Jeep Wrangler Unlimited - 2011 Fuse Box Diagram

Jeep Wrangler Unlimited - 2011 Fuse Box Diagram

Air Bag Warning Light
You will want to have the air bags ready to
inflate for your protection in a collision. The
Air Bag Warning Light monitors the internal
circuits and interconnecting wiring associated
with air bag system electrical components. While the air
bag system is designed to be maintenance free. If any of
the following occurs, have an authorized dealer service
the air bag system immediately.
The Air Bag Warning Light does not come on during
the four to eight seconds when the ignition switch is
first turned to the ON/RUN position.
The Air Bag Warning Light remains on after the four to
eight-second interval.
The Air Bag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The air bags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper air bag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
This vehicle is equipped with an event data recorder
(EDR). The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as an air
bag deployment or hitting a road obstacle, data that will
assist in understanding how a vehicle’s systems per-
formed. The EDR is designed to record data related to
vehicle dynamics and safety systems for a short period of
time, typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating;
70
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
The front power outlet is powered from the ignition
switch. Power is available when the ignition switch is in
the ON or ACC position.
When the optional cigar lighter heating element is used
in the power outlet, it heats when pushed in and pops out
automatically when ready for use.
To preserve the heat-
ing element, do not hold the lighter in the heating
position.
A second power outlet is located inside the center console
and is powered directly from the vehicle battery.
CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp)
power rating is exceeded the fuse protecting the
system will need to be replaced.
Power outlets are designed for accessory plugs
only. Do not insert any other object in the power
outlets as this will damage the outlet and blow the
fuse. Improper use of the power outlet can cause
damage not covered by your New Vehicle Limited
Warranty.
Front Power Outlet
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
163
On vehicles equipped with a rear subwoofer, there is a
third power outlet located in the right rear cargo area.
Rear Power Outlet — If Equipped
Power Outlet Fuse Locations
1 — M7 Fuse 20 A Yellow Power Outlet Rear with Sub Woofer
(Opt.)
2 — M6 Fuse 20 A Yellow Cigar Lighter Instrument Panel
3 — M36 Fuse 20 A Yellow Power Outlet Console Bin
164
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
(e.g., snow plowing, off-road operation). If this “HOT-
OIL” message turns on, stop the vehicle and run the
engine at idle or faster with the transmission in NEU-
TRAL until the message turns off.
CAUTION!
Continuous driving with the Transmission Tempera-
ture “HOTOIL” Warning message illuminated will
eventually
cause
severe
transmission
damage
or
transmission failure.
WARNING!
If the Transmission Temperature “HOTOIL” Warn-
ing message is illuminated and you continue operat-
ing the vehicle, in some circumstances you could
cause the fluid to boil over, come in contact with hot
engine or exhaust components and cause a fire.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and press the
TRIP ODOMETER button to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations refer to “Fuses” in “Maintaining Your
Vehicle”.
CHAngE OIL Message
Your vehicle is equipped with an engine oil change
indicator system. The “CHANgE OIL” message will flash
276
UNDERSTANDING YOUR INSTRUMENT PANEL
ENGINE COMPARTMENT — 3.8L
1 — Integrated Power Module (Fuses)
7 — Engine Coolant Reservoir
2 — Battery
8 — Engine Oil Fill
3 — Automatic Transmission Dipstick
9 — Air Cleaner Filter
4 — Engine Oil Dipstick
10 — Coolant Pressure Cap
5 — Brake Fluid Reservoir
11 — Power Steering Fluid Reservoir
6 — Washer Fluid Reservoir
7
MAINTAINING YOUR VEHICLE
505
zipper teeth. If a stuck zipper slide is experienced, work
the MOPAR
²
Soft Top Zipper Cleaner and Lubricant or
equivalent into the zipper slide. Several applications may
be required before the zipper comes free.
6. Never paste stickers, gummed labels or any tape to the
windows. Adhesives are hard to remove and may dam-
age the windows.
FUSES
Totally Integrated Power Module
The Totally Integrated Power Module is located in the
engine compartment near the battery. This center con-
tains cartridge fuses, mini fuses and relays. A label that
identifies each component is printed on the inside of the
cover.
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J1
J2
30 Amp
Pink
Transfer Case Module
J3
Totally Integrated Power Module
7
MAINTAINING YOUR VEHICLE
539
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J4
25 Amp
Natural
Driver Door Node
J5
25 Amp
Natural
Passenger Door Node
J6
40 Amp
Green
Anti-Lock Brake Sys-
tem (ABS) Pump/
Stability Control Sys-
tem
J7
30 Amp
Pink
Anti-Lock Brake Sys-
tem (ABS) Valve/
Stability Control Sys-
tem
J8
J9
40 Amp
Green
PZEV Sec Motor/Flex
Fuel
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J10
30 Amp
Pink
Headlamp Wash
Relay/Manifold Tun-
ing Valve
J11
30 Amp
Pink
Sway Bar
J13
60 Amp
Yellow
Ignition Off Draw
(IOD) – Main
J14
40 Amp
Green
Rear Defroster
J15
40 Amp
Green
Front Blower
J17
40 Amp
Green
Starter Solenoid
J18
20 Amp
Blue
Powertrain Control
Module (PCM) Trans
Range
540
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J19
60 Amp
Yellow
Radiator Fan
J20
30 Amp
Pink
Front Wiper LO/HI
J21
20 Amp
Blue
Front/Rear Washer
J22
Spare
M1
15 Amp
Blue
Center High-Mounted
Stop Light (CHMSL)/
Switch Stop Lamp
Feed
M2
20 Amp
Yellow
Relay Trailer Lighting
(Stoplamp)
M3
20 Amp
Yellow
Frt/Rear Axle Locker
Relay
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M4
M5
25 Amp
Natural
Power Inverter – If
Equipped
M6
20 Amp
Yellow
Power Outlet #1/Rain
Sensor
M7
20 Amp
Yellow
Power Outlet #2
(BATT/ACC SELECT)
M8
20 Amp
Yellow
Front Heated Seat
M9
20 Amp
Yellow
Rear Heated Seat – If
Equipped
7
MAINTAINING YOUR VEHICLE
541
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M10
15 Amp
Blue
Ignition Off Draw –
Vehicle Entertainment
System, Satellite Digi-
tal Audio Receiver
(SDARS), DVD,
Hands-Free Module,
RADIO, Antenna,
Universal Garage
Door Opener, Vanity
Lamp
M11
10 Amp
Red
(Ignition Off Draw)
Climate Control Sys-
tem, Underhood
Lamp
M12
30 Amp
Green
Amplifier
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M13
20 Amp
Yellow
Ignition Off Draw –
Cabin Compartment
Node, Wireless Con-
trol Module, SIREN,
Multifunction Control
Switch
M14
20 Amp
Yellow
Trailer Tow (Export
Only)
M15
20 Amp
Yellow
Climate Control Sys-
tem, Rear View Mir-
ror, Cabin Compart-
ment Node, Transfer
Case Switch, Multi-
Function Control
Switch, Tire Pressure
Monitor, Glow Plug
Module – Export Die-
sel Only
542
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M16
10 Amp
Red
Airbag Module
M17
15 Amp
Blue
Left Tail/License/
Park Lamp
M18
15 Amp
Blue
Right Tail/Park/Run
Lamp
M19
25 Amp
Natural
Auto Shut Down
(ASD #1 and #2)
M20
15 Amp
Blue
Cabin Compartment
Node Interior Light,
Switch Bank
M21
20 Amp
Yellow
Auto Shut Down
(ASD #3)
M22
10 Amp
Red
Right Horn (HI/
LOW)
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M23
10 Amp
Red
Left Horn (HI/LOW)
M24
25 Amp
Natural
Rear Wiper
M25
20 Amp
Yellow
Fuel Pump, Diesel
Lift Pump – Export
Only
M26
M27
10 Amp
Red
Ignition Switch Feed,
Wireless Module
M28
10 Amp
Red
Powertrain Control
Module
M29
M30
15 Amp
Blue
Wiper Motor Frt,
J1962 Diagnostic Feed
7
MAINTAINING YOUR VEHICLE
543
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M31
20 Amp
Yellow
Backup Lamps
M32
10 Amp
Red
Airbag Controller, TT
EUROPE
M33
10 Amp
Red
Powertrain Controller
M34
10 Amp
Red
Park Assist, Climate
Control System,
Headlamp Wash,
Compass
M35
10 Amp
Red
Heated Mirrors
M36
20 Amp
Yellow
Power Outlet
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M37
10 Amp
Red
Anti-Lock Brake Sys-
tem, Electronic Stabil-
ity Control, Stop
Lamp Switch, Fuel
Pump Relay
M38
25 Amp
Natural
Lock/Unlock Motors
CAUTION!
When
installing
the
Integrated
Power
Module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the Integrated Power
Module, and possibly result in an electrical system
failure.
(Continued)
544
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
Indicators
- Turn Signal Indicators
- High Beam Indicator
- Front Fog Light Indicator
- Front Axle Lock Indicator*
- Rear Axle Lock Indicator*
- Vehicle Security Indicator*
- O/D (Overdrive) Off
Indicator
- 4WD Indicator*
- Sway Bar Indicator*
- Electronic Stability Control
(ESC) Off Indicator
- Cruise Indicator
Odometer Messages
ECO - Fuel Saver Indicator Off
noFUSE* - Fuse Fault
ECO-ON - Fuel Saver Indicator On
LoW tirE* - Low Tire Pressure
door - Door Ajar
HOTOIL* - Transmission Temperature
Warning Message
gASCAP - Fuel Cap Fault
CHAngE OIL* - Change Engine Oil
gATE* - Liftgate Ajar
ESPOFF * - ESP Deactivated
* If equipped
** Bulb Check with Key On
CONTROLS AT A GLANCE
7
POWER OUTLETS
• There are three possible 12–Volt Power Outlets in this vehicle.
• The front power outlet, located in the lower portion of the instrument panel, is
powered when the key is in the ON or ACC position.
• A second power outlet is located inside the center console bin and is powered
directly from the vehicle battery.
• On vehicles equipped with a rear subwoofer, there is a power outlet located in the
right rear cargo area.
NOTE:
• Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the 160
Watt (13 Amp) power rating is exceeded the fuse protecting the system will need to be
replaced.
• Power outlets are designed for accessory plugs only. Do not insert any other object in
the power outlet as this will damage the outlet and blow the fuse. Improper use of the
power outlet can cause damage not covered by your warranty.
ELECTRONICS
48
FUSES
Integrated Power Module (fuses)
MAINTAINING YOUR VEHICLE
73
• The Integrated Power Module is located in the engine compartment near the battery.
This center contains cartridge fuses, mini-fuses and relays.
Cavity
Cartridge Fuse
Mini Fuse
Description
J1
J2
30 Amp Pink
Transfer Case Module
J3
J4
25 Amp Natural
Driver Door Node
J5
25 Amp Natural
Passenger Door Node
J6
40 Amp Green
Anti-Lock Brake System (ABS)
Pump Feed/ESP
J7
30 Amp Pink
Anti-Lock Brake System (ABS) Valve
Feed/ESP
J8
J9
40 Amp Green
PZEV Sec Motor Feed/Flex Fuel
J10
30 Amp Pink
Headlamp Wash Relay/Manifold
Tuning Valve
J11
30 Amp Pink
Sway Bar
J13
60 Amp Yellow
Ignition Off Draw (IOD) — Main
J14
40 Amp Green
EBL (Rear Window Defogger)
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module (PCM)
Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
Spare
M1
15 Amp Blue
Center High-Mounted Stop Light
(CHMSL)/Switch Stop Lamp Feed
M2
20 Amp Yellow
Relay Trailer Lighting (Stop)
M3
20 Amp Yellow
Frt/Rear Axle Locker Relay
M4
M5
25 Amp Natural
Power Inverter - If Equipped
M6
20 Amp Yellow
Power Outlet #1/Rain Sensor
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC
SELECT)
M8
20 Amp Yellow
Front Heated Seat
M9
20 Amp Yellow
Rear Heated Seat (If Equipped)
M10
15 Amp Blue
Ignition Off Draw — Vehicle
Entertainment System (IOD-VES),
Satellite Digital Audio Receiver
(SDARS), DVD, Hands-Free Module
(HFM), RADIO, Antenna (ANT),
Universal Garage Door Opener
(UGDO), Vanity Lamp (VANITY LP)
MAINTAINING YOUR VEHICLE
74
Cavity
Cartridge Fuse
Mini Fuse
Description
M11
10 Amp Red
(Ignition Off Draw) IOD-HVAC/ATC,
MW SENSR, Underhood Lamp (UH
LMP)
M12
30 Amp Green
Amplifier (AMP)
M13
20 Amp Yellow
Ignition Off Draw— Cabin
Compartment Node (IOD-CCN),
Wireless Control Module (WCM),
SIREN, Multifunction Control Switch
(MULTIFCTN SW)
M14
20 Amp Yellow
Trailer Tow (Export Only)
M15
20 Amp Yellow
COL MOD, IR SNS, Heater
Ventilation, Air Conditioning/
Automatic Temperature Control
(HVAC/ATC), Rear View Mirror (RR
VW MIR), Cabin Compartment Node
(CCN), Transfer Case Switch
(T-CASE SW), RUN/ST,
Multi-Function Control Switch
(MULTIFTCN SW), Tire Pressure
Monitor (TPM), Glow Plug Module
(GLW PLG MOD) — Export Diesel
Only
M16
10 Amp Red
Occupant Restraint Controller (ORC)
M17
15 Amp Blue
Left Tail/License/Park Lamp
(LT-TAIL/LIC/PRK LMP)
M18
15 Amp Blue
Right Tail/Park/Run Lamp
(RT-TAIL/PRK/RUN LMP)
M19
25 Amp Natural
Auto Shut Down (ASD #1 and #2)
M20
15 Amp Blue
Cabin Compartment Node Interior
Light (CCN INT LIGHT), Switch
Bank (SW BANK)
M21
20 Amp Yellow
Auto Shut Down (ASD #3)
M22
10 Amp Red
Right Horn (RT HORN (HI/LOW)
M23
10 Amp Red
Left Horn (LT HORN (HI/LOW)
M24
25 Amp Natural
Rear Wiper (REAR WIPER)
M25
20 Amp Yellow
Fuel Pump (FUEL PUMP), Diesel Lift
Pump (DSL LIFT PUMP) — Export
Only
M26
M27
10 Amp Red
Ignition Switch Feed, Wireless
Module
M28
10 Amp Red
PCM Feed/TCM
M29
M30
15 Amp Blue
Wiper Motor Frt, J1962 Diagnostic
Feed
M31
20 Amp Yellow
Backup Lamps (B/U LAMPS)
MAINTAINING YOUR VEHICLE
75
Cavity
Cartridge Fuse
Mini Fuse
Description
M32
10 Amp Red
Occupant Restraint Controller
(ORC), TT EUROPE
M33
10 Amp Red
Next Generation Controller (NGC),
Global Powertrain Engine Controller
(GPEC)
M34
10 Amp Red
Park Assist (PRK ASST), Heater
Ventilation, Air Conditioning Module
(HVAC MOD), Headlamp Wash
(HDLP WASH), Compass (COMPAS)
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet
M37
10 Amp Red
Anti-Lock Brake System (ABS),
Electronic Stability Program (ESP),
Stop Lamp Switch (STP LP SW),
Fuel Pump Rly Hi Control
M38
25 Amp Natural
Lock/Unlock Motors (LOCK/
UNLOCK MTRS)
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly
and inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the DVD for more information regarding tire
warnings and instructions.
WARNING!
• Overloading of your tires is dangerous. Overloading can cause tire failure,
affect vehicle handling, and increase your stopping distance. Use tires of the
recommended load capacity for your vehicle. Never overload them.
• Improperly inflated tires are dangerous and can cause collisions.
Under-inflation is the leading cause of tire failure and may result in severe
cracking, component separation, or “blow out”. Over-inflation reduces a tire’s
ability to cushion shock. Objects on the road and chuck holes can cause
damage that results in tire failure. Unequal tire pressures can cause steering
problems. You could lose control of your vehicle. Over-inflated or under-inflated
tires can affect vehicle handling and can fail suddenly, resulting in loss of
vehicle control.
MAINTAINING YOUR VEHICLE
76