Dodge Caliber - 2010 Fuse Box Diagram

Dodge Caliber - 2010 Fuse Box Diagram

NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The airbags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper airbag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
In the event of a collision, your vehicle is designed to
record up to five seconds of specific vehicle data param-
eters (see list below) in an event data recorder prior to the
moment of airbag deployment, or near deployment (if
applicable), and up to a quarter second of either high-
speed deceleration data or change in velocity during
and/or after airbag deployment or near-deployment.
EDR data is ONLY recorded if an airbag deploys, or
nearly deploys, and is otherwise unavailable.
NOTE:
1. A near-deployment event occurs when the airbag
sensor detects severe vehicle deceleration usually indica-
tive of a crash, but not severe enough to warrant airbag
deployment.
2. Under certain circumstances, EDR data may not be
recorded (e.g., loss of battery power).
In conjunction with other data gathered during a com-
plete accident investigation, the electronic data may be
used by Chrysler Group LLC and others to learn more
about the possible causes of crashes and associated
injuries in order to assess and improve vehicle perfor-
mance. In addition to crash investigations initiated by
Chrysler Group LLC, such investigations may be re-
quested by customers, insurance carriers, government
officials, and professional crash researchers, such as those
associated with universities, and with hospital and insur-
ance organizations.
72
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
NOTE:
To ensure proper operation, a MOPAR
²
knob and
element must be used.
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system will
need to be replaced.
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of
outlet should be inserted into any 12 Volt outlet.
Do not touch with wet hands.
Close the lid when not in use and while driving
the vehicle.
If this outlet is mishandled, it may cause an
electric shock and failure.
CAUTION!
Many accessories that can be plugged in draw
power from the vehicle’s battery, even when not in
use
(i.e.,
cellular
phones,
etc.).
Eventually,
if
plugged in long enough, the vehicle’s battery will
discharge
sufficiently
to
degrade
battery
life
and/or prevent the engine from starting.
Accessories that draw higher power (i.e., coolers,
vacuum cleaners, lights, etc.) will degrade the
battery even more quickly. Only use these inter-
mittently and with great caution.
After the use of high power draw accessories, or
long periods of the vehicle not being started (with
accessories still plugged in), the vehicle must be
driven a sufficient length of time to allow the
generator to recharge the vehicle’s battery.
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
169
“gATE” and “Oil Change Required” will only be dis-
played in the EVIC display. For additional information,
refer to “Electronic Vehicle Information Center (EVIC) —
If Equipped”.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and press the
TRIP ODOMETER button to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
LoW TirE
When tire pressure is low, the odometer display will
toggle between LoW and TirE for three cycles.
HOTOIL
When this message is displayed there is a engine over-
temperature condition. When this condition occurs, the
“HOTOIL” message will be displayed in the odometer
along with a chime.
Refer to “Engine Oil Overheating” under in “What To Do
In Emergencies”.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations refer to “Fuses” in “Maintaining Your
Vehicle”.
CHAngE OIL
Your vehicle is equipped with an engine oil change
indicator system. The “CHAngE OIL” message will flash
in the instrument cluster odometer for approximately
198
UNDERSTANDING YOUR INSTRUMENT PANEL
Replace the seat belts if they appear frayed or worn or if
the buckles do not work properly.
Dry with a soft cloth.
FUSES
Integrated Power Module (IPM)
The Integrated Power Module (IPM) is located in the
engine compartment near the air cleaner assembly. This
center contains cartridge fuses and mini-fuses. A label
that identifies each component may be printed on the
inside of the cover. Refer to “Engine Compartment” in
“Maintaining Your Vehicle” for further information.
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
1
Empty
Empty
2
15 Amp
Lt Blue
AWD/4WD ECU
Feed
Integrated Power Module
7
MAINTAINING YOUR VEHICLE
423
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
3
10 Amp
Red
CHMSL Brake Switch
Feed
4
10 Amp
Red
Ignition Switch Feed/
OCM
5
20 Amp
Yellow
Trailer Tow – If
Equipped
6
10 Amp
Red
IOD Sw/Pwr Mir/
Steering Cntrl Sdar/
Hands-Free Phone –
If Equipped
7
30 Amp
Green
IOD Sense1
8
30 Amp
Green
IOD Sense2
9
40 Amp
Green
Power Seats – If
Equipped
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
10
20 Amp
Yellow
CCN Power Locks/
Interior Lighting
11
15 Amp
Lt Blue
Power Outlet
12
20 Amp
Yellow
Ign Run/Acc Inverter
13
20 Amp
Yellow
Pwr Run/Acc Outlet
RR/Dome Lamp/
Cigar Lighter
14
10 Amp
Red
IOD CCN
15
40 Amp
Green
RAD Fan Relay Bat-
tery Feed
16
15 Amp
Lt Blue
IGN Run/Acc Dome
Lamp/Sunroof/Rear
Wiper Motor/ACC
Inverter
424
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
17
10 Amp
Red
IOD Feed Mod-Wcm
18
40 Amp
Green
ASD Relay Contact
PWR Feed
19
20 Amp
Yellow
PWR Amp 1 & Amp
2 Feed
20
15 Amp
Lt Blue
IOD Feed Radio
21
10 Amp
Red
IOD Feed Intrus
Mod/Siren – If
Equipped
22
10 Amp
Red
IGN RUN Heat/AC/
Compass Sensor
23
15 Amp
Lt Blue
ENG ASD Relay Feed
3
24
15 Amp
Lt Blue
Power Sunroof Feed –
If Equipped
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
25
10 Amp
Red
Heated Mirror – If
Equipped
26
15 Amp
Lt Blue
ENG ASD Relay Feed
2
27
10 Amp
Red
IGN RUN Only ORC
Feed
28
10 Amp
Red
IGN RUN ORC/OCM
Feed
29
Hot Car (No Fuse Re-
quired)
30
20 Amp
Yellow
Heated Seat – If
Equipped
31
10 Amp
Red
Headlamp Washer
Relay Control – If
Equipped
32
30 Amp
Pink
ENG ASD Control
Feed 1
7
MAINTAINING YOUR VEHICLE
425
Cavity
Cartridge
Fuse
Mini-
Fuse
Description
33
10 Amp
Red
ABS MOD/J1962
Conn/PCM
34
30 Amp
Pink
ABS Valve Feed
35
40 Amp
Green
ABS Pump Feed
36
30 Amp
Pink
Headlamp/Washer
Control/Smart Glass
– If Equipped
37
25 Amp
Natural
Diesel Fuel Heater –
If Equipped
CAUTION!
When installing the IPM cover, it is important to
ensure the cover is properly positioned and fully
latched. Failure to do so may allow water to get
into the IPM, and possibly result in an electrical
system failure.
When replacing a blown fuse, it is important to
use only a fuse having the correct amperage rating.
The use of a fuse with a rating other than indicated
may result in a dangerous electrical system over-
load. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be
corrected.
426
MAINTAINING YOUR VEHICLE
WARNING!
To avoid serious injury or death: Do not use a three-prong adaptor. Do not insert any
objects into the receptacles. Do not touch with wet hands. Close the lid when not in
use. If this outlet is mishandled, it may cause an electric shock and failure.
POWER OUTLET
• The power outlet is located on the instrument panel below the climate control and is
powered when the ignition switch is in the ON/RUN position.
• The outlet can operate a conventional cigar lighter unit or power accessories designed
for use with a standard power outlet adapter.
NOTE:
Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the 160
Watt (13 Amp) power rating is exceeded the fuse protecting the system will need to be
replaced.
Uconnect™ Phone
• The Uconnect™ Phone is a voice-activated, hands-free, in-vehicle communications
system.
• The Uconnect™ Phone allows you to dial a phone number with your cellular phone
using simple voice commands.
• For vehicles equipped with Video Entertainment System (VES)™, refer to the
Uconnect™ Phone section of the Uconnect™ User's Manual on the DVD for further
details.
• For vehicles not equipped with VES™, refer to your vehicle Owner's Manual on the
DVD for further details.
WARNING!
• Any voice commanded system should be used only in safe driving conditions
following local laws and phone use. All attention should be kept on the roadway
ahead. Failure to do so may result in an accident causing serious injury or death.
• Your phone must be turned on and paired to the Uconnect™ Phone to allow use of
this vehicle feature in emergency situations, when the cellular phone has network
coverage and stays paired to the Uconnect™ Phone.
NOTE:
The Uconnect™ Phone requires a cellular phone equipped with the Bluetooth
®
Hands-Free Profile, Version 0.96 or higher. For Uconnect™ customer support, call
1–877–855–8400.
35
ELECTRONICS
FUSES
Integrated Power Module (IPM)
• The Integrated Power Module (IPM) is located in the engine compartment near the air
cleaner assembly. This center contains cartridge fuses and mini-fuses.
Cavity
Cartridge Fuse
Mini-Fuse
Description
1
Empty
Empty
2
15 Amp Lt Blue
AWD/4WD ECU Feed
3
10 Amp Red
CHMSL Brake Switch Feed
4
10 Amp Red
Ignition Switch Feed/OCM
5
20 Amp Yellow
Trailer Tow
6
10 Amp Red
IOD Sw/Pwr Mir/Steering Cntrl
Sdar/Hands-Free Phone
7
30 Amp Green
IOD Sense1
8
30 Amp Green
IOD Sense2
9
40 Amp Green
Power Seats
10
20 Amp Yellow
CCN Power Locks/Interior Lighting
11
15 Amp Lt Blue
Power Outlet
12
20 Amp Yellow
Ign Run/Acc Inverter
13
20 Amp Yellow
Pwr Run/Acc Outlet RR/Dome Lamp/Cigar
Lighter
14
10 Amp Red
IOD CCN
15
40 Amp Green
RAD Fan Relay Battery Feed
16
15 Amp Lt Blue
IGN Run/ACC Dome Lamp/Sunroof/Rear
Wiper Motor/ACC Inverter
17
10 Amp Red
IOD Feed Mod-Wcm
18
40 Amp Green
ASD Relay Contact PWR Feed
19
20 Amp Yellow
PWR Amp 1 & Amp 2 Feed
20
15 Amp Lt Blue
IOD Feed Radio
21
10 Amp Red
IOD Feed Intrus Mod/Siren (If Equipped)
MAINTAINING YOUR VEHICLE
62
Cavity
Cartridge Fuse
Mini-Fuse
Description
22
10 Amp Red
IGN RUN Heat/AC/Compass Sensor
23
15 Amp Lt Blue
ENG ASD Relay Feed 3
24
15 Amp Lt Blue
Power Sunroof Feed
25
10 Amp Red
Heated Mirror (If Equipped)
26
15 Amp Lt Blue
ENG ASD Relay Feed 2
27
10 Amp Red
IGN RUN Only ORC Feed
28
10 Amp Red
IGN RUN ORC/OCM Feed
29
Hot Car (No Fuse Required)
30
20 Amp Yellow
Heated Seat (If Equipped)
31
10 Amp Red
Headlamp Washer Relay Control (If
Equipped)
32
30 Amp Pink
ENG ASD Control Feed 1
33
10 Amp Red
ABS MOD/J1962 Conn/PCM
34
30 Amp Pink
ABS Valve Feed
35
40 Amp Green
ABS Pump Feed
36
30 Amp Pink
Headlamp/Washer Control/Smart Glass (If
Equipped)
37
25 Amp
Natural
Diesel Fuel Heater (If Equipped)
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly and
inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the DVD for more information on the life of tires.
WARNING!
Overloading of your tires is dangerous. Overloading can cause tire failure, affect
vehicle handling, and increase your stopping distance. Use tires of the recommended
load capacity for your vehicle. Never overload them.
WARNING!
Improperly inflated tires are dangerous and can cause accidents. Under-inflation is
the leading cause of tire failure and may result in severe cracking, component
separation, or “blow out”. Over-inflation reduces a tire’s ability to cushion shock.
Objects on the road and chuck holes can cause damage that results in tire failure.
Unequal tire pressures can cause steering problems. You could lose control of your
vehicle. Over-inflated or under-inflated tires can affect vehicle handling and can fail
suddenly, resulting in loss of vehicle control.
63
MAINTAINING YOUR VEHICLE