Chrysler 300 - 2010 Fuse Box Diagram

Chrysler 300 - 2010 Fuse Box Diagram

Airbag Warning Light
You will want to have the airbags ready to
inflate for your protection in a collision. While
the airbag system is designed to be mainte-
nance free, if any of the following occurs, have
an authorized dealer service the system immediately.
The Airbag Warning Light does not come on for
approximately six to eight seconds when the ignition
switch is first placed into the RUN position.
The Airbag Warning Light remains on after the ap-
proximate six to eight-second interval.
The Airbag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The airbags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper airbag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
In the event of a collision, your vehicle is designed to
record up to five seconds of specific vehicle data param-
eters (see list below) in an event data recorder prior to the
moment of airbag deployment, or near deployment (if
applicable), and up to a quarter second of either high-
speed deceleration data or change in velocity during
and/or after airbag deployment or near-deployment.
EDR data is ONLY recorded if an airbag deploys, or
nearly deploys, and is otherwise unavailable.
NOTE:
1. A near-deployment event occurs when the airbag
sensor detects severe vehicle deceleration usually indica-
tive of a crash, but not severe enough to warrant airbag
deployment.
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
69
ELECTRICAL POWER OUTLETS
There are two 12 Volt (13 Amp) electrical power outlets
on this vehicle. Both of the power outlets are protected by
a fuse.
Insert cigar lighter or accessory plug into the power
outlets for use to ensure proper operation.
NOTE:
To ensure proper operation a MOPAR
²
knob and
element must be used.
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system will
need to be replaced.
The 12 Volt power outlet next to the ash receiver tray has
power available only when the ignition is placed in the
ACC or RUN position.
WARNING!
Do not place ashes inside the cubby bin located on
the center console on vehicle’s not equipped with the
ash receiver tray. A fire leading to bodily injury could
result.
Front Power Outlet
200
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
Rear Wheel Drive (RWD) / All Wheel Drive (AWD)
Displays (Base Cluster)
On vehicles equipped with a Base Instrument Cluster, the
odometer will display “2drivE” when the vehicle is in
Rear Wheel Drive (RWD), and “4drivE” when All Wheel
Drive (AWD) is activated.
If the odometer displays the “tCASE” warning message
after engine start up, or during driving, the AWD system
is not functioning properly and service is required.
NOTE:
Vehicles equipped with Electronic Vehicle Infor-
mation
Center
(EVIC)
will
display
“ALL
WHEEL
DRIVE” and “REAR WHEEL DRIVE” when the appro-
priate condition exists. The EVIC will display “SERVICE
AWD SYSTEM” if the system is not functioning properly
and service is required. Refer to “Electronic Vehicle
Information Center (EVIC)” for further information.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and press the
TRIP ODOMETER button to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
Lo tirE
When the appropriate tire pressure is low, the odometer
display will toggle between Lo and tirE for three cycles.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
218
UNDERSTANDING YOUR INSTRUMENT PANEL
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations refer to “Fuses” in “Maintaining Your
Vehicle”.
CHAngE OIL
Your vehicle is equipped with an engine oil change
indicator system. The “CHAngE OIL” message will flash
in the instrument cluster odometer for approximately
12 seconds after a single chime has sounded to indicate
the next scheduled oil change interval. The engine oil
change indicator system is duty cycle based, which
means the engine oil change interval may fluctuate
dependent upon your personal driving style.
Unless reset, this message will continue to display each
time you place the ignition switch in the RUN position.
To turn off the message temporarily, press and release the
TRIP ODOMETER button on the instrument cluster. To
reset the oil change indicator system (after performing
the scheduled maintenance) perform the following pro-
cedure:
1. Place the ignition switch in the RUN position. (Do
not start the engine).
2. Fully depress the accelerator pedal slowly three
times within 10 seconds.
3. Place the ignition switch in the OFF position.
NOTE:
If the indicator message illuminates when you
start the vehicle, the oil change indicator system did not
reset. If necessary, repeat this procedure.
On vehicles equipped with a Premium Instrument Clus-
ter, this display shows the Electronic Vehicle Information
Center (EVIC) messages when the appropriate conditions
exist.
4
UNDERSTANDING YOUR INSTRUMENT PANEL
219
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning the Center Console Cupholders
Clean with a damp cloth or towel using a mild detergent
with the cupholder in the center console.
NOTE:
The cupholder cannot be removed.
FUSES
Integrated Power Module
The Integrated Power Module (IPM) is located in the
engine compartment. This module contains fuses and
relays.
Integrated Power Module
460
MAINTAINING YOUR VEHICLE
CAUTION!
When
installing
the
integrated
power
module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the integrated power
module and possibly result in an electrical system
failure.
When replacing a blown fuse, it is important to
use only a fuse having the correct amperage rating.
The use of a fuse with a rating other than indicated
may result in a dangerous electrical system over-
load. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be
corrected.
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
1
15 Amp
Blue
Washer Motor
2
25 Amp
Neutral
Powertrain Control
Module (PCM)
3
25 Amp
Neutral
Ignition Run/Start
4
25 Amp
Neutral
Alternator/EGR Sole-
noid
5
6
25 Amp
Neutral
Ignition Coils/Injectors/
Short Runner Valve
7
7
MAINTAINING YOUR VEHICLE
461
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
8
30 Amp
Green
Starter
9
10
30 Amp
Pink
Windshield Wiper
11
30 Amp
Pink
Anti-Lock Brake System
(ABS) Valves – If
Equipped
12
40 Amp
Green
Radiator Fan
13
50 Amp
Red
Anti-Lock Brake System
(ABS) Pump Motor – If
Equipped
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
14
15
50 Amp
Red
Radiator Fan
16
17
18
19
20
21
22
462
MAINTAINING YOUR VEHICLE
Rear Power Distribution Center
There is also a power distribution center located in the
trunk under the spare tire access panel. This center
contains fuses and relays.
Opening The Access Panel
Rear Power Distribution Center
7
MAINTAINING YOUR VEHICLE
463
CAUTION!
When
installing
the
power
distribution
center
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the power distribution
center and possibly result in an electrical system
failure.
When replacing a blown fuse, it is important to
use only a fuse having the correct amperage rating.
The use of a fuse with a rating other than indicated
may result in a dangerous electrical system over-
load. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be
corrected.
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
1
60 Amp
Yellow
Ignition Off Draw (IOD)
Cavity 1 of the Rear
Power Distribution
Center contains a black
IOD fuse needed for
vehicle processing dur-
ing assembly. The ser-
vice replacement part is
a 60 Amp yellow car-
tridge fuse.
2
40 Amp
Green
Integrated Power Mod-
ule (IPM)
3
4
40 Amp
Green
Integrated Power Mod-
ule (IPM)
464
MAINTAINING YOUR VEHICLE
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
5
30 Amp
Pink
Heated Seats – If
Equipped
6
20 Amp
Yellow
Fuel Pump
7
15 Amp
Blue
Rear Heated Seats – If
Equipped
8
15 Amp
Blue
Diagnostic Link Connec-
tor (DLC)/Wireless Con-
trol Module (WCM)/
Wireless Ignition Node
(WIN)
9
20 Amp
Yellow
Power Outlet
10
11
*
12
*
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
13
*
14
10 Amp
Red
AC Heater Control/
Cluster/Security Mod-
ule – If Equipped
15
20 Amp
Yellow
Trailer Tow Brake Mod-
ule – If Equipped
16
17
20 Amp
Yellow
Cluster
18
20 Amp
Yellow
Selectable Power Outlet
19
10 Amp
Red
Stop Lights
20
21
7
MAINTAINING YOUR VEHICLE
465
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
22
23
24
25
26
27
10 Amp
Red
Occupant Restraint Con-
troller (ORC)
28
10 Amp
Red
Ignition Run, AC Heater
Control/Headlights/
Park Assist – If
Equipped/Tire Pressure
Monitoring – If
Equipped/Occupant
Restraint Controller
(ORC)
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
29
5 Amp
Orange
Adaptive Cruise Control
(ACC) – If Equipped/
Cluster/Electronic Sta-
bility Program (ESP) – If
Equipped/Powertrain
Control Module (PCM)/
STOP LIGHT Switch
30
10 Amp
Red
Door Modules/Power
Mirrors/Steering Con-
trol Module (SCM)
31
32
33
34
466
MAINTAINING YOUR VEHICLE
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
35
5 Amp
Orange
Antenna Module – If
Equipped/Power
Mirrors/Rain Sensor – If
Equipped
36
25 Amp
Natural
Hands-Free Phone – If
Equipped/Video Moni-
tor – If Equipped/Radio
37
15 Amp
Blue
Transmission
38
10 Amp
Red
Analog Clock/Cargo
Light/Satellite Receiver
(SDARS) Video – If
Equipped/Vehicle Infor-
mation Module – If
Equipped
Cavity
Car-
tridge
Fuse
Mini-
Fuse
Description
39
10 Amp
Red
Heated Mirrors – If
Equipped
40
5 Amp
Orange
Auto Inside Rearview
Mirror – If Equipped/
Heated Seats – If
Equipped/Switch Bank
41
15 Amp
Blue
AWD Module – If
Equipped
42
30 Amp
Pink
Front Blower Motor
43
30 Amp
Pink
Rear Window Defroster
44
20 Amp
Blue
Amplifier – If
Equipped/Sunroof – If
Equipped
7
MAINTAINING YOUR VEHICLE
467
Indicators
- Turn Signal Indicators
- High Beam Indicator
- Front Fog Light Indicator
- Vehicle Security Indicator*
- Electronic Speed
Control/Adaptive Cruise
Control (ACC) Indicator
- Electronic Stability Program
(ESP)/Traction Control
System (TCS) Indicator
- Windshield Washer Fluid
Low Indicator
- Door Ajar Indicator
- Decklid Ajar Indicator
Odometer Messages
ECO - Fuel Saver Indicator
CHAngE OIL* - Change Engine Oil
2drivE - Vehicle is in Rear Wheel Drive (RWD)
noFUSE* - Fuse Fault
4drivE - Vehicle is in All Wheel Drive (AWD)
Lo tirE* - Low Tire Pressure
tCASE - AWD System Fault
gASCAP - Fuel Cap Fault
* If equipped
** Bulb Check with Key On
7
CONTROLS AT A GLANCE
• The second outlet in the center console is powered directly from the battery
(power available at all times). Items plugged into this outlet may discharge the
battery and/or prevent engine starting.
NOTE:
Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the
160 Watt (13 Amp) power rating is exceeded the fuse protecting the system will need
to be replaced.
Uconnect™ Phone
• The Uconnect™ Phone is a voice-activated, hands-free, in-vehicle communications
system.
• The Uconnect™ Phone allows you to dial a phone number with your cellular phone
using simple voice commands.
• For vehicles equipped with Video Entertainment System (VES)™, refer to the
Uconnect™ Phone section of the Uconnect™ User’s Manual on the DVD for further
details.
• For vehicles not equipped with VES™, refer to your vehicle Owner’s Manual on the
DVD for further details.
WARNING!
• Any voice commanded system should be used only in safe driving conditions
following local laws and phone use. All attention should be kept on the roadway
ahead. Failure to do so may result in an accident causing serious injury or death.
• Your phone must be turned on and paired to the Uconnect™ Phone to allow use
of this vehicle feature in emergency situations, when the cellular phone has
network coverage and stays paired to the Uconnect™ Phone.
NOTE:
The Uconnect™ Phone requires a cellular phone equipped with the
Bluetooth
®
Hands-Free Profile, Version 0.96 or higher. For Uconnect™ customer
support, call 1–877–855–8400.
Phone Pairing
NOTE:
Pairing is a one-time initial setup before using the phone. You will also need
to follow the Bluetooth
®
instructions in your cell phone user guide to complete the
phone pairing setup.
• Press the Phone button
to begin.
• Wait for the “ready” prompt and beep.
• (After the BEEP), say “Uconnect setup”.
• (After the BEEP), say “phone pairing”.
• (After the BEEP), say “pair a phone”.
• Follow the audible prompts.
ELECTRONICS
40
FUSES
Integrated Power Module (IPM)
• The Integrated Power Module (IPM) is located in the engine compartment on the
right hand side near the Washer Fluid Reservoir. This module contains fuses and
relays.
Cavity
Cartridge Fuse
Mini-Fuse
Description
1
15 Amp Blue
Washer Motor
2
25 Amp Natural
Powertrain Control Module (PCM)
3
25 Amp Natural
Ignition Run/Start
4
25 Amp Natural
EGR Solenoid/Alternator
5
6
25 Amp Natural
Ignition Coils/Injectors
7
8
30 Amp Green
Starter
10
30 Amp Pink
Windshield Wiper
11
30 Amp Pink
Anti-Lock Brake System (ABS)
Valves
12
40 Amp Green
Radiator Fan Lo/High
13
50 Amp Red
Anti-Lock Brake System (ABS)
Pump Motor
14
15
50 Amp Red
Radiator Fan
MAINTAINING YOUR VEHICLE
74
Fuses – Rear Power Distribution Center
75
MAINTAINING YOUR VEHICLE
• There is also a power distribution center located in the trunk under the spare tire
access panel. This center contains fuses and relays.
Cavity
Cartridge Fuse
Mini-Fuse
Description
1
60 Amp Yellow
Ignition Off Draw (IOD)
2
40 Amp Green
Integrated Power Module (IPM)
3
4
40 Amp Green
Integrated Power Module (IPM)
5
30 Amp Pink
Heated Seats - if equipped
6
20 Amp Yellow
Fuel Pump
7
15 Amp Blue
Sub Amp - if equipped
8
15 Amp Blue
Diagnostic Link Connector
(DLC)/Wireless Control Module
(WCM)/Wireless Ignition Node (WIN)
9
20 Amp Yellow
Power Outlet
10
11
12
13
14
10 Amp Red
AC Heater Control/Cluster/Security
Module - if equipped
15
16
17
20 Amp Yellow
Cluster
18
20 Amp Yellow
Selectable Power Outlet
19
10 Amp Red
Stop Lights
20
21
22
23
24
25
26
27
10 Amp Red
Occupant Restraint Controller (ORC)
28
10 Amp Red
Ignition Run
29
5 Amp Orange
Cluster/Electronic Stability Program
(ESP)/Powertrain Control Module
(PCM)/STOP LIGHT Switch
30
10 Amp Red
Door Modules/Power Mirrors/Steering
Control Module (SCM)
31
32
33
34
MAINTAINING YOUR VEHICLE
76
Cavity
Cartridge Fuse
Mini-Fuse
Description
35
5 Amp Orange
Antenna Module - if equipped/Power
Mirrors
36
25 Amp Natural
Uconnect™ Phone - if equipped/
Radio/Amplifier Feed
37
15 Amp Blue
Transmission
38
10 Amp Red
Cargo Light/Vehicle Information
Module - if equipped
39
10 Amp Red
Heated Mirrors - if equipped
40
5 Amp Orange
Auto Inside Rearview Mirror/Heated
Seats - if equipped/Switch Bank
41
42
30 Amp Pink
Front Blower Motor
43
30 Amp Pink
Rear Window Defroster
44
20 Amp Blue
Amplifier/Sunroof - if equipped
45
46
47
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly
and inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and
Loading Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner’s Manual on the DVD for more information on the life of
tires.
WARNING!
Overloading of your tires is dangerous. Overloading can cause tire failure, affect
vehicle handling, and increase your stopping distance. Use tires of the
recommended load capacity for your vehicle. Never overload them.
WARNING!
Improperly inflated tires are dangerous and can cause accidents. Under-inflation is
the leading cause of tire failure and may result in severe cracking, component
separation, or “blow out”. Over-inflation reduces a tire’s ability to cushion shock.
Objects on the road and chuck holes can cause damage that results in tire failure.
Unequal tire pressures can cause steering problems. You could lose control of your
vehicle. Over-inflated or under-inflated tires can affect vehicle handling and can
fail suddenly, resulting in loss of vehicle control.
77
MAINTAINING YOUR VEHICLE