Dodge Journey - 2011 Fuse Box Diagram

Dodge Journey - 2011 Fuse Box Diagram

Air Bag Warning Light
You will want to have the air bags ready to
inflate for your protection in a collision. The
Air Bag Warning Light monitors the internal
circuits and interconnecting wiring associated
with air bag system electrical components. While the air
bag system is designed to be maintenance free. If any of
the following occurs, have an authorized dealer service
the air bag system immediately.
The Air Bag Warning Light does not come on during
the four to eight seconds when the ignition is first
cycled to the ON/RUN position.
The Air Bag Warning Light remains on after the four to
eight-second interval.
The Air Bag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The air bags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper air bag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
This vehicle is equipped with an event data recorder
(EDR). The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as an air
bag deployment or hitting a road obstacle, data that will
assist in understanding how a vehicle’s systems per-
formed. The EDR is designed to record data related to
vehicle dynamics and safety systems for a short period of
time, typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating;
74
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
A third fused 12 Volt power outlet is located on the back
of the center console. This power outlet has power
available when the ignition switch is in the LOCK, ON or
ACC position.
A fourth fused 12 Volt power outlet is located on the left
quarter trim panel in the cargo area. This power outlet
has power available when the ignition switch is in the
ON or ACC position.
NOTE:
To ensure proper operation a MOPAR
²
knob
and element must be used.
Rear Seat 12 Volt Power Outlet
Rear Cargo Area Power Outlet
232
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp)
power rating is exceeded the fuse protecting the
system will need to be replaced.
The power outlet on the bottom of the center
console shares the fuse with the power outlet on
the back of the console. The combined usage must
not exceed 160 Watts (13 Amps) at 12 Volts.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
Power Outlet Fuses
1 — F103 20 A Yellow Power Outlet Console Bin & Power Out-
let Console Rear
2 — F102 20 A Yellow Cigar Lighter Instrument Panel & Power
Outlet Left Rear Cargo Area
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
233
ENGINE BLOCK HEATER — IF EQUIPPED
The engine block heater warms the engine, and permits
quicker starts in cold weather. Connect the cord to a
standard
110-115
Volt
AC
electrical
outlet
with
a
grounded, three-wire extension cord.
The engine block heater cord is bundled under the hood
between the headlight assembly and the Totally Inte-
grated Power Module (Fuse Box) on the driver’s side of
the vehicle.
The engine block heater must be plugged in at least one
hour to have an adequate effect on the engine.
WARNING!
Remember to disconnect the engine block heater
cord before driving. Damage to the 110-115 Volt
electrical cord could cause electrocution.
AUTOMATIC TRANSMISSION
CAUTION!
Damage to the transmission may occur if the follow-
ing precautions are not observed:
Shift into PARK only after the vehicle has come to
a complete stop.
Shift
into
or
out
of
REVERSE
only
after
the
vehicle has come to a complete stop and the engine
is at idle speed.
Do not shift from REVERSE, PARK, or NEUTRAL
into any forward gear when the engine is above
idle speed.
Before shifting into any gear, make sure your foot
is firmly on the brake pedal.
NOTE:
You must press and hold the brake pedal down
while shifting out of PARK.
338
STARTING AND OPERATING
ENGINE COMPARTMENT — 2.4L
1 — Engine Coolant Reservoir
7 — Totally Integrated Power Module (Fuses)
2 — Power Steering Fluid Reservoir
8 — Automatic Transmission Dipstick
3 — Engine Oil Fill
9 — Washer Fluid Reservoir
4 — Brake Fluid Reservoir
10 — Coolant Pressure Cap
5 — Remote Jump Start (Positive Battery Post)
11 — Engine Oil Dipstick
6 — Remote Jump Start (Negative Battery Post)
7
MAINTAINING YOUR VEHICLE
451
ENGINE COMPARTMENT — 3.6L
1 — Engine Coolant Reservoir
5 — Air Cleaner Filter
2 — Power Steering Fluid Reservoir
6 — Washer Fluid Reservoir
3 — Brake Fluid Reservoir
7 — Engine Oil Dipstick
4 — Totally Integrated Power Module (Fuses)
8 — Engine Oil Fill
452
MAINTAINING YOUR VEHICLE
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning The Cupholders
Clean with a damp cloth or towel using a mild detergent.
FUSES
Interior Fuses
The interior fuse panel is located on the passenger side
under the instrument panel.
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F100
30 Amp
Pink
110V AC Inverter – If
Equipped
F101
10 Amp
Red
Interior Lights
F102
20 Amp
Yellow
Cigar Lighter in In-
strument Panel/Left
Rear Power Outlet
F103
20 Amp
Yellow
Power Outlet in Con-
sole Bin/Power Out-
let in Rear of Console
F105
20 Amp
Yellow
Heated Seats – If
Equipped
7
MAINTAINING YOUR VEHICLE
489
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F106
20 Amp
Yellow
Rear Power Outlet
F107
10 Amp
Red
Rear Camera – If
Equipped
F108
15 Amp
Blue
Instrument Panel
F109
10 Amp
Red
Climate Control/
HVAC
F110
10 Amp
Red
Occupant Restraint
Controller
F112
10 Amp
Red
Spare
F114
20 Amp
Yellow
Rear HVAC Blower/
Motor
F115
20 Amp
Yellow
Rear Wiper Motor
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F116
30 Amp
Pink
Rear Defroster (EBL)
F117
10 Amp
Red
Heated Mirrors
F118
10 Amp
Red
Occupant Restraint
Controller
F119
10 Amp
Red
Steering Column Con-
trol Module
F120
10 Amp
Red
All Wheel Drive – If
Equipped
F121
15 Amp
Blue
Wireless Ignition
Node
F122
25 Amp
Natural
Driver Door Module
F123
25 Amp
Natural
Passenger Door Mod-
ule
490
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F124
10 Amp
Red
Mirrors
F125
10 Amp
Red
Steering Column Con-
trol Module
F126
10 Amp
Red
Audio Amplifier
F127
20 Amp
Yellow
Trailer Tow – If
Equipped
F128
15 Amp
Blue
Radio
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F129
15 Amp
Blue
Video/DVD – If
Equipped
F130
15 Amp
Blue
Climate Control/
Instrument Panel
F131
10 Amp
Red
Passenger Assistance/
Hands Free System –
If Equipped
F132
10 Amp
Red
Tire Pressure Module
F133
10 Amp
Red
Spare
7
MAINTAINING YOUR VEHICLE
491
Underhood Fuses (Power Distribution Center)
The power distribution center is located in the engine
compartment.
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F101
60 Amp
Yellow
Interior Power Distri-
bution Center Rail
F102
60 Amp
Yellow
Interior Power Distri-
bution Center Rail
F103
60 Amp
Yellow
Interior Power Distri-
bution Center Rail
F105
60 Amp
Yellow
Interior Power Distri-
bution Center Rail
Ignition Run Relay
F106
60 Amp
Yellow
Interior Power Distri-
bution Center Rail
Run/Accessory Relays
F139
40 Amp
Green
Climate Control Sys-
tem Blower
F140
30 Amp
Pink
Power Locks
492
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F141
40 Amp
Green
Anti-Lock Brake Sys-
tem
F142
40 Amp
Green
Glow Plugs – If
Equipped
F143
40 Amp
Green
Exterior Lights 1
F144
40 Amp
Green
Exterior Lights 2
F145
30 Amp
Pink
To Body Computer –
Lamp
F146
30 Amp
Pink
Spare
F147
30 Amp
Pink
Spare
F148
40 Amp
Green
Radiator Fan Motor
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F149
30 Amp
Pink
Starter Solenoid
F150
25 Amp
Natural
Powertrain Control
Modules
F151
30 Amp
Pink
Headlamp Washer
Motor – If Equipped
F152
25 Amp
Natural
Diesel Fuel Heater – If
Equipped
F153
20 Amp
Yellow
Fuel Pump
F156
10 Amp
Red
Brake/Electronic Sta-
bility Control Module
F157
10 Amp
Red
Transfer Case Module
– If Equipped
F158
10 Amp
Red
Active Hood Module
– If Equipped
7
MAINTAINING YOUR VEHICLE
493
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F159
10 Amp
Red
Spare
F160
20 Amp
Yellow
Interior Lights
F161
20 Amp
Yellow
Horn
F162
50 Amp
Red
Cabin Heater #1/
Vacuum Pump – If
Equipped
F163
50 Amp
Red
Cabin Heater #2 – If
Equipped
F164
25 Amp
Natural
Powertrain Auto Shut-
down
F165
20 Amp
Yellow
Powertrain Shutdown
F166
20 Amp
Yellow
Spare
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F167
30 Amp
Green
Powertrain Shutdown
F168
10 Amp
Red
Air Conditioner
Clutch
F169
40 Amp
Green
Emissions – Partial
Zero Emissions Ve-
hicle Motor
F170
15 Amp
Blue
Emissions – Partial
Zero Emissions Ve-
hicle Actuators
F172
20 Amp
Yellow
Spare
F173
25 Amp
Natural
Anti Lock Brake
Valves
F174
20 Amp
Yellow
Siren – If Equipped
494
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
F175
30 Amp
Green
Spare
F176
10 Amp
Red
Powertrain Control
Modules
F177
20 Amp
Yellow
All Wheel Drive Mod-
ule – If Equipped
F178
25 Amp
Natural
Sunroof – If Equipped
F179
10 Amp
Red
Battery Sensor
F181
100 Amp
Blue
Electrohydraulic Steer-
ing (EHPS) – If
Equipped
F182
50 Amp
Red
Cabin Heater #3 – If
Equipped
F184
30 Amp
Pink
Front Wiper Motor
VEHICLE STORAGE
If you will not be using your vehicle for more than
21 days you may want to take steps to preserve your
battery. You may:
Remove the IOD (Ignition Off-Draw) mini-fuses from
the Totally Integrated Power Module located in the
engine compartment.
Or, disconnect the battery negative cable.
REPLACEMENT BULBS
All the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved and should not
be used for replacement.
7
MAINTAINING YOUR VEHICLE
495
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
• A third 12 Volt power outlet is located on the back of the center console. This
outlet has power available when the ignition switch is in the LOCK, ON or ACC
position.
• A fourth fused 12 Volt power outlet is located on the left quarter trim panel in the
cargo area. This outlet has power available when the ignition switch is in the ON or
ACC position.
NOTE:
• Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the 160
Watt (13 Amp) power rating is exceeded, the fuse protecting the system will need to
be replaced.
• Power outlets are designed for accessory plugs only. Do not insert any other object in
the power outlet as this will damage the outlet and blow the fuse. Improper use of
the power outlet can cause damage not covered by your new vehicle warranty.
ELECTRONICS
62
Integrated Power Module (fuses)
• The Integrated Power Module (fuses) is located in the engine compartment near
the air cleaner assembly. This center contains fuses and relays.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Transfer Case Module - if equipped
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Natural
Driver Door Node
J5
25 Amp Natural
Passenger Door Node
J6
40 Amp Green
Anti-Lock Brake System (ABS)
Pump/Electronic Stability Program
(ESP)
J7
30 Amp Pink
Anti-Lock Brake System (ABS)
Valve/Electronic Stability Program
(ESP)
J8
40 Amp Green
Power Memory Seat - if equipped
J9
40 Amp Green
Flex Fuel/PZEV Motor - if equipped
J10
30 Amp Pink
(If Equipped) Headlamp Washer
Relay(BUX), Manifold Tuning Valve
J11
30 Amp Pink
(If Equipped) Sway Bar/Thatchum
Security (BUX)/Power Sliding Door
J13
60 Amp Yellow
Ignition Off Draw (IOD) Main
J14
40 Amp Green
Electric Back Light (EBL)
J15
30 Amp Pink
Rear Blower - if equipped
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
NGC (Powertrain Control Module)/
Transmission Range
J19
60 Amp Yellow
Radiator Fan Motor
J20
30 Amp Pink
Front Windshield Wiper Hi/Low
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Natural
Sunroof Module - if equipped
M1
15 Amp Blue
Center High Mounted Stop Light
(CHMSL)
M2
20 Amp Yellow
(If Equipped) Trailer Lights
M3
20 Amp Yellow
Front/Rear Axle, AWD Mod
M4
10 Amp Red
(If Equipped) Trailer Tow
M5
25 Amp Natural
Power Inverter - if equipped
M6
20 Amp Yellow
Power Outlet #1/Accessory (ACC)
Rain Sensor
M7
20 Amp Yellow
Power Outlet #2 (Battery or
Accessory (ACC) Selectable)
M8
20 Amp Yellow
Front Heated Seats - if equipped
M9
20 Amp Yellow
(If Equipped) Rear Heated Seats
MAINTAINING YOUR VEHICLE
88
Cavity
Cartridge Fuse
Mini-Fuse
Description
M10
15 Amp Blue
Vanity Lamps/Hands-Free Module
(HFM) - if equipped, Remote
Display - if equipped, Satellite
Digital Audio Receiver (SDARS) - if
equipped, Universal Garage Door
Opener (UGDO) - if equipped,
Vanity Light, Video Entertainment
System (VES)™ - if equipped
M11
10 Amp Red
Automatic Temperature Control
(ATC) - if equipped, Underhood
Light
M12
30 Amp Green
Radio, Amplifier (AMP)
M13
20 Amp Yellow
Cabin Compartment Node (CCN),
Multifunction Switch/Siren Module,
ITM
M14
20 Amp Yellow
(If Equipped) Trailer Tow (BUX)
M15
20 Amp Yellow
Auto Dim Rearview Mirror - if
equipped, Infrared Sensor (IR) - if
equipped, Multifunction Switch,
Tire Pressure Monitor System
(TPMS) - if equipped, Transfer Case
Module - if equipped,
M16
10 Amp Red
Occupant Restraint Controller
(ORC)/Occupant Classification
Module (OCM)
M17
15 Amp Blue
Left Park/Side Marker/Running/Tail
Lights, License Lights
M18
15 Amp Blue
Right Park/Side Marker/Running/
Tail Lights
M19
25 Amp Natural
Auto Shut Down (ASD) #1 and #2
M20
15 Amp Blue
Electronic Vehicle Information
Center (EVIC) - if equipped, Interior
Lighting, Steering Wheel Switches -
if equipped, Switch Bank
M21
20 Amp Yellow
Auto Shut Down (ASD) #3
M22
10 Amp Red
Right Horn
M23
10 Amp Red
Left Horn
M24
25 Amp Natural
Rear Wiper
M25
20 Amp Yellow
Fuel Pump/Diesel Lift Pump
M26
10 Amp Red
Power MIRRORS Switch/Drivers
Window Switch
M27
10 Amp Red
Steering Column Lock, Wireless
Ignition Node (WIN)/PEM
M28
10 Amp Red
NGC (Powertrain Control
Module)/Transmission Feed (Batt)
MAINTAINING YOUR VEHICLE
89
Cavity
Cartridge Fuse
Mini-Fuse
Description
M29
10 Amp Red
Occupant Classification Module
(OCM)
M30
15 Amp Blue
Rear Wiper Module Module/Power
Folding Mirror, J1962 Diag Feed
M31
20 Amp Yellow
Back-Up Lights
M32
10 Amp Red
Occupant Restraint Controller
(ORC)
M33
10 Amp Red
NGC (Powertrain Control Module)
Battery Feed/TCM
M34
10 Amp Red
Power Assist Module, HVAC
Module, Headlamp Washers,
Compass Module - if equipped,
Flashlight - if equipped, RAD Fan
Diesel
M35
10 Amp Red
Heated Mirrors - if equipped
M36
20 Amp Yellow
Power Outlet #3 (Batt)
M37
10 Amp Red
Anti-Lock Brake System (ABS),
Electronic Stability Program (ESP),
STOP LIGHT Switch
M38
25 Amp Natural
Lock/Unlock Motors
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly
and inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and
Loading Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the
DVD for more information regarding tire
warnings and instructions.
WARNING!
• Overloading of your tires is dangerous. Overloading can cause tire failure,
affect vehicle handling, and increase your stopping distance. Use tires of the
recommended load capacity for your vehicle. Never overload them.
(Continued)
MAINTAINING YOUR VEHICLE
90