Ram Cargo Van - 2015 Fuse Box Diagram

Ram Cargo Van - 2015 Fuse Box Diagram

CAUTION!
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system
will need to be replaced.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
One outlet in the removable floor console (if equipped)
shares a fuse with the lower outlet in the instrument
panel and is also connected to the battery. Do not exceed
a
maximum
power
of
160
Watts
(13 Amps)
shared
between the lower panel outlet and the removable floor
console outlet.
On vehicles equipped with the Super Console the power
outlets are located under the retractable cover. To access
the power outlets push down on the cover and slide it
toward the instrument panel.
Removable Console Outlet
242
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of outlet
should be inserted into any 12 Volt outlet.
Do not touch with wet hands.
Close the lid when not in use and while driving the
vehicle.
If this outlet is mishandled, it may cause an electric
shock and failure.
Power Outlet Fuses
1 — M7 Fuse 20 A Yellow Power Outlet Center Seat (Opt) or with
Console Rear
2 — M6 Fuse 20 A Yellow Cigar Lighter Instrument Panel or with
Console Front
3 — M36 Fuse 20 A Yellow Power Outlet Instrument Panel or
with Console Center
244
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
NOTE:
Some of the above warnings will be displayed in
the Electronic Vehicle Information Center Display Area
located in the instrument cluster.
Refer to ”Electronic Vehicle Information Center (EVIC) —
If Equipped” in this section for further information.
LoW tirE
When the appropriate condition exists, the odometer
display will toggle between LoW and tirE for three
cycles.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and push the
STEP button
on
the
steering
wheel
to
turn
off
the
message. If the problem continues, the message will
appear the next time the vehicle is started.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations, refer to “Fuses” in “Maintaining Your
Vehicle.”
CHAngE OIL
Your vehicle is equipped with an engine oil change
indicator system. The
CHAngE OIL
message will flash in
the instrument cluster odometer for approximately 12
seconds, after a single chime has sounded, to indicate the
next scheduled oil change interval. The engine oil change
indicator system is duty cycle-based, which means the
engine oil change interval may fluctuate dependent upon
your personal driving style.
Unless reset, this message will continue to display each
time you turn the ignition switch to the ON/RUN
4
UNDERSTANDING YOUR INSTRUMENT PANEL
287
ENGINE COMPARTMENT — 3.6L
1 — Air Filter
6 — Engine Coolant Reservoir
2 — Power Steering Fluid Reservoir
7 — Engine Oil Dipstick
3 — Brake Fluid Reservoir
8 — Engine Oil Fill
4 — Battery
9 — Coolant Pressure Cap
5 — Totally Integrated Power Module (Fuses)
10 — Washer Fluid Reservoir
7
MAINTAINING YOUR VEHICLE
567
Cleaning The Instrument Panel Cupholders
Removal
Pull the flexible liner from the cupholder drawer starting
at one edge to ease removal.
Cleaning
The liner is top shelf dishwasher safe, or you may follow
the cleaning procedure below.
Soak the liner in a mixture of medium hot tap water and
one teaspoon of mild liquid dish soap. Let soak for
approximately 30 minutes. After 30 minutes, pull the
liner from the water and dip it back into the water about
six times. This will loosen any remaining debris. Rinse
the liner thoroughly under warm running water. Shake
the excess water from the liner and dry the outer surfaces
with a clean soft cloth.
Installation
Place the liner into the cupholder drawer and press the
liner into place so that the retention tabs seat into the
corresponding openings in the drawer.
FUSES
WARNING!
When replacing a blown fuse, always use an ap-
propriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
with another fuse of higher amp rating. Never
replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in
serious
personal
injury,
fire
and/or
property
damage.
(Continued)
7
MAINTAINING YOUR VEHICLE
601
WARNING!
(Continued)
Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
Totally Integrated Power Module (Fuses)
The Totally Integrated Power Module is located in the
engine compartment near the battery. Refer to the appli-
cable “Engine Compartment” illustration in this section.
This center contains cartridge fuses and mini-fuses. A
label that identifies each component may be printed or
embossed on the inside of the cover.
602
MAINTAINING YOUR VEHICLE
CAUTION!
When installing the Totally Integrated Power Mod-
ule cover, it is important to ensure the cover is
properly positioned and fully latched. Failure to do
(Continued)
CAUTION!
(Continued)
so may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.
The numbers inside the TIPM cover correspond to the
following table.
Totally Integrated Power Module
7
MAINTAINING YOUR VEHICLE
603
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Clear
Driver Door Node
J5
25 Amp Clear
Passenger Door Node
J6
40 Amp Green
Antilock Brakes Pump/Stability Control
System
J7
30 Amp Pink
Antilock Brakes Valve/Stability Control
System
J8
40 Amp Green
Power Memory Seat – If Equipped
J9
40 Amp Green
Partial Zero Emissions Vehicle Motor/Flex
Fuel – If Equipped
J10
30 Amp Pink
Headlamp Wash/Manifold Tuning Valve –
If Equipped
604
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
J11
30 Amp Pink
Power Sliding Door Module/Anti–Theft
Module – If Equipped
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan Motor
J13
60 Amp Yellow
Ignition Off Draw (IOD) – Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Clear
Sunroof Module
M1
15 Amp Blue
Rear Center Brake Lamp/Brake Switch
M2
20 Amp Yellow
Front Fog Lamps
7
MAINTAINING YOUR VEHICLE
605
Cavity
Cartridge Fuse
Mini-Fuse
Description
M3
20 Amp Yellow
Front/Rear Axle Locker, Vacuum Pump
Motor
M4
10 Amp Red
Trailer Tow
M5
25 Amp Clear
Inverter
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sensor, Cigar
Lighter (Instrument Panel or with Console
Rear)
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC SELECT) –
Center Seat or with Console Rear
M8
20 Amp Yellow
Front Heated Seat – If Equipped
M9
20 Amp Yellow
Rear Heated Seat – If Equipped
M10
15 Amp Blue
Ignition Off Draw — Video System, Satel-
lite Radio, DVD, Hands-Free Module, Uni-
versal Garage Door Opener, Vanity Lamp,
Streaming Video Module – If Equipped
M11
10 Amp Red
Climate Control System
606
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
M12
30 Amp Green
Amplifier/Radio
M13
20 Amp Yellow
Instrument Cluster, SIREN, Clock Module,
Multi-Function Control Switch – If
Equipped
M14
20 Amp Yellow
Trailer Tow – If Equipped
M15
20 Amp Yellow
Rear View Mirror, Instrument Cluster,
Multi-Function Control Switch, Tire Pres-
sure Monitor, Glow Plug Module – If
Equipped
M16
10 Amp Red
Airbag Module/Occupant Classification
Module
M17
15 Amp Blue
Left Tail/License/Park Lamp, Running
Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
M19
25 Amp Clear
Powertrain
7
MAINTAINING YOUR VEHICLE
607
Cavity
Cartridge Fuse
Mini-Fuse
Description
M20
15 Amp Blue
Instrument Cluster Interior Light, Switch
Bank, Steering Column Module, Switch
Steering Wheel
M21
20 Amp Yellow
Powertrain
M22
10 Amp Red
Horn
M23
10 Amp Red
Horn
M24
25 Amp Clear
Rear Wiper
M25
20 Amp Yellow
Fuel Pump, Diesel Lift Pump – If
Equipped
M26
10 Amp Red
Power Mirror Switch, Driver Window
Switch
M27
10 Amp Red
Wireless Control Module, Keyless Entry
Module
M28
10 Amp Red
Powertrain, Transmission Control Module
M29
10 Amp Red
Occupant Classification Module
608
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
M30
15 Amp Blue
Rear Wiper Module, Power Folding Mirror
M31
20 Amp Yellow
Back-Up Lamps
M32
10 Amp Red
Airbag Module, THATCHUM – If
Equipped
M33
10 Amp Red
Powertrain
M34
10 Amp Red
Park Assist, Heater Climate Control Mod-
ule, Headlamp Wash, Compass, Rear Cam-
era, Door Lamps, Flashlight, Relay Diesel
Cabin Heater, Rad Fan Diesel – If Equipped
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet #3 (Instrument Panel or with
Console Center)
M37
10 Amp Red
Antilock Brakes, Stability Control, Stop
Lamp, Fuel Pump
M38
25 Amp Clear
Door Lock/Unlock Motors, Liftgate Lock/
Unlock Motors
7
MAINTAINING YOUR VEHICLE
609
The power windows are fused by a 25 Amp circuit
breaker located in the Totally Integrated Power Module.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take steps to protect your battery.
You may do the following:
Remove the 60 Amp cartridge in the Totally Integrated
Power
Module
(TIPM)
labeled
Ignition-Off
Draw
(IOD).
Or, disconnect the negative cable from the battery.
Anytime you store your vehicle, or keep it out of
service for two weeks or more, run the air conditioning
system at idle for about five minutes in the fresh air
and high blower setting. This will ensure adequate
system lubrication to minimize the possibility of com-
pressor damage when the system is started again.
610
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
ENGINE COMPARTMENT
3.6L Engine
1. Air Cleaner Filter
2. Brake Fluid Reservoir
3. Integrated Power Module (Fuses)
4. Battery
5. Engine Coolant Reservoir
MAINTAINING YOUR VEHICLE
100
FUSES
Totally Integrated Power Module (Fuses)
The Totally Integrated Power Module is located in the engine compartment near the
battery. Refer to the applicable “Engine Compartment” illustration in this section.
This center contains cartridge fuses and mini-fuses. A label that identifies each
component may be printed or embossed on the inside of the cover.
CAUTION!
• When installing the Totally Integrated Power Module cover, it is important to
ensure the cover is properly positioned and fully latched. Failure to do so may
allow water to get into the Integrated Power Module, and possibly result in a
electrical system failure.
• When replacing a blown fuse, it is important to use only a fuse having the correct
amperage rating. The use of a fuse with a rating other than indicated may result
in a dangerous electrical system overload. If a properly rated fuse continues to
blow, it indicates a problem in the circuit that must be corrected.
The numbers inside the TIPM cover correspond to the following table.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Clear
Driver Door Node
J5
25 Amp Clear
Passenger Door Node
J6
40 Amp Green
Antilock Brakes Pump/Stability Control
System
J7
30 Amp Pink
Antilock Brakes Valve/Stability Control
System
J8
40 Amp Green
Power Memory Seat – If Equipped
J9
40 Amp Green
Partial Zero Emissions Vehicle Motor/Flex
Fuel – If Equipped
J10
30 Amp Pink
Headlamp Wash/Manifold Tuning Valve –
If Equipped
J11
30 Amp Pink
Power Sliding Door Module/Anti–Theft
Module – If Equipped
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan Motor
J13
60 Amp Yellow
Ignition Off Draw (IOD) – Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module Trans Range
MAINTAINING YOUR VEHICLE
109
Cavity
Cartridge Fuse
Mini-Fuse
Description
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Clear
Sunroof Module
M1
15 Amp Blue
Rear Center Brake Lamp/Brake Switch
M2
20 Amp Yellow
Front Fog Lamps
M3
20 Amp Yellow
Front/Rear Axle Locker, Vacuum Pump
Motor
M4
10 Amp Red
Trailer Tow
M5
25 Amp Clear
Inverter
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sensor, Ci-
gar Lighter (Instrument Panel or with
Console Rear)
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC SELECT) –
Center Seat or with Console Rear
M8
20 Amp Yellow
Front Heated Seat – If Equipped
M9
20 Amp Yellow
Rear Heated Seat – If Equipped
M10
15 Amp Blue
Ignition Off Draw — Video System, Satel-
lite Radio, DVD, Hands-Free Module,
Universal Garage Door Opener, Vanity
Lamp, Streaming Video Module – If
Equipped
M11
10 Amp Red
Climate Control System
M12
30 Amp Green
Amplifier/Radio
M13
20 Amp Yellow
Instrument Cluster, SIREN, Clock Mod-
ule, Multi-Function Control Switch – If
Equipped
M14
20 Amp Yellow
Trailer Tow – If Equipped
M15
20 Amp Yellow
Rear View Mirror, Instrument Cluster,
Multi-Function Control Switch, Tire Pres-
sure Monitor, Glow Plug Module – If
Equipped
M16
10 Amp Red
Airbag Module/Occupant Classification
Module
M17
15 Amp Blue
Left Tail/License/Park Lamp, Running
Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
M19
25 Amp Clear
Powertrain
M20
15 Amp Blue
Instrument Cluster Interior Light, Switch
Bank, Steering Column Module, Switch
Steering Wheel
M21
20 Amp Yellow
Powertrain
M22
10 Amp Red
Horn
MAINTAINING YOUR VEHICLE
110
Cavity
Cartridge Fuse
Mini-Fuse
Description
M23
10 Amp Red
Horn
M24
25 Amp Clear
Rear Wiper
M25
20 Amp Yellow
Fuel Pump, Diesel Lift Pump – If
Equipped
M26
10 Amp Red
Power Mirror Switch, Driver Window
Switch
M27
10 Amp Red
Wireless Control Module, Keyless Entry
Module
M28
10 Amp Red
Powertrain, Transmission Control Module
M29
10 Amp Red
Occupant Classification Module
M30
15 Amp Blue
Rear Wiper Module, Power Folding Mirror
M31
20 Amp Yellow
Back-Up Lamps
M32
10 Amp Red
Airbag Module, THATCHUM – If
Equipped
M33
10 Amp Red
Powertrain
M34
10 Amp Red
Park Assist, Heater Climate Control Mod-
ule, Headlamp Wash, Compass, Rear
Camera, Door Lamps, Flashlight, Relay
Diesel Cabin Heater, Rad Fan Diesel – If
Equipped
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet #3 (Instrument Panel or
with Console Center)
M37
10 Amp Red
Antilock Brakes, Stability Control, Stop
Lamp, Fuel Pump
M38
25 Amp Clear
Door Lock/Unlock Motors, Liftgate Lock/
Unlock Motors
The power windows are fused by a 25 Amp circuit breaker located in the Totally
Integrated Power Module.
MAINTAINING YOUR VEHICLE
111
UTILITY
How do I know how much I can tow with my Ram Cargo Van? pg. 74
WHAT TO DO IN EMERGENCIES
What do I do if my TPMS warning light is blinking? pg. 77
How do I change a flat tire? pg. 83
How do I Jump-Start my vehicle? pg. 95
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 109
What type of oil do I use? pg. 102
How often should I change my engine’s oil? pg. 104
What should my tire pressure be set at? pg. 112
FREQUENTL Y ASKED QUESTIONS
123