Ram Cargo Van - 2014 Fuse Box Diagram

Ram Cargo Van - 2014 Fuse Box Diagram

bag system is designed to be maintenance free, if any of
the following occurs, have an authorized dealer service
the air bag system immediately.
The Air Bag Warning Light does not come on for
approximately four to eight seconds when the ignition
switch is first turned to ON/RUN.
The Air Bag Warning Light remains on after the
approximate four to eight-second interval.
The Air Bag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The air bags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper air bag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
This vehicle is equipped with an event data recorder
(EDR). The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as an air
bag deployment or hitting a road obstacle, data that will
assist in understanding how a vehicle’s systems per-
formed. The EDR is designed to record data related to
vehicle dynamics and safety systems for a short period of
time, typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating;
Whether or not the driver and passenger safety belts
were buckled/fastened;
How far (if at all) the driver was depressing the
accelerator and/or brake pedal; and,
How fast the vehicle was traveling.
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
87
CAUTION!
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system
will need to be replaced.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
One outlet in the removable floor console (if equipped)
shares a fuse with the lower outlet in the instrument
panel and is also connected to the battery. Do not exceed
a
maximum
power
of
160
Watts
(13 Amps)
shared
between the lower panel outlet and the removable floor
console outlet.
Removable Console Outlet
256
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of outlet
should be inserted into any 12 Volt outlet.
Do not touch with wet hands.
Close the lid when not in use and while driving the
vehicle.
If this outlet is mishandled, it may cause an electric
shock and failure.
Power Outlet Fuses
1 — M7 Fuse 20 A Yellow Power Outlet Center Seat (Opt) or with
Console Rear
2 — M6 Fuse 20 A Yellow Cigar Lighter Instrument Panel or with
Console Front
3 — M36 Fuse 20 A Yellow Power Outlet Instrument Panel or
with Console Center
258
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
Refer to ”Electronic Vehicle Information Center (EVIC) —
If Equipped” in this section for further information.
LoW tirE
When the appropriate condition exists, the odometer
display will toggle between LoW and tirE for three
cycles.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and press the
STEP button
on
the
steering
wheel
to
turn
off
the
message. If the problem continues, the message will
appear the next time the vehicle is started.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations refer to “Fuses” in “Maintaining Your
Vehicle”.
CHAngE OIL
Your vehicle is equipped with an engine oil change
indicator system. The
CHAngE OIL
message will flash in
the instrument cluster odometer for approximately 12
seconds, after a single chime has sounded, to indicate the
next scheduled oil change interval. The engine oil change
indicator system is duty cycle-based, which means the
engine oil change interval may fluctuate dependent upon
your personal driving style.
Unless reset, this message will continue to display each
time you turn the ignition switch to the ON/RUN
position. To reset the oil change indicator system (after
performing the scheduled maintenance), perform the
following steps.
4
UNDERSTANDING YOUR INSTRUMENT PANEL
301
ENGINE COMPARTMENT — 3.6L
1 — Air Filter
6 — Engine Coolant Reservoir
2 — Power Steering Fluid Reservoir
7 — Engine Oil Dipstick
3 — Brake Fluid Reservoir
8 — Engine Oil Fill
4 — Battery
9 — Coolant Pressure Cap
5 — Totally Integrated Power Module (Fuses)
10 — Washer Fluid Reservoir
7
MAINTAINING YOUR VEHICLE
575
six times. This will loosen any remaining debris. Rinse
the liner thoroughly under warm running water. Shake
the excess water from the liner and dry the outer surfaces
with a clean soft cloth.
Installation
Place the liner into the cupholder drawer and press the
liner into place so that the retention tabs seat into the
corresponding openings in the drawer.
FUSES
WARNING!
When replacing a blown fuse, always use an ap-
propriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
with another fuse of higher amp rating. Never
(Continued)
WARNING!
(Continued)
replace a blown fuse with metal wires or any other
material. Failure to use proper fuses may result in
serious personal injury, fire and/or property dam-
age.
Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
7
MAINTAINING YOUR VEHICLE
609
Totally Integrated Power Module
The Totally Integrated Power Module is located in the
engine compartment near the battery. Refer to the appli-
cable “Engine Compartment” illustration in this section.
This center contains cartridge fuses and mini-fuses. A
label that identifies each component may be printed or
embossed on the inside of the cover.
CAUTION!
When installing the Totally Integrated Power Mod-
ule cover, it is important to ensure the cover is
properly positioned and fully latched. Failure to do
so may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.
The numbers inside the TIPM cover correspond to the
following table.
Totally Integrated Power Module
610
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Natural
Driver Door Node
J5
25 Amp Natural
Passenger Door Node
J6
40 Amp Green
Antilock Brakes Pump/Stability Control System
J7
30 Amp Pink
Antilock Brakes Valve/Stability Control System
J8
40 Amp Green
Power Memory Seat – If Equipped
J9
40 Amp Green
Partial Zero Emissions Vehicle Motor/Flex Fuel
– If Equipped
J10
30 Amp Pink
Headlamp Wash/Manifold Tuning Valve –
If Equipped
J11
30 Amp Pink
Power Sliding Door Module/Anti–Theft
Module – If Equipped
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan Motor
7
MAINTAINING YOUR VEHICLE
611
Cavity
Cartridge Fuse
Mini-Fuse
Description
J13
60 Amp Yellow
Ignition Off Draw (IOD) – Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Natural
Sunroof Module
M1
15 Amp Blue
Rear Center Brake Lamp/Brake Switch
M2
20 Amp Yellow
Front Fog Lamps
M3
20 Amp Yellow
Front/Rear Axle Locker, Vacuum Pump Motor
M4
10 Amp Red
Trailer Tow
M5
25 Amp Natural
Inverter
612
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sensor, Cigar Lighter
(Instrument Panel or with Console Rear)
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC SELECT) – Cen-
ter Seat or with Console Rear
M8
20 Amp Yellow
Front Heated Seat – If Equipped
M9
20 Amp Yellow
Rear Heated Seat – If Equipped
M10
15 Amp Blue
Ignition Off Draw — Video System, Satellite
Radio, DVD, Hands-Free Module, Universal
Garage Door Opener, Vanity Lamp, Streaming
Video Module – If Equipped
M11
10 Amp Red
Climate Control System
M12
30 Amp Green
Amplifier/Radio
M13
20 Amp Yellow
Instrument Cluster, SIREN, Clock Module,
Multi-Function Control Switch – If Equipped
M14
20 Amp Yellow
Trailer Tow – If Equipped
7
MAINTAINING YOUR VEHICLE
613
Cavity
Cartridge Fuse
Mini-Fuse
Description
M15
20 Amp Yellow
Rear View Mirror, Instrument Cluster, Multi-
Function Control Switch, Tire Pressure Monitor,
Glow Plug Module – If Equipped
M16
10 Amp Red
Airbag Module/Occupant Classification
Module
M17
15 Amp Blue
Left Tail/License/Park Lamp, Running Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
M19
25 Amp Natural
Powertrain
M20
15 Amp Blue
Instrument Cluster Interior Light, Switch Bank,
Steering Column Module, Switch Steering
Wheel
M21
20 Amp Yellow
Powertrain
M22
10 Amp Red
Horn
M23
10 Amp Red
Horn
M24
25 Amp Natural
Rear Wiper
614
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
M25
20 Amp Yellow
Fuel Pump, Diesel Lift Pump – If Equipped
M26
10 Amp Red
Power Mirror Switch, Driver Window Switch
M27
10 Amp Red
Wireless Control Module, Keyless Entry
Module
M28
10 Amp Red
Powertrain, Transmission Control Module
M29
10 Amp Red
Occupant Classification Module
M30
15 Amp Blue
Rear Wiper Module, Power Folding Mirror
M31
20 Amp Yellow
Back-Up Lamps
M32
10 Amp Red
Airbag Module, THATCHUM – If Equipped
M33
10 Amp Red
Powertrain
M34
10 Amp Red
Park Assist, Heater Climate Control Module,
Headlamp Wash, Compass, Rear Camera, Door
Lamps, Flashlight, Relay Diesel Cabin Heater,
Rad Fan Diesel – If Equipped
M35
10 Amp Red
Heated Mirrors
7
MAINTAINING YOUR VEHICLE
615
Cavity
Cartridge Fuse
Mini-Fuse
Description
M36
20 Amp Yellow
Power Outlet #3 (Instrument Panel or with
Console Center)
M37
10 Amp Red
Antilock Brakes, Stability Control, Stop Lamp,
Fuel Pump
M38
25 Amp Natural
Door Lock/Unlock Motors, Liftgate Lock/
Unlock Motors
The power windows are fused by a 25 Amp circuit
breaker located in the Totally Integrated Power Module.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take steps to protect your battery.
You may do the following:
Remove the 60 Amp cartridge in the Totally Integrated
Power
Module
(TIPM)
labeled
Ignition-Off
Draw
(IOD).
Or, disconnect the negative cable from the battery.
Anytime you store your vehicle, or keep it out of
service for two weeks or more, run the air conditioning
system at idle for about five minutes in the fresh air
and high blower setting. This will ensure adequate
system lubrication to minimize the possibility of com-
pressor damage when the system is started again.
616
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
Indicators
- Turn Signal Indicators
- High Beam Indicator
- Front Fog Light Indicator
- Vehicle Security Indica-
tor*
- Electronic Stability Con-
trol (ESC) Off Indicator*
- Electronic Speed Control
ON Indicator
- Electronic Speed Control
Set Indicator
Odometer Messages
door - Door Ajar
noFUSE* - Fuse Fault
gATE* - Liftgate Ajar
CHAngE OIL* - Change Engine Oil
gASCAP - Fuel Cap Fault
LoCOOL - Low Coolant
LoW tirE* - Low Tire Pressure
* If equipped
** Bulb Check with Key On
CONTROLS AT A GLANCE
9
POWER OUTLETS
Two 12 Volt (13 Amp) power outlets
are located on the lower instrument
panel, below the open storage bin. The
driver-side power outlet is controlled
by
the
ignition
switch
and
the
passenger-side power outlet is con-
nected directly to the battery. The
driver-side power outlet will also oper-
ate a conventional cigar lighter unit (if
equipped with an optional Smoker's
Package).
One outlet in the removable floor con-
sole (if equipped) shares a fuse with the lower outlet in the instrument panel and
is also connected to the battery. Do not exceed a maximum power of 160 Watts
(13 Amps) shared between the lower panel outlet and the removable floor console
outlet.
On vehicles equipped with the Super Console the power outlets are located under
the retractable cover. To access the power outlets push down on the cover and
slide it toward the instrument panel.
The outlet in the rear quarter panel near the liftgate and the upper outlet in the
instrument panel are both controlled by the ignition switch. Each of these outlets
can support 160 Watts (13 Amps). Do not exceed 160 Watts (13 Amps) for each
of these outlets.
ELECTRONICS
86
NOTE:
Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the
160 Watt (13 Amp) power rating is exceeded, the fuse protecting the system will
need to be replaced.
Power outlets are designed for accessory plugs only. Do not insert any other object
in the power outlet as this will damage the outlet and blow the fuse. Improper use
of the power outlet can cause damage not covered by your new vehicle warranty.
ELECTRONICS
87
Integrated Power Module (fuses)
The Totally Integrated Power Module is located in the engine compartment near
the battery. This center contains cartridge fuses and mini-fuses. A label that
identifies each component may be printed or embossed on the inside of the cover.
The numbers inside the TIPM cover correspond to the following table.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Natural
Driver Door Node
J5
25 Amp Natural
Passenger Door Node
J6
40 Amp Green
Antilock Brakes Pump/Stability
Control System
J7
30 Amp Pink
Antilock Brakes Valve/Stability
Control System
J8
40 Amp Green
Power Memory Seat –
If Equipped
J9
40 Amp Green
Partial Zero Emissions Vehicle
Motor/Flex Fuel – If Equipped
J10
30 Amp Pink
Headlamp Wash/Manifold Tuning
Valve – If Equipped
J11
30 Amp Pink
Power Sliding Door Module/Anti–
Theft Module – If Equipped
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan
Motor
J13
60 Amp Yellow
Ignition Off Draw (IOD) – Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module Trans
Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Natural
Sunroof Module
M1
15 Amp Blue
Rear Center Brake Lamp/Brake
Switch
M2
20 Amp Yellow
Front Fog Lamps
M3
20 Amp Yellow
Front/Rear Axle Locker, Vacuum
Pump Motor
M4
10 Amp Red
Trailer Tow
M5
25 Amp Natural
Inverter
MAINTAINING YOUR VEHICLE
122
Cavity
Cartridge Fuse
Mini-Fuse
Description
M6
20 Amp Yellow
Power Outlet #1 (ACC),
Rain Sensor, Cigar Lighter
(Instrument Panel or with
Console Rear)
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC
SELECT) – Center Seat or with
Console Rear
M8
20 Amp Yellow
Front Heated Seat – If Equipped
M9
20 Amp Yellow
Rear Heated Seat – If Equipped
M10
15 Amp Blue
Ignition Off Draw — Video Sys-
tem, Satellite Radio, DVD,
Hands-Free Module, Universal
Garage Door Opener, Vanity
Lamp, Streaming Video Module
– If Equipped
M11
10 Amp Red
Climate Control System
M12
30 Amp Green
Amplifier/Radio
M13
20 Amp Yellow
Instrument Cluster, SIREN,
Clock Module, Multi-Function
Control Switch – If Equipped
M14
20 Amp Yellow
Trailer Tow – If Equipped
M15
20 Amp Yellow
Rear View Mirror, Instrument
Cluster, Multi-Function Control
Switch, Tire Pressure Monitor,
Glow Plug Module – If Equipped
M16
10 Amp Red
Airbag Module/Occupant Classi-
fication Module
M17
15 Amp Blue
Left Tail/License/Park Lamp,
Running Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
M19
25 Amp Natural
Powertrain
M20
15 Amp Blue
Instrument Cluster Interior Light,
Switch Bank, Steering Column
Module, Switch Steering Wheel
M21
20 Amp Yellow
Powertrain
M22
10 Amp Red
Horn
M23
10 Amp Red
Horn
M24
25 Amp Natural
Rear Wiper
M25
20 Amp Yellow
Fuel Pump, Diesel Lift Pump –
If Equipped
M26
10 Amp Red
Power Mirror Switch, Driver Win-
dow Switch
M27
10 Amp Red
Wireless Control Module, Keyless
Entry Module
MAINTAINING YOUR VEHICLE
123
Cavity
Cartridge Fuse
Mini-Fuse
Description
M28
10 Amp Red
Powertrain, Transmission Control
Module
M29
10 Amp Red
Occupant Classification Module
M30
15 Amp Blue
Rear Wiper Module, Power Fold-
ing Mirror
M31
20 Amp Yellow
Back-Up Lamps
M32
10 Amp Red
Airbag Module, THATCHUM –
If Equipped
M33
10 Amp Red
Powertrain
M34
10 Amp Red
Park Assist, Heater Climate Con-
trol Module, Headlamp Wash,
Compass, Rear Camera, Door
Lamps, Flashlight, Relay Diesel
Cabin Heater, Rad Fan Diesel –
If Equipped
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet #3 (Instrument
Panel or with Console Center)
M37
10 Amp Red
Antilock Brakes, Stability Con-
trol, Stop Lamp, Fuel Pump
M38
25 Amp Natural
Door Lock/Unlock Motors,
Liftgate Lock/Unlock Motors
The power windows are fused by a 25 Amp circuit breaker located in the Totally
Integrated Power Module.
TIRE PRESSURES
Check the inflation pressure of each tire, including the spare tire, at least monthly
and inflate to the recommended pressure for your vehicle.
The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the DVD
for more information regarding tire warn-
ings and instructions.
Tire And Loading Information Location (Ex-
ample)
MAINTAINING YOUR VEHICLE
124
WHAT TO DO IN EMERGENCIES
What do I do if my TPMS warning light is blinking? pg. 93
How do I change a flat tire? pg. 98
How do I Jump-Start my vehicle? pg. 107
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 122
What type of oil do I use? pg. 115
How often should I change my engine’s oil? pg. 116
What should my tire pressure be set at? pg. 124
FREQUENTLY ASKED QUESTIONS
131