Dodge Grand Caravan C/V - 2010 Fuse Box Diagram

Dodge Grand Caravan C/V - 2010 Fuse Box Diagram

Airbag Warning Light
You will want to have the airbags ready to
inflate for your protection in a collision. While
the airbag system is designed to be mainte-
nance free, if any of the following occurs, have
an authorized dealer service the system immediately.
The Airbag Warning Light does not come on for
approximately four to six seconds when the ignition
switch is first turned ON.
The Airbag Warning Light remains on after the ap-
proximate four to six-second interval.
The Airbag Warning Light comes on intermittently or
remains on while driving.
NOTE:
If the speedometer, tachometer, or any engine
related gauges are not working, the Occupant Restraint
Controller (ORC) may also be disabled. The airbags may
not be ready to inflate for your protection. Promptly
check the fuse block for blown fuses. Refer to the label
located on the inside of the fuse block cover for the
proper airbag fuses. See your authorized dealer if the
fuse is good.
Event Data Recorder (EDR)
In the event of a collision, your vehicle is designed to
record up to five seconds of specific vehicle data param-
eters (see list below) in an event data recorder prior to the
moment of airbag deployment, or near deployment (if
applicable), and up to a quarter second of either high-
speed deceleration data or change in velocity during
and/or after airbag deployment or near-deployment.
EDR data is ONLY recorded if an airbag deploys, or
nearly deploys, and is otherwise unavailable.
NOTE:
1. A near-deployment event occurs when the airbag
sensor detects severe vehicle deceleration usually indica-
tive of a crash, but not severe enough to warrant airbag
deployment.
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
81
with the sunroof open, adjust the sunroof opening to
minimize the buffeting or open any window.
Sunroof Maintenance
Use only a non-abrasive cleaner and a soft cloth to clean
the glass panel.
ELECTRICAL POWER OUTLETS — IF EQUIPPED
Two 12 Volt (13 Amp) power outlets are located on the
lower instrument panel, next to the open storage bin. The
upper power outlet is controlled by the ignition switch
and the lower power outlet is connected directly to the
battery. The upper power outlet will also operate a
conventional cigar lighter unit (if equipped with an
optional Smoker’s Package).
NOTE:
To ensure proper operation a MOPAR
²
cigar knob and
element must be used.
Do not exceed the maximum power of 160 Watts (13
Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system will
need to be replaced.
One outlet in the removable floor console shares a fuse
with the lower outlet in the instrument panel and is also
12 Volt Power Outlets
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
195
NOTE:
If your vehicle is equipped with a hood switch, in the
case of hood ajar, a warning message will be displayed
in either the PRNDL/Odometer display as “hood” or
“Hood Ajar” in the EVIC display.
Some of the above warnings will be displayed in the
Compass Mini-Trip Computer / Electronic Vehicle
Information Center Display Area located in the instru-
ment cluster.
Refer
to
”Compass
Mini-Trip
Computer
(CMTC)
Display— If Equipped” / ”Electronic Vehicle Informa-
tion Center (EVIC) Display — If Equipped” for further
information.
ECO / ECO-on (Fuel Saver Indicator) — If Equipped
The ECO-on indicator will illuminate when you are
driving in a fuel efficient manner and can be used to
modify driving habits in order to increase fuel economy.
The ECO display will toggle between ECO and ECO-on
depending on driving habits and vehicle usage.
LoW tirE
When the appropriate condition exists, the odometer
display will toggle between LoW and tirE for three
cycles.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and press the
Odometer / Trip Odometer Display Reset button to turn
off the message. If the problem continues, the message
will appear the next time the vehicle is started.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
232
UNDERSTANDING YOUR INSTRUMENT PANEL
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations refer to “Fuses” in “Maintaining Your
Vehicle”.
CHAngE OIL
Your vehicle is equipped with an engine oil change
indicator system. The “Change Oil” message will flash in
the
instrument
cluster
odometer
for
approximately
12 seconds after a single chime has sounded to indicate
the next scheduled oil change interval. The engine oil
change
indicator
system
is
duty
cycle-based,
which
means the engine oil change interval may fluctuate
dependent upon your personal driving style.
Unless reset, this message will continue to display each
time you turn the ignition switch to the ON/RUN
position. To turn off the message temporarily, press and
release the Trip Odometer button on the instrument
cluster. To reset the oil change indicator system (after
performing the scheduled maintenance), refer to the
following procedure:
1. Turn the ignition switch to the ON position (Do not
start the engine).
2. Fully depress the accelerator pedal slowly three times
within 10 seconds.
3. Turn the ignition switch to the OFF/LOCK position.
NOTE:
If the indicator message illuminates when you
start the vehicle, the oil change indicator system did not
reset. If necessary repeat this procedure.
13. Odometer / Trip Odometer Display Reset Button
To reset a message display (gATE, gASCAP, noFUSE,
CHAngE OIL, LoCOOL, LoWASH), push and hold the
button until the display resets (approximately two sec-
onds).
4
UNDERSTANDING YOUR INSTRUMENT PANEL
233
Installation
Place the liner into the cupholder drawer and press the
liner into place so that the retention tabs seat into the
corresponding openings in the drawer.
FUSES
Totally Integrated Power Module (TIPM)
The Totally Integrated Power Module (TIPM) is located
in the engine compartment near the battery. Refer to the
applicable “Engine Compartment” illustration in this
section. This center contains cartridge fuses and mini-
fuses. A label that identifies each component may be
printed or embossed on the inside of the cover.
Totally Integrated Power Module (TIPM)
7
MAINTAINING YOUR VEHICLE
465
CAUTION!
When
installing
the
Totally
Integrated
Power
Module cover, it is important to ensure the cover is
properly positioned and fully latched. Failure to
do so may allow water to get into the Integrated
Power Module, and possibly result in a electrical
system failure.
When replacing a blown fuse, it is important to
use only a fuse having the correct amperage rating.
The use of a fuse with a rating other than indicated
may result in a dangerous electrical system over-
load. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be
corrected.
The numbers inside the TIPM cover correspond to the
following table.
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
J1
40 Amp
Green
Power Folding Seat
J2
30 Amp
Pink
Power Liftgate
Module
J3
30 Amp
Pink
Rear Door Module
(RR Door Node)
J4
25 Amp
Natural
Driver Door Node
J5
25 Amp
Natural
Passenger Door
Node
J6
40 Amp
Green
Antilock Brakes
Pump/Stability
Control System
J7
30 Amp
Pink
Antilock Brakes
Valve/Stability
Control System
466
MAINTAINING YOUR VEHICLE
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
J8
40 Amp
Green
Power Memory
Seat – If Equipped
J9
40 Amp
Green
Partial Zero Emis-
sions Vehicle
Motor/Flex Fuel
J10
30 Amp
Pink
Headlamp Wash
Relay/Manifold
Tuning Valve
J11
30 Amp
Pink
Power Sliding Door
Module/Anti–Theft
Module Relay Lock
Feed
J13
60 Amp
Yellow
Ignition Off Draw
(IOD) – Main
J14
40 Amp
Green
Rear Window De-
fogger
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
J15
30 Amp
Pink
Rear Blower
J17
40 Amp
Green
Starter Solenoid
J18
20 Amp
Blue
Powertrain
Control Module
Trans Range
J19
60 Amp
Yellow
Radiator Fan
J20
30 Amp
Pink
Front Wiper LO/HI
J21
20 Amp
Blue
Front/Rear Washer
J22
25 Amp
Natural
Sunroof Module
7
MAINTAINING YOUR VEHICLE
467
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M1
15 Amp
Blue
Rear Center Brake
Lamp/Brake
Switch
M2
M3
20 Amp
Yellow
Spare Fuse
M4
10 Amp
Red
Trailer Tow
M5
25 Amp
Natural
Inverter
M6
20 Amp
Yellow
Power Outlet #1
(ACC), Rain Sensor
M7
20 Amp
Yellow
Power Outlet #2
(BATT/ACC
SELECT)
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M8
20 Amp
Yellow
Front Heated
Seat – If Equipped
M9
20 Amp
Yellow
Rear Heated
Seat – If Equipped
M10
15 Amp
Blue
Ignition Off
Draw — Video Sys-
tem, Satellite Ra-
dio, DVD, Hands-
Free Module,
Universal Garage
Door Opener, Van-
ity Lamp, Stream-
ing Video Module
M11
10 Amp
Red
Ignition Off
Draw – Climate
Control System
468
MAINTAINING YOUR VEHICLE
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M12
30 Amp
Green
Amplifier (AMP)/
Radio
M13
20 Amp
Yellow
Ignition Off
Draw— Instrument
Cluster, SIREN,
Clock Module,
Multi-Function
Control Switch/
ITM
M14
20 Amp
Yellow
Spare Fuse
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M15
20 Amp
Yellow
Rear View Mirror,
Instrument Cluster,
Multi-Function
Control Switch,
Tire Pressure Moni-
tor, Glow Plug
Module – Export
Diesel Only, Assy-
Shifter (Hall Effect),
Acoustic Noise
Cancellation
M16
10 Amp
Red
Airbag Module/
Occupant Classifi-
cation Module
M17
15 Amp
Blue
Left Tail/License/
Park Lamp, Run-
ning Lamps
7
MAINTAINING YOUR VEHICLE
469
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M18
15 Amp
Blue
Right Tail/Park/
Run Lamp
M19
25 Amp
Natural
Automatic Shut-
down #1 and #2
M20
15 Amp
Blue
Instrument Cluster
Interior Light,
Switch Bank, Steer-
ing Column Mod-
ule, Switch Steering
Wheel
M21
20 Amp
Yellow
Automatic
Shutdown #3
M22
10 Amp
Red
Right Horn
(HI/LOW)
M23
10 Amp
Red
Left Horn
(HI/LOW)
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M24
25 Amp
Natural
Rear Wiper
M25
20 Amp
Yellow
Fuel Pump, Diesel
Lift Pump – Export
Only
M26
10 Amp
Red
Power Mirror
Switch, Driver
Window Switch
M27
10 Amp
Red
Ignition Switch,
Wireless Control
Module, Keyless
Entry Module,
Steering Column
Lock
470
MAINTAINING YOUR VEHICLE
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M28
10 Amp
Red
Powertrain Control
Module, Transmis-
sion Feed, Trans-
mission Control
Module
M29
10 Amp
Red
Occupant Classifi-
cation Module
M30
15 Amp
Blue
Rear Wiper Mod-
ule, Power Folding
Mirror, J1962 Diag-
nostic Feed
M31
20 Amp
Yellow
Back-Up Lamps
M32
10 Amp
Red
Airbag Module, TT
EUROPE
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M33
10 Amp
Red
Powertrain Control
Module, Transmis-
sion Control Mod-
ule
M34
10 Amp
Red
Park Assist, Heater
Climate Control
System Module,
Headlamp Wash,
Compass, IR Sen-
sor, Rear Camera,
Lamp Door FT
Drv/Pass, Lamp
Flashlight, AHLM,
Relay Diesel Cabin
Heater, Rad Fan
Diesel
7
MAINTAINING YOUR VEHICLE
471
FUSES/TIPM
Cavity
Cartridge
Fuse
Mini-Fuse
Description
M35
10 Amp
Red
Heated Mirrors
M36
20 Amp
Yellow
Power Outlet #3
M37
10 Amp
Red
Antilock Brakes,
Stability Control
System, Stop Lamp
Switch, Fuel Pump
Rly Hi Control
M38
25 Amp
Natural
Door Lock/Unlock
Motors, Liftgate
Lock/Unlock
Motors
The heated mirrors, lower instrument panel power outlet
and removable floor console, when in the front position
are fused with self-resetting fuses that are only service-
able by an authorized dealer. The power seats are fused
by a 30 Amp circuit breaker located under the driver’s
seat. The power windows are fused by a 25 Amp circuit
breaker located under the instrument panel near the
steering column. If you experience temporary or perma-
nent loss of these systems, see your authorized dealer for
service.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than
21 days, you may want to take steps to protect your
battery. You may do the following:
Remove the 20 Amp mini-fuse in the Totally Inte-
grated Power Module (TIPM) labeled Ignition-Off
Draw (IOD).
Or, disconnect the negative cable from the battery.
472
MAINTAINING YOUR VEHICLE
Indicators
- Turn Signal Indicators
- High Beam Indicator
- Front Fog Light Indicator
- Vehicle Security Indicator*
- Electronic Stability Program (ESP)/Traction Control System (TCS)
Indicator
Odometer Messages
ECO - Fuel Saver Indicator
LoWASH - Low Washer Fluid
ECO-ON - Fuel Saver Indicator On
noFUSE* - Fuse Fault
door - Door Ajar
LoW tirE* - Low Tire Pressure
gATE* - Liftgate Ajar
LoCOOL - Low Coolant
hood - Hood Ajar
CHAngE OIL* - Change Engine Oil
gASCAP - Fuel Cap Fault
CRUISE - Cruise Control On
* If equipped
** Bulb Check with Key On
7
CONTROLS AT A GLANCE
POWER INVERTER
• There is a 115 Volt, 150 Watt power inverter
outlet located on the left rear trim panel
immediately behind the second row left
passenger seat. This outlet can power
cellular phones, electronics and other low
power devices requiring power up to 150
Watts.
• Press the switch located in the center of the
instrument panel to turn the power to the
outlet on.
• Press the switch again to turn the power off.
• The status indicator of the AC power inverter
indicates whether the inverter is producing
AC power.
NOTE:
The power inverter is designed with built-in overload protection. If the power
rating of 150 Watts is exceeded, the power inverter will automatically shut down. Once
the electrical device has been removed from the outlet, the inverter should automatically
reset. If the power rating exceeds approximately 170 Watts, the power inverter may have
to be reset manually. To reset the inverter manually, unplug the device and plug it in
again. To avoid overloading the circuit, check the power ratings on electrical devices
prior to using the inverter.
WARNING!
To Avoid Serious Injury or Death: Do not use a three-prong adaptor. Do not insert any
objects into the receptacles. Do not touch with wet hands. Close the lid when not in
use. If this outlet is mishandled, it may cause an electric shock and failure.
POWER OUTLETS
• There are four 12 Volt power outlets in your vehicle.
• Two are located on the lower instrument panel, next to the open storage bin. The
upper power outlet is controlled by the ignition switch and the lower power outlet is
connected directly to the battery.
• One is located in the removable floor console and is also connected directly to the
battery.
• One is located in the rear quarter panel near the liftgate. This outlet is also controlled
by the ignition switch.
NOTE:
Do not exceed the maximum power of 160 Watts (13 Amps) at 12 Volts. If the 160
Watt (13 Amp) power rating is exceeded the fuse protecting the system will need to be
replaced.
45
ELECTRONICS
Totally Integrated Power Module (TIPM)
• The Totally Integrated Power Module (TIPM) is located in the engine compartment near
the battery. This center contains cartridge fuses, mini-fuses and relays.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module (RR Door Node)
J4
25 Amp Natural
Driver Door Node
J5
25 Amp Natural
Passenger Door Node
J6
40 Amp Green
Anti-Lock Brake System (ABS)
Pump/ESP
J7
30 Amp Pink
Anti-Lock Brake System (ABS)
Valve/ESP
J8
40 Amp Green
Power Memory Seat (If Equipped)
J9
40 Amp Green
PZEV Motor/Flex Fuel
J10
30 Amp Pink
Headlamp Wash Relay/Manifold
Tuning Valve
J11
30 Amp Pink
Power Sliding Door Module/
Thatchum Relay Lock Feed
J13
60 Amp Yellow
Ignition Off Draw (IOD) — Main
J14
40 Amp Green
Rear Window Defogger
J15
30 Amp Pink
Rear Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module (PCM)
Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Natural
Sunroof Module
M1
15 Amp Blue
Center High Mounted Stop Light
(CHMSL)/Brake Switch
M2
M3
20 Amp Yellow
Spare Fuse
M4
10 Amp Red
Trailer Tow
M5
25 Amp Natural
Inverter
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sensor
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC SELECT)
M8
20 Amp Yellow
Front Heated Seat (If Equipped)
M9
20 Amp Yellow
Rear Heated Seat (If Equipped)
75
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
M10
15 Amp Blue
Ignition Off Draw — Vehicle
Entertainment System (IOD-VES),
Satellite Digital Audio Receiver
(SDARS), DVD, Hands-Free Module
(HFM), Universal Garage Door
Opener (UGDO), Vanity Lamp
(VANITY LP), Streaming Video
Module
M11
10 Amp Red
(Ignition Off Draw) IOD-HVAC/ATC
M12
30 Amp Green
Amplifier (AMP)/Radio
M13
20 Amp Yellow
Ignition Off Draw— Cabin
Compartment Node (IOD-CCN),
SIREN, Clock Module (CLK MOD),
Multi-Function Control Switch
(MULTIFCTN SW)/ITM
M14
20 Amp Yellow
Spare Fuse
M15
20 Amp Yellow
Rear View Mirror (RR VW MIR), Cabin
Compartment Node (CCN),
Multi-Function Control Switch
(MULTIFTCN SW), Tire Pressure
Monitor (TPM), Glow Plug Module
(GLW PLG MOD) — Export Diesel
Only, Assy-Shifter (Hall Effect),
Acoustic Noise Cancellation (ANC)
M16
10 Amp Red
Occupant Restraint Controller/
Occupant Classification Module
(ORC/OCM)
M17
15 Amp Blue
Left Tail/License/Park Lamp
(LT-TAIL/LIC/PRK LMP), Running
Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
(RT-TAIL/PRK/RUN LMP)
M19
25 Amp Natural
Auto Shut Down (ASD #1 and #2)
M20
15 Amp Blue
Cabin Compartment Node Interior
Light (CCN INT LIGHT), Switch Bank
(SW BANK), Steering Control Module
(SCM), Switch Steering Wheel
M21
20 Amp Yellow
Auto Shut Down (ASD #3)
M22
10 Amp Red
Right Horn (RT HORN (HI/LOW)
M23
10 Amp Red
Left Horn (LT HORN (HI/LOW)
M24
25 Amp Natural
Rear Wiper (REAR WIPER)
M25
20 Amp Yellow
Fuel Pump (FUEL PUMP), Diesel Lift
Pump (DSL LIFT PUMP) — Export Only
M26
10 Amp Red
Power Mirror Switch (PWR MIRR SW),
Driver Window Switch (DRVR WIND
SW)
MAINTAINING YOUR VEHICLE
76
Cavity
Cartridge Fuse
Mini-Fuse
Description
M27
10 Amp Red
Ignition Switch (IGN SW), Window
Module (WIN MOD), PEM, Steering
Column Lock
M28
10 Amp Red
Next Generation Controller (NGC),
PCM, Transmission Feed (TRANS
FEED), TCM
M29
10 Amp Red
Occupant Classification Module
(OCM)
M30
15 Amp Blue
Rear Wiper Module (RR WIPER MOD),
Power Folding Mirror (PWR FOLD
MIR), J1962 Diagnostic Feed
M31
20 Amp Yellow
Back-Up Lamps (B/U LAMPS)
M32
10 Amp Red
Occupant Restraint Controller (ORC),
TT EUROPE
M33
10 Amp Red
Next Generation Controller (NGC),
Global Powertrain Engine Controller
(GPEC), TCM
M34
10 Amp Red
Park Assist (PRK ASST), Heater
Ventilation, Air Conditioning Module
(HVAC MOD), Headlamp Wash (HDLP
WASH), Compass (COMPAS), IR
Sensor, Rear Camera, Lamp Door FT
Drv/Pass, Lamp Flashlight, AHLM,
Relay Diesel Cabin Heater, Rad Fan
Diesel
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet #3 (BATT)
M37
10 Amp Red
Anti-Lock Brake System (ABS),
Electronic Stability Program (ESP),
Stop Lamp Switch (STP LP SW), Fuel
Pump Rly Hi Control
M38
25 Amp Natural
Door Lock/Unlock Motors
(LOCK/UNLOCK MTRS), Liftgate
Lock/Unlock Motors
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly and
inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the DVD for more information regarding tire
warnings and instructions.
77
MAINTAINING YOUR VEHICLE