Dodge Grand Caravan - 2017 Fuse Box Diagram

Dodge Grand Caravan - 2017 Fuse Box Diagram

CAUTION!
Do not exceed the maximum power of 160 Watts
(13 Amps) at 12 Volts. If the 160 Watt (13 Amp) power
rating is exceeded the fuse protecting the system will
need to be replaced.
Power outlets are designed for accessory plugs only.
Do not insert any other object in the power outlets as
this
will
damage
the
outlet
and
blow
the
fuse.
Improper use of the power outlet can cause damage
not covered by your New Vehicle Limited Warranty.
One outlet in the removable floor console (if equipped)
shares a fuse with the lower outlet in the instrument panel
and is also connected to the battery. Do not exceed a
maximum power of 160 Watts (13 Amps) shared between
the lower panel outlet and the removable floor console
outlet.
On vehicles equipped with the Super Console the power
outlets are located under the retractable cover. To access the
power outlets push down on the cover and slide it toward
the instrument panel.
Removable Console Power Outlet
212
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
The outlet in the rear quarter panel near the liftgate and the
upper outlet in the instrument panel are both controlled by
the ignition switch. Each of these outlets can support 160
Watts (13 Amps). Do not exceed 160 Watts (13 Amps) for
each of these outlets.
The power outlets include tethered caps, labeled with a key
or battery symbol indicating the power source. The power
outlet, located on the lower instrument panel, is powered
directly from the battery. Items plugged into this power
outlet may discharge the battery and/or prevent the engine
from starting.
WARNING!
To avoid serious injury or death:
Only devices designed for use in this type of outlet
should be inserted into any 12 Volt outlet.
(Continued)
Super Console Power Outlets
Power Outlet Fuses
1 — M7 Fuse 20 A Yellow Power Outlet Center Seat (Opt) Or With
Console Rear
2 — M6 Fuse 20 A Yellow Cigar Lighter Instrument Panel Or With
Console Front
3 — M36 Fuse 20 A Yellow Power Outlet Instrument Panel Or With
Console Center
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
213
LoW tirE
When the appropriate condition exists, the odometer will
toggle between LoW and tirE for three cycles.
gASCAP
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will display in the odometer display
area. Tighten the fuel filler cap properly and push the STEP
button on the steering wheel to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
noFUSE
If the vehicle diagnostic system determines that the Igni-
tion
Off
Draw
(IOD)
fuse
is
improperly
installed,
or
damaged, a “noFUSE” message will display in the odom-
eter display area. Refer to “Fuses” in “Maintaining Your
Vehicle” for further information on fuses and fuse loca-
tions.
CHAngE OIL
Your vehicle is equipped with an engine oil change indi-
cator system. The odometer display will toggle between
CHAngE
and
Oil
for approximately 12 seconds, after a
single chime has sounded, to indicate the next scheduled
oil change interval. The engine oil change indicator system
is duty cycle-based, which means the engine oil change
interval may fluctuate dependent upon your personal
driving style.
3. Speedometer
Indicates vehicle speed.
4. Fuel Gauge
The pointer shows the level of fuel in the fuel tank
when the ignition switch is in the ON/RUN position.
The fuel pump symbol points to the side of the
vehicle where the fuel door is located.
5. Temperature Gauge
The temperature gauge shows engine coolant tem-
perature. Any reading within the normal range indi-
cates that the engine cooling system is operating
satisfactorily.
The gauge pointer will likely indicate a higher tem-
perature when driving in hot weather or up mountain
grades. It should not be allowed to exceed the upper
limits of the normal operating range.
246
UNDERSTANDING YOUR INSTRUMENT PANEL
ENGINE COMPARTMENT — 3.6L
1 — Air Filter
6 — Engine Coolant Reservoir
2 — Power Steering Fluid Reservoir
7 — Engine Oil Dipstick
3 — Brake Fluid Reservoir
8 — Engine Oil Fill
4 — Battery
9 — Coolant Pressure Cap
5 — Totally Integrated Power Module (Fuses)
10 — Washer Fluid Reservoir
7
MAINTAINING YOUR VEHICLE
465
If the belts need cleaning, use Mopar Total Clean, a mild
soap solution, or lukewarm water. Do not remove the belts
from the vehicle to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
Cleaning The Instrument Panel Cupholders
Removal
Pull the flexible liner from the cupholder drawer starting at
one edge to ease removal.
Cleaning
The liner is top shelf dishwasher safe, or you may follow
the cleaning procedure below.
Soak the liner in a mixture of medium hot tap water and
one
teaspoon
of
mild
liquid
dish
soap.
Let
soak
for
approximately 30 minutes. After 30 minutes, pull the liner
from the water and dip it back into the water about six
times. This will loosen any remaining debris. Rinse the
liner thoroughly under warm running water. Shake the
excess water from the liner and dry the outer surfaces with
a clean soft cloth.
Installation
Place the liner into the cupholder drawer and push the
liner into place so that the retention tabs seat into the
corresponding openings in the drawer.
FUSES
WARNING!
When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as
the original fuse. Never replace a fuse with another
fuse of higher amp rating. Never replace a blown
fuse with metal wires or any other material. Failure
to use proper fuses may result in serious personal
injury, fire and/or property damage.
(Continued)
490
MAINTAINING YOUR VEHICLE
WARNING!
(Continued)
Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off
and/or disengaged.
If the replaced fuse blows again, contact an autho-
rized dealer.
If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
Totally Integrated Power Module (Fuses)
The Totally Integrated Power Module is located in the
engine compartment near the battery. Refer to the appli-
cable “Engine Compartment” illustration in this section.
This center contains cartridge fuses and mini-fuses. A label
that identifies each component may be printed or em-
bossed on the inside of the cover.
CAUTION!
When installing the Totally Integrated Power Mod-
ule cover, it is important to ensure the cover is
properly positioned and fully latched. Failure to do
so may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
(Continued)
Totally Integrated Power Module
7
MAINTAINING YOUR VEHICLE
491
CAUTION!
(Continued)
result in a dangerous electrical system overload. If a
properly rated fuse continues to blow, it indicates a
problem in the circuit that must be corrected.
The numbers inside the TIPM cover correspond to the
following table.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Clear
Driver Door Node
J5
25 Amp Clear
Passenger Door Node
J6
40 Amp Green
Antilock Brakes Pump/Stability Control
System
J7
30 Amp Pink
Antilock Brakes Valve/Stability Control
System
J8
40 Amp Green
Power Memory Seat – If Equipped
J9
Not Used
J10
30 Amp Pink
Headlamp Wash/Manifold Tuning Valve – If
Equipped
J11
30 Amp Pink
Power Sliding Door Module/Anti–Theft
Module – If Equipped
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan Motor
492
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
J13
60 Amp Yellow
Ignition Off Draw (IOD) – Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module Trans Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Clear
Sunroof Module
M1
15 Amp Blue
Rear Center Brake Lamp/Brake Switch
M2
20 Amp Yellow
Front Fog Lamps
M3
20 Amp Yellow
Vacuum Pump Motor
M5
25 Amp Clear
Inverter
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sensor,
Cigar Lighter (Instrument Panel or with
Console Rear)
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC SELECT) –
Center Seat or with Console Rear
M8
20 Amp Yellow
Front Heated Seat — If Equipped
M9
20 Amp Yellow
Rear Heated Seat — If Equipped
7
MAINTAINING YOUR VEHICLE
493
Cavity
Cartridge Fuse
Mini-Fuse
Description
M10
15 Amp Blue
Ignition Off Draw — Video System, Satellite
Radio, DVD, Hands-Free Module, Universal
Garage Door Opener, Vanity Lamp, Stream-
ing Video Module — If Equipped
M11
10 Amp Red
Climate Control System
M12
30 Amp Green
Amplifier/Radio
M13
20 Amp Yellow
Instrument Cluster, SIREN, Clock Module,
Multifunction Control Switch – If Equipped
M14
20 Amp Yellow
Trailer Tow — If Equipped
M15
20 Amp Yellow
Rear View Mirror, Instrument Cluster,
Multifunction Control Switch, Tire Pressure
Monitor
M16
10 Amp Red
Airbag Module/Occupant Classification
Module
M17
15 Amp Blue
Left Tail/License/Park Lamp, Running
Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
M19
25 Amp Clear
Powertrain
M20
15 Amp Blue
Instrument Cluster Interior Light, Switch
Bank, Steering Column Module, Switch
Steering Wheel
494
MAINTAINING YOUR VEHICLE
Cavity
Cartridge Fuse
Mini-Fuse
Description
M21
20 Amp Yellow
Powertrain
M22
10 Amp Red
Horn
M23
10 Amp Red
Horn
M24
25 Amp Clear
Rear Wiper
M25
20 Amp Yellow
Fuel Pump
M26
10 Amp Red
Power Mirror Switch, Driver Window Switch
M27
10 Amp Red
Wireless Control Module, Keyless Entry
Module
M28
10 Amp Red
Powertrain, Transmission Control Module
M29
10 Amp Red
Occupant Classification Module
M30
15 Amp Blue
Diagnostic Feed
M31
20 Amp Yellow
Back-Up Lamps
M32
10 Amp Red
Airbag Module, THATCHUM — If
Equipped
M33
10 Amp Red
Powertrain
M34
10 Amp Red
Park Assist, Heater Climate Control Module,
Headlamp Wash, Compass, Rear Camera,
Door Lamps, Flashlight, Relay Diesel Cabin
Heater
M35
10 Amp Red
Heated Mirrors
7
MAINTAINING YOUR VEHICLE
495
Cavity
Cartridge Fuse
Mini-Fuse
Description
M36
20 Amp Yellow
Power Outlet #3 (Instrument Panel or with
Console Center)
M37
10 Amp Red
Antilock Brakes, Stability Control, Stop
Lamp, Fuel Pump
M38
25 Amp Clear
Door Lock/Unlock Motors, Liftgate Lock/
Unlock Motors
The power windows are fused by a 25 Amp circuit breaker
located in the Totally Integrated Power Module.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take steps to protect your battery.
You may do the following:
Remove the 60 Amp cartridge in the Totally Integrated
Power Module (TIPM) labeled Ignition-Off Draw (IOD).
Or, disconnect the negative cable from the battery.
Anytime you store your vehicle, or keep it out of service
for two weeks or more, run the air conditioning system
at idle for about five minutes in the fresh air and high
blower setting. This will ensure adequate system lubri-
cation to minimize the possibility of compressor damage
when the system is started again.
496
MAINTAINING YOUR VEHICLE
INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
ENGINE COMPARTMENT — 3.6L
1. Air Cleaner Filter
2. Brake Fluid Reservoir
3. Integrated Power Module (Fuses)
4. Battery
5. Engine Coolant Reservoir
MAINTAINING YOUR VEHICLE
154
FUSES
WARNING!
• When replacing a blown fuse, always use an appropriate replacement fuse with the
same amp rating as the original fuse. Never replace a fuse with another fuse of higher
amp rating. Never replace a blown fuse with metal wires or any other material. Failure
to use proper fuses may result in serious personal injury, fire and/or property damage.
• Before replacing a fuse, make sure that the ignition is off and that all the other
services are switched off and/or disengaged.
• If the replaced fuse blows again, contact an authorized dealer.
• If a general protection fuse for safety systems (air bag system, braking system),
power unit systems (engine system, gearbox system) or steering system blows,
contact an authorized dealer.
Totally Integrated Power Module (Fuses)
The Totally Integrated Power Module is located in the engine compartment near the
battery. Refer to the applicable “Engine Compartment” illustration in this section. This
center contains cartridge fuses and mini-fuses. A label that identifies each component
may be printed or embossed on the inside of the cover.
CAUTION!
• When installing the Totally Integrated Power Module cover, it is important to ensure
the cover is properly positioned and fully latched. Failure to do so may allow water to
get into the Integrated Power Module, and possibly result in a electrical system
failure.
• When replacing a blown fuse, it is important to use only a fuse having the correct
amperage rating. The use of a fuse with a rating other than indicated may result in a
dangerous electrical system overload. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be corrected.
The numbers inside the TIPM cover correspond to the following table.
Cavity
Cartridge Fuse
Mini-Fuse
Description
J1
40 Amp Green
Power Folding Seat
J2
30 Amp Pink
Power Liftgate Module
J3
30 Amp Pink
Rear Door Module
J4
25 Amp Clear
Driver Door Node
J5
25 Amp Clear
Passenger Door Node
J6
40 Amp Green
Antilock Brakes Pump/Stability
Control System
J7
30 Amp Pink
Antilock Brakes Valve/Stability
Control System
J8
40 Amp Green
Power Memory Seat – If Equipped
MAINTAINING YOUR VEHICLE
162
Cavity
Cartridge Fuse
Mini-Fuse
Description
J9
Not Used
J10
30 Amp Pink
Headlamp Wash/Manifold Tuning
Valve – If Equipped
J11
30 Amp Pink
Power Sliding Door Module/Anti–
Theft Module – If Equipped
J12
30 Amp Pink
HVAC Rear Blower, Radiator Fan
Motor
J13
60 Amp Yellow
Ignition Off Draw (IOD) – Main
J14
40 Amp Green
Rear Window Defogger
J15
40 Amp Green
Front Blower
J17
40 Amp Green
Starter Solenoid
J18
20 Amp Blue
Powertrain Control Module Trans
Range
J19
60 Amp Yellow
Radiator Fan
J20
30 Amp Pink
Front Wiper LO/HI
J21
20 Amp Blue
Front/Rear Washer
J22
25 Amp Clear
Sunroof Module
M1
15 Amp Blue
Rear Center Brake Lamp/Brake
Switch
M2
20 Amp Yellow
Front Fog Lamps
M3
20 Amp Yellow
Vacuum Pump Motor
M5
25 Amp Clear
Inverter
M6
20 Amp Yellow
Power Outlet #1 (ACC), Rain Sen-
sor, Cigar Lighter (Instrument
Panel or with Console Rear)
M7
20 Amp Yellow
Power Outlet #2 (BATT/ACC SE-
LECT) – Center Seat or with Con-
sole Rear
M8
20 Amp Yellow
Front Heated Seat — If Equipped
M9
20 Amp Yellow
Rear Heated Seat — If Equipped
M10
15 Amp Blue
Ignition Off Draw — Video Sys-
tem, Satellite Radio, DVD, Hands-
Free Module, Universal Garage
Door Opener, Vanity Lamp,
Streaming Video Module — If
Equipped
M11
10 Amp Red
Climate Control System
M12
30 Amp Green
Amplifier/Radio
M13
20 Amp Yellow
Instrument Cluster, SIREN, Clock
Module, Multifunction Control
Switch – If Equipped
M14
20 Amp Yellow
Trailer Tow — If Equipped
MAINTAINING YOUR VEHICLE
163
Cavity
Cartridge Fuse
Mini-Fuse
Description
M15
20 Amp Yellow
Rear View Mirror, Instrument Clus-
ter, Multifunction Control Switch,
Tire Pressure Monitor
M16
10 Amp Red
Airbag Module/Occupant Classifi-
cation Module
M17
15 Amp Blue
Left Tail/License/Park Lamp, Run-
ning Lamps
M18
15 Amp Blue
Right Tail/Park/Run Lamp
M19
25 Amp Clear
Powertrain
M20
15 Amp Blue
Instrument Cluster Interior Light,
Switch Bank, Steering Column
Module, Switch Steering Wheel
M21
20 Amp Yellow
Powertrain
M22
10 Amp Red
Horn
M23
10 Amp Red
Horn
M24
25 Amp Clear
Rear Wiper
M25
20 Amp Yellow
Fuel Pump
M26
10 Amp Red
Power Mirror Switch, Driver Win-
dow Switch
M27
10 Amp Red
Wireless Control Module, Keyless
Entry Module
M28
10 Amp Red
Powertrain, Transmission Control
Module
M29
10 Amp Red
Occupant Classification Module
M30
15 Amp Blue
Diagnostic Feed
M31
20 Amp Yellow
Back-Up Lamps
M32
10 Amp Red
Airbag Module, THATCHUM — If
Equipped
M33
10 Amp Red
Powertrain
M34
10 Amp Red
Park Assist, Heater Climate Con-
trol Module, Headlamp Wash,
Compass, Rear Camera, Door
Lamps, Flashlight, Relay Diesel
Cabin Heater
M35
10 Amp Red
Heated Mirrors
M36
20 Amp Yellow
Power Outlet #3 (Instrument
Panel or with Console Center)
M37
10 Amp Red
Antilock Brakes, Stability Control,
Stop Lamp, Fuel Pump
M38
25 Amp Clear
Door Lock/Unlock Motors, Liftgate
Lock/Unlock Motors
The power windows are fused by a 25 Amp circuit breaker located in the Totally Integrated
Power Module.
MAINTAINING YOUR VEHICLE
164
UTILITY
How do I know how much I can tow with my vehicle? pg. 115
WHAT TO DO IN EMERGENCIES
What do I do if my TPMS warning light is blinking? pg. 118
How do I change a flat tire? pg. 131
How do I Jump-Start my vehicle? pg. 145
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 162
What type of oil do I use? pg. 156
How often should I change my engine’s oil? pg. 158
What should my tire pressure be set at? pg. 168
FREQUENTLY ASKED QUESTIONS
190