Ram ProMaster - 2016 Fuse Box Diagram

Ram ProMaster - 2016 Fuse Box Diagram

NOTE:
Do not connect devices with power higher than
180 W to the socket. Do not damage the socket by using
unsuitable adaptors.
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of outlet
should be inserted into any 12 Volt outlet.
Do not touch with wet hands.
Close the lid when not in use and while driving the
vehicle.
If this outlet is mishandled, it may cause an electric
shock and failure.
Power Outlet Fuse Locations
1 — F14 Fuse 20 A Yellow Front Power Outlet
2 — F09 Fuse 15 A Blue Rear Power Outlet
126
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
Connections to the switches are found in the right central
pillar fuse panel at the base of the passenger side B pillar.
Auxiliary Switch 1 is configured to constant battery feed,
while Auxiliary Switch 2 is configured to ignition feed.
For further information on using the auxiliary switches,
please refer to the Ram Body Builders Guide by accessing
www.rambodybuilder.com and choosing the appropriate
links.
Auxiliary Upfitter Switches
128
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
INSTRUMENT PANEL FEATURES
Instrument Panel Features Will Vary As Equipped
1 — Air Outlet
10 — Lower Glove Compartment
19 — Uconnect Phone Buttons
2 — Multifunction Lever (External Lights)
11 — Cup Holder
20 — Tilt Steering Column Release Lever
3 — Instrument Cluster
12 — USB Charger/12V
21 — Horn
4 — Multifunction Lever (Front Wiper,
Trip Computer)
13 — Climate Controls
22 — Mute/Uconnect Voice Command
Buttons
5 — Radio (As Equipped)
14 — Lower Switch Ban
23 — Cruise Control Switches
6 — Clip Board
15 — Cup Holders
24 — Fuse Box Lid
7 — Upper Glove Compartment
16 — Gear Selector
25 — Electronic Vehicle Information Center
(EVIC) Controls
8 — Passenger Air Bag
17 — USB / AUX
26 — Hood Release
9 — Storage Compartment
18 — Ignition Switch
136
UNDERSTANDING YOUR INSTRUMENT PANEL
Yellow Telltale Indicator Lights
Stop Light Failure Indicator Light
Yellow Telltale
Light
What It Means
Stop Light Failure Indicator Light
This light will illuminate if one or more of the stop light bulb fails.
The failure relating to this light could be:
One or more blown bulbs
A blown protection fuse
A break in the electrical connection
152
UNDERSTANDING YOUR INSTRUMENT PANEL
External Light Failure Indicator Light — If Equipped
Yellow Telltale
Light
What It Means
External Light Failure Indicator Light — If Equipped
The External Light Failure Indicator will come on when a failure to one of the following
lights is detected:
Direction Indicators
Backup Lights
Parking Lights
Daytime Running Lights
Clearance Lights
License Plate Lights
The failure relating to these lights could be:
One or more blown bulbs
A blown protection fuse
A break in the electrical connection
4
UNDERSTANDING YOUR INSTRUMENT PANEL
153
ENGINE COMPARTMENT — 3.6L
1 — Washer Solvent Reservoir
2 — Engine Oil Fill
3 — Engine Oil Dipstick
4 — Brake Fluid Reservoir
5 — Power Distribution Center (Fuses)
6 — Coolant Reservoir
7 — Power Steering Reservoir
7
MAINTAINING YOUR VEHICLE
367
FUSES
WARNING!
When replacing a blown fuse, always use an ap-
propriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
with another fuse of higher amp rating. Never
replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in
serious personal injury, fire and/or property dam-
age.
Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
(Continued)
WARNING!
(Continued)
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
7
MAINTAINING YOUR VEHICLE
403
Underhood Fuses
The Front Power Distribution Center is located on the
driver’s side of the engine compartment. To access the
fuses, remove the cover.
The ID number of the electrical component correspond-
ing to each fuse can be found on the back of the cover.
Front Power Distribution Center
404
MAINTAINING YOUR VEHICLE
Cavity
Maxi Fuse
Mini Fuse
Description
F01
40 Amp Orange
Electronic Stability Control (ESC) Pump
F02
20 Amp Yellow
(3.6 Gasoline Engine)
Starter Relay 3.6L (3.6 Gasoline Engine)
F02
50 Amp Red
(3.0 Diesel Engine)
Glow Plug Unit (3.0 Diesel Engine)
F04
50 Amp Red
(3.6 Gasoline Engine)
Secondary Power Distribution Center (PDC) (Trans
Power Relay, Vacuum Pump, KL30 for the Shifter
Transmission Module [STM]) (3.6 Gasoline Engine)
F04
40 Amp Orange
(3.0 Diesel Engine)
Fuel Filter Heater (3.0 Diesel Engine)
F05
30 Amp Green
SELESPEED Pump RELE (3.0 Diesel Engine) -
If Equipped
F06
40 Amp Orange
(non A/C)
60 Amp Blue (A/C)
Engine Cooling Fan - 2nd Speed
7
MAINTAINING YOUR VEHICLE
405
Cavity
Maxi Fuse
Mini Fuse
Description
F07
50 Amp Red
(non A/C)
60 Amp Blue (A/C)
Engine Cooling Fan - 1st Speed
F08
40 Amp Orange
Passenger Compartment Blower
F09
15 Amp Blue
Rear Power Outlet
F10
15 Amp Blue
Horn
F11
15 Amp Blue
Fuel Pressure Regulator (MPROP)-DRV
(3.0 Diesel Engine) — If Equipped
F14
20 Amp Yellow
Power Outlet
F15
7.5 Amp Brown
USB Charger
F16
7.5 Amp Brown
KL15 Shifter Transmission Module (STM) (3.6),
KL15 Starter Relay Coil (3.6 Gasoline Engine)
F16
7.5 Amp Brown
KL15 Manual Transmission Automated (MTA),
KL15
Gear Selector Unit, KL15 Engine Control Module
(ECM), KL15 Starter Relay Coil (3.0 Diesel Engine)
406
MAINTAINING YOUR VEHICLE
Cavity
Maxi Fuse
Mini Fuse
Description
F17
20 Amp Yellow
Engine Control Module (ECM), Injectors
(3.6 Gasoline Engine)
F17
20 Amp Yellow
Secondary Loads, Engine Control Module (ECM)
(3.0 Diesel Engine)
F18
7.5 Amp Brown
KL30 Engine Control Module (ECM),
KL30 Main Relay Coil (3.6 Gasoline Engine)
F18
7.5 Amp Brown
KL30 Manual Transmission Automated (MTA),
KL30 Engine Control Module (ECM),
KL30 Main Relay Coil (3.0 Diesel Engine)
F19
7.5 Amp Brown
A/C Compressor (If Equipped)
F20
30 Amp Green
Windshield Wiper
F21
15 Amp Blue
Fuel Pump
F22
20 Amp Yellow
Engine Control Module (ECM), Ignition Coils
(3.6 Gasoline Engine)
F22
20 Amp Yellow
Engine Control Module (ECM), Primary Loads
(3.0 Diesel Engine)
7
MAINTAINING YOUR VEHICLE
407
Cavity
Maxi Fuse
Mini Fuse
Description
F23
20 Amp Yellow
Electronic Stability Control (ESC) Valves
F24
7.5 Amp Brown
KL15 Vacuum pump relay coil (3.6 Gasoline Engine)
— If Equipped
F30
15 Amp Blue
Heated Mirrors
Front PDC Additional Fuses
The additional fuse box is located inside the front PDC
Box.
Front Power Distribution Center Additional Fuses
408
MAINTAINING YOUR VEHICLE
Cavity
Mini Fuse
Description
F61
20 Amp Yellow
Vacuum Pump (3.6 Gasoline Engine) — If Equipped
F62
30 Amp Green
Transmission Power RELE (3.6 Gasoline Engine) —
If Equipped
F64
7.5 Amp Brown
Urea Pump (3.0 Diesel Engine) — If Equipped
F65
25 Amp White
Urea NOX Sensor 1–2 — PM Sensor
(3.0 Diesel Engine) — If Equipped
F66
5 Amp Beige
Shifter Transmission Module (STM)
(3.6 Gasoline Engine) — If Equipped
7
MAINTAINING YOUR VEHICLE
409
Interior Fuses
The interior fuse panel is part of the Body Control
Module (BCM) and is located on the driver’s side under
the instrument panel.
Fuse Panel
410
MAINTAINING YOUR VEHICLE
Fuse Panel Cavity Locations
7
MAINTAINING YOUR VEHICLE
411
Cavity
Mini Fuse
Description
F12
10 Amp Red
Right Low Beam
F13
10 Amp Red
Left Low Beam
F31
5 Amp Beige
INT/A
F32
10 Amp Red
SBMT
F34
7.5 Amp Brown
Clearance Lights
F36
15 Amp Blue
+30 (ACM – TPCU – RRM – DLC)
F37
5 Amp Beige
INT (BRAKE NO – IPC)
F38
15 Amp Blue
Central Locking
F42
5 Amp Beige
INT (BSM – SAS – BRAKE NC)
F43
20 Amp Yellow
Bi-Directional Washer Pump
F47
20 Amp Yellow
Driver Power Window
F48
20 Amp Yellow
Passenger Power Window
F49
5 Amp Beige
INT (PAM – CCS – RRM – ECM)
F50
7.5 Amp Brown
INT (ORC)
F51
5 Amp Beige
INT (REAR CAMERA-AUX)
412
MAINTAINING YOUR VEHICLE
Cavity
Mini Fuse
Description
F53
5 Amp Beige
+30 (IPC)
F90
7.5 Amp Brown
Left High Beam
F91
7.5 Amp Brown
Right High Beam
F92
7.5 Amp Brown
Left Fog Lamp
F93
7.5 Amp Brown
Right Fog Lamp
7
MAINTAINING YOUR VEHICLE
413
Right Central Pillar Fuses
The right central pillar fuse panel is located on the
interior side at the base of the passenger side B pillar.
Fuse Panel Location
Fuse Panel
414
MAINTAINING YOUR VEHICLE
Cavity
Mini Fuse
Description
F81
7.5 Amp Brown
Seat Heater
F83
20 Amp Yellow
Rear Left Windows Heater
F84
20 Amp Yellow
Rear Right Windows Heater
F86
20 Amp Yellow
Auxiliary Switch (From Battery) – If Equipped
F87
20 Amp Yellow
Auxiliary Switch (From Ignition) – If Equipped
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than
21 days, you may want to take these steps to protect your
battery.
Disconnect the negative cable from the battery.
Anytime you store your vehicle, or keep it out of
service (e.g., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
7
MAINTAINING YOUR VEHICLE
415
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
ignition switch is in the MAR/ON position, while the outlets labeled with a “battery”
are connected directly to the battery and powered at all times.
NOTE:
Do not exceed the maximum power of
160 Watts (13 Amps) at 12 Volts. If
the 160 Watt (13 Amp) power rating is
exceeded, the fuse protecting the sys-
tem needs to be replaced.
Power outlets are designed for acces-
sory plugs only. Do not insert any other
object in the power outlet as this will
damage the outlet and blow the fuse.
Improper use of the power outlet can
cause damage not covered by your
New Vehicle Limited Warranty.
Front USB Port and Power Outlet
1 — USB Charge Only Port
2 — Front Power Outlet
Power Outlet Fuses
1 — F14 Fuse 20 Amp Yellow Front Power Outlet
2 — F09 Fuse 15 Amp Blue Rear Power Outlet
ELECT RONICS
67
5. Engine Coolant Reservoir
6. Brake Fluid Reservoir
7. Power Distribution Center (Fuses)
8. Remote Jump Starting Points
MAINTAINING YOUR VEHICLE
117
5. Engine Coolant Reservoir Cap
6. Brake Fluid Reservoir
7. Power Distribution Center (Fuses)
8. Remote Jump Starting Positive
MAINTAINING YOUR VEHICLE
119
FUSES
WARNING!
• When replacing a blown fuse, always use an appropriate replacement fuse with
the same amp rating as the original fuse. Never replace a fuse with another fuse
of higher amp rating. Never replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in serious personal injury, fire
and/or property damage.
• Before replacing a fuse, make sure that the ignition is off and that all the other
services are switched off and/or disengaged.
• If the replaced fuse blows again, contact an authorized dealer.
• If a general protection fuse for safety systems (air bag system, braking system),
power unit systems (engine system, gearbox system) or steering system blows,
contact an authorized dealer.
Underhood Fuses
The Front Power Distribution Center is located on the driver’s side of the engine
compartment. To access the fuses, remove the cover.
The ID number of the electrical component corresponding to each fuse can be found
on the back of the cover.
Cavity
Maxi Fuse
Mini Fuse
Description
F01
40 Amp Orange
Electronic Stability Control
(ESC) Pump
F02
20 Amp Yellow
(3.6 Gasoline
Engine)
Starter Relay 3.6L (3.6 Gaso-
line Engine)
F02
50 Amp Red
(3.0 Diesel En-
gine)
Glow Plug Unit (3.0 Diesel En-
gine)
F04
50 Amp Red
(3.6 Gasoline
Engine)
Secondary Power Distribution
Center (PDC) (Trans Power Re-
lay, Vacuum Pump, KL30 for
the Shifter Transmission Mod-
ule [STM]) (3.6 Gasoline En-
gine)
F04
40 Amp Orange
(3.0 Diesel En-
gine)
Fuel Filter Heater (3.0 Diesel
Engine)
F05
30 Amp Green
SELESPEED Pump RELE
(3.0 Diesel Engine) - If
Equipped
MAINTAINING YOUR VEHICLE
136
Cavity
Maxi Fuse
Mini Fuse
Description
F06
40 Amp Orange
(non A/C)
60 Amp Blue
(A/C)
Engine Cooling Fan - 2nd
Speed
F07
50 Amp Red
(non A/C)
60 Amp Blue
(A/C)
Engine Cooling Fan - 1st
Speed
F08
40 Amp Orange
Passenger Compartment
Blower
F09
15 Amp Blue
Rear Power Outlet
F10
15 Amp Blue
Horn
F11
15 Amp Blue
Fuel Pressure Regulator
(MPROP)-DRV (3.0 Diesel En-
gine) — If Equipped
F14
20 Amp Yellow
Power Outlet
F15
7.5 Amp Brown
USB Charger
F16
7.5 Amp Brown
KL15 Shifter Transmission
Module (STM) (3.6),
KL15 Starter Relay Coil
(3.6 Gasoline Engine)
F16
7.5 Amp Brown
KL15 Manual Transmission
Automated (MTA), KL15 Gear
Selector Unit, KL15 Engine
Control Module (ECM),
KL15 Starter Relay Coil
(3.0 Diesel Engine)
F17
20 Amp Yellow
Engine Control Module (ECM),
Injectors (3.6 Gasoline Engine)
F17
20 Amp Yellow
Secondary Loads, Engine Con-
trol Module (ECM) (3.0 Diesel
Engine)
F18
7.5 Amp Brown
KL30 Engine Control Module
(ECM), KL30 Main Relay Coil
(3.6 Gasoline Engine)
F18
7.5 Amp Brown
KL30 Manual Transmission
Automated (MTA), KL30 En-
gine Control Module (ECM),
KL30 Main Relay Coil
(3.0 Diesel Engine)
F19
7.5 Amp Brown
A/C Compressor (If Equipped)
F20
30 Amp Green
Windshield Wiper
F21
15 Amp Blue
Fuel Pump
F22
20 Amp Yellow
Engine Control Module (ECM),
Ignition Coils (3.6 Gasoline
Engine)
MAINTAINING YOUR VEHICLE
137
Cavity
Maxi Fuse
Mini Fuse
Description
F22
20 Amp Yellow
Engine Control Module (ECM),
Primary Loads (3.0 Diesel En-
gine)
F23
20 Amp Yellow
Electronic Stability Control
(ESC) Valves
F24
7.5 Amp Brown
KL15 Vacuum Pump Relay Coil
(3.6 Gasoline Engine) — If
Equipped
F30
15 Amp Blue
Heated Mirrors
Front PDC Additional Fuses
The additional fuse box is located inside the front PDC Box.
Cavity
Mini Fuse
Description
F61
20 Amp Yellow
Vacuum Pump (3.6 Gasoline Engine) —
If Equipped
F62
30 Amp Green
Transmission Power RELE (3.6 Gasoline
Engine) — If Equipped
F64
7.5 Amp Brown
Urea Pump (3.0 Diesel Engine) — If
Equipped
F65
25 Amp White
Urea NOX Sensor 1–2 — PM Sensor
(3.0 Diesel Engine) — If Equipped
F66
5 Amp Beige
Shifter Transmission Module (STM)
(3.6 Gasoline Engine) — If Equipped
Interior Fuses
The interior fuse panel is part of the Body Control Module (BCM) and is located on the
driver's side under the instrument panel.
Cavity
Mini Fuse
Description
F12
10 Amp Red
Right Low Beam
F13
10 Amp Red
Left Low Beam
F31
5 Amp Beige
INT/A
F32
10 Amp Red
SBMT
F34
7.5 Amp Brown
Clearance Lights
F36
15 Amp Blue
+30 (ACM – TPCU – RRM – DLC)
F37
5 Amp Beige
INT (BRAKE NO – IPC)
F38
15 Amp Blue
Central Locking
F42
5 Amp Beige
INT (BSM – SAS – BRAKE NC)
F43
20 Amp Yellow
Bi-Directional Washer Pump
F47
20 Amp Yellow
Driver Power Window
F48
20 Amp Yellow
Passenger Power Window
MAINTAINING YOUR VEHICLE
138
Cavity
Mini Fuse
Description
F49
5 Amp Beige
INT (PAM – CCS – RRM – ECM)
F50
7.5 Amp Brown
INT (ORC)
F51
5 Amp Beige
INT (REAR CAMERA-AUX)
F53
5 Amp Beige
+30 (IPC)
F90
7.5 Amp Brown
Left High Beam
F91
7.5 Amp Brown
Right High Beam
F92
7.5 Amp Brown
Left Fog Lamp
F93
7.5 Amp Brown
Right Fog Lamp
Right Central Pillar Fuses
The right central pillar fuse panel is located on the interior side at the base of the
passenger side B pillar.
Cavity
Mini Fuse
Description
F81
7.5 Amp Brown
Seat Heater
F83
20 Amp Yellow
Rear Left Windows Heater
F84
20 Amp Yellow
Rear Right Windows Heater
F86
20 Amp Yellow
Auxiliary Switch (From Battery) – If
Equipped
F87
20 Amp Yellow
Auxiliary Switch (From Ignition) – If
Equipped
MAINTAINING YOUR VEHICLE
139
FREQUENTLY ASKED QUESTIONS
GETTING STARTED
Where are the controls for the Heated Seats? pg. 22
How to adjust your seat? pg. 17
ELECTRONICS
Which radio is in my vehicle?
Uconnect RH3 pg. 40
Uconnect 5.0 pg. 43
How do I activate the Audio Jack?
Uconnect RH3 pg. 42
Uconnect 5.0 pg. 47
How do I set the clock on my radio?
Uconnect RH3 pg. 40
Uconnect 5.0 pg. 43
How do I pair my cell phone via Bluetooth with the Uconnect Hands-Free Voice
Activation System? pg. 55
How to use the power outlet? pg. 66
UTILITY
How do I know how much I can tow with my Ram ProMaster? pg. 68
WHAT TO DO IN EMERGENCIES
What do I do if my TPMS warning light is blinking? pg. 87
How do I change a flat tire? pg. 92
How do I Jump-Start my vehicle? pg. 108
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 136
What type of oil do I use 3.6L gasoline engine? pg. 120
What type of oil do I use 3.0L diesel engine? pg. 122
How often should I change my engine’s oil? pg. 124
What should my tire pressure be set at? pg. 140
FAQ’s
148