Ram 3500 - 2017 Fuse Box Diagram

Ram 3500 - 2017 Fuse Box Diagram

ELECTRICAL POWER OUTLETS
The auxiliary 12 Volt (13 Amp) power outlets can provide
power for in-cab accessories designed for use with the
standard “cigar lighter” plug. The 12 Volt power outlets
and USB Port (Charge Only) have a cap attached to the
outlet indicating “12V DC,” together with either a key
symbol, battery symbol, or USB symbol.
A key symbol indicates that the key must be in the
ON/RUN or ACC positions for the outlet to provide
power. The battery symbol indicates that the outlet is
connected to the battery, and can provide power at all
times.
NOTE:
To ensure proper operation, a Mopar knob and
element must be used.
CAUTION!
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watts (13 Amps) power
rating is exceeded, the fuse protecting the system
will need to be replaced.
Power outlets are designed for accessory plugs only.
Do not insert any other object in the power outlets as
this
will
damage
the
outlet
and
blow
the
fuse.
Improper use of the power outlet can cause damage
not covered by your New Vehicle Limited Warranty.
182
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
When the vehicle is turned off, be sure to unplug any
equipment as to not drain the battery of the vehicle. All
accessories connected to the outlet(s) should be removed or
turned off when the vehicle is not in use to protect the
battery against discharge.
Power Outlet — Rear Center Console Fuse
Power Outlet Fuse Locations
1 — F104 Fuse 20 A Yellow Power Outlet Center Console Bin / USB
Port (Charge Only)
2 — F90–F91 Fuse 20 A Yellow Power Outlet Rear Center Console
3 — F93 Fuse 20 A Yellow Cigar Lighter Instrument Panel
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
185
JUMP STARTING PROCEDURES
If your vehicle has a discharged battery, it can be jump
started using a set of jumper cables and a battery in another
vehicle or by using a portable battery booster pack. Jump
starting can be dangerous if done improperly, so please
follow the procedures in this section carefully.
NOTE:
When using a portable battery booster pack, follow
the manufacturer’s operating instructions and precautions.
WARNING!
Do not attempt jump-starting if the battery is frozen. It
could rupture or explode and cause personal injury.
CAUTION!
Do not use a portable battery booster pack or any other
booster source with a system voltage greater than 12
Volts or damage to the battery, starter motor, alternator
or electrical system may occur.
Preparations For Jump-Start
The battery in your vehicle is located in the front of the
engine compartment, behind the left headlight assembly.
NOTE:
The positive battery post may be covered with a
protective cap if equipped. Lift up on the cap to gain access
to the positive battery post. Do not jump off fuses. Only
jump directly off positive post which has a positive
(+)
symbol on or around the post.
Correct Positive Jumping Location
604
WHAT TO DO IN EMERGENCIES
WARNING!
Take care to avoid the radiator cooling fan whenever
the hood is raised. It can start anytime the ignition
switch is ON. You can be injured by moving fan
blades.
Remove any metal jewelry such as rings, watch
bands and bracelets that could make an inadvertent
electrical contact. You could be seriously injured.
Batteries contain sulfuric acid that can burn your
skin or eyes and generate hydrogen gas which is
flammable
and
explosive.
Keep
open
flames
or
sparks away from the battery.
1. Apply the parking brake, shift the automatic transmis-
sion into PARK and turn the ignition to LOCK.
2. Turn off the heater, radio, and all unnecessary electrical
accessories.
3. If using another vehicle to jump-start the battery, park
the vehicle within the jumper cables reach, apply the
parking brake and make sure the ignition is OFF.
WARNING!
Do not allow vehicles to touch each other as this could
establish a ground connection and personal injury
could result.
Jump-Starting Procedure
WARNING!
Failure to follow this jump-starting procedure could
result in personal injury or property damage due to
battery explosion.
CAUTION!
Failure to follow these procedures could result in
damage to the charging system of the booster vehicle
or the discharged vehicle.
Connecting The Jumper Cables
1. Connect the positive
(+)
end of the jumper cable to the
positive
(+)
post of the discharged vehicle.
NOTE: Do not jump off fuses. Only jump directly off
positive post.
6
WHAT TO DO IN EMERGENCIES
605
2. Connect the opposite end of the positive
(+)
jumper
cable to the positive
(+)
post of the booster battery.
3. Connect the negative
(-)
end of the jumper cable to the
negative
(-)
post of the booster battery.
4. Connect the opposite end of the negative
(-)
jumper
cable to a good engine ground (exposed metal part of
the discharged vehicle’s engine) away from the battery
and the fuel injection system.
WARNING!
Do not connect the jumper cable to the negative (-) post
of the discharged battery. The resulting electrical spark
could cause the battery to explode and could result in
personal injury. Only use the specific ground point, do
not use any other exposed metal parts.
5. Start the engine in the vehicle that has the booster
battery, let the engine idle a few minutes, and then start
the engine in the vehicle with the discharged battery.
CAUTION!
Do not connect jumper cable to any of the fuses on the
positive battery terminal. The resulting electrical cur-
rent will blow the fuse.
6. Once the engine is started, remove the jumper cables in
the reverse sequence:
Disconnecting The Jumper Cables
1. Disconnect the negative
(-)
end of the jumper cable from
the engine ground of the vehicle with the discharged
battery.
2. Disconnect the opposite end of the negative
(-)
jumper
cable from the negative
(-)
post of the booster battery.
3. Disconnect the positive
(+)
end of the jumper cable from
the positive
(+)
post of the booster battery.
4. Disconnect the opposite end of the positive
(+)
jumper
cable from the positive
(+)
post of the vehicle with the
discharged battery.
If frequent jump-starting is required to start your vehicle
you should have the battery and charging system in-
spected at your authorized dealer.
606
WHAT TO DO IN EMERGENCIES
ENGINE COMPARTMENT — 3.6L
1 — Air Cleaner Filter
2 — Engine Oil Dipstick
3 — Engine Oil Fill
4 — Brake Fluid Reservoir
5 — Battery
6 — Washer Fluid Reservoir
7 — Power Distribution Center (Fuses)
8 — Coolant Pressure Cap
9 — Engine Coolant Reservoir
7
MAINTAINING YOUR VEHICLE
619
ENGINE COMPARTMENT — 5.7L
1 — Air Cleaner Filter
7 — Washer Fluid Reservoir
2 — Automatic Transmission Dipstick (6-Speed Trans Only)
8 — Power Distribution Center (Fuses)
3 — Engine Oil Fill
9 — Power Steering Fluid Reservoir (2500/3500 Models Only)
4 — Engine Oil Dipstick
10 — Coolant Pressure Cap
5 — Brake Fluid Reservoir
11 — Engine Coolant Reservoir
6 — Battery
620
MAINTAINING YOUR VEHICLE
ENGINE COMPARTMENT — 6.4L
1 — Coolant Pressure Bottle
6 — Battery
2 — Transmission Dipstick
7 — Power Distribution Center (Fuses)
3 — Engine Oil Fill
8 — Washer Solvent
4 — Engine Oil Dipstick
9 — Power Steering Fluid Reservoir
5 — Brake Fluid Reservoir
10 — Air Cleaner Filter
7
MAINTAINING YOUR VEHICLE
621
Spray-On Bedliners are chemically-resistant to many dif-
ferent types of chemicals (including gasoline, oil, hydraulic
fluids) for short periods of time. If a spill occurs on your
Spray-On Bedliner, rinse the truck out as soon as possible
to avoid permanent damage.
Repairing The Spray-On Bedliner
While extremely tough, it is possible to damage a Spray-On
Bedliner. One common condition is when loading a heavy
pallet and dragging that pallet across the floor of the bed.
If a nail or sharp point is exposed under the weight of the
pallet a scratch or tear is possible. While not covered by
your new vehicle warranty, a cosmetic fix to cover the
metal exposed by the scratch is required. To repair a tear or
gouge, follow the directions provided in the Mopar Quick
Repair Kit.
FUSES
WARNING!
When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as
the original fuse. Never replace a fuse with another
fuse of higher amp rating. Never replace a blown
fuse with metal wires or any other material. Failure
to use proper fuses may result in serious personal
injury, fire and/or property damage.
Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
664
MAINTAINING YOUR VEHICLE
Power Distribution Center
The Power Distribution Center is located in the engine
compartment near the battery. This center contains car-
tridge fuses, micro fuses, relays, and circuit breakers. A
description of each fuse and component may be stamped
on the inside cover, otherwise the cavity number of each
fuse is stamped on the inside cover that corresponds to the
following chart.
Cavity
Cartridge Fuse
Micro Fuse
Description
F01
80 Amp Black
Rad Fan Control Module – If Equipped
F03
60 Amp Yellow
Rad Fan – If Equipped
F05
40 Amp Green
Compressor for Air Suspension – If
Equipped
F06
40 Amp Green
Antilock Brakes/Electronic Stability Control
Pump
F07
40 Amp Green
Starter Solenoid
Power Distribution Center Location
7
MAINTAINING YOUR VEHICLE
665
Cavity
Cartridge Fuse
Micro Fuse
Description
F08
20 Amp Blue (1500
LD/Cummins Die-
sel)
Emissions Diesel – If Equipped
F09
40 Amp Green (Spe-
cial Services Vehicle
& Cummins Diesel)
Diesel Fuel Heater – If Equipped
F10
40 Amp Green
Body Controller / Exterior Lighting #2
F10
50 Amp Red
Body Controller / Exterior Lighting #2 – If
Equipped with Stop/Start
F11
30 Amp Pink
Integrated Trailer Brake Module – If
Equipped
F12
40 Amp Green
Body Controller #3 / Power Locks
F13
40 Amp Green
Blower Motor
F14
40 Amp Green
Body Controller #4 / Interior Lighting
F16
30 Amp Pink
Smart Bar – If Equipped
F19
20 Amp Blue (1500
LD Diesel)
30 Amp Pink (Cum-
mins Diesel)
SCR – If Equipped
F20
30 Amp Pink
Passenger Door Module
F21
30 Amp Pink
Drive Train Control Module
666
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F22
20 Amp Blue
30 Amp Pink (Cum-
mins Diesel)
Engine Control Module
F23
30 Amp Pink
Body Controller #1 / Interior Lighting
F24
30 Amp Pink
Driver Door Module
F25
30 Amp Pink
Front Wiper
F26
30 Amp Pink
Antilock Brakes / Stability Control Module /
Valves
F28
20 Amp Blue
Trailer Tow Backup Lights – If Equipped
F29
20 Amp Blue
Trailer Tow Parking Lights – If Equipped
F30
30 Amp Pink
Trailer Tow Receptacle
F31
30 Amp Pink (1500
LD Diesel)
Urea Heater Control – If Equipped
F32
Spare Fuse
F33
20 Amp Blue
Special Services Vehicle Only
F34
30 Amp Pink
Vehicle System Interface Module #2 – If
Equipped
F35
30 Amp Pink
Sunroof – If Equipped
F36
30 Amp Pink
Rear Defroster – If Equipped
F37
30 Amp Pink
Cummins Diesel Fuel Heater #2 – If
Equipped
7
MAINTAINING YOUR VEHICLE
667
Cavity
Cartridge Fuse
Micro Fuse
Description
F38
30 Amp Pink
Power Inverter 115V AC – If Equipped
F39
20 Amp Blue
Power Outlet – Special Services Only
F41
10 Amp Red
Active Grill Shutter – If Equipped
F42
20 Amp Yellow
Horn
F44
10 Amp Red
Diagnostic Port
F46
10 Amp Red
Upfitter – If Equipped
F49
10 Amp Red
Instrument Panel Cluster (Except Fleet Ve-
hicles)
F50
20 Amp Yellow
Air Suspension Control Module – If
Equipped
F51
10 Amp Red
Ignition Node Module / Keyless Ignition
(Instrument Panel Cluster – Fleet Vehicles
Only)
F52
5 Amp Tan
Battery Sensor
F53
20 Amp Yellow
Trailer Tow – Left Turn/Stop Lights
F54
20 Amp Yellow
Adjustable Pedals
F56
15 Amp Blue
Additional Diesel Content – If Equipped
F57
20 Amp Yellow
Transmission
F58
20 Amp Yellow
Spare Fuse
F59
10 Amp Red
SCR Relay – If Equipped
668
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F60
15 Amp Blue
Underhood Lamp
F61
10 Amp Red (1500
LD Diesel & Cum-
mins Diesel)
PM Sensor – If Equipped
F62
10 Amp Red
Air Conditioning Clutch
F63
20 Amp Yellow
Ignition Coils (Gas), Urea Heater (Cummins
Diesel)
F64
25 Amp Clear
Fuel Injectors / Powertrain
F65
Spare Fuse
F66
10 Amp Red
Sunroof / Passenger Window Switches /
Rain Sensor
F67
10 Amp Red
CD / DVD / Bluetooth Hands-free Module –
If Equipped
F69
15 Amp Blue
Mod SCR 12V (Cummins Diesel) – If
Equipped
F70
30 Amp Green
Fuel Pump Motor
F71
25 Amp Clear
Amplifier
F72
10 Amp Red
PCM – If Equipped
F73
20 Amp Yellow
Fuel Transfer Pump (HD Only) – If
Equipped
7
MAINTAINING YOUR VEHICLE
669
Cavity
Cartridge Fuse
Micro Fuse
Description
F74
20 Amp Yellow (Gas
Engine & 1500 LD
Diesel)
Brake Vacuum Pump Gas/Diesel – If
Equipped
F75
10 Amp Red
Coolant Temperature Valve Actuator
F76
10 Amp Red
Antilock Brakes / Electronic Stability Control
F77
10 Amp Red
Drivetrain Control Module/Front Axle Dis-
connect Module
F78
10 Amp Red
Engine Control Module / Electric Power
Steering
F79
15 Amp Blue
Clearance Lights
F80
10 Amp Red
Universal Garage Door Opener / Compass
F81
20 Amp Yellow
Trailer Tow Right Turn / Stop Lights
F82
10 Amp Red
Steering Column Control Module / Cruise
Control
F84
15 Amp Blue
Switch Bank / Instrument Cluster
F85
10 Amp Red
Airbag Module
F86
10 Amp Red
Airbag Module
F87
10 Amp Red
Air Suspension – If Equipped / Trailer Tow
/ Steering Column Control Module
F88
15 Amp Blue
Instrument Panel Cluster
670
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F90/F91
20 Amp Yellow
Power Outlet (Rear Seats) Customer Select-
able
F93
20 Amp Yellow
Cigar Lighter
F94
10 Amp Red
Shifter / Transfer Case Module
F95
10 Amp Red
Rear Camera / Park Assist
F96
10 Amp Red
Rear Seat Heater Switch
F97
25 Amp Clear
Rear Heated Seats & Heated Steering Wheel
– If Equipped
F98
25 Amp Clear
Front Heated Seats – If Equipped
F99
10 Amp Red
Climate Control
F100
10 Amp Red
Upfitters – If Equipped
F101
15 Amp Blue
Electrochromatic Mirror / Smart High Beams
– If Equipped
F104
20 Amp Yellow
Power Outlets (Instrument Panel / Center
Console)
7
MAINTAINING YOUR VEHICLE
671
CAUTION!
When installing the power distribution center cover,
it is important to ensure the cover is properly posi-
tioned and fully latched. Failure to do so may allow
water to get into the power distribution center and
possibly result in an electrical system failure.
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If a
properly rated fuse continues to blow, it indicates a
problem in the circuit that must be corrected.
VEHICLE STORAGE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to minimize
the drain on your vehicle’s battery:
Disconnect the negative cable from battery.
Any time you store your vehicle or keep it out of service
(i.e., vacation) for two weeks or more, run the air
conditioning system at idle for about five minutes in the
fresh air and high blower setting. This will ensure
adequate system lubrication to minimize the possibility
of compressor damage when the system is started again.
REPLACEMENT BULBS
All of the inside bulbs are brass or glass-wedge base.
Aluminum base bulbs are not approved.
Interior Bulbs
Bulb Number
Overhead Console Lamps
TS 212–9
Dome Lamp
7679
For lighted switches, see your authorized dealer for
replacement instructions.
672
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect
the
accuracy
or
operation
of
the
compass
on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
Inside the upper lid of the center storage compartment.
NOTE:
Do not exceed the maximum power of
160 Watts (13 Amps) at 12 Volts. If
the 160 Watt (13 Amp) power rating is
exceeded, the fuse protecting the sys-
tem will need to be replaced.
Power outlets are designed for acces-
sory plugs only. Do not insert any other
object in the power outlet as this will
damage the outlet and blow the fuse.
Improper use of the power outlet can
cause damage not covered by your new
vehicle warranty.
The rear center console power outlet
can be switched to “ignition” powered
all the time by switching the power
outlet rear center console fuse in the fuse panel.
Power Outlet (USB Charge Only Port) —
Storage Compartment
Power Outlet Fuse Locations
1 — F90 – F91 Fuse 20A Yellow Power Outlet Rear Center Console
2 — F104 Fuse 20A Yellow Power Outlet Center Console
3 — F93 Fuse 20A Yellow Cigar Lighter Instrument Panel
ELECT RONICS
202
JUMP STARTING PROCEDURES
If your vehicle has a discharged battery, it can be jump started using a set of jumper
cables and a battery in another vehicle or by using a portable battery booster pack.
Jump starting can be dangerous if done improperly, so please follow the procedures
in this section carefully.
NOTE:
When using a portable battery booster pack, follow the manufacturer’s operating
instructions and precautions.
WARNING!
Do not attempt jump-starting if the battery is frozen. It could rupture or explode
and cause personal injury.
CAUTION!
Do not use a portable battery booster pack or any other booster source with a
system voltage greater than 12 Volts or damage to the battery, starter motor,
alternator or electrical system may occur.
Preparations For Jump-Start
The battery in your vehicle is located in the front of the engine compartment, behind
the left headlight assembly.
NOTE:
The positive battery post may be covered
with a protective cap if equipped. Lift up
on the cap to gain access to the positive
battery post. Do not jump off fuses. Only
jump directly off positive post which has
a positive
(+)
symbol on or around the
post.
Positive Jumping Location
WHAT TO DO IN EMERGENCIES
281
WARNING!
• Take care to avoid the radiator cooling fan whenever the hood is raised. It can
start anytime the ignition switch is ON. You can be injured by moving fan blades.
• Remove any metal jewelry such as rings, watch bands and bracelets that could
make an inadvertent electrical contact. You could be seriously injured.
• Batteries contain sulfuric acid that can burn your skin or eyes and generate
hydrogen gas which is flammable and explosive. Keep open flames or sparks
away from the battery.
1. Apply the parking brake, shift the automatic transmission into PARK and turn the
ignition to LOCK.
2. Turn off the heater, radio, and all unnecessary electrical accessories.
3. If using another vehicle to jump-start the battery, park the vehicle within the
jumper cables reach, apply the parking brake and make sure the ignition is OFF.
WARNING!
Do not allow vehicles to touch each other as this could establish a ground
connection and personal injury could result.
Jump-Starting Procedure
WARNING!
Failure to follow this jump-starting procedure could result in personal injury or
property damage due to battery explosion.
CAUTION!
Failure to follow these procedures could result in damage to the charging system
of the booster vehicle or the discharged vehicle.
Connecting The Jumper Cables
1. Connect the positive
(+)
end of the jumper cable to the positive
(+)
post of the
discharged vehicle.
NOTE:
Do not jump off fuses. Only jump directly off positive post.
2. Connect the opposite end of the positive
(+)
jumper cable to the positive
(+)
post
of the booster battery.
WHAT TO DO IN EMERGENCIES
282
3. Connect the negative
(-)
end of the jumper cable to the negative
(-)
post of the
booster battery.
4. Connect the opposite end of the negative
(-)
jumper cable to a good engine ground
(exposed metal part of the discharged vehicle’s engine) away from the battery and
the fuel injection system.
WARNING!
Do not connect the jumper cable to the negative
(-)
post of the discharged battery.
The resulting electrical spark could cause the battery to explode and could result
in personal injury. Only use the specific ground point, do not use any other exposed
metal parts.
5. Start the engine in the vehicle that has the booster battery, let the engine idle a
few minutes, and then start the engine in the vehicle with the discharged battery.
CAUTION!
Do not connect jumper cable to any of the fuses on the positive battery terminal.
The resulting electrical current will blow the fuse.
6. Once the engine is started, remove the jumper cables in the reverse sequence:
Disconnecting The Jumper Cables
1. Disconnect the negative
(-)
end of the jumper cable from the engine ground of the
vehicle with the discharged battery.
2. Disconnect the opposite end of the negative
(-)
jumper cable from the negative
(-)
post of the booster battery.
3. Disconnect the positive
(+)
end of the jumper cable from the positive
(+)
post of
the booster battery.
4. Disconnect the opposite end of the positive
(+)
jumper cable from the positive
(+)
post of the vehicle with the discharged battery.
If frequent jump-starting is required to start your vehicle you should have the battery
and charging system inspected at your authorized dealer.
CAUTION!
Accessories plugged into the vehicle power outlets draw power from the vehicle’s
battery, even when not in use (i.e., cellular devices, etc.). Eventually, if plugged in
long enough without engine operation, the vehicle’s battery will discharge suffi-
ciently to degrade battery life and/or prevent the engine from starting.
WHAT TO DO IN EMERGENCIES
283
ENGINE COMPARTMENT — 3.6L
1. Air Cleaner Filter
2. Engine Oil Fill (Under Cover)
3. Brake Fluid Reservoir
4. Battery
5. Power Distribution Center (Fuses)
MAINTAINING YOUR VEHICLE
292
6. Engine Oil Dipstick
7. Power Distribution Center (Fuses)
8. Washer Fluid Reservoir
9. Engine Coolant Reservoir
10. Engine Coolant Pressure Cap
MAINTAINING YOUR VEHICLE
295
ENGINE COMPARTMENT — 6.4L
1. Engine Coolant Reservoir
2. Transmission Fluid Dipstick
3. Engine Oil Fill
4. Brake Fluid Reservoir
5. Aux Power Distribution Center (Fuses)
6. Battery
MAINTAINING YOUR VEHICLE
296
7. Power Distribution Center (Fuses)
8. Washer Fluid Reservoir
9. Power Steering Reservoir
10. Engine Oil Dipstick
11. Air Cleaner Filter
MAINTAINING YOUR VEHICLE
297
ENGINE COMPARTMENT — 3.0L DIESEL
1. Air Cleaner Filter
2. Engine Oil Fill
3. Brake Fluid Reservoir
4. Aux Power Distribution Center (Fuses)
5. Battery
MAINTAINING YOUR VEHICLE
298
6. Power Distribution Center (Fuses)
7. Washer Fluid Reservoir
8. Engine Coolant Reservoir
9. Engine Oil Dipstick
MAINTAINING YOUR VEHICLE
299
ENGINE COMPARTMENT — 6.7L DIESEL WITH 68RFE TRANSMISSION
1. Batteries
2. Engine Coolant Reservoir
3. Transmission Fluid Dipstick
4. Brake Fluid Reservoir
5. Aux Power Distribution Center (Fuses)
6. Washer Fluid Reservoir
MAINTAINING YOUR VEHICLE
300
7. Power Steering Fluid Reservoir
8. Power Distribution Center (Fuses)
9. Engine Oil Dipstick
10. Engine Oil Fill
11. Air Cleaner Filter
MAINTAINING YOUR VEHICLE
301
ENGINE COMPARTMENT — 6.7L DIESEL WITH AS69RC TRANSMISSION
1. Batteries
2. Engine Coolant Reservoir
3. Transmission Fluid Dipstick
4. Brake Fluid Reservoir
5. Aux Power Distribution Center (Fuses)
6. Power Distribution Center (Fuses)
MAINTAINING YOUR VEHICLE
302
FUSES
WARNING!
• When replacing a blown fuse, always use an appropriate replacement fuse with
the same amp rating as the original fuse. Never replace a fuse with another fuse
of higher amp rating. Never replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in serious personal injury, fire
and/or property damage.
• Before replacing a fuse, make sure that the ignition is off and that all the other
services are switched off and/or disengaged.
• If the replaced fuse blows again, contact an authorized dealer.
• If a general protection fuse for safety systems (air bag system, braking system),
power unit systems (engine system, gearbox system) or steering system blows,
contact an authorized dealer.
Power Distribution Center
The Power Distribution Center is located in the engine compartment near the battery.
This center contains cartridge fuses, micro fuses, relays, and circuit breakers. A
description of each fuse and component may be stamped on the inside cover,
otherwise the cavity number of each fuse is stamped on the inside cover that
corresponds to the following chart.
Cavity
Cartridge Fuse
Micro Fuse
Description
F01
80 Amp Black
Rad Fan Control Module – If Equipped
F03
60 Amp Yellow
Rad Fan – If Equipped
F05
40 Amp Green
Compressor for Air Suspension –
If Equipped
F06
40 Amp Green
Antilock Brakes/Electronic Stability
Control Pump
F07
40 Amp Green
Starter Solenoid
F08
20 Amp Blue
(1500 LD/
Cummins
Diesel)
Emissions Diesel – If Equipped
MAINTAINING YOUR VEHICLE
331
Cavity
Cartridge Fuse
Micro Fuse
Description
F09
40 Amp Green
(Special Ser-
vices Vehicle
& Cummins
Diesel)
Diesel Fuel Heater – If Equipped
F10
40 Amp Green
Body Controller / Exterior Lighting #2
F10
50 Amp Red
Body Controller / Exterior Lighting #2 –
If Equipped with Stop/Start
F11
30 Amp Pink
Integrated Trailer Brake Module – If
Equipped
F12
40 Amp Green
Body Controller #3 / Power Locks
F13
40 Amp Green
Blower Motor
F14
40 Amp Green
Body Controller #4 / Interior Lighting
F16
30 Amp Pink
Smart Bar – If Equipped
F19
20 Amp Blue
(1500 LD
Diesel)
30 Amp Pink
(Cummins
Diesel)
SCR – If Equipped
F20
30 Amp Pink
Passenger Door Module
F21
30 Amp Pink
Drive Train Control Module
F22
20 Amp Blue
30 Amp Pink
(Cummins
Diesel)
Engine Control Module
F23
30 Amp Pink
Body Controller #1 / Interior Lighting
F24
30 Amp Pink
Driver Door Module
F25
30 Amp Pink
Front Wiper
F26
30 Amp Pink
Antilock Brakes / Stability Control Module
/ Valves
F28
20 Amp Blue
Trailer Tow Backup Lights – If Equipped
F29
20 Amp Blue
Trailer Tow Parking Lights – If Equipped
F30
30 Amp Pink
Trailer Tow Receptacle
F31
30 Amp Pink
(1500 LD
Diesel)
Urea Heater Control – If Equipped
F32
Spare Fuse
F33
20 Amp Blue
Special Services Vehicle Only
F34
30 Amp Pink
Vehicle System Interface Module #2 –
If Equipped
F35
30 Amp Pink
Sunroof – If Equipped
F36
30 Amp Pink
Rear Defroster – If Equipped
MAINTAINING YOUR VEHICLE
332
Cavity
Cartridge Fuse
Micro Fuse
Description
F37
30 Amp Pink
Cummins Diesel Fuel Heater #2 –
If Equipped
F38
30 Amp Pink
Power Inverter 115V AC – If Equipped
F39
20 Amp Blue
Power Outlet – Special Services Only
F41
10 Amp Red
Active Grill Shutter – If Equipped
F42
20 Amp Yellow
Horn
F44
10 Amp Red
Diagnostic Port
F46
10 Amp Red
Upfitter – If Equipped
F49
10 Amp Red
Instrument Panel Cluster
(Except Fleet Vehicles)
F50
20 Amp Yellow
Air Suspension Control Module –
If Equipped
F51
10 Amp Red
Ignition Node Module / Keyless Ignition
(Instrument Panel Cluster – Fleet
Vehicles Only)
F52
5 Amp Tan
Battery Sensor
F53
20 Amp Yellow
Trailer Tow – Left Turn/Stop Lights
F54
20 Amp Yellow
Adjustable Pedals
F56
15 Amp Blue
Additional Diesel Content – If Equipped
F57
20 Amp Yellow
Transmission
F58
20 Amp Yellow
Spare Fuse
F59
10 Amp Red
SCR Relay – If Equipped
F60
15 Amp Blue
Underhood Lamp
F61
10 Amp Red
(1500 LD
Diesel & Cum-
mins Diesel)
PM Sensor – If Equipped
F62
10 Amp Red
Air Conditioning Clutch
F63
20 Amp Yellow
Ignition Coils (Gas), Urea Heater
(Cummins Diesel)
F64
25 Amp Clear
Fuel Injectors / Powertrain
F65
Spare Fuse
F66
10 Amp Red
Sunroof / Passenger Window Switches /
Rain Sensor
F67
10 Amp Red
CD / DVD / Bluetooth Hands-free Module
– If Equipped
F69
15 Amp Blue
Mod SCR 12V (Cummins Diesel) –
If Equipped
F70
30 Amp Green
Fuel Pump Motor
F71
25 Amp Clear
Amplifier
F72
10 Amp Red
PCM – If Equipped
MAINTAINING YOUR VEHICLE
333
Cavity
Cartridge Fuse
Micro Fuse
Description
F73
20 Amp Yellow
Fuel Transfer Pump (HD Only) –
If Equipped
F74
20 Amp Yellow
(Gas Engine &
1500 LD
Diesel)
Brake Vacuum Pump Gas/Diesel –
If Equipped
F75
10 Amp Red
Coolant Temperature Valve Actuator
F76
10 Amp Red
Antilock Brakes / Electronic Stability
Control
F77
10 Amp Red
Drivetrain Control Module/Front Axle
Disconnect Module
F78
10 Amp Red
Engine Control Module /
Electric Power Steering
F79
15 Amp Blue
Clearance Lights
F80
10 Amp Red
Universal Garage Door Opener / Compass
F81
20 Amp Yellow
Trailer Tow Right Turn / Stop Lights
F82
10 Amp Red
Steering Column Control Module /
Cruise Control
F84
15 Amp Blue
Switch Bank / Instrument Cluster
F85
10 Amp Red
Airbag Module
F86
10 Amp Red
Airbag Module
F87
10 Amp Red
Air Suspension – If Equipped / Trailer Tow
/ Steering Column Control Module
F88
15 Amp Blue
Instrument Panel Cluster
F90/
F91
20 Amp Yellow
Power Outlet (Rear Seats) Customer
Selectable
F93
20 Amp Yellow
Cigar Lighter
F94
10 Amp Red
Shifter / Transfer Case Module
F95
10 Amp Red
Rear Camera / Park Assist
F96
10 Amp Red
Rear Seat Heater Switch
F97
25 Amp Clear
Rear Heated Seats & Heated Steering
Wheel – If Equipped
F98
25 Amp Clear
Front Heated Seats – If Equipped
F99
10 Amp Red
Climate Control
F100
10 Amp Red
Upfitters – If Equipped
F101
15 Amp Blue
Electrochromatic Mirror / Smart High
Beams – If Equipped
F104
20 Amp Yellow
Power Outlets (Instrument Panel /
Center Console)
MAINTAINING YOUR VEHICLE
334
CAUTION!
When installing the power distribution center cover, it is important to ensure the
cover is properly positioned and fully latched. Failure to do so may allow water to get
into the power distribution center and possibly result in an electrical system failure.
• When replacing a blown fuse, it is important to use only a fuse having the correct
amperage rating. The use of a fuse with a rating other than indicated may result
in a dangerous electrical system overload. If a properly rated fuse continues to
blow, it indicates a problem in the circuit that must be corrected.
TIRE SAFETY INFORMATION
Tire Markings
NOTE:
P (Passenger) — Metric tire sizing is
based
on
U.S.
design
standards.
P-Metric
tires
have
the
letter
“P”
molded into the sidewall preceding
the size designation. Example: P215/
65R15 95H.
European — Metric tire sizing is based
on European design standards. Tires
designed to this standard have the tire
size molded into the sidewall begin-
ning with the section width. The letter
"P" is absent from this tire size desig-
nation. Example: 215/65R15 96H.
LT (Light Truck) — Metric tire sizing is
based on U.S. design standards. The
size designation for LT-Metric tires is
the same as for P-Metric tires except
for the letters “LT” that are molded
into the sidewall preceding the size
designation. Example: LT235/85R16.
Temporary spare tires are designed for
temporary emergency use only. Temporary high pressure compact spare tires have
the letter “T” or “S” molded into the sidewall preceding the size designation.
Example: T145/80D18 103M.
High flotation tire sizing is based on U.S. design standards and it begins with the
tire diameter molded into the sidewall. Example: 31x10.5 R15 LT.
1 — U.S. DOT
Safety
Standards
Code (TIN)
4 — Maximum
Load
2 — Size Desig-
nation
5 — Maximum
Pressure
3 — Service
Descrip-
tion
6 — Treadwear,
Traction
and Tem-
perature
Grades
MAINTAINING YOUR VEHICLE
335
OFF-ROAD CAPABILITIES
How do I shift into different four-wheel drive selections? pg. 204
UTILITY
How do I know how much I can tow with my Ram Truck? pg. 219
How do I adjust the gain on the Integrated Trailer Brake Module? pg. 220
WHAT TO DO IN EMERGENCIES
How do I change a flat tire? pg. 266
How do I Jump-Start my vehicle? pg. 281
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 331
What type of oil do I use? pg. 304
How often should I change my engine’s oil?
Gasoline Engine pg. 312
Cummins Diesel Engine pg. 323
1500 Diesel Engine pg. 318
FAQ’s
359