Jeep Wrangler - 2010 Fuse Box Diagram

Jeep Wrangler - 2010 Fuse Box Diagram

ELECTRICAL POWER OUTLET
There are two 12 Volt (13 Amp) auxiliary power outlets
that can provide power for accessories designed for use
with the standard power outlet adapters. The power
outlet, located in the lower portion of the instrument
panel, has a snap-on plastic cap so that it can be covered
when not in use. When the optional cigar lighter heating
element is used in the left-side power outlet, it heats
when pushed in and pops out automatically when ready
for use.
To preserve the heating element, do not hold the
lighter in the heating position.
NOTE:
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system will
need to be replaced.
The left-side power outlet is powered when the key is in
the ON or ACC positions.
Power Outlets
150
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and press the
TRIP ODOMETER button to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
noFUSE
If the vehicle diagnostic system determines that the
Ignition Off Draw (IOD) fuse is improperly installed, or
damaged, a “noFUSE” message will display in the odom-
eter display area. For further information on fuses and
fuse locations refer to “Fuses” in “Maintaining Your
Vehicle”.
CHAngE OIL Message
Your vehicle is equipped with an engine oil change
indicator system. The “CHANgE OIL” message will flash
in the instrument cluster odometer for approximately
12 seconds after a single chime has sounded to indicate
the next scheduled oil change interval. The engine oil
change
indicator
system
is
duty-cycle
based,
which
means the engine oil change interval may fluctuate
dependent upon your personal driving style.
Unless reset, this message will continue to display each
time you turn the ignition switch to the ON/RUN
position. To turn off the message temporarily, press and
release the Trip Odometer button on the instrument
cluster. To reset the oil change indicator system (after
performing the scheduled maintenance), refer to the
following procedure:
256
UNDERSTANDING YOUR INSTRUMENT PANEL
FUSES
Totally Integrated Power Module
The Totally Integrated Power Module (TIPM) is located
in the engine compartment near the battery. This center
contains cartridge fuses, mini fuses and relays. A label
that identifies each component is printed on the inside of
the cover.
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J1
J2
30 Amp
Pink
Transfer Case Module
J3
J4
25 Amp
Natural
Driver Door Node
J5
25 Amp
Natural
Passenger Door Node
J6
40 Amp
Green
Anti-Lock Brake Sys-
tem (ABS) Pump
Feed/ESP
J7
30 Amp
Pink
Anti-Lock Brake Sys-
tem (ABS) Valve Feed/
ESP
J8
Totally Integrated Power Module (TIPM)
490
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J9
40 Amp
Green
PZEV Sec Motor
Feed/Flex Fuel
J10
30 Amp
Pink
Headlamp Wash
Relay/Manifold Tun-
ing Valve
J11
30 Amp
Pink
Sway Bar
J13
60 Amp
Yellow
Ignition Off Draw
(IOD) – Main
J14
40 Amp
Green
EBL (Rear Window
Defogger)
J15
30 Amp
Pink
Rear Blower
J17
40 Amp
Green
Starter Solenoid
Cavity
Cartridge
Fuse
Mini
Fuse
Description
J18
20 Amp
Blue
Powertrain Control
Module (PCM) Trans
Range
J19
60 Amp
Yellow
Radiator Fan
J20
30 Amp
Pink
Front Wiper LO/HI
J21
20 Amp
Blue
Front/Rear Washer
J22
Spare
M1
15 Amp
Blue
Center High-Mounted
Stop Light (CHMSL)/
Switch Stop Lamp
Feed
M2
20 Amp
Yellow
Relay Trailer Lighting
(Stop)
7
MAINTAINING YOUR VEHICLE
491
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M3
20 Amp
Yellow
Frt/Rear Axle Locker
Relay
M4
M5
M6
20 Amp
Yellow
Power Outlet #1/Rain
Sensor
M7
20 Amp
Yellow
Power Outlet #2
(BATT/ACC SELECT)
M8
20 Amp
Yellow
Front Heated Seat
M9
20 Amp
Yellow
Rear Heated Seat – If
Equipped
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M10
20 Amp
Yellow
Ignition Off Draw –
Vehicle Entertainment
System (IOD-VES),
Satellite Digital Audio
Receiver (SDARS),
DVD, Hands-Free
Module (HFM), RA-
DIO, Antenna (ANT),
Universal Garage Door
Opener (UGDO), Van-
ity Lamp (VANITY LP)
M11
10 Amp
Red
(Ignition Off Draw)
IOD-HVAC/ATC, MW
SENSR, Underhood
Lamp (UH LMP)
M12
30 Amp
Green
Amplifier (AMP)
492
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M13
20 Amp
Yellow
Ignition Off Draw –
Cabin Compartment
Node (IOD-CCN),
Wireless Control Mod-
ule (WCM), SIREN,
Multifunction Control
Switch (MULTIFCTN
SW)
M14
20 Amp
Yellow
Trailer Tow (Export
Only)
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M15
20 Amp
Yellow
COL MOD, IR SNS,
Heater Ventilation, Air
Conditioning/
Automatic Tempera-
ture Control (HVAC/
ATC), Rear View
Mirror (RR VW MIR),
Cabin Compartment
Node (CCN), Transfer
Case Switch (T-CASE
SW), RUN/ST, Multi-
Function Control
Switch (MULTIFTCN
SW), Tire Pressure
Monitor (TPM), Glow
Plug Module (GLW
PLG MOD) – Export
Diesel Only
7
MAINTAINING YOUR VEHICLE
493
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M16
10 Amp
Red
Occupant Restraint
Controller (ORC)
M17
15 Amp
Blue
Left Tail/License/Park
Lamp (LT-TAIL/LIC/
PRK LMP)
M18
15 Amp
Blue
Right Tail/Park/Run
Lamp (RT-TAIL/PRK/
RUN LMP)
M19
25 Amp
Natural
Auto Shut Down (ASD
#1 and #2)
M20
15 Amp
Blue
Cabin Compartment
Node Interior Light
(CCN INT LIGHT),
Switch Bank (SW
BANK)
M21
20 Amp
Yellow
Auto Shut Down (ASD
#3)
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M22
10 Amp
Red
Right Horn (RT HORN
(HI/LOW)
M23
10 Amp
Red
Left Horn (LT HORN
(HI/LOW)
M24
25 Amp
Natural
Rear Wiper (REAR
WIPER)
M25
20 Amp
Yellow
Fuel Pump (FUEL
PUMP), Diesel Lift
Pump (DSL LIFT
PUMP) — Export Only
M26
M27
10 Amp
Red
Ignition Switch Feed,
Wireless Module
M28
10 Amp
Red
PCM Feed/TCM
M29
494
MAINTAINING YOUR VEHICLE
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M30
15 Amp
Blue
Wiper Motor Frt, J1962
Diagnostic Feed
M31
20 Amp
Yellow
Backup Lamps (B/U
LAMPS)
M32
10 Amp
Red
Occupant Restraint
Controller (ORC), TT
EUROPE
M33
10 Amp
Red
Next Generation Con-
troller (NGC), Global
Powertrain Engine
Controller (GPEC)
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M34
10 Amp
Red
Park Assist (PRK
ASST), Heater Ventila-
tion, Air Conditioning
Module (HVAC MOD),
Headlamp Wash
(HDLP WASH), Com-
pass (COMPAS)
M35
10 Amp
Red
Heated Mirrors
M36
20 Amp
Yellow
Power Outlet
M37
10 Amp
Red
Anti-Lock Brake Sys-
tem (ABS), Electronic
Stability Program
(ESP), Stop Lamp
Switch (STP LP SW),
Fuel Pump Rly Hi
Control
7
MAINTAINING YOUR VEHICLE
495
Cavity
Cartridge
Fuse
Mini
Fuse
Description
M38
25 Amp
Natural
Lock/Unlock Motors
(LOCK/UNLOCK
MTRS)
CAUTION!
When
installing
the
Integrated
Power
Module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the Integrated Power
Module, and possibly result in an electrical system
failure.
(Continued)
CAUTION! (Continued)
When replacing a blown fuse, it is important to
use only a fuse having the correct amperage rating.
The use of a fuse with a rating other than indicated
may result in a dangerous electrical system over-
load. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be
corrected.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than
21 days, you may want to take steps to protect your
battery. You may:
Remove Cartridge fuse #15 in the Power Distribution
Center labeled Ignition-Off Draw (IOD).
Store the removed IOD fuse in the Power Distribution
Center location #11 labeled “IOD Storage.”
496
MAINTAINING YOUR VEHICLE
Indicators
- Turn Signal Indicators
- High Beam Indicator
- Front Fog Light Indicator
- Front Axle Lock Indicator*
- Rear Axle Lock Indicator*
- Vehicle Security Indicator*
- O/D (Overdrive) Off Indicator
- 4WD Indicator*
- Sway Bar Indicator*
- Cruise Indicator
Odometer Messages
ECO - Fuel Saver Indicator Off
noFUSE* - Fuse Fault
ECO-ON - Fuel Saver Indicator On
LoW tirE* - Low Tire Pressure
door - Door Ajar
HOTOIL* - Transmission Oil Temperature
Above Normal Limits
gASCAP - Fuel Cap Fault
CHAngE OIL* - Change Engine Oil
gATE* - Liftgate Ajar
ESPOFF * - ESP Deactivated
* If equipped
** Bulb Check with Key On
7
CONTROLS AT A GLANCE
• The Totally Integrated Power Module (TIPM) is located in the engine compartment near
the battery. This center contains cartridge fuses, mini-fuses and relays.
Cavity
Cartridge Fuse
Mini Fuse
Description
J1
J2
30 Amp Pink
Transfer Case Module
J3
J4
25 Amp Natural
Driver Door Node
J5
25 Amp Natural
Passenger Door Node
J6
40 Amp Green
Anti-Lock Brake System (ABS)
Pump Feed/ESP
J7
30 Amp Pink
Anti-Lock Brake System (ABS) Valve
Feed/ESP
J8
J9
40 Amp Green
PZEV Sec Motor Feed/Flex Fuel
J10
30 Amp Pink
Headlamp Wash Relay/Manifold
Tuning Valve
J11
30 Amp Pink
Sway Bar
J13
60 Amp Yellow
Ignition Off Draw (IOD) — Main
J14
40 Amp Green
EBL (Rear Window Defogger)
J15
30 Amp Pink
Rear Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module (PCM)
Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
Spare
M1
15 Amp Blue
Center High-Mounted Stop Light
(CHMSL)/Switch Stop Lamp Feed
M2
20 Amp Yellow
Relay Trailer Lighting (Stop)
M3
20 Amp Yellow
Frt/Rear Axle Locker Relay
M4
M5
M6
20 Amp Yellow
Power Outlet #1/Rain Sensor
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC
SELECT)
M8
20 Amp Yellow
Front Heated Seat
M9
20 Amp Yellow
Rear Heated Seat (If Equipped)
M10
20 Amp Yellow
Ignition Off Draw — Vehicle
Entertainment System (IOD-VES),
Satellite Digital Audio Receiver
(SDARS), DVD, Hands-Free Module
(HFM), RADIO, Antenna (ANT),
Universal Garage Door Opener
(UGDO), Vanity Lamp (VANITY LP)
59
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini Fuse
Description
M11
10 Amp Red
(Ignition Off Draw) IOD-HVAC/ATC,
MW SENSR, Underhood Lamp (UH
LMP)
M12
30 Amp Green
Amplifier (AMP)
M13
20 Amp Yellow
Ignition Off Draw— Cabin
Compartment Node (IOD-CCN),
Wireless Control Module (WCM),
SIREN, Multifunction Control Switch
(MULTIFCTN SW)
M14
20 Amp Yellow
Trailer Tow (Export Only)
M15
20 Amp Yellow
COL MOD, IR SNS, Heater
Ventilation, Air Conditioning/
Automatic Temperature Control
(HVAC/ATC), Rear View Mirror (RR
VW MIR), Cabin Compartment Node
(CCN), Transfer Case Switch
(T-CASE SW), RUN/ST,
Multi-Function Control Switch
(MULTIFTCN SW), Tire Pressure
Monitor (TPM), Glow Plug Module
(GLW PLG MOD) — Export Diesel
Only
M16
10 Amp Red
Occupant Restraint Controller
(ORC)
M17
15 Amp Blue
Left Tail/License/Park Lamp
(LT-TAIL/LIC/PRK LMP)
M18
15 Amp Blue
Right Tail/Park/Run Lamp
(RT-TAIL/PRK/RUN LMP)
M19
25 Amp Natural
Auto Shut Down (ASD #1 and #2)
M20
15 Amp Blue
Cabin Compartment Node Interior
Light (CCN INT LIGHT), Switch Bank
(SW BANK)
M21
20 Amp Yellow
Auto Shut Down (ASD #3)
M22
10 Amp Red
Right Horn (RT HORN (HI/LOW)
M23
10 Amp Red
Left Horn (LT HORN (HI/LOW)
M24
25 Amp Natural
Rear Wiper (REAR WIPER)
M25
20 Amp Yellow
Fuel Pump (FUEL PUMP), Diesel
Lift Pump (DSL LIFT PUMP) —
Export Only
M26
M27
10 Amp Red
Ignition Switch Feed, Wireless
Module
M28
10 Amp Red
PCM Feed/TCM
M29
M30
15 Amp Blue
Wiper Motor Frt, J1962 Diagnostic
Feed
M31
20 Amp Yellow
Backup Lamps (B/U LAMPS)
MAINTAINING YOUR VEHICLE
60
Cavity
Cartridge Fuse
Mini Fuse
Description
M32
10 Amp Red
Occupant Restraint Controller
(ORC), TT EUROPE
M33
10 Amp Red
Next Generation Controller (NGC),
Global Powertrain Engine Controller
(GPEC)
M34
10 Amp Red
Park Assist (PRK ASST), Heater
Ventilation, Air Conditioning Module
(HVAC MOD), Headlamp Wash
(HDLP WASH), Compass (COMPAS)
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet
M37
10 Amp Red
Anti-Lock Brake System (ABS),
Electronic Stability Program (ESP),
Stop Lamp Switch (STP LP SW),
Fuel Pump Rly Hi Control
M38
25 Amp Natural
Lock/Unlock Motors (LOCK/
UNLOCK MTRS)
TIRE PRESSURES
• Check the inflation pressure of each tire, including the spare tire, at least monthly and
inflate to the recommended pressure for your vehicle.
• The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the DVD for more information on the life of tires.
WARNING!
Overloading of your tires is dangerous. Overloading can cause tire failure, affect
vehicle handling, and increase your stopping distance. Use tires of the
recommended load capacity for your vehicle. Never overload them.
WARNING!
Improperly inflated tires are dangerous and can cause accidents. Under-inflation is
the leading cause of tire failure and may result in severe cracking, component
separation, or “blow out”. Over-inflation reduces a tire’s ability to cushion shock.
Objects on the road and chuck holes can cause damage that results in tire failure.
Unequal tire pressures can cause steering problems. You could lose control of your
vehicle. Over-inflated or under-inflated tires can affect vehicle handling and can fail
suddenly, resulting in loss of vehicle control.
61
MAINTAINING YOUR VEHICLE