Ram Cargo Van - 2013 Fuse Box Diagram

Ram Cargo Van - 2013 Fuse Box Diagram

Indicators
- Turn Signal Indicators
- High Beam Indicator
- Front Fog Light Indicator
- Vehicle Security Indicator*
- Electronic Stability Control
(ESC) Off Indicator*
- Electronic Speed Control
ON Indicator
- Electronic Speed Control
Set Indicator
Odometer Messages
door - Door Ajar
noFUSE* - Fuse Fault
gATE* - Liftgate Ajar
CHAngE OIL* - Change Engine Oil
gASCAP - Fuel Cap Fault
LoCOOL - Low Coolant
LoW tirE* - Low Tire Pressure
* If equipped
** Bulb Check with Key On
CONTROLS AT A GLANCE
7
POWER OUTLETS
Two 12 Volt (13 Amp) power outlets
are located on the lower instrument
panel, below the open storage bin. The
driver-side power outlet is controlled
by
the
ignition
switch
and
the
passenger-side power outlet is con-
nected directly to the battery. The
driver-side power outlet will also oper-
ate a conventional cigar lighter unit (if
equipped with an optional Smoker's
Package).
One outlet in the removable floor con-
sole (if equipped) shares a fuse with the lower outlet in the instrument panel and
is also connected to the battery. Do not exceed a maximum power of 160 Watts
(13 Amps) shared between the lower panel outlet and the removable floor console
outlet.
On vehicles equipped with the Super Console the power outlets are located under
the retractable cover. To access the power outlets push down on the cover and
slide it toward the instrument panel.
The outlet in the rear quarter panel near the liftgate and the upper outlet in the
instrument panel are both controlled by the ignition switch. Each of these outlets
can support 160 Watts (13 Amps). Do not exceed 160 Watts (13 Amps) for each
of these outlets.
ELECTRONICS
86
NOTE:
Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the
160 Watt (13 Amp) power rating is exceeded, the fuse protecting the system will
need to be replaced.
Power outlets are designed for accessory plugs only. Do not insert any other object
in the power outlet as this will damage the outlet and blow the fuse. Improper use
of the power outlet can cause damage not covered by your new vehicle warranty.
ELECTRONICS
87
Integrated Power Module (fuses)
The Integrated Power Module (fuses) is located in the engine compartment near
the battery. This center contains cartridge fuses, mini-fuses and relays.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module (RR Door Node)
J4
25 Amp Natu-
ral
Driver Door Node
J5
25 Amp Natu-
ral
Passenger Door Node
J6
40 Amp Green
Anti-Lock
Brake
System
(ABS)
Pump/ESP
J7
30 Amp Pink
Anti-Lock
Brake
System
(ABS)
Valve/ESP
J8
40 Amp Green
Power Memory Seat (If Equipped)
J9
40 Amp Green
PZEV Motor/Flex Fuel
J10
30 Amp Pink
Headlamp
Wash
Relay/Manifold
Tuning Valve
J11
30 Amp Pink
Power
Sliding
Door
Module/
Thatchum Relay Lock Feed
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan
Motor
J13
60 Amp Yellow
Ignition Off Draw (IOD) — Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module (PCM)
Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Natu-
ral
Sunroof Module
M1
15 Amp Blue
Center High Mounted Stop Light
(CHMSL)/Brake Switch
M2
20 Amp Yellow
Trailer Lighting, Front Fog Lamps,
Intelligent Battery Sensor (IBS)
M3
20 Amp Yellow
Front/Rear
Axle
Locker,
Vacuum
Pump Motor
M4
10 Amp Red
Trailer Tow
M5
25 Amp
natural
Inverter
MAINTAINING YOUR VEHICLE
124
Cavity
Cartridge Fuse
Mini-Fuse
Description
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sensor
M7
20 Amp Yellow
Power
Outlet
#2
(BATT/ACC
SE-
LECT)
M8
20 Amp Yellow
Front Heated Seat (If Equipped)
M9
20 Amp Yellow
Rear Heated Seat (If Equipped)
M10
15 Amp Blue
Ignition Off Draw — Vehicle Enter-
tainment System (IOD-VES), Satel-
lite Digital Audio Receiver (SDARS),
DVD, Hands-Free Module (HFM),
Universal
Garage
Door
Opener
(UGDO), Vanity Lamp (VANITY LP),
Streaming Video Module
M11
10 Amp Red
(Ignition Off Draw) IOD-HVAC/ATC
M12
30 Amp Green
Amplifier (AMP)/Radio
M13
20 Amp Yellow
Ignition Off Draw— Cabin Compart-
ment
Node
(IOD-CCN),
SIREN,
Clock Module (CLK MOD), Multi-
Function Control Switch (MULTI-
FCTN SW)/ITM
M14
20 Amp Yellow
Trailer Tow — If Equipped
M15
20 Amp Yellow
Rear
View
Mirror
(RR
VW
MIR),
Cabin Compartment Node (CCN),
Multi-Function
Control
Switch
(MULTIFTCN
SW),
Tire
Pressure
Monitor (TPM), Glow Plug Module
(GLW PLG MOD) — Export Diesel
Only,
Assy-Shifter
(Hall
Effect),
Acoustic Noise Cancellation (ANC)
M16
10 Amp Red
Occupant
Restraint
Controller/
Occupant
Classification
Module
(ORC/OCM)
M17
15 Amp Blue
Left
Tail/License/Park
Lamp
(LT-
TAIL/LIC/PRK
LMP),
Running
Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp (RT-TAIL/
PRK/RUN LMP)
M19
25 Amp Natu-
ral
Auto Shut Down (ASD #1 and #2)
M20
15 Amp Blue
Cabin Compartment Node Interior
Light
(CCN
INT
LIGHT),
Switch
Bank (SW BANK), Steering Control
Module
(SCM),
Switch
Steering
Wheel
M21
20 Amp Yellow
Auto Shut Down (ASD #3)
M22
10 Amp Red
Right Horn (RT HORN (HI/LOW)
MAINTAINING YOUR VEHICLE
125
Cavity
Cartridge Fuse
Mini-Fuse
Description
M23
10 Amp Red
Left Horn (LT HORN (LT HORN (HI/
LOW)
M24
25 Amp Natu-
ral
Rear Wiper (REAR WIPER)
M25
20 Amp Yellow
Fuel Pump (FUEL PUMP), Diesel
Lift Pump (DSL LIFT PUMP) — Ex-
port Only
M26
10 Amp Red
Power Mirror Switch (PWR MIRR
SW), Driver Window Switch (DRVR
WIND SW)
M27
10 Amp Red
Wireless Ignition Module, Keyless
Entry Module
M28
10 Amp Red
Next Generation Controller (NGC),
PCM, Transmission Feed (TRANS
FEED), TCM
M29
10 Amp Red
Occupant
Classification
Module
(OCM)
M30
15 Amp Blue
Rear
Wiper
Module
(RR
WIPER
MOD), Power Folding Mirror (PWR
FOLD MIR), J1962 Diagnostic Feed
M31
20 Amp Yellow
Back-Up Lamps (B/U LAMPS)
M32
10 Amp Red
Occupant
Restraint
Controller
(ORC), TT EUROPE
M33
10 Amp Red
Next Generation Controller (NGC),
Global Powertrain Engine Controller
(GPEC), TCM
M34
10 Amp Red
Park
Assist
(PRK
ASST),
Heater
Ventilation, Air Conditioning Mod-
ule (HVAC MOD), Headlamp Wash
(HDLP
WASH),
Compass
(COM-
PAS),
IR
Sensor,
Rear
Camera,
Lamp
Door
FT
Drv/Pass,
Lamp
Flashlight,
AHLM,
Relay
Diesel
Cabin Heater, Rad Fan Diesel
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet #3 (BATT)
M37
10 Amp Red
Anti-Lock
Brake
System
(ABS),
Electronic Stability Program (ESP),
Stop Lamp Switch (STP LP SW),
Fuel Pump Rly Hi Control
M38
25 Amp Natu-
ral
Door
Lock/Unlock
Motors
(LOCK/
UNLOCK
MTRS),
Liftgate
Lock/
Unlock Motors
MAINTAINING YOUR VEHICLE
126
UTILITY
How do I know how much I can tow with my Ram Cargo Van? pg. 92
WHAT TO DO IN EMERGENCIES
What do I do if my TPMS warning light is blinking? pg. 93
How do I change a flat tire? pg. 98
How do I Jump-Start my vehicle? pg. 108
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 124
What type of oil do I use? pg. 117
How often should I change my engine’s oil? pg. 118
What should my tire pressure be set at? pg. 127
FAQ (How To?)
134
WARNING!
(Continued)
seat accessories may be used. If it is necessary to
modify the air bag system for persons with dis-
abilities, contact your authorized dealer.
Air Bag Warning Light
You will want to have the air bags ready to
inflate for your protection in a collision. The
Air Bag Warning Light monitors the internal
circuits and interconnecting wiring associated
with air bag system electrical components. While the air
bag system is designed to be maintenance free, if any of
the following occurs, have an authorized dealer service
the air bag system immediately.
The Air Bag Warning Light does not come on for
approximately four to eight seconds when the ignition
switch is first turned to ON/RUN.
The Air Bag Warning Light remains on after the
approximate four to eight-second interval.
The Air Bag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The air bags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper air bag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
This vehicle is equipped with an event data recorder
(EDR). The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as an air
bag deployment or hitting a road obstacle, data that will
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
87
NOTE:
To ensure proper operation a MOPAR® cigar
knob and element must be used.
CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp)
power rating is exceeded the fuse protecting the
system will need to be replaced.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
One outlet in the removable floor console (if equipped)
shares a fuse with the lower outlet in the instrument
panel and is also connected to the battery. Do not exceed
a
maximum
power
of
160
Watts
(13 Amps)
shared
Instrument Panel Outlets
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
263
The power outlets include tethered caps, labeled with a
key or battery symbol indicating the power source. The
power outlet, located on the lower instrument panel, is
powered directly from the battery. Items plugged into
this power outlet may discharge the battery and/or
prevent the engine from starting.
Power Outlet Fuses
1 — M7 Fuse 20 A Yellow Power Outlet Center Seat (Opt) or with
Console Rear
2 — M6 Fuse 20 A Yellow Cigar Lighter Instrument Panel or with
Console Front
3 — M36 Fuse 20 A Yellow Power Outlet Instrument Panel or
with Console Center
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
265
ENGINE COMPARTMENT — 3.6L
1 — Air Filter
6 — Engine Coolant Reservoir
2 — Power Steering Fluid Reservoir
7 — Engine Oil Dipstick
3 — Brake Fluid Reservoir
8 — Engine Oil Fill
4 — Battery
9 — Coolant Pressure Cap
5 — Totally Integrated Power Module (Fuses)
10 — Washer Fluid Reservoir
7
MAINTAINING YOUR VEHICLE
585
If the belts need cleaning, use MOPAR® Total Clean, a
mild soap solution, or lukewarm water. Do not remove
the belts from the vehicle to wash them. Dry with a soft
cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning The Instrument Panel Cupholders
Removal
Pull the flexible liner from the cupholder drawer starting
at one edge to ease removal.
Cleaning
The liner is top shelf dishwasher safe, or you may follow
the cleaning procedure below.
Soak the liner in a mixture of medium hot tap water and
one teaspoon of mild liquid dish soap. Let soak for
approximately 30 minutes. After 30 minutes, pull the
liner from the water and dip it back into the water about
six times. This will loosen any remaining debris. Rinse
the liner thoroughly under warm running water. Shake
the excess water from the liner and dry the outer surfaces
with a clean soft cloth.
Installation
Place the liner into the cupholder drawer and press the
liner into place so that the retention tabs seat into the
corresponding openings in the drawer.
FUSES
Totally Integrated Power Module
The Totally Integrated Power Module is located in the
engine compartment near the battery. Refer to the appli-
cable “Engine Compartment” illustration in this section.
This center contains cartridge fuses and mini-fuses. A
label that identifies each component may be printed or
embossed on the inside of the cover.
618
MAINTAINING YOUR VEHICLE
CAUTION!
When installing the Totally Integrated Power Mod-
ule cover, it is important to ensure the cover is
properly positioned and fully latched. Failure to do
so may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.
Totally Integrated Power Module
7
MAINTAINING YOUR VEHICLE
619
The numbers inside the TIPM cover correspond to the
following table.
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
J1
40 Amp
Green
Power Folding
Seat
J2
30 Amp
Pink
Power Liftgate
Module
J3
30 Amp
Pink
Rear Door Mod-
ule
J4
25 Amp
Natural
Driver Door
Node
J5
25 Amp
Natural
Passenger Door
Node
J6
40 Amp
Green
Antilock Brakes
Pump/Stability
Control System
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
J7
30 Amp
Pink
Antilock Brakes
Valve/Stability
Control System
J8
40 Amp
Green
Power Memory
Seat – If
Equipped
J9
40 Amp
Green
Partial Zero
Emissions Vehicle
Motor/Flex Fuel
– If Equipped
J10
30 Amp
Pink
Headlamp Wash/
Manifold Tuning
Valve – If
Equipped
J11
30 Amp
Pink
Power Sliding
Door Module/
620
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
Anti–Theft Mod-
ule – If Equipped
J12
30 Amp
Pink
HVAC Rear
Blower, Radiator
Fan Motor
J13
60 Amp
Yellow
Ignition Off Draw
(IOD) – Main
J14
40 Amp
Green
Rear Window
Defogger
J15
40 Amp
Green
Front Blower
J17
40 Amp
Green
Starter Solenoid
J18
20 Amp
Blue
Powertrain Con-
trol Module Trans
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
Range
J19
60 Amp
Yellow
Radiator Fan
J20
30 Amp
Pink
Front Wiper
LO/HI
J21
20 Amp
Blue
Front/Rear
Washer
J22
25 Amp
Natural
Sunroof Module
M1
15 Amp
Blue
Rear Center
Brake Lamp/
Brake Switch
M2
20 Amp
Yellow
Front Fog Lamps
7
MAINTAINING YOUR VEHICLE
621
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M3
20 Amp
Yellow
Front/Rear Axle
Locker, Vacuum
Pump Motor
M4
10 Amp
Red
Trailer Tow
M5
25 Amp
Natural
Inverter
M6
20 Amp
Yellow
Power Outlet #1
(ACC), Rain Sen-
sor, Cigar Lighter
(Instrument Panel
or with Console
Rear)
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M7
20 Amp
Yellow
Power Outlet #2
(BATT/ACC SE-
LECT) – Center
Seat or with Con-
sole Rear
M8
20 Amp
Yellow
Front Heated Seat
– If Equipped
M9
20 Amp
Yellow
Rear Heated Seat
– If Equipped
M10
15 Amp
Blue
Ignition Off Draw
— Video System,
Satellite Radio,
DVD, Hands-Free
Module, Univer-
sal Garage Door
Opener, Vanity
622
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
Lamp, Streaming
Video Module –
If Equipped
M11
10 Amp
Red
Climate Control
System
M12
30 Amp
Green
Amplifier/Radio
M13
20 Amp
Yellow
Instrument Clus-
ter, SIREN, Clock
Module, Multi-
Function Control
Switch – If
Equipped
M14
20 Amp
Yellow
Trailer Tow – If
Equipped
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M15
20 Amp
Yellow
Rear View Mirror,
Instrument Clus-
ter, Multi-
Function Control
Switch, Tire Pres-
sure Monitor,
Glow Plug Mod-
ule – If Equipped
M16
10 Amp
Red
Airbag Module/
Occupant Classi-
fication Module
M17
15 Amp
Blue
Left Tail/
License/Park
Lamp, Running
Lamps
7
MAINTAINING YOUR VEHICLE
623
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M18
15 Amp
Blue
Right Tail/Park/
Run Lamp
M19
25 Amp
Natural
Powertrain
M20
15 Amp
Blue
Instrument Clus-
ter Interior Light,
Switch Bank,
Steering Column
Module, Switch
Steering Wheel
M21
20 Amp
Yellow
Powertrain
M22
10 Amp
Red
Horn
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M23
10 Amp
Red
Horn
M24
25 Amp
Natural
Rear Wiper
M25
20 Amp
Yellow
Fuel Pump, Die-
sel Lift Pump – If
Equipped
M26
10 Amp
Red
Power Mirror
Switch, Driver
Window Switch
M27
10 Amp
Red
Wireless Control
Module, Keyless
Entry Module
624
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M28
10 Amp
Red
Powertrain,
Transmission
Control Module
M29
10 Amp
Red
Occupant Classi-
fication Module
M30
15 Amp
Blue
Rear Wiper Mod-
ule, Power Fold-
ing Mirror
M31
20 Amp
Yellow
Back-Up Lamps
M32
10 Amp
Red
Airbag Module,
THATCHUM – If
Equipped
M33
10 Amp
Red
Powertrain
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M34
10 Amp
Red
Park Assist,
Heater Climate
Control Module,
Headlamp Wash,
Compass, Rear
Camera, Door
Lamps, Flash-
light, Relay Die-
sel Cabin Heater,
Rad Fan Diesel –
If Equipped
M35
10 Amp
Red
Heated Mirrors
7
MAINTAINING YOUR VEHICLE
625
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
M36
20 Amp
Yellow
Power Outlet #3
(Instrument Panel
or with Console
Center)
M37
10 Amp
Red
Antilock Brakes,
Stability Control,
Stop Lamp, Fuel
Pump
M38
25 Amp
Natural
Door Lock/
Unlock Motors,
Liftgate Lock/
Unlock Motors
The power windows are fused by a 25 Amp circuit
breaker located in the Totally Integrated Power Module.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take steps to protect your battery.
You may do the following:
Remove the 60 Amp cartridge in the Totally Integrated
Power
Module
(TIPM)
labeled
Ignition-Off
Draw
(IOD).
Or, disconnect the negative cable from the battery.
Anytime you store your vehicle, or keep it out of
service for two weeks or more, run the air conditioning
system at idle for about five minutes in the fresh air
and high blower setting. This will ensure adequate
system lubrication to minimize the possibility of com-
pressor damage when the system is started again.
626
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.