Dodge Sprinter Wagon - 2005 Fuse Box Diagram

Dodge Sprinter Wagon - 2005 Fuse Box Diagram

UNDERSTANDING THE FEATURES OF YOUR VEHICLE 81
3
Mechanical Sun Roof Operation
The sun roof does not open or close:
Check electrical fuse. Electrical fuses refer to “Electrical
Fuses“.
If the fuse works correctly, the sun roof can also be
closed or opened manually.
Remove cover (1) at the front frame of the sun roof.
Remove tool (2) from the cover (1) and insert.
Open manually:
Press in tool (2) and turn counterclockwise (3).
Close manually:
Press in tool (2) and turn clockwise (4).
Have malfunctions rectified by an authorized Sprinter
Dealer.
90 UNDERSTANDING YOUR INSTRUMENT PANEL
Legend For Instruments And Controls
1.
Left-hand air vent.
2.
Multifunction switch.
3.
Speed control
.
4.
Hood release lever
.
5.
Instrument cluster, refer to "Instrument Cluster
and Indicator Lamps".
6.
Hazard warning flasher switch
.
7.
Steering wheel with horn, front driver airbag
.
8.
Fuse box
.
9.
Windshield wiper switch, refer to "Windshield
Wiper Switch".
10. Ignition lock/starter switch
.
11. Center air vents
.
12. Upper air vents
.
13. Radio, see individual manual.
14. Temperature control switch
.
15. Airflow control switch
.
16. Air distribution switch
.
17. Temperature sensor, automatic heating
control/air conditioning, regulated
.
18. Air conditioning switch
.
19. Heater booster switch
.
20. Residual engine heat utilization switch
.
21. Gear selector lever (automatic transmission)
22. Timer for auxiliary heater
.
23. Electrical outlet
.
24. Ashtray
.
25. Cup holder
.
26. Front passenger airbag
.
27. Right-hand air vent
.
28. Glove compartment
.
NOTE: For layout of switches, see previous page.
138 UNDERSTANDING YOUR INSTRUMENT PANEL
AUXILIARY HEATER – TIPS FOR COPING WITH
PROBLEMS
NOTE:
After three successive attempts to start the
heater, a malfunction will be recorded in the integrated
diagnostic system and no further operation on
auxiliary heater will be available (lock-out). The work
to annul the lock-out must be carried out at an
authorized Sprinter Dealer.
The heater either does not switch on or automatically
switches off:
Insufficient fuel, fill up the fuel tank. Start up heater
two times, until the fuel lines are filled.
The auxiliary heater will automatically switch off if
the fuel level is under about 4 US gal (15 l).
• The fuses in the fuse box are damaged. Electric
fuses.
• The battery voltage is too low, an undervoltage
protector switches off the heater if the battery
voltage falls below about 10 volts.
The heater motor does not run
The battery voltage is too low, check the battery.
Batteries.
The fuses in the fuse box are damaged.
Electric fuses.
The heater motor is damaged.
Overheating
The air channels are clogged.
The heater can be restarted once the fault has been
repaired. When this is done, the heater should be
switched on and off.
The heater will remain switched off after it has been
overheated a number of times (about 10 times in
succession).
Have
the
fault
repaired
by
an
authorized Sprinter Dealer.
NOTE:
Repairs should only be made by an authorized
Sprinter Dealer.
216 MAINTAINING YOUR VEHICLE
Legend For Engine Compartment
1.
Windshield washer system fluid reservoir.
2.
Maintenance indicator for air cleaner element
(Optional).
3.
Oil dipstick.
4.
Oil filler neck.
5.
Ribbed V-belt.
Auxiliary drive (Optional) refer to “Auxiliary
drive“.
6.
Fuel filter with water separator.
7.
Hydraulic brake fluid reservoir.
8.
Coolant reservoir.
9.
Battery
The auxiliary battery is located underneath the
front passenger seat (optional equipment).
10. Fuse box
(These special fuses should only be replaced at by
an authorized Sprinter Dealer).
238 MAINTAINING YOUR VEHICLE
Plastic and Rubber Parts
Do not use oil or wax on these parts.
Do not use any caustic or alcohol-based or solvent-
based substances to clean plastic surfaces.
Avoid the use of stain removers, iodine tincture, nail
varnish and nail varnish remover, acetone, methylated
spirits, chlorine or ammonium-based cleaning agents,
cleaning agents containing abrasive substances.
ELECTRICAL FUSES
Damaged fuses are recognizable from their burnt-out
filament.
Prior to exchanging a fuse, turn the key in the ignition-
column lock to the 0 position and switch off the
consumer involved.
NOTE:
Fuses must not be bridged. Replace fuses with
specified rated current. Only replace fuses when the
cause of the malfunction has been rectified.
NOTE:
Fuses and relays (standard equipment) are on
the underside of the ignition column, refer to "Fuses
and Relays Standard Equipment".
Fuses, relays and diodes (optional equipment) are
below the driver’s seat, refer to "Optional Fuse and
Relay Equipment".
CAUTION!
When replacing a blown fuse, it is important to
use only a fuse having the correct amperage
rating. The use of a fuse with a rating other than
indicated may result in a dangerous electrical
system overload. If a properly rated fuse
continues to blow, it indicates a problem in the
circuit that must be corrected.
MAINTAINING YOUR VEHICLE 239
7
Standard Fuse and Relay Equipment
1.
Locked
2.
Unlocked
3.
Detent spring – engage when the cover is fitted
Position of fuses and relays
4.
Fuses
5.
Relays
240 MAINTAINING YOUR VEHICLE
Fuse Assignment, Standard Equipment
242 MAINTAINING YOUR VEHICLE
Relay Assignment, Standard Equipment
1.
Windshield wiper motor (W)
2.
Diesel engine control unit (M)
3.
Turn signals (B)
Fuse and Relay Optional Equipment
The cover is located below the driver’s seat.
Remove cover:
1.
Press both detent springs down and remove cover.
Install cover:
2.
Position cover at bottom and engage both detent
springs.
MAINTAINING YOUR VEHICLE 243
7
Fuse, Relay, and Diode Assignments – Optional Equipment
244 MAINTAINING YOUR VEHICLE
NOTE:
The arrangement of the fuses (1) depends on
the optional equipment installed on the vehicle. The
assignments are shown on the inside of the cover of the
fuse box.
Diodes:
No.
Circuit
1.
Not in use
2.
Not in use
3.
Not in use
4.
Not in use
Fuses:
No.
Rated
Circuit
5.
10A
Immobilizer
6.
7.5A
Anti-lock brake system (ABS) Electronic
Stability program (ESP)
*
7.
25A
Anti-lock brake system (ABS) Electronic
Stability program (ESP)
*
8.
40A
Not in use Electronic Stability program
(ESP)
*
9.
40A
Anti-lock brake system (ABS)
10.
Not in use
Relays:
No.
Circuit
11.
Not in use
12.
Starter relay
13.
Not in use
*
2500 Type Vehicles only