoring System
(TPMS), on-board diagnostics socket
7.5 A
Brown
P
Air conditioning system, exterior rear view
mirror adjustment, washer pump, audio, seat
heating, wiper switch, soft top switch (cab-
riolet only)
10 A
Red
Q
Auxiliary power outlet
15 A
Blue
R
Left low‑beam headlamp
7.5 A
Brown
S
Right low‑beam headlamp
7.5 A
Brown
T
Backup lamp
15 A
Blue
U
Right high‑beam headlamp
7.5 A
Brown
V
Left high‑beam headlamp
7.5 A
Brown
W
Engine
7.5 A
Brown
X
Rear window defroster
40 A
Orange
208
Fuses
>> Practical hints.
No.
Accessory/Component
Amperage
Color
Y
Soft top (cabriolet only)
30 A
Green
Z
Transmission control unit, radiator cooling
fan
40 A
Orange
\
Horn, central locking system
20 A
Yellow
^
_
Starter switch (ignition)
50 A
Red
a
ESP
®
control unit
40 A
Orange
©
EPS control unit
30 A
Green
y
Exterior rear view mirror heating
7.5 A
Brown
z
Brake lamps
7.5 A
Brown
|
~
¡
Windshield unit car2go
10 A
Red
¢
£
Interior lighting
5 A
Light brown
¤
Surround sound system
20 A
Yellow
¥
Seat heating control unit
25 A
Neutral
Fuses
209
>> Practical hints.
Z
compartment as shown in the illustra-
tion.
When doing so, observe that the display
and buttons on control element
?
both
point upwards.
Control element on the charging cable
(Level 1)
G
WARNING
When connected to a power supply socket, a
high electrical load during the charging
process can lead to overheating of the
external power supply. There is a risk of
fire.
Check the maximum permissible charge
current on site before you begin the charg-
ing process. Contact an authorized electric
drive smart center should you require
assistance. If necessary, adjust the set-
tings of your vehicle.
!
An excessive charge current can blow a
fuse or lead to overheating of the exter-
nal power supply. Check whether the
external power supply is compatible
with the set charge current. If necessary,
lower the set charge current or use
another power socket.
:
AC status display
;
Monitoring and safety system display
=
Charge current display
?
Set charge current button
If the lights on indicator lamps
:
and
;
light up, it means the following:
Indicator lamp
:
lights up
green
The connection to the
external power supply is
OK. The high‑voltage bat-
tery can be charged.
flashes red
A malfunction is detected
in the external power sup-
ply. The high‑voltage bat-
tery will be charged when
the current signal reaches
a normal value.
lights up
red
There is a malfunction.
The charging cable must
be unplugged from the
power socket and plugged
in again.
Indicator lamp
;
lights up
green
There is no malfunction.
The high‑voltage battery
can be charged.
lights up
red
The power supply on the
control element is not
permissible. The
high‑voltage battery can-
not be charged.
i
Information on problems during the
charging process can be found on
(
Y
page 120).
X
To set the charge current:
press but-
ton
?
repeatedly until the desired set-
ting is selected in display
=
.
R
An LED lights up: minimum setting
R
All LEDs light up: maximum setting
i
Depending on the country, the value of
the maximum setting may vary.
If you leave the charging cable in the power
supply socket after charging, the set value
is used for the next charging process.
116
High-voltage battery
>> Operation.
Front cover
Rear covers
X
Remove respective cover
:
or
;
using
a suitable object to reveal the threaded
hole for the towing eye bolt.
X
Screw towing eye bolt in clockwise to its
stop and tighten with a suitable object.
G
WARNING
For safety reasons, recovery or lashing
down of the vehicle by means of the towing
eye is not allowed. Failure to observe this
could result in the towing eye being ripped
out of its mounting and people being
injured.
Towing the vehicle
X
Engage the parking brake.
X
Connect the strap or tow bar to the towing
eye.
X
Switch on the ignition.
X
Depress the brake pedal and keep it
pressed.
X
Move the gear selector lever to neutral
position
N
.
X
Release the brake pedal.
X
Switch on the hazard warning flasher.
X
Release the parking brake.
Wait for at least 2 minutes after the vehicle
has been towed until start working on the
vehicle.
Fuses
The electrical fuses in your vehicle serve
to switch off malfunctioning power cir-
cuits.
If a fuse is blown, the components and sys-
tems secured by that fuse will stop operat-
ing.
G
WARNING
Only use fuses approved by smart with the
specified amperage for the system in ques-
tion and do not attempt to repair or bridge
a blown fuse this may cause an overload
leading to a fire, and/or cause damage to
electrical components and/or systems.
Contact an authorized electric drive smart
center if you encounter any electrical
problems.
!
A blown fuse must be replaced by an
appropriate spare fuse (recognizable by
its color or the fuse rating given on the
fuse) of the amperage recommended in
the fuse chart. Any smart center will be
glad to advise you on this subject.
If a newly inserted fuse blows again, have
the cause determined and rectified at an
authorized electric drive smart center.
Before replacing fuses:
R
Engage the parking brake.
R
Make sure the gear selector lever is in
park position
P
.
R
Turn off all electrical accessories.
Fuses
205
>> Practical hints.
Z
R
Switch off the drive system.
R
Remove the key from the starter switch.
Replacing a fuse
The fuse box is located on the driver’s side
below the dashboard.
X
From the fuse chart (
Y
page 208), deter-
mine which fuse belongs to the malfunc-
tioning accessory or component.
X
Remove the respective fuse.
X
Replace the defective fuse with a new one
of the same amperage.
206
Fuses
>> Practical hints.
Fuse box
Front side
:
-
\
Fuse
y
-
¥
Backup fuse slots
Fuses
207
>> Practical hints.
Z
Rear side
^
-
©
Fuse
Fuse chart
No.
Accessory/Component
Amperage
Color
:
;
Windshield wipers
25 A
Neutral
=
Power window (left and right)
20 A
Yellow
?
Passenger compartment blower
25 A
Neutral
A
Front fog lamps, LED daytime running lamps
10 A
Red
B
Right parking lamp, right tail lamp, license
plate lamps
7.5 A
Brown
C
Left parking lamp, left tail lamp
7.5 A
Brown
D
Vehicle interior pre-heating and cooling
25 A
Neutral
208
Fuses
>> Practical hints.
No.
Accessory/Component
Amperage
Color
E
CPC, shifter, brake force booster vacuum
pump
7.5 A
Brown
F
Coolant pumps 1 and 2, high-voltage battery
15 A
Blue
G
ESP
®
control unit
25 A
Neutral
H
Exterior lamp switch, turn signal lamp
switch, cockpit switch module, on-board
diagnostics socket, exterior rear view mir-
ror heating, anti-theft warning system,
rain-light sensor, charge level and power
gauges, central locking system, instrument
cluster, Tire Pressure Monitoring System
(TPMS), brake and turn signal lamps (left and
right)
10 A
Red
I
J
K
Safety circuit high-voltage battery
15 A
Blue
L
M
Rear window wiper (coupé only)
15 A
Blue
N
ESP
®
control unit, EPS control unit, restraint
systems
10 A
Red
O
Electric drive components, engine control
unit, transmission control unit, on-board
diagnostics socket, sound generator
7.5 A
Brown
P
Air conditioning system, exterior rear view
mirror adjustment, washer pump, audio, seat
heating, wiper switch, cruise control, soft
top switch (cabriolet only), backup lamp
10 A
Red
Q
Auxiliary power outlet
15 A
Blue
R
Left low‑beam headlamp
7.5 A
Brown
S
Right low‑beam headlamp
7.5 A
Brown
T
U
Right high‑beam headlamp
7.5 A
Brown
V
Left high‑beam headlamp
7.5 A
Brown
W
Electric drive components
7.5 A
Brown
Fuses
209
>> Practical hints.
Z
No.
Accessory/Component
Amperage
Color
X
Rear window defroster
40 A
Orange
Y
Soft top (cabriolet only)
30 A
Green
Z
Radiator cooling fan
40 A
Orange
\
Horn, central locking system
20 A
Yellow
^
_
Starter switch (ignition)
50 A
Red
a
ESP
®
control unit
40 A
Orange
©
EPS control unit
30 A
Green
y
Exterior rear view mirror heating
7.5 A
Brown
z
Brake lamps
7.5 A
Brown
|
~
Tire pressure monitor control unit
7.5 A
Brown
¡
Coolant pump, electric drive components, HV
interior PTC heater passenger compartment,
windshield unit car2go
10 A
Red
¢
Audio, subwoofer, sound system, soft top
(cabriolet only)
15 A
Blue
£
Interior lighting
5 A
Light brown
¤
Surround sound system
20 A
Yellow
¥
Seat heating control unit
25 A
Neutral
210
Fuses
>> Practical hints.