Chrysler 200 - 2012 Fuse Box Diagram

Chrysler 200 - 2012 Fuse Box Diagram

Air Bag Warning Light
You will want to have the air bags ready to
inflate for your protection in a collision. The
Air Bag Warning Light monitors the internal
circuits and interconnecting wiring associated
with air bag system electrical components. While the air
bag system is designed to be maintenance free, if any of
the following occurs, have an authorized dealer service
the air bag system immediately.
The Air Bag Warning Light does not come on during
the four to eight seconds when the ignition switch is
first turned to the ON/RUN position.
The Air Bag Warning Light remains on after the four to
eight-second interval.
The Air Bag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The air bags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper air bag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
This vehicle is equipped with an event data recorder
(EDR). The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as an air
bag deployment or hitting a road obstacle, data that will
assist in understanding how a vehicle’s systems per-
formed. The EDR is designed to record data related to
vehicle dynamics and safety systems for a short period of
time, typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating;
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
71
For vehicles equipped with the EVIC, the power sunroof
switch will remain active for up to 10 minutes after the
ignition switch is turned OFF. Opening either front door
will cancel this feature. The time is programmable. Refer
to
“Electronic
Vehicle
Information
Center
(EVIC)/
Personal Settings (Customer-Programmable Features)” in
“Understanding
Your
Instrument
Panel”
for
further
information.
ELECTRICAL POWER OUTLETS
There are two 12 Volt (13 Amp) electrical power outlets
on this vehicle. Both of the power outlets are protected by
a fuse.
The instrument panel power outlet, located below the
climate control knobs, has power available only when the
ignition is ON. This power outlet will also operate a
conventional cigar lighter unit.
NOTE:
To preserve the heating element, do not hold the
lighter in the heating position.
Instrument Panel Power Outlet
176
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp)
power rating is exceeded the fuse protecting the
system will need to be replaced.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
Power Outlet Fuse Locations
1 — #16 Fuse 15 A Blue Cigar Lighter Instrument Panel
2 — #11 Fuse 15 A Blue Power Outlet Inside Arm Rest
178
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
CAUTION!
To prevent damage to the starter, wait 10 to 15 sec-
onds before trying again.
After Starting
The idle speed will automatically decrease as the engine
warms up.
ENGINE BLOCK HEATER — IF EQUIPPED
The engine block heater warms the engine, and permits
quicker starts in cold weather. Connect the cord to a
standard
110-115
Volt
AC
electrical
outlet
with
a
grounded, three-wire extension cord.
The engine block heater cord is bundled under the hood
between the headlight assembly and the Totally Inte-
grated Power Module (Fuse Box) on the driver’s side of
the vehicle.
The engine block heater must be plugged in at least one
hour to have an adequate warning effect on the engine.
WARNING!
Remember to disconnect the engine block heater
cord before driving. Damage to the 110-115 Volt
electrical cord could cause electrocution.
AUTOMATIC TRANSMISSION
CAUTION!
Damage to the transmission may occur if the follow-
ing precautions are not observed:
Shift into PARK only after the vehicle has come to
a complete stop.
(Continued)
5
STARTING AND OPERATING
297
ENGINE COMPARTMENT — 2.4L
1 — Engine Coolant Reservoir
7 — Air Cleaner Filter
2 — Power Steering Fluid Reservoir
8 — Engine Oil Fill
3 — Automatic Transmission Dipstick
9 — Coolant Pressure Cap
4 — Brake Fluid Reservoir
10 — Engine Oil Dipstick
5 — Power Distribution Center (Fuses)
11 — Washer Fluid Reservoir
6 — Integrated Power Module (Fuses)
7
MAINTAINING YOUR VEHICLE
409
ENGINE COMPARTMENT — 3.6L
1 — Engine Coolant Reservoir
5 — Air Cleaner Filter
2 — Power Steering Fluid Reservoir
6 — Engine Oil Dipstick
3 — Brake Fluid Reservoir
7 — Engine Oil Fill
4 — Integrated Power Module (Fuses)
8 — Washer Fluid Reservoir
410
MAINTAINING YOUR VEHICLE
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning Center Console Cupholders
Removal
Grab
the
rubber
portion
of
the
cupholder
and
lift
upward.
Cleaning
Soak the rubber cupholder liner in a mixture of medium
hot tap water and one teaspoon of mild liquid dish soap.
Let soak for approximately one hour. After one hour pull
the liner from the water and dip it back into the water
about six times. This will loosen any remaining debris.
Rinse the liner thoroughly under warm running water.
Shake the excess water from the liner and dry the outer
surfaces with a clean soft cloth.
Installation
Align the liner in the cupholder and press down firmly.
FUSES
Integrated Power Module
The Integrated Power Module is located in the engine
compartment near the air cleaner assembly. This center
contains cartridge fuses and mini fuses. A label that
identifies each component may be printed on the inside
of the cover. Refer to the graphic below for FUSES/TIPM
location.
444
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
1
40 Amp
Green
Power Top Module –
If Equipped
2
20 Amp
Yellow
Brake Vacuum Pump
Cavity
Cartridge
Fuse
Mini
Fuse
Description
3
10 Amp
Red
Center High
Mounted Stop Light
(CHMSL)/Brake
Switch
4
10 Amp
Red
Ignition Switch
5
20 Amp
Yellow
Trailer Tow – If
Equipped
6
10 Amp
Red
Power Mirror
Switch/Climate Con-
trols
7
30 Amp
Green
Ignition Off Draw
(IOD) Sense 1
8
30 Amp
Green
Ignition Off Draw
(IOD) Sense 2
9
40 Amp
Green
Battery Feed – Power
Seats – If Equipped
Integrated Power Module
7
MAINTAINING YOUR VEHICLE
445
Cavity
Cartridge
Fuse
Mini
Fuse
Description
10
20 Amp
Yellow
Instrument Panel/
Power Locks/Interior
Lights
11
15 Amp
Lt Blue
Selectable Power Out-
let (Inside Center
Arm Rest)
12
13
20 Amp
Yellow
Ignition/Cigar
Lighter
14
10 Amp
Red
Instrument Panel
15
40 Amp
Green
Radiator Fan Relay
16
15 Amp
Lt. Blue
Sunroof – If
Equipped
Cavity
Cartridge
Fuse
Mini
Fuse
Description
17
10 Amp
Red
Wireless Control
Module (WCM)/
Clock/Steering Con-
trol Module (SCM)
18
40 Amp
Green
Auto Shutdown
(ASD) Relay
19
20 Amp
Yellow
Audio Amplifier – If
Equipped
20
15 Amp
Lt. Blue
Radio
21
10 Amp
Red
Siren – If Equipped
22
10 Amp
Red
Ignition Run – Cli-
mate Controls/Hot
Cupholder – If
Equipped
446
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
23
15 Amp
Lt. Blue
Auto Shutdown
(ASD) Relay 3
24
25 Amp
Natural
Sunroof – If
Equipped
25
10 Amp
Red
Ignition Run —
Heated Mirrors - If
Equipped
26
15 Amp
Lt. Blue
Auto Shutdown
(ASD) Relay 2
27
10 Amp
Red
Ignition Run – Occu-
pant Classification
Module (OCM)/
Occupant Restraint
Controller (ORC)
Cavity
Cartridge
Fuse
Mini
Fuse
Description
28
10 Amp
Red
Ignition Run — Occu-
pant Classification
Module (OCM)/
Occupant Restraint
Controller (ORC)
29
Hot Car (No Fuse
Required)
30
20 Amp
Yellow
Ignition Run –
Heated Seats – If
Equipped
31
Spare
32
30 Amp
Pink
Auto Shutdown
(ASD) Relay 1
7
MAINTAINING YOUR VEHICLE
447
Cavity
Cartridge
Fuse
Mini
Fuse
Description
33
10 Amp
Red
Switch Bank/
Diagnostic Link
Connector/
Powertrain Control
Module (PCM)
34
30 Amp
Pink
Anti-Lock Brakes
(ABS) Module – If
Equipped/Electronic
Stability Control
(ESC) Module – If
Equipped
35
40 Amp
Green
Anti-Lock Brakes
(ABS) Module – If
Equipped/Electronic
Stability Control
(ESC) Module – If
Equipped
Cavity
Cartridge
Fuse
Mini
Fuse
Description
36
30 Amp
Pink
Passenger Door Mod-
ule (PDM)/Driver
Door Module (DDM)
37
25 Amp
Natural
Power Top Module –
If Equipped
CAUTION!
When
installing
the
Integrated
Power
Module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the Integrated Power
Module, and possibly result in an electrical system
failure.
(Continued)
448
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
POWER OUTLETS
• There are two 12 Volt electrical outlets on
this vehicle.
• The instrument panel power outlet,
located below the climate control knobs,
has power available only when the ignition
is ON. This power outlet will also operate
a conventional cigar lighter unit.
• There is also a power outlet located on the inside of the center console. This power outlet
is powered directly from the battery (power available at all times). Items plugged into this
power outlet may discharge the battery and/or prevent the engine from starting.
NOTE:
• Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the 160 Watt
(13 Amp) power rating is exceeded, the fuse protecting the system will need to be replaced.
• Power outlets are designed for accessory plugs only. Do not insert any other object in the
power outlet as this will damage the outlet and blow the fuse. Improper use of the power
outlet can cause damage not covered by your new vehicle warranty.
ELECTRONICS
63
FUSES
Integrated Power Module
• The Integrated Power Module (fuses) is located in the engine compartment near the air
cleaner assembly. This center contains cartridge fuses and mini fuses. A label that
identifies each component may be printed on the inside of the cover.
Cavity
Cartridge Fuse
Mini Fuse
Description
1
40 Amp Green
Power Top Module – If Equipped
2
20 Amp Yellow
Brake Vacuum Pump
3
10 Amp Red
Center High Mounted Stop Light
(CHMSL)/Brake Switch
4
10 Amp Red
Ignition Switch
5
20 Amp Yellow
Trailer Tow – If Equipped
6
10 Amp Red
Power Mirror Switch/Climate Controls
7
30 Amp Green
Ignition Off Draw (IOD) Sense 1
8
30 Amp Green
Ignition Off Draw (IOD) Sense 2
9
40 Amp Green
Battery Feed – Power Seats – If
Equipped
10
20 Amp Yellow
Instrument Panel/Power Locks/Interior
Lights
11
15 Amp Lt Blue
Selectable Power Outlet (Inside
Center Arm Rest)
12
20 Amp Yellow
13
20 Amp Yellow
Ignition/Cigar Lighter
14
10 Amp Red
Instrument Panel
15
40 Amp Green
Radiator Fan Relay
16
15 Amp Lt. Blue
Sunroof – If Equipped
17
10 Amp Red
Wireless Control Module
(WCM)/Clock/Steering Control
Module (SCM)
MAINTAINING YOUR VEHICLE
89
Cavity
Cartridge Fuse
Mini Fuse
Description
18
40 Amp Green
Auto Shutdown (ASD) Relay
19
20 Amp Yellow
Audio Amplifier – If Equipped
20
15 Amp Lt. Blue
Radio
21
10 Amp Red
Siren – If Equipped
22
10 Amp Red
Ignition Run – Climate Controls/Hot
Cupholder – If Equipped
23
15 Amp Lt. Blue
Auto Shutdown (ASD) Relay 3
24
25 Amp Natural
Sunroof – If Equipped
25
10 Amp Red
Ignition Run — Heated Mirrors - If
Equipped
26
15 Amp Lt. Blue
Auto Shutdown (ASD) Relay 2
27
10 Amp Red
Ignition Run – Occupant Classification
Module (OCM)/Occupant Restraint
Controller (ORC)
28
10 Amp Red
Ignition Run — Occupant
Classification Module
(OCM)/Occupant Restraint
Controller (ORC)
29
Hot Car (No Fuse Required)
30
20 Amp Yellow
Ignition Run – Heated Seats – If
Equipped
31
10 Amp Red
Headlamp Washer – If Equipped
32
30 Amp Pink
Auto Shutdown (ASD) Relay 1
33
10 Amp Red
Switch Bank/Diagnostic Link
Connector/Powertrain Control
Module (PCM)
34
30 Amp Pink
Anti-Lock Brakes (ABS) Module – If
Equipped/Electronic Stability Control
(ESC) Module – If Equipped
35
40 Amp Green
Anti-Lock Brakes (ABS) Module – If
Equipped/Electronic Stability Control
(ESC) Module – If Equipped
36
30 Amp Pink
Passenger Door Module
(PDM)/Driver Door Module (DDM)
37
25 Amp Natural
Power Top Module – If Equipped
MAINTAINING YOUR VEHICLE
90
CAUTION!
• When installing the Totally Integrated Power Module cover, it is important to ensure the
cover is properly positioned and fully latched. Failure to do so may allow water to get into
the Totally Integrated Power Module, and possibly result in an electrical system failure.
• When replacing a blown fuse, it is important to use only a fuse having the correct
amperage rating. The use of a fuse with a rating other than indicated may result in a
dangerous electrical system overload. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be corrected.
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly and
inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the
DVD for more information regarding tire
warnings and instructions.
WARNING!
• Overloading of your tires is dangerous. Overloading can cause tire failure, affect vehicle
handling, and increase your stopping distance. Use tires of the recommended load
capacity for your vehicle. Never overload them.
• Improperly inflated tires are dangerous and can cause collisions. Under-inflation is the
leading cause of tire failure and may result in severe cracking, component separation, or
“blow out”. Over-inflation reduces a tire’s ability to cushion shock. Objects on the road
and chuck holes can cause damage that results in tire failure. Unequal tire pressures can
cause steering problems. You could lose control of your vehicle. Over-inflated or
under-inflated tires can affect vehicle handling and can fail suddenly, resulting in loss of
vehicle control.
MAINTAINING YOUR VEHICLE
91
FREQUENTLY ASKED QUESTIONS
GETTING STARTED
• How do I install my LATCH Equipped Child Seat? pg. 11
• How do I fold down my rear seat? pg. 14
ELECTRONICS
• Which radio is in my vehicle? pg. 26, 28, 30, 39
• How do I activate the Audio Jack? pg. 27, 30, 33, 42
• How do I set the clock on my radio? pg. 26, 28, 31, 39
• How do I use the Navigation feature? pg. 36, 46
• How do I pair my cell phone via Bluetooth® with the UConnect™ Hands-Free Voice
Activation System? pg. 53
• How do I use my iPod®? pg. 52
• How do I use my USB port to listen to audio through my touch-screen radio? pg. 52
• How do I configure my Universal Garage Door Opener (HomeLink)? pg. 60
UTILITY
• How do I know how much I can tow with my Chrysler 200? pg. 64
WHAT TO DO IN EMERGENCIES
• What do I do if my TPMS warning light is blinking? pg. 66
• How do I change a flat tire? pg. 71
• How do I Jump-Start my vehicle? pg. 76
MAINTAINING YOUR VEHICLE
• Where is my Fuse Block located? pg. 89
• What type of oil do I use? pg. 85
• How often should I change my engine’s oil? pg. 87
• What should my tire pressure be set at? pg. 91
FAQ (How To?)
99