Ram 3500 - 2014 Fuse Box Diagram

Ram 3500 - 2014 Fuse Box Diagram

WARNING!
(Continued)
modify the air bag system for persons with dis-
abilities, contact your authorized dealer.
Air Bag Warning Light
You will want to have the air bags ready to
inflate for your protection in a collision. The
Air Bag Warning Light monitors the internal
circuits and interconnecting wiring associated
with air bag system electrical components. While the air
bag system is designed to be maintenance free, if any of
the following occurs, have an authorized dealer service
the air bag system immediately.
The Air Bag Warning Light does not come on during
the four to eight seconds when the ignition switch is
first turned to the ON/RUN position.
The Air Bag Warning Light remains on after the four to
eight second interval.
The Air Bag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The air bags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper air bag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
This vehicle is equipped with an event data recorder
(EDR). The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as an air
bag deployment or hitting a road obstacle, data that will
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
79
A key symbol indicates that the key must be in the
ON/RUN or ACC positions for the outlet to provide
power. The battery symbol indicates that the outlet is
connected to the battery, and can provide power at all
times.
NOTE:
To ensure proper operation, a MOPAR® knob
and element must be used.
The auxiliary power outlets can be found in the following
locations:
CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watts (13 Amps)
power rating is exceeded, the fuse protecting the
system will need to be replaced.
(Continued)
CAUTION!
(Continued)
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
220
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
ENGINE COMPARTMENT — 3.6L
1 — Air Cleaner Filter
5 — Battery
2 — Engine Oil Dipstick
6 — Washer Fluid Reservoir
3 — Engine Oil Fill
7 — Power Distribution Center (Fuses)
4 — Brake Fluid Reservoir
8 — Engine Coolant Reservoir
7
MAINTAINING YOUR VEHICLE
681
ENGINE COMPARTMENT — 5.7L
1 — Air Cleaner Filter
7 — Washer Fluid Reservoir
2 — Automatic Transmission Dipstick (6-Speed Trans Only)
8 — Power Distribution Center (Fuses)
3 — Engine Oil Fill
9 — Power Steering Fluid Reservoir (2500/3500 Models Only)
4 — Engine Oil Dipstick
10 — Coolant Pressure Cap
5 — Brake Fluid Reservoir
11 — Engine Coolant Reservoir
6 — Battery
682
MAINTAINING YOUR VEHICLE
ENGINE COMPARTMENT — 6.4L
1 — Coolant Pressure Bottle
6 — Battery
2 — Transmission Dipstick
7 — Power Distribution Center (Fuses)
3 — Engine Oil Fill
8 — Washer Solvent
4 — Engine Oil Dipstick
9 — Power Steering Fluid Reservoir
5 — Brake Fluid Reservoir
10 — Air Cleaner Filter
7
MAINTAINING YOUR VEHICLE
683
Repairing The Spray-On Bedliner
While
extremely
tough,
it
is
possible
to
damage
a
Spray-On
Bedliner.
One
common
condition
is
when
loading a heavy pallet and dragging that pallet across the
floor of the bed. If a nail or sharp point is exposed under
the weight of the pallet a scratch or tear is possible. While
not covered by your new vehicle warranty, a cosmetic fix
to cover the metal exposed by the scratch is required. To
repair a tear or gouge, follow the directions provided in
the MOPAR® Quick Repair Kit.
FUSES
WARNING!
When replacing a blown fuse, always use an ap-
propriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
(Continued)
WARNING!
(Continued)
with another fuse of higher amp rating. Never
replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in
serious personal injury, fire and/or property dam-
age.
Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
724
MAINTAINING YOUR VEHICLE
Power Distribution Center
The Power Distribution Center is located in the engine
compartment near the battery. This center contains car-
tridge fuses, micro fuses, relays, and circuit breakers. A
description of each fuse and component may be stamped
on the inside cover, otherwise the cavity number of each
fuse is stamped on the inside cover that corresponds to
the following chart.
Cavity
Cartridge Fuse
Micro Fuse
Description
F01
80 Amp Red
Rad Fan Control Module – If equipped
F03
60 Amp Yellow
Rad Fan – If Equipped
F05
40 Amp Green
Compressor for Air Suspension – If
Equipped
Power Distribution Center Location
7
MAINTAINING YOUR VEHICLE
725
Cavity
Cartridge Fuse
Micro Fuse
Description
F06
40 Amp Green
Antilock Brakes/Electronic Stability Con-
trol Pump
F07
40 Amp Green
Starter Solenoid
F08
20 Amp Yellow
Emissions Diesel – If Equipped
F09
40 Amp Green
(Cummins Diesel)
30 Amp Pink (1500
LD Diesel)
Diesel Fuel Heater – If Equipped
F10
40 Amp Green
Body Controller / Exterior Lighting #2
F10
50 Amp Red
Body Controller / Exterior Lighting #2 – If
Equipped with Stop/Start
F11
30 Amp Pink
Integrated Trailer Brake Module – If
Equipped
F12
40 Amp Green
Body Controller #3 / Interior Lights
F13
40 Amp Green
Blower Motor
F14
40 Amp Green
Body Controller #4 / Power Locks
726
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F15
30 Amp Pink
Electric Park Brake Right Side – If
Equipped
F19
30 Amp Pink
SCR – If Equipped
F20
30 Amp Pink
Passenger Door Module
F21
30 Amp Pink
Drive Train Control Module
F22
20 Amp Yellow
Engine Control Module
F23
30 Amp Pink
Body Controller #1
F24
30 Amp Pink
Driver Door Module
F25
30 Amp Pink
Front Wiper Low Speed
F25
30 Amp Pink
Front Wiper High Speed
F26
30 Amp Pink
Antilock Brakes/Stability Control
Module/Valves
F28
20 Amp Yellow
Trailer Tow Backup Lights – If Equipped
F29
20 Amp Yellow
Trailer Tow Parking Lights – If Equipped
F30
30 Amp Pink
Trailer Tow Receptacle
7
MAINTAINING YOUR VEHICLE
727
Cavity
Cartridge Fuse
Micro Fuse
Description
F32
30 Amp Pink
Drive Train Control Module – If Equipped
F33
20 Amp Yellow
Cummins Diesel Fuel Heater #1 – If
Equipped / Rear Blower – If Equipped
F34
30 Amp Pink
Vehicle System Interface Module #2 – If
Equipped
F35
30 Amp Pink
Sunroof – If Equipped
F36
30 Amp Pink
Rear Defroster– If Equipped
F37
30 Amp Pink
Cummins Diesel Fuel Heater #2 If
Equipped
F38
30 Amp Pink
Power Inverter 115V AC– If Equipped
F39
30 Amp Pink
Vehicle System Interface Module #1– If
Equipped
F41
10 Amp Red
Active Grill Shutter
F42
20 Amp Yellow
Horn
F43
10 Amp Red
Snow Plow (Left) – If Equipped
728
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F44
10 Amp Red
Diagnostic Port
F46
10 Amp Red
Tire Pressure Monitor
F47
10 Amp Red
Snow Plow (Right) – If Equipped
F49
10 Amp Red
Instrument Panel Cluster
F50
20 Amp Yellow
Air Suspension Control Module – If
Equipped
F51
10 Amp Red
Ignition Node Module / Keyless Ignition
F52
5 Amp Tan
Battery Sensor
F53
20 Amp Yellow
Trailer Tow – Left Turn/Stop Lights
F54
20 Amp Yellow
Adjustable Pedals
F55
20 Amp Yellow
E38 Radio – If Equipped
F56
15 Amp Blue
Additional Diesel Content – If Equipped
F57
20 Amp Yellow
Transmission
7
MAINTAINING YOUR VEHICLE
729
Cavity
Cartridge Fuse
Micro Fuse
Description
F58
20 Amp Yellow
(Gas Engine) / 25
Amp Natural
(Cummins Diesel
Engine)
Engine Cooling Pump
F60
15 Amp Blue
Underhood Lamp
F61
20 Amp Yellow
Power Take-off Unit – If Equipped
F62
10 Amp Red
Air Conditioning Clutch
F63
20 Amp Yellow
Ignition Coils (Gas), Urea Heater (Cum-
mins Diesel)
F64
25 Amp Natural
Fuel Injectors / Powertrain
F65
10 Amp Red
USB interface
F66
10 Amp Red
Sunroof / Passenger Window Switches /
Rain Sensor
F67
10 Amp Red
CD / DVD / Bluetooth Hands-free Mod-
ule – If Equipped
730
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F69
15 Amp Blue
Mod SCR 12V (Cummins Diesel) – If
Equipped
F70
30 Amp Green
Fuel Pump Motor
F71
25 Amp Natural
Amplifier
F72
10 Amp Red
Voltage Stabilizer Modules – If Equipped
F74
20 Amp Yellow
(Gas Engine & 1500
LD Diesel) / 10
Amp Red (Cum-
mins Diesel Engine)
Brake Vacuum Pump Gas/Diesel – If
Equipped
F75
10 Amp Red
Coolant Temperature Valve Actuator
F76
10 Amp Red
Antilock Brakes/Electronic Stability Control
F77
10 Amp Red
Drivetrain Control Module/Front Axle
Disconnect Module
F78
10 Amp Red
Engine Control Module / Electric Power
Steering
7
MAINTAINING YOUR VEHICLE
731
Cavity
Cartridge Fuse
Micro Fuse
Description
F79
15 Amp Blue
Clearance Lights
F80
10 Amp Red
Universal Garage Door Opener / Compass
F81
20 Amp Yellow
Trailer Tow Right Turn/Stop Lights
F82
10 Amp Red
Steering Column Control Module/ Cruise
Control
F84
15 Amp Blue
Switch Bank/Instrument Cluster
F85
10 Amp Red
Airbag Module
F86
10 Amp Red
Airbag Module
F87
10 Amp Red
Air Suspension-If Equipped / Trailer Tow
/ Steering Column Control Module
F88
15 Amp Blue
Instrument Panel Cluster
F90/F91
20 Amp Yellow
Power Outlet (Rear seats) Customer Select-
able
F93
20 Amp Yellow
Cigar Lighter
F94
10 Amp Red
Shifter / Transfer Case Module
732
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Micro Fuse
Description
F95
10 Amp Red
Rear Camera / Park Assist
F96
10 Amp Red
Rear Seat Heater Switch
F97
25 Amp Natural
Rear Heated Seats & Heated Steering
Wheel – If Equipped
F98
25 Amp Natural
Front Heated Seats – If Equipped
F99
10 Amp Red
Climate Control
F101
15 Amp Blue
Electrochromatic Mirror / Smart High
Beams – If Equipped
F104
20 Amp Yellow
Power Outlets (Instrument Panel/Center
Console)
7
MAINTAINING YOUR VEHICLE
733
CAUTION!
When installing the power distribution center cover,
it is important to ensure the cover is properly posi-
tioned and fully latched. Failure to do so may allow
water to get into the power distribution center and
possibly result in an electrical system failure.
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.
VEHICLE STORAGE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to mini-
mize the drain on your vehicle’s battery:
Disconnect the negative cable from battery.
Any time you store your vehicle or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
734
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
POWER OUTLETS
The auxiliary 12 Volt (13 Amp) power outlets can provide power for in-cab accesso-
ries designed for use with the standard “cigar lighter” plug. The 12 Volt power outlets
have a cap attached to the outlet indicating “12V DC”, together with either a key
symbol or a battery symbol.
The auxiliary power outlets can be found in the following locations:
Lower left and lower right in the center of the instrument panel – if equipped with
a column or a eight-speed electronic shifter.
Inside the top storage tray.
Inside the upper lid of the center stor-
age compartment — if equipped.
Rear of the center console storage
compartment — Quad Cab
®
or Crew
Cab.
NOTE:
Do not exceed the maximum power of
160 Watts (13 Amps) at 12 Volts. If
the 160 Watt (13 Amp) power rating is
exceeded, the fuse protecting the sys-
tem will need to be replaced.
Power outlets are designed for acces-
sory plugs only. Do not insert any other
object in the power outlet as this will
damage the outlet and blow the fuse.
Improper use of the power outlet can
cause damage not covered by your new
vehicle warranty.
ELECTRONICS
128
The rear center console power outlet can be switched to “battery” powered all the
time by switching the power outlet right rear quarter panel fuse in the fuse panel.
ELECTRONICS
129
FUSES
POWER DISTRIBUTION CENTER (FUSES)
The Power Distribution Center is located
in the engine compartment near the bat-
tery. This center contains cartridge fuses
and mini fuses. A description of each
fuse and component may be stamped on
the inside cover, otherwise the cavity
number of each fuse is stamped on the
inside cover that corresponds to the fol-
lowing chart.
Cavity
Cartridge Fuse
Micro Fuse
Description
F01
80 Amp Red
Rad Fan Control Module – If
Equipped
F03
60 Amp Yellow
Rad Fan – If Equipped
F05
40 Amp Green
Compressor for Air Suspension –
If Equipped
F06
40 Amp Green
Antilock Brakes/Electronic
Stability Control Pump
F07
40 Amp Green
Starter Solenoid
F08
20 Amp Yellow
Emissions Diesel – If Equipped
F09
40 Amp Green
(Cummins
Diesel)
30 Amp Pink
(1500 LD
Diesel)
Diesel Fuel Heater – If Equipped
F10
40 Amp Green
Body Controller/Exterior
Lighting #2
F10
50 Amp Red
Body Controller/Exterior
Lighting #2 – If Equipped with
Stop/Start
F11
30 Amp Pink
Integrated Trailer Brake Module
– If Equipped
F12
40 Amp Green
Body Controller #3/Interior
Lights
F13
40 Amp Green
Blower Motor
F14
40 Amp Green
Body Controller #4/Power Locks
F15
30 Amp Pink
Electric Park Brake Right Side –
If Equipped
F19
30 Amp Pink
SCR – If Equipped
F20
30 Amp Pink
Passenger Door Module
F21
30 Amp Pink
Drive Train Control Module
MAINTAINING YOUR VEHICLE
242
Cavity
Cartridge Fuse
Micro Fuse
Description
F22
20 Amp Yellow
Engine Control Module
F23
30 Amp Pink
Body Controller #1
F24
30 Amp Pink
Driver Door Module
F25
30 Amp Pink
Front Wiper Low Speed
F25
30 Amp Pink
Front Wiper High Speed
F26
30 Amp Pink
Antilock Brakes/Stability Control
Module/Valves
F28
20 Amp Yellow
Trailer Tow Backup Lights – If
Equipped
F29
20 Amp Yellow
Trailer Tow Parking Lights – If
Equipped
F30
30 Amp Pink
Trailer Tow Receptacle
F32
30 Amp Pink
Drive Train Control Module – If
Equipped
F33
20 Amp Yellow
Cummins Diesel Fuel Heater #1
– If Equipped/Rear Blower – If
Equipped
F34
30 Amp Pink
Vehicle System Interface
Module #2 – If Equipped
F35
30 Amp Pink
Sunroof – If Equipped
F36
30 Amp Pink
Rear Defroster – If Equipped
F37
30 Amp Pink
Cummins Diesel Fuel Heater #2
– If Equipped
F38
30 Amp Pink
Power Inverter 115V AC –
If Equipped
F39
30 Amp Pink
Vehicle System Interface
Module #1 – If Equipped
F41
10 Amp Red
Active Grill Shutter
F42
20 Amp Yellow
Horn
F43
10 Amp Red
Snow Plow (Left) – If Equipped
F44
10 Amp Red
Diagnostic Port
F46
10 Amp Red
Tire Pressure Monitor
F47
10 Amp Red
Snow Plow (Right) – If Equipped
F49
10 Amp Red
Instrument Panel Cluster
F50
20 Amp Yellow
Air Suspension Control Module –
If Equipped
F51
10 Amp Red
Ignition Node Module/Keyless
Ignition
F52
5 Amp Tan
Battery Sensor
F53
20 Amp Yellow
Trailer Tow – Left Turn/Stop
Lights
F54
20 Amp Yellow
Adjustable Pedals
MAINTAINING YOUR VEHICLE
243
Cavity
Cartridge Fuse
Micro Fuse
Description
F55
20 Amp Yellow
E38 Radio – If Equipped
F56
15 Amp Blue
Additional Diesel Content – If
Equipped
F57
20 Amp Yellow
Transmission
F58
20 Amp Yellow
(Gas Engine) /
25 Amp Natu-
ral (Cummins
Diesel)
Engine Cooling Pump
F60
15 Amp Blue
Underhood Lamp
F61
20 Amp Yellow
Power Take-off Unit – If
Equipped
F62
10 Amp Red
Air Conditioning Clutch
F63
20 Amp Yellow
Ignition Coils (Gas), Urea Heater
(Cummins Diesel)
F64
25 Amp
Natural
Fuel Injectors/Powertrain
F65
10 Amp Red
USB interface
F66
10 Amp Red
Sunroof/Passenger Window
Switches/Rain Sensor
F67
10 Amp Red
CD/DVD/Bluetooth Hands-free
Module – If Equipped
F69
15 Amp Blue
Mod SCR 12V (Cummins Diesel)
– If Equipped
F70
30 Amp Green
Fuel Pump Motor
F71
25 Amp
Natural
Amplifier
F72
10 Amp Red
Voltage Stabilizer Modules – If
Equipped
F74
20 Amp Yellow
(Gas &
1500 LD
Diesel)/10 Amp
Red (Cummins
Diesel Engine)
Brake Vacuum Pump Gas/Diesel
– If Equipped
F75
10 Amp Red
Coolant Temperature Valve
Actuator
F76
10 Amp Red
Antilock Brakes/Electronic
Stability Control
F77
10 Amp Red
Drivetrain Control Module/Front
Axle Disconnect Module
F78
10 Amp Red
Engine Control Module/Electric
Power Steering
F79
15 Amp Blue
Clearance Lights
MAINTAINING YOUR VEHICLE
244
Cavity
Cartridge Fuse
Micro Fuse
Description
F80
10 Amp Red
Universal Garage Door
Opener/Compass
F81
20 Amp Yellow
Trailer Tow Right Turn/Stop
Lights
F82
10 Amp Red
Steering Column Control
Module/Cruise Control
F84
15 Amp Blue
Switch Bank/Instrument Cluster
F85
10 Amp Red
Airbag Module
F86
10 Amp Red
Airbag Module
F87
10 Amp Red
Air Suspension/Trailer Tow/
Steering Column Control Module
F88
15 Amp Blue
Instrument Panel Cluster
F90/F91
20 Amp Yellow
Power Outlet (Rear seats)
Customer Selectable
F93
20 Amp Yellow
Cigar Lighter
F94
10 Amp Red
Shifter/Transfer Case Module
F95
10 Amp Red
Rear Camera/Park Assist
F96
10 Amp Red
Rear Seat Heater Switch
F97
25 Amp
Natural
Rear Heated Seats & Heated
Steering Wheel – If Equipped
F98
25 Amp
Natural
Front Heated Seats – If
Equipped
F99
10 Amp Red
Climate Control
F101
15 Amp Blue
Electrochromatic Mirror/Smart
High Beams – If Equipped
F104
20 Amp Yellow
Power Outlets (Instrument
Panel/Center Console)
CAUTION!
• When installing the power distribution center cover, it is important to ensure the
cover is properly positioned and fully latched. Failure to do so may allow water
to get into the power distribution center and possibly result in an electrical
system failure.
• When replacing a blown fuse, it is important to use only a fuse having the correct
amperage rating. The use of a fuse with a rating other than indicated may result
in a dangerous electrical system overload. If a properly rated fuse continues to
blow, it indicates a problem in the circuit that must be corrected.
MAINTAINING YOUR VEHICLE
245
OFF-ROAD CAPABILITIES
How do I shift into different four-wheel drive selections? pg. 130
UTILITY
How do I know how much I can tow with my Ram Truck? pg. 145
How do I adjust the gain on the Integrated Trailer Brake Module? pg. 147
WHAT TO DO IN EMERGENCIES
How do I change a flat tire? pg. 188
How do I Jump-Start my vehicle? pg. 199
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 242
What type of oil do I use? pg. 215
How often should I change my engine’s oil?
Gasoline Engine pg. 225
Cummins
®
Diesel Engine pg. 235
1500 Diesel Engine pg. 230
FREQUENTLY ASKED QUESTIONS
253