Lincoln Zephyr - 2006 Fuse Box Diagram

Lincoln Zephyr - 2006 Fuse Box Diagram

CENTER CONSOLE
Your vehicle may be equipped with a variety of console features. These
include:
1. Cupholders
2. Sliding arm rest
Note:
Slide the arm rest to the
rearward position to open the utility
compartment
3. Utility compartment with power
point, a removable tray and coin
holder inside
Use only soft cups in the cupholder. Hard objects can injure you
in a collision.
AUXILIARY POWER POINT (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power point is located in the center console utility
compartment.
Do not use the power point for operating the cigarette lighter element (if
equipped).
To prevent the fuse from being blown, do not use the power point(s)
over the vehicle capacity of 12 VDC/180W.
To prevent the battery from being discharged, do not use the power
point longer than necessary when the engine is not running.
Always keep the power point caps closed when not being used.
1
2
3
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
51
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 10 inches (25 cm)
between an occupant’s chest and the driver airbag module.
Never place your arm over the airbag module as a deploying
airbag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the airbag module. Placing
objects on or over the airbag inflation area may cause those
objects to be propelled by the airbag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the airbag
supplemental restraint system (SRS) or its fuses. See your
authorized dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the airbag system, increasing the
risk of injury. Do not modify the front end of the vehicle.
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
118
Do not attempt to service, repair, or modify the airbag SRS, its
fuses or the seat cover on a seat containing an airbag. See your
authorized dealer.
All occupants of the vehicle should always wear their safety belts
even when an airbag SRS is provided.
How does the side airbag system work?
The design and development of the side airbag system included
recommended testing procedures that were developed by a group of
automotive safety experts known as the Side Airbag Technical Working
Group. These recommended testing procedures help reduce the risk of
injuries related to the deployment of side airbags (including side air
curtain systems).
The side airbag system consists of
the following:
An inflatable nylon bag (airbag)
with a gas generator concealed
behind the outboard bolster of
the driver and front passenger
seatbacks.
The same warning light,
electronic control and diagnostic
unit as used for the front airbags.
Two crash sensors located under the outboard side of the front seats,
attached near the floor.
Side airbags, in combination with seat belts, can help reduce the risk of
severe injuries in the event of a significant side impact collision.
The side airbags are fitted on the outboard side of the seatbacks of the
front seats. In certain lateral collisions, the airbag on the side affected by
the collision will be inflated, even if the respective seat is not occupied.
The airbag was designed to inflate between the door panel and occupant
to further enhance the protection provided occupants in side impact
collisions.
The airbag SRS is designed to activate when the vehicle sustains lateral
deceleration sufficient to cause the sensors to close an electrical circuit
that initiates airbag inflation.
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
127
Side curtain airbag system
Do not place objects or
mount equipment on or
near the airbag cover on the side
of the seatbacks of the front seats
or in front seat areas that may
come into contact with a
deploying airbag. Failure to follow
these instructions may increase
the risk of personal injury in the
event of a collision.
Do not place objects or mount equipment on or near the
headliner at the siderail that may come into contact with a
deploying side air curtain. Failure to follow these instructions may
increase the risk of personal injury in the event of a collision.
Do not place objects or mount equipment on or near the side air
curtain cover.
Do not lean your head on the door. The side airbag could injure
you as it deploys from the seat.
Do not lean your head on the door. The side air curtain could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the side air curtain
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a side air curtain. See your authorized dealer.
Do not attempt to service, repair, or modify the airbag
supplemental restraint system, its fuses, or the seat cover on a
seat containing an airbag. See your authorized dealer.
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
129
If you cannot move the gearshift lever out of P (Park) with ignition in
the RUN position and the brake pedal depressed:
1. Apply the parking brake, turn
ignition key to LOCK, then remove
the key.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock release access hole
on the console. Insert the
screwdriver (or similar tool) to
release the interlock.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your authorized dealer as soon as possible.
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Driving
173
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
The fuel pump shut-off switch is
located in the front passenger
footwell area in the right upper
corner.
To reset the switch:
1. Turn the ignition to 1 (LOCK).
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition to 3 (RUN).
5. Wait a few seconds and return
the key to 1 (LOCK).
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
178
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
179
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
10A
Backup lamps, Electrochromatic
mirror
2
20A
Horns
3
15A
Battery saver: Interior lamps,
Puddle lamps, Trunk lamp, Glove
box lamp, Rear power windows
4
15A
Parklamps, License plate lamps
5
Not used
6
Not used
7
Not used
8
30A
Rear window defroster
9
10A
Heated mirrors
10
30A
Starter coil, PCM
11
15A
High beams
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
180
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
12
7.5A
Delay accessories: Radio head
units, Moonroof, Front power
windows, Electrochromatic
mirrors
13
7.5A
Cluster, KAM-PCM, Analog clock,
Climate control head units,
Canister vent solenoid
14
15A
Washer pump
15
20A
Cigar lighter
16
15A
Door lock actuator, Decklid lock
solenoid
17
20A
Subwoofer, THXII DSP module
18
20A
Radio head units, OBDII
connector
19
Not used
20
7.5A
Power mirrors, DSP
(THX/Navigation radio)
21
7.5A
Stop lamps
22
7.5A
Audio
23
7.5A
Wiper relay coil, Cluster logic
24
7.5A
OCS (Passenger’s seat), PAD
indicator
25
7.5A
RCM
26
7.5A
PATS Transceiver, Brake shift
interlock solenoid, Brake pedal
switch
27
7.5A
Cluster, Climate control head
units
28
10A
ABS/Traction Control, Heated
seats, Compass
C/B
30A Circuit
Breaker
Rear p ower windows, Delayed
accessory (SJB fuse12)
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
181
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
60A***
SJB power feed (fuses 12, 13, 14,
15, 16, 17, 18, C/B)
2
40A**
Powertrain power
3
Not used
4
40A**
Blower motor
5
Not used
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
182
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
6
40A**
Rear window defroster, Heated
mirrors
7
Not used
8
Not used
9
20A**
Wipers
10
20A**
ABS Valves
11
30A**
Heated seats, Passenger
heated/cooled seat
12
30A**
Driver heated/cooled seat
13
Not used
14
15A*
Ignition switch
15
10A*
Memory module logic
16
15A*
Transmission
17
20A*
Console power point
18
10A*
Alternator sense
19
40A**
Logic feed to SJB (solid state
devices)
20
20A**
THXII Amplifier #1
21
20A**
THXII Amplifier #2
22
Not used
23
60A**
SJB power feed (fuses 1, 2, 4, 10,
11)
24
15A*
Fog lamps
25
10A*
A/C Compressor clutch
26
15A*
LH HID Low beam
27
15A*
RH HID Low beam
28
Not used
29
60A***
Engine cooling fan
30
30A**
Fuel pump relay feed
31
30A**
Passenger power seat
32
30A**
Driver power seat
33
20A**
Moonroof
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
183
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
34
30A**
Driver Smart power window
35
30A**
Passenger Smart power window
36
40A**
ABS Pump
37
Not used
38
Not used
39
Not used
40
Not used
41
Not used
42
15A*
PCM non-emission related
43
15A*
Coil on plug
44
15A*
PCM emission related
45
Not used
46
15A*
Injectors
47
1/2 ISO Relay
Fog lamps
48
1/2 ISO Relay
LH HID Low beam
49
1/2 ISO Relay
RH HID Low beam
50
1/2 ISO Relay
Wiper Park
51
1/2 ISO Relay
A/C Clutch
52
Not used
53
1/2 ISO Relay
Wiper RUN
54
Not used
55
Full ISO Relay
Fuel pump
56
Full ISO Relay
Blower motor
57
Full ISO Relay
PCM
58
Not used
59
Not used
60
Diode
Fuel pump
61
Not used
62
Circuit Breaker
Spare
*Mini fuses **A1 fuses ***A3 fuses
2006 Zephyr
(378)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
184