Chrysler 200 - 2016 Fuse Box Diagram

Chrysler 200 - 2016 Fuse Box Diagram

CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp)
power rating is exceeded the fuse protecting the
system will need to be replaced.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of outlet
should be inserted into any 12 Volt outlet.
(Continued)
WARNING!
(Continued)
Do not touch with wet hands.
Close the lid when not in use and while driving the
vehicle.
If this outlet is mishandled, it may cause an electric
shock and failure.
CAUTION!
Many accessories that can be plugged in draw
power from the vehicle’s battery, even when not in
use
(i.e.,
cellular
phones,
etc.).
Eventually,
if
plugged in long enough, the vehicle’s battery will
discharge sufficiently to degrade battery life and/or
prevent the engine from starting.
Accessories that draw higher power (i.e., coolers,
vacuum cleaners, lights, etc.), will degrade the
(Continued)
300
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
ENGINE COMPARTMENT — 2.4L
1 — Air Cleaner Filter
5 — Power Distribution Center (Fuses)
2 — Engine Coolant Pressure Cap
6 — Battery
3 — Oil Fill Cap
7 — Washer Fluid Reservoir
4 — Brake Fluid Reservoir
8 — Engine Oil Dipstick
7
MAINTAINING YOUR VEHICLE
599
ENGINE COMPARTMENT — 3.6L
1 — Engine Coolant Reservoir
5 — Washer Fluid Reservoir
2 — Engine Oil Filter Access Cover
6 — Battery
3 — Brake Fluid Reservoir
7 — Engine Oil Fill
4 — Power Distribution Center (Fuses)
8 — Air Cleaner Filter
600
MAINTAINING YOUR VEHICLE
WARNING!
(Continued)
assemblies must be replaced after a collision if they
have been damaged (i.e., bent retractor, torn web-
bing, etc.).
FUSES
WARNING!
When replacing a blown fuse, always use an ap-
propriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
with another fuse of higher amp rating. Never
replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in
serious personal injury, fire and/or property dam-
age.
(Continued)
WARNING!
(Continued)
Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
7
MAINTAINING YOUR VEHICLE
637
Power Distribution Center (Fuses)
The Power Distribution Center is located in the engine
compartment near the battery. This center contains car-
tridge fuses, mini-fuses, micro-fuses, circuit breakers and
relays. A label that identifies each component is printed
on the inside of the cover.
Cavity
Cartridge Fuse
Blade Fuse
Description
F06
Not Used
F07
Not Used
F08
25 Amp Clear
Engine Control Module
(ECM)/Fuel Inj.
Power Distribution Center
638
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Blade Fuse
Description
F09
Not Used
F10
20 Amp Yellow
Power Transfer Unit
(PTU) – If Equipped
F11
Not Used
F12
20 Amp Yellow
Brake Vacuum Pump – If
Equipped
F13
10 Amp Red
Engine Control Module
(ECM)/VSM (Engine
Stop/Start Only)
F14
10 Amp Red
Drivetrain Control Mod-
ule (DTCM)/Power
Transfer Unit (PTU) – If
Equipped/RDM/Brake
System Module (BSM)/
Brake Pedal Switch/EPB
(Electric Park Brake)
7
MAINTAINING YOUR VEHICLE
639
Cavity
Cartridge Fuse
Blade Fuse
Description
F15
Not Used
F16
20 Amp Yellow
Ignition Coil
F17
Not Used
F18
Not Used
F19
40 Amp Green
Starter Solenoid
F20
10 Amp Red
A/C Compressor Clutch
F21
Not Used
F22
5 Amp Tan
Radiator Fan Enable
F23
70 Amp Tan
Body Controller Module
(BCM) – Feed 2
F23
50 Amp Red
Voltage Stability Module
(VSM) #2 – If Equipped
With Engine Stop/Start
Option
F24
Not Used
640
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Blade Fuse
Description
F25B
20 Amp Yellow
Front Washer Pump – If
Equipped with Engine
Stop/Start Option
F26
Not Used
F27
Not Used
F28
15 Amp Blue
Transmission Control
Module (TCM)
F29
Not Used
F30
10 Amp Red
Engine Control Module
(ECM)/EPS/Fuel Pump
Relay Feed
F31
Not Used
F32
Not Used
F33
Not Used
F34
Not Used
7
MAINTAINING YOUR VEHICLE
641
Cavity
Cartridge Fuse
Blade Fuse
Description
F35
Not Used
F36
Not Used
F37
50 Amp Red
Radiator Fan PWM Con-
troller
F38
Not Used
F39
40 Amp Green
HVAC Blower Motor
F40
Not Used
F41
50 Amp Red
Voltage Stability Module
(VSM) #1 – If Equipped
With Engine Stop/Start
Option
F41
60 Amp Yellow
Body Controller Module
(BCM) – Feed 1
F42
Not Used
F43
20 Amp Yellow
Fuel Pump Motor
642
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Blade Fuse
Description
F44
Not Used
F45
30 Amp Pink
Passenger Door Module
(PDM) – If Equipped
F46
25 Amp Clear
Sunroof – If Equipped
F47
Not Used
F48
30 Amp Pink
Driver Door Module
(DDM)
F49
30 Amp Pink
Power Inverter (115V
A/C) – If Equipped
F50
30 Amp Pink
Windshield Wiper Smart
Motor (WWSM)
F51
Not Used
F52
Not Used
F53
30 Amp Pink
Brake System Module
BSM & Valves
7
MAINTAINING YOUR VEHICLE
643
Cavity
Cartridge Fuse
Blade Fuse
Description
F54
30 Amp Pink
Body Controller Module
(BCM) – Feed 3
F55
10 Amp Red
Blind Spot Sensors/
Compass/Rearview Cam-
era – If Equipped
F56
15 Amp Blue
Ignition Node Module
(IGNM)/RF Hub
F57
Not Used
F58
10 Amp Red
Occupant Classification
Module/Voltage Stability
Module (VSM) #2 – If
Equipped With Engine
Stop/Start Option
F59
30 Amp Pink
Drivetrain Control Mod-
ule (DTCM)
644
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Blade Fuse
Description
F60
20 Amp Yellow
Power Outlet – Center
Console
F61
Not Used
F62
Not Used
F63
20 Amp Yellow
Front Heated Seats – If
Equipped
F64
20 Amp Yellow
Heated Steering Wheel –
If Equipped
F65
10 Amp Red
In Vehicle Temperature
Sensor/Humidity Sensor/
Driver Assist System
Module (DASM)/Park
Assist (PAM) – If
Equipped With Engine
Stop/Start Option
7
MAINTAINING YOUR VEHICLE
645
Cavity
Cartridge Fuse
Blade Fuse
Description
F66
15 Amp Blue
Instrument Panel Cluster
(IPC)/Electronic Climate
Control (ECC)
F67
10 Amp Red
In Vehicle Temperature
Sensor/Humidity Sensor/
Drivers Assist System
Module (DASM)/Park
Assist (PAM) – If
Equipped
F68
Not Used
F69
10 Amp Red
Gear Shift Module
(GSM)/Active Grill Shut-
ter (AGS). – If Equipped/
EPB SW
F70
5 Amp Tan
Intelligent Battery Sensor
(IBS) – If Equipped with
Engine Stop/Start Option
646
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Blade Fuse
Description
F71
20 Amp Yellow
HID Headlamp Right – If
Equipped with Engine
Stop/Start Option
F72
10 Amp Red
Heated Mirrors – If
Equipped
F73
Not Used
F74
30 Amp Pink
Rear Defroster/Defogger
F75
20 Amp Yellow
Cigar Lighter
F76
10 Amp Red
Drivers Window SW– If
Equipped
F77
10 Amp Red
UCI Port/Brake Pedal
Switch
F78
10 Amp Red
Diagnostic Port/Steering
Column Control Module
(SCCM)
7
MAINTAINING YOUR VEHICLE
647
Cavity
Cartridge Fuse
Blade Fuse
Description
F79
10 Amp Red
Integrated Center Stack
(ICS)/Switch Bank/
Instrument Panel Cluster
(IPC)/EPB SW
F80
20 Amp Yellow
Radio
F81
Not Used
F82
Not Used
F83
20 Amp Blue
Engine Control Module
(ECM)
F84
30 Amp Pink
Electric Park Brake (EPB)
– Left
F85
Not Used
F86
20 Amp Yellow
Horns – If Equipped With
Engine Stop/Start Option
648
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Blade Fuse
Description
F87A
20 Amp Yellow
HID Headlamp Left – If
Equipped Engine Stop/
Start Option
F88
10 Amp Red
Collision Mitigation Mod-
ule (CMM)/
Electrochromatic Mirror/
Haptic Lane Feedback
Module (Half)/Humidity
Sensor– If Equipped
F89
Not Used
F90
Not Used
F91
Not Used
F92
Not Used
F93
40 Amp Green
Brake System Module
(BSM) – Pump Motor – If
Equipped
7
MAINTAINING YOUR VEHICLE
649
Cavity
Cartridge Fuse
Blade Fuse
Description
F94
30 Amp Pink
Electric Park Brake (EPB)
– Right
F95
10 Amp Red
Electrochromatic Mirror/
Rain/Pass. Window SW/
Power Outlet Console
Illumination/Sensor/
Sunroof – If Equipped
F96
10 Amp Red
Occupant Restraint Con-
troller (ORC) (Airbag)
F97
10 Amp Red
Occupant Restraint Con-
troller (ORC) (Airbag)
F98
25 Amp Clear
Audio Amplifier – If
Equipped
F99
Not Used
F100
Not Used
650
MAINTAINING YOUR VEHICLE
Interior Fuses
The interior fuse panel is located in the passenger com-
partment on the left side dash panel under the instru-
ment panel.
Cavity
Blade Fuse
Description
F13
15 Amp Blue
Low Beam Left
F32
10 Amp Red
Interior Lighting
F36
10 Amp Red
Intrusion Module / Siren
F37
7.5 Amp Brown
Aux. Switch Bank Module (ASBM)
F38
20 Amp Yellow
All Doors Lock/Unlock
F43
20 Amp Yellow
Washer Pump Front
F48
20 Amp Yellow
Horns
F49
7.5 Amp Brown
Lumbar Support
F51
10 Amp Red
Driver Window Switch / Power Mirrors – If
Equipped
7
MAINTAINING YOUR VEHICLE
651
Cavity
Blade Fuse
Description
F53
7.5 Amp Brown
UCI Port (USB & AUX)
F89
5 Amp Tan
Trunk Lamp
F91
5 Amp Tan
Fog Lamp Front Left
F92
5 Amp Tan
Fog Lamp Front Right
F93
10 Amp Red
Low Beam Right
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery.
You may:
Disconnect the negative cable from the battery.
Anytime you store your vehicle, or keep it out of
service (i.e. vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
652
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
POWER OUTLET
There are two 12 Volt electrical power outlets on this vehicle
The front 12 Volt power outlet is located on the passenger side of the Center Console, and is
powered when the ignition switch is in the ON/RUN position. The outlet can operate a
conventional cigar lighter unit or power accessories designed for use with a standard power outlet
adapter.
The center console 12 Volt power outlet is powered directly from the battery (power available at
all times). Items plugged into this outlet may discharge the battery and/or prevent the engine
from starting.
NOTE:
Do not exceed the maximum power of
160 Watts (13 Amps) at 12 Volts. If the
160 Watt (13 Amp) power rating is ex-
ceeded, the fuse protecting the system will
need to be replaced.
Power outlets are designed for accessory
plugs only. Do not insert any other object in
the power outlet as this will damage the
outlet and blow the fuse. Improper use of the power outlet can cause damage not covered by
your New Vehicle Limited Warranty.
Front Power Outlet
Center Console Outlet
E L E C T R O N I C S
140
5. Power Distribution Center (Fuses)
6. Battery
7. Washer Fluid Reservoir
8. Engine Oil Dipstick
M A I N TA I N I N G YO U R V E H I C L E
177
ENGINE COMPARTMENT — 3.6L
1. Air Cleaner Filter
2. Engine Coolant Reservoir
3. Brake Fluid Reservoir
4. Power Distribution Center (Fuses)
M A I N TA I N I N G YO U R V E H I C L E
178
FUSES
WARNING!
• When replacing a blown fuse, always use an appropriate replacement fuse with the same
amp rating as the original fuse. Never replace a fuse with another fuse of higher amp rating.
Never replace a blown fuse with metal wires or any other material. Failure to use proper
fuses may result in serious personal injury, fire and/or property damage.
• Before replacing a fuse, make sure that the ignition is off and that all the other services are
switched off and/or disengaged.
• If the replaced fuse blows again, contact an authorized dealer.
• If a general protection fuse for safety systems (air bag system, braking system), power unit
systems (engine system, gearbox system) or steering system blows, contact an authorized
dealer.
Power Distribution Center (Fuses)
The Power Distribution Center is located in the engine compartment near the battery. This
center contains cartridge fuses, mini-fuses, micro-fuses, circuit breakers and relays. A label that
identifies each component is printed on the inside of the cover.
Cavity
Cartridge Fuse
Blade Fuse
Description
F06
Not Used
F07
Not Used
F08
25 Amp Clear
Engine Control Module (ECM)/
Fuel Inj.
F09
Not Used
F10
20 Amp Yellow
Power Transfer Unit (PTU) – If
Equipped
F11
Not Used
F12
20 Amp Yellow
Brake Vacuum Pump – If
Equipped
F13
10 Amp Red
Engine Control Module (ECM)/
VSM (Engine Stop/Start Only)
F14
10 Amp Red
Drivetrain Control Module
(DTCM)/Power Transfer Unit
(PTU) – If Equipped/RDM/
Brake System Module (BSM)/
Brake Pedal Switch/EPB (Electric
Park Brake)
F15
Not Used
F16
20 Amp Yellow
Ignition Coil
F17
Not Used
F18
Not Used
F19
40 Amp Green
Starter Solenoid
M A I N TA I N I N G YO U R V E H I C L E
186
Cavity
Cartridge Fuse
Blade Fuse
Description
F20
10 Amp Red
A/C Compressor Clutch
F21
Not Used
F22
5 Amp Tan
Radiator Fan Enable
F23
70 Amp Tan
Body Controller Module (BCM)
– Feed 2
F23
50 Amp Red
Voltage Stability Module (VSM)
#2 – If Equipped With Engine
Stop/Start Option
F24
Not Used
F25B
20 Amp Yellow
Front Washer Pump – If
Equipped with Engine Stop/Start
Option
F26
Not Used
F27
Not Used
F28
15 Amp Blue
Transmission Control Module
(TCM)
F29
Not Used
F30
10 Amp Red
Engine Control Module (ECM)/
EPS/Fuel Pump Relay Feed
F31
Not Used
F32
Not Used
F33
Not Used
F34
Not Used
F35
Not Used
F36
Not Used
F37
50 Amp Red
Radiator Fan PWM Controller
F38
Not Used
F39
40 Amp Green
HVAC Blower Motor
F40
Not Used
F41
50 Amp Red
Voltage Stability Module (VSM)
#1 – If Equipped With Engine
Stop/Start Option
F41
60 Amp Yellow
Body Controller Module (BCM)
– Feed 1
F42
Not Used
F43
20 Amp Yellow
Fuel Pump Motor
F44
Not Used
F45
30 Amp Pink
Passenger Door Module (PDM)
– If Equipped
F46
25 Amp Clear
Sunroof – If Equipped
F47
Not Used
F48
30 Amp Pink
Driver Door Module (DDM)
M A I N TA I N I N G YO U R V E H I C L E
187
Cavity
Cartridge Fuse
Blade Fuse
Description
F49
30 Amp Pink
Power Inverter (115V A/C) – If
Equipped
F50
30 Amp Pink
Windshield Wiper Smart Motor
(WWSM)
F51
Not Used
F52
Not Used
F53
30 Amp Pink
Brake System Module BSM &
Valves
F54
30 Amp Pink
Body Controller Module (BCM)
– Feed 3
F55
10 Amp Red
Blind Spot Sensors/Compass/
Rearview Camera – If Equipped
F56
15 Amp Blue
Ignition Node Module
(IGNM)/RF Hub
F57
Not Used
F58
10 Amp Red
Occupant Classification Module/
Voltage Stability Module (VSM)
#2 – If Equipped With Engine
Stop/Start Option
F59
30 Amp Pink
Drivetrain Control Module
(DTCM)
F60
20 Amp Yellow
Power Outlet – Center Console
F61
Not Used
F62
Not Used
F63
20 Amp Yellow
Front Heated Seats – If Equipped
F64
20 Amp Yellow
Heated Steering Wheel – If
Equipped
F65
10 Amp Red
In Vehicle Temperature Sensor/
Humidity Sensor/Driver Assist
System Module (DASM)/Park
Assist (PAM) – If Equipped With
Engine Stop/Start Option
F66
15 Amp Blue
Instrument Panel Cluster (IPC)/
(Electronic Climate Control
(ECC)) HVAC
F67
10 Amp Red
In Vehicle Temperature Sensor/
Humidity Sensor/Drivers Assist
System Module (DASM)/Park
Assist (PAM) – If Equipped
F68
Not Used
F69
10 Amp Red
Gear Shift Module (GSM)/
Active Grill Shutter (AGS). – If
Equipped/EPB SW
M A I N TA I N I N G YO U R V E H I C L E
188
Cavity
Cartridge Fuse
Blade Fuse
Description
F70
5 Amp Tan
Intelligent Battery Sensor (IBS) –
If Equipped with Engine Stop/
Start Option
F71
20 Amp Yellow
HID Headlamp Right – If
Equipped with Engine Stop/Start
Option
F72
10 Amp Red
Heated Mirrors – If Equipped
F73
Not Used
F74
30 Amp Pink
Rear Defroster/Defogger
F75
20 Amp Yellow
Cigar Lighter
F76
10 Amp Red
Drivers Window SW– If
Equipped
F77
10 Amp Red
UCI Port/Brake Pedal Switch
F78
10 Amp Red
Diagnostic Port/Steering Column
Control Module (SCCM)
F79
10 Amp Red
Integrated Center Stack (ICS)/
Switch Bank/Instrument Panel
Cluster (IPC)/EPB SW
F80
20 Amp Yellow
Radio
F81
Not Used
F82
Not Used
F83
20 Amp Blue
Engine Control Module (ECM)
F84
30 Amp Pink
Electric Park Brake (EPB) – Left
F85
Not Used
F86
20 Amp Yellow
Horns – If Equipped With Engine
Stop/Start Option
F87A
20 Amp Yellow
HID Headlamp Left – If
Equipped Engine Stop/Start Op-
tion
F88
10 Amp Red
Collision Mitigation Module
(CMM)/Electrochromatic
Mirror/Haptic Lane Feedback
Module (Half)/Humidity Sensor–
If Equipped
F89
Not Used
F90
Not Used
F91
Not Used
F92
Not Used
F93
40 Amp Green
Brake System Module (BSM) –
Pump Motor – If Equipped
F94
30 Amp Pink
Electric Park Brake (EPB) – Right
M A I N TA I N I N G YO U R V E H I C L E
189
Cavity
Cartridge Fuse
Blade Fuse
Description
F95
10 Amp Red
Electrochromatic Mirror/Rain/
Pass. Window SW/Power Outlet
Console Illumination/Sensor/
Sunroof – If Equipped
F96
10 Amp Red
Occupant Restraint Controller
(ORC) (Airbag)
F97
10 Amp Red
Occupant Restraint Controller
(ORC) (Airbag)
F98
25 Amp Clear
Audio Amplifier – If Equipped
F99
Not Used
F100
Not Used
Interior Fuses
The interior fuse panel is located in the passenger compartment on the left side dash panel under
the instrument panel.
Cavity
Blade Fuse
Description
F13
15 Amp Blue
Low Beam Left
F32
10 Amp Red
Interior Lighting
F36
10 Amp Red
Intrusion Module / Siren
F37
7.5 Amp Brown
Aux. Switch Bank Module (ASBM)
F38
20 Amp Yellow
All Doors Lock/Unlock
F43
20 Amp Yellow
Washer Pump Front
F48
20 Amp Yellow
Horns
F49
7.5 Amp Brown
Lumbar Support
F51
10 Amp Red
Driver Window Switch / Power Mirrors – If
Equipped
F53
7.5 Amp Brown
UCI Port (USB & AUX)
F89
5 Amp Tan
Trunk Lamp
F91
5 Amp Tan
Fog Lamp Front Left
F92
5 Amp Tan
Fog Lamp Front Right
F93
10 Amp Red
Low Beam Right
M A I N TA I N I N G YO U R V E H I C L E
190
UTILITY
How do I know how much I can tow with my Chrysler 200? pg. 141
WHAT TO DO IN EMERGENCIES
What do I do if my TPMS warning light is blinking? pg. 144
How do I change a flat tire? pg. 157
How do I Jump-Start my vehicle? pg. 167
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 186
What type of oil do I use? pg. 180
How often should I change my engine’s oil? pg. 182
What should my tire pressure be set at? pg. 194
F R E Q U E N T LY A S K E D Q U E S T I O N S
203