Lincoln Navigator - 2004 Fuse Box Diagram

Lincoln Navigator - 2004 Fuse Box Diagram

AUXILIARY POWER POINT
Power points are designed for accessory plugs only. Do not hang
any type of accessory or accessory bracket from the plug.
Improper use of the power points can cause damage not covered
by your warranty.
An auxiliary power point is located
by the passenger
s ankle near the
floor in the front console bin.
Do not plug optional electrical
accessories into the cigarette lighter.
Use the power point.
Do not use the power point for
operating the cigarette lighter
element.
The Maximum power each power
point can supply depends on the fuse rating. For example: a 20A fuse
should supply a maximum of 240 Watts, a 15A fuse should supply a
maximum of 180 Watts and a 10A fuse should supply a maximum of 120
Watts. Exceeding these limits will result in a blown fuse.
Always keep the power point caps closed when not being used.
A second auxiliary power point is
located inside the cupholder door
on the rear side of the center
console. The power point is
accessible from the rear seats.
4
3
2
1
0
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driver Controls
118
on the owner
s wallet card in the glove compartment,
at your dealer,
or on the module located under
the right-hand side of the
instrument panel, adjacent to the
passenger compartment fuse
panel.
Note:
The 5
digit code (e.g. 12345)
will be in large,
BOLD
numbers on
the module label.
When pressing the controls on the keyless entry keypad, press the
middle of the controls to ensure a good activation.
Programming your own personal entry code
To program your own code:
6. Enter factory set code (keypad will illuminate when pressed).
7. Press 1/2 control within five seconds of step 1.
8. Enter your personal 5 digit code.
Enter each digit within five seconds
of previous one.
9. After the code is entered, the
locks will cycle, confirming that the
new code has been set.
Do not set a code that includes five of the same number or presents
them in sequential order. Thieves can easily figure out these types of
codes.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Locks and Security
164
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
The National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant
s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
The front passenger air bag is not designed to offer protection to
an occupant in the center front seating position.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the Body
Builders Layout Book for instructions about the appropriate installation
of additional equipment.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
196
Do not attempt to service, repair, or modify the Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
±
. See your Ford or Lincoln
Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
±
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
±
.
How does the Safety Canopy
´
system work?
The design and development of the
Safety Canopy
±
system included
recommended testing procedures
that were developed by a group of
automotive safety experts known as
the Side Air Bag Technical Working
Group. These recommended testing
procedures help reduce the risk of
injuries related to the deployment of
side airbags (including the Safety
Canopy
±
).
The Safety Canopy
±
system
consists of the following:
An inflatable nylon curtain with a
gas generator concealed behind
the headliner and above the doors
(one on each side of vehicle).
A headliner designed to flex open
above the side doors to allow Safety Canopy
±
deployment.
The same warning light, electronic control and diagnostic unit as used
for the front airbags.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
200
Do not alter or modify your vehicle
s suspension or steering; the
resulting changes to the vehicle
s handling can adversely affect
the Roll Stability Control system. Also, do not install a stereo
loudspeaker near the front center console or under either front
seat. The speaker vibrations can adversely affect the Roll
Stability Control sensors located in this area.
Note:
Pressing the Roll Stability Control button will disable the Roll
Stability Control.
Aggressive driving in any road conditions can cause you to lose
control of your vehicle increasing the risk of severe personal
injury or property damage. The occurrence of an Roll Stability Control
event is an indication that at least some of the tires have exceeded
their ability to grip the road; this may lead to an increased risk of loss
of vehicle control, vehicle rollover, personal injury and death. If you
experience a severe road event, SLOW DOWN.
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed, it is possible that a fuse
has blown or the vehicle
s brakelamps are not operating properly. Refer
to
Fuses and relays
in the
Roadside emergencies
chapter.
If the fuse is not blown, perform the following procedure:
1. Apply the parking brake, turn the ignition to LOCK, then remove the
key.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driving
231
The fuel pump shut-off switch has a
red reset button on top of it and is
located beneath the air suspension
switch (if equipped). If the vehicle
is not equipped with air suspension,
the fuel pump shut-off switch
s red
reset button will still be visible
behind this access panel.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
265
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel / power distribution box
The fuse panel is located under the right-hand side of the instrument
panel.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
266
To remove the trim panel for access
to the fuse box, pull the panel
toward you and swing it out away
from the side and remove it. To
reinstall it, line up the tabs with the
grooves on the panel, then push it
shut.
To remove the fuse box cover, place
a finger behind the PULL tab and
your thumb above the PULL tab as
shown in the illustration, then pull
the cover off.
To reinstall the fuse box cover, place the top part of the cover on the
fuse panel, then push the bottom part of the cover until you hear it click
shut. Gently pull on the cover to make sure it is seated properly.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
267
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
10A*
Run/Accessory - Instrument cluster, Front
wiper motor, Rear wiper motor, Tire
Pressure Monitor System (TPMS) module
2
20A*
Brake On/Off (stoplamp) switch, Turn
signal/Hazard flasher, AdvanceTrac
±
stoplamps relay, Stoplamps, Center
High-Mounted Stoplamp (CHMSL), Turn
signal lamps
3
7.5A*
Power mirror switch, Memory module (logic
power), Driver seat switch (memory)
4
15A*
Rear seat audio controls, Navigation module,
DVD player
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
268
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
5
7.5A*
Brake On/Off (stoplamp) switch, Powertrain
Control Module (PCM) (keep alive power),
EATC control head, Body Security Module
(BSM) (keep alive power), Speed control
deactivation switch, Speed control servo,
SecuriLock LED, 3rd row seat relay coils,
Power liftgate module, Clock, Brake Shift
Interlock (BSI) solenoid
6
15A*
Headlamp switch (parklamps and switch
backlighting feed), Parklamps, License
lamps, Foglamp relay coil, Trailer tow
electric brake controller (illumination), BSM
(autolamp parklamps), Floor console gear
selector lighting, Switch backlighting
module, Foglamp indicator
7
7.5A*
Radio (Start signal)
8
10A*
Rear window defroster switch, Heated
outside mirrors, Rear window defroster
indicator (climate control head)
9
Not used
10
20A*
Trailer tow back-up lamps relay, Trailer tow
7
wire connector (back-up lamps), Trailer
tow parklamps relay, Trailer tow 7
and
4
wire connectors (parklamps)
11
10A*
A/C compressor clutch relay, A/C
compressor clutch solenoid, Air suspension
compressor relay, 4x4 Integrated Wheel
Ends (IWE) solenoid
12
10A*
Speed control relay, Speed control servo
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
269
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
13
10A*
Rear window defroster relay coil, A/C
refrigerant containment switch, A/C
compressor thermistor, DEATC control
head, DEATC solenoids, DEATC blower
controller, Trailer tow battery charge relay
coil
14
10A*
Daytime Running Lamps (DRL) ignition
relay coil, Digital Transmission Range Sensor
(DTRS back-up lamps), Trailer tow back-up
lamps relay coil, Elctrochromatic mirror
15
5A*
AdvanceTrac
±
switch, Instrument cluster
(Run/Start feed)
16
10A*
ABS/AdvanceTrac
±
module (Run/Start
feed)
17
15A*
Foglamps
18
10A*
Auxiliary A/C temperature blend door
actuator, Auxiliary A/C front auxiliary
control, Park brake release relay coils, Turn
signal flasher, Electrochromatic mirror,
Auxiliary mode motor, Climate controlled
seat modules
19
10A*
Restraints Control Module (RCM)
20
30A*
4x4 module, Air suspension module (air
spring solenoids and height sensors)
21
15A*
Instrument cluster (B+), Interior (courtesy)
lamps, TPMS module, Park brake release
relays, Park brake release motor, Puddle
lamps (outside mirrors)
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
270
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
22
10A*
Moonroof switch illumination, Flip window
switch, Flip window relays, Flip window
motors, Electronic Hidden Antenna Module
(EHAM) antenna amplifier (navigation
radio), Radio (delayed accessory feed), Left
front window motor, Navigation radio
amplifier
23
10A*
RH low beam
24
15A*
Interior demand lamps (front map/dome
lamps, glove compartment lamp, cargo lamp,
roof rail lamps, vanity mirror lamps),
Battery saver relay coil, Battery saver relay
power
25
10A*
LH low beam
26
20A*
Horn relay, Horns
27
5A*
BSI solenoid, Overdrive cancel switch,
Reverse park aid system module, Air
suspension module (Run/Start), Compass
module
28
5A*
PCM relay coil, Speed control relay coil,
SecuriLock transceiver
29
30A*
Trailer tow electric brake controller, Trailer
tow 7
wire connector (electric brake)
30
30A*
BSM (door locks, liftgate glass release
relay), Liftgate glass release motor, Left
front window motor, Door/Liftgate lock
motors
31
20A*
Radio (B+), Subwoofer, Navigation radio
audio amplifier
32
15A*
Catalyst Monitor Sensors (CMS),
Transmission solenoids
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
271
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
33
20A*
HEGO sensors, EGR vacuum regulator
(EVR) solenoid, Intake Manifold Tuning
valve (IMTV) solenoid, Canister vent
solenoid, Vapor Management valve (VMV)
solenoid, A/C compressor clutch relay coil
34
20A*
PCM, Idle Air Control (IAC) solenoid, Mass
Air Flow (MAF) sensor, Fuel injectors, Fuel
pump relay, Fuel pump shut-off switch, Fuel
pump motor
35
20A*
High beam headlamps, Instrument cluster
high beam indicator
36
10A*
Trailer tow right turn/stop lamps
37
20A*
Cargo area power point
38
25A*
Rear wiper motor, Washer pump (rear
window wash)
39
20A*
Console power points
40
20A*
DRL relays, DRL foglamps, DRL headlamp
relay coil, Headlamp switch (headlamps),
Multifunction switch (flash-to-pass), BSM
(autolamp headlamps relay), High beam
relay coil, Fuse 25 (LH low beam), Fuse 23
(RH low beam)
41
20A*
Cigar lighter, OBD II diagnostic connector
42
10A*
Trailer tow left turn/stop lamps
101
30A**
Starter motor relay, Starter motor solenoid
102
30A**
Ignition switch power
103
30A**
ABS/AdvanceTrac
±
module (pump motor)
104
30A**
LH 3rd row seat relay, LH 3rd row seat
switch, LH 3rd row seat motor
105
30A**
Power liftgate module, Power liftgate
motors, Power running boards control
106
30A**
Trailer tow battery charge relay, Trailer tow
7
wire connector (battery charge)
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
272
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
107
30A**
Auxiliary A/C blower relay, Auxiliary A/C
blower motor
108
30A**
Passenger seat motor switch, Passenger seat
lumbar switch and motor
109
30A**
Driver seat lumbar switch and motor,
Memory module, Power memory mirrors,
Adjustable pedals switch and motor
110
30A**
Power running boards
111
50A**
Air suspension compressor relay, Air
suspension compressor
112
30A**
ABS/AdvanceTrac
±
module (valves)
113
30A**
Front wiper motor, Washer pump
(windshield wash)
114
40A**
Rear window defroster relay, Rear window
defroster grid, Heated mirrors (Fuse 8)
115
30A**
4x4 module, Transfer case shift motor
116
40A**
Front blower motor relay, Front blower
motor
117
30A**
RH 3rd row seat relay, RH 3rd row seat
switch, RH 3rd row seat motor
118
30A**
Driver and passenger climate control seat
module
401
30A**
Power windows (circuit breaker), Main
window switch, Window motors, Window
switches, Moonroof module
R01
Starter relay
Starter motor solenoid
R02
Delayed
accessory
relay
Fuse 22, CB 401, Power windows, Moonroof,
Flip windows, Radio, DVD, Navigation radio
amplifier, Navigation antenna amplifier
R03
Hi-beam
relay
Fuse 35, Hi-beam headlamps, Hi-beam
indicator
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
273
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
R04
Rear window
defrost relay
Fuse 8 (heated mirrors), Rear window
defroster, Heated outside mirrors, Rear
window defroster indicator (climate control
head)
R05
Trailer tow
battery
charge relay
Trailer tow 7
wire connector (battery
charge)
R06
Front blower
relay
Front blower motor
R201
Trailer tow
park lamp
relay
Trailer tow 7
and 4
wire connectors (park
lamps)
R202
Foglamp
relay
Front foglamps
R203
PCM relay
Fuse 32, Fuse 33, Fuse 34, Fuel pump relay,
Fuel pump, PCM solenoids and sensors
R301
Trailer tow
back-up lamp
relay
Trailer tow 7
wire connector (back-up
lamps)
R302
Speed
control relay
Speed control servo
R303
Fuel pump
relay
Fuel pump shut-off switch, PCM (fuel pump
monitor), Fuel pump
R304
Battery saver
relay
Roof rail lamps, Vanity mirror lamps,
Map/Dome lamp, Glove box lamp, Cargo
area lamp, Outside mirror puddle lamps,
Instrument cluster (interior lamps)
R305
Horn relay
Dual note horn
* Mini Fuses ** Maxi Fuses
Note:
Relays R301
R305 are not serviceable components; see your
dealer or a qualified technician for assistance.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
274
AUXILIARY POWER POINT
Power points are designed for accessory plugs only. Do not hang
any type of accessory or accessory bracket from the plug.
Improper use of the power points can cause damage not covered
by your warranty.
An auxiliary power point is located
by the passenger
s ankle near the
floor in the front console bin.
Do not plug optional electrical
accessories into the cigarette lighter.
Use the power point.
Do not use the power point for
operating the cigarette lighter
element.
The Maximum power each power
point can supply depends on the fuse rating. For example: a 20A fuse
should supply a maximum of 240 Watts, a 15A fuse should supply a
maximum of 180 Watts and a 10A fuse should supply a maximum of 120
Watts. Exceeding these limits will result in a blown fuse.
Always keep the power point caps closed when not being used.
A second auxiliary power point is
located inside the cupholder door
on the rear side of the center
console. The power point is
accessible from the rear seats.
4
3
2
1
0
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driver Controls
128
Power door lock disable feature
This feature will help protect your vehicle from unauthorized entry.
The UNLOCK function on the power door control will not operate with
the ignition in the 1 (OFF/LOCK) position and twenty seconds after the
doors are closed and electronically locked by the remote entry
transmitter, key pad, or power door control (if pressed while the door
was open).
The UNLOCK function will operate again after you unlock the vehicle
using the remote entry transmitter or key pad, turn the ignition to the 3
(ON) position, or open the door from inside of the vehicle.
Deactivating/activating power door lock disable feature
This feature may be deactivated/activated by an authorized dealer.
KEYLESS ENTRY SYSTEM
With the keyless entry keypad, you can:
lock or unlock the vehicle doors without using the key,
release the liftgate glass,
enable or disable the autolock function, and
add or delete a 5
digit personal user code.
Your vehicle has a factory set 5
digit code that operates the keyless
entry system. You can also program your own 5
digit personal entry
code. The factory-set code is located:
on the owner
s wallet card in the glove compartment,
at your dealer,
or on the module located under
the right-hand side of the
instrument panel, adjacent to the
passenger compartment fuse
panel.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Locks and Security
172
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
The front passenger air bag is not designed to offer protection to
an occupant in the center front seating position.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the
Body
Builders Layout Book
for instructions about the appropriate
installation of additional equipment.
Children and air bags
Children must always be properly
restrained. Accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
206
Safety Canopy
´
system
Do not place objects or
mount equipment on or
near the headliner at the siderail
that may come into contact with a
deploying Safety Canopy
±
. Failure
to follow these instructions may
increase the risk of personal injury
in the event of a collision.
Do not lean your head on the door. The Safety Canopy
±
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
±
. See your Ford or Lincoln
Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
±
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
±
.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
209
Do not alter or modify your vehicle
s suspension or steering; the
resulting changes to the vehicle
s handling can adversely affect
the Roll Stability Control system. Also, do not install a stereo
loudspeaker near the front center console or under either front
seat. The speaker vibrations can adversely affect the Roll
Stability Control sensors located in this area.
Note:
Pressing the Roll Stability Control button will disable the Roll
Stability Control.
Aggressive driving in any road conditions can cause you to lose
control of your vehicle increasing the risk of severe personal
injury or property damage. The occurrence of an Roll Stability Control
event is an indication that at least some of the tires have exceeded
their ability to grip the road; this may lead to an increased risk of loss
of vehicle control, vehicle rollover, personal injury and death. If you
experience a severe road event, SLOW DOWN.
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed, it is possible that a fuse
has blown or the vehicle
s brakelamps are not operating properly. Refer
to
Fuses and relays
in the
Roadside Emergencies
chapter.
If the fuse is not blown, perform the following procedure:
1. Apply the parking brake, turn the ignition to LOCK, then remove the
key.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driving
239
The fuel pump shut-off switch has a
red reset button on top of it and is
located beneath the air suspension
switch (if equipped).
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
273
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
274
Passenger compartment fuse panel / power distribution box
The fuse panel is located under the right-hand side of the instrument
panel.
To remove the trim panel for access
to the fuse box, pull the panel
toward you and swing it out away
from the side and remove it. To
reinstall it, line up the tabs with the
grooves on the panel, then push it
shut.
To remove the fuse box cover, place
a finger behind the PULL tab and
your thumb above the PULL tab as
shown in the illustration, then pull
the cover off.
To reinstall the fuse box cover, place the top part of the cover on the
fuse panel, then push the bottom part of the cover until you hear it click
shut. Gently pull on the cover to make sure it is seated properly.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
275
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
10A*
Run/Accessory - Instrument
cluster, Front wiper motor, Rear
wiper motor, Tire Pressure
Monitor System (TPMS) module
2
20A*
Brake On/Off (stoplamp) switch,
Turn signal/Hazard flasher,
AdvanceTrac
±
stoplamps relay (if
equipped), Stoplamps, Center
High-Mounted Stoplamp
(CHMSL), Turn signal lamps
3
7.5A*
Power mirror switch, Memory
module (logic power), Driver seat
switch (memory)
4
15A*
Rear seat audio controls,
Navigation module, DVD player
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
276
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
5
7.5A*
Brake On/Off (stoplamp) switch,
Powertrain Control Module (PCM)
(keep alive power), EATC control
head, Body Security Module
(BSM) (keep alive power), Speed
control deactivation switch, Speed
control servo, SecuriLock LED,
3rd row seat relay coils, Power
liftgate module, Clock, Brake Shift
Interlock (BSI) solenoid
6
15A*
Headlamp switch (parklamps and
switch backlighting feed),
Parklamps, License lamps,
Foglamp relay coil, Trailer tow
electric brake controller
(illumination), BSM (autolamp
parklamps), Floor console gear
selector lighting, Switch
backlighting module, Foglamp
indicator
7
7.5A*
Radio (Start signal)
8
10A*
Rear window defroster switch,
Heated outside mirrors, Rear
window defroster indicator
(climate control head)
9
15A*
Fuel pump relay, Fuel pump
shut-off switch, Fuel pump motor
10
20A*
Trailer tow back-up lamps relay,
Trailer tow 7
wire connector
(back-up lamps), Trailer tow
parklamps relay, Trailer tow 7
and 4
wire connectors
(parklamps)
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
277
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
11
10A*
A/C compressor clutch relay, A/C
compressor clutch solenoid, Air
suspension compressor relay, 4x4
Integrated Wheel Ends (IWE)
solenoid
12
10A*
Speed control relay, Speed control
servo
13
10A*
Rear window defroster relay coil,
A/C refrigerant containment
switch, A/C compressor
thermistor, DEATC control head,
DEATC solenoids, DEATC blower
controller, Trailer tow battery
charge relay coil
14
10A*
Daytime Running Lamps (DRL)
ignition relay coil, Digital
Transmission Range Sensor
(DTRS back-up lamps), Trailer
tow back-up lamps relay coil,
Electrochromatic mirror
15
5A*
AdvanceTrac
±
switch, Instrument
cluster (Run/Start feed)
16
10A*
ABS/AdvanceTrac
±
module
(Run/Start feed)
17
15A*
Foglamps
18
10A*
Auxiliary A/C temperature blend
door actuator, Auxiliary A/C front
auxiliary control, Park brake
release relay coils, Turn signal
flasher, Electrochromatic mirror,
Auxiliary mode motor, Climate
controlled seat modules
19
10A*
Restraints Control Module (RCM)
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
278
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
20
30A*
4x4 module, Air suspension
module (air spring solenoids and
height sensors)
21
15A*
Instrument cluster (B+), Interior
(courtesy) lamps, TPMS module,
Park brake release relays, Park
brake release motor, Puddle lamps
(outside mirrors)
22
10A*
Moonroof switch illumination, Flip
window switch, Flip window
relays, Flip window motors,
Electronic hidden antenna
amplifier (navigation radio), Radio
(delayed accessory feed), Left
front window motor, Navigation
module
23
10A*
RH low beam
24
15A*
Interior demand lamps (front
map/dome lamps, glove
compartment lamp, cargo lamp,
roof rail lamps, vanity mirror
lamps), Battery saver relay coil,
Battery saver relay power
25
10A*
LH low beam
26
20A*
Horn relay, Horns
27
5A*
Brake Shift Interlock solenoid,
Overdrive cancel switch, Reverse
park aid system module, Air
suspension module (Run/Start),
Compass module
28
5A*
PCM relay coil, Speed control
relay coil, SecuriLock transceiver
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
279
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
29
30A*
Trailer tow electric brake
controller, Trailer tow 7
wire
connector (electric brake)
30
30A*
BSM (door locks, liftgate glass
release relay), Liftgate glass
release motor, Left front window
motor, Door/Liftgate lock motors
31
20A*
Radio (B+), Subwoofer,
Navigation radio audio amplifier
32
15A*
Catalyst Monitor Sensors (CMS),
Transmission solenoids
33
10A*
HEGO sensors, EGR vacuum
regulator (EVR) solenoid,
Canister vent solenoid, Vapor
Management valve (VMV)
solenoid, A/C compressor clutch
relay coil
34
15A*
PCM, Idle Air Control (IAC)
solenoid, Mass Air Flow (MAF)
sensor, Fuel injectors
35
20A*
High beam headlamps, Instrument
cluster high beam indicator
36
10A*
Trailer tow right turn/stop lamps
37
20A*
Cargo area power point
38
25A*
Rear wiper motor, Washer pump
(rear window wash)
39
20A*
Console power points
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
280
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
40
20A*
DRL relays, DRL foglamps, DRL
headlamp relay coil, Headlamp
switch (headlamps), Multifunction
switch (flash-to-pass), BSM
(autolamp headlamps relay), High
beam relay coil, Fuse 25 (LH low
beam), Fuse 23 (RH low beam)
41
20A*
Cigar lighter, OBD II diagnostic
connector
42
10A*
Trailer tow left turn/stop lamps
101
30A**
Starter motor relay, Starter motor
solenoid
102
30A**
Ignition switch power
103
30A**
ABS/AdvanceTrac
±
module
(pump motor)
104
30A**
LH 3rd row seat relay, LH 3rd row
seat switch, LH 3rd row seat
motor
105
30A**
Power liftgate module, Power
liftgate motors, Power running
boards control
106
30A**
Trailer tow battery charge relay,
Trailer tow 7
wire connector
(battery charge)
107
30A**
Auxiliary A/C blower relay,
Auxiliary A/C blower motor
108
30A**
Passenger seat motor switch,
Passenger seat lumbar switch and
motor
109
30A**
Driver seat lumbar switch and
motor, Memory module, Power
memory mirrors, Adjustable
pedals switch and motor
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
281
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
110
30A**
Power running boards
111
50A**
Air suspension compressor relay,
Air suspension compressor
112
30A**
ABS/AdvanceTrac
±
module
(valves)
113
30A**
Front wiper motor, Washer pump
(windshield wash)
114
40A**
Rear window defroster relay, Rear
window defroster grid, Heated
mirrors (Fuse 8)
115
30A**
4x4 module, Transfer case shift
motor
116
40A**
Front blower motor relay, Front
blower motor
117
30A**
RH 3rd row seat relay, RH 3rd
row seat switch, RH 3rd row seat
motor
118
30A**
Driver and passenger climate
control seat module
401
30A CB (circuit
breaker)
Power windows (circuit breaker),
Main window switch, Window
motors, Window switches,
Moonroof module
R01
Starter relay
Starter motor solenoid
R02
Delayed
accessory relay
Fuse 22, CB 401, Power windows,
Moonroof, Flip windows, Radio,
Navigation module, Navigation
antenna amplifier
R03
Hi-beam relay
Fuse 35, Hi-beam headlamps,
Hi-beam indicator
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
282
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
R04
Rear window
defrost relay
Fuse 8 (heated mirrors), Rear
window defroster, Heated outside
mirrors, Rear window defroster
indicator (climate control head)
R05
Trailer tow
battery charge
relay
Trailer tow 7
wire connector
(battery charge)
R06
Front blower
relay
Front blower motor
R201
Trailer tow park
lamp relay
Trailer tow 7
and 4
wire
connectors (park lamps)
R202
Foglamp relay
Front foglamps
R203
PCM relay
Fuse 32, Fuse 33, Fuse 34, Fuel
pump relay, PCM solenoids and
sensors
R301
Trailer tow
back-up lamp
relay
Trailer tow 7
wire connector
(back-up lamps)
R302
Speed control
relay
Speed control servo
R303
Fuel pump relay
Fuel pump shut-off switch, PCM
(fuel pump monitor), Fuel pump
R304
Battery saver
relay
Roof rail lamps, Vanity mirror
lamps, Map/Dome lamp, Glove box
lamp, Cargo area lamp, Outside
mirror puddle lamps, Instrument
cluster (interior lamps)
R305
Horn relay
Dual note horn
* Mini Fuses ** Maxi Fuses
Note:
Relays R301
R305 are not serviceable components; see your
dealer or a qualified technician for assistance.
2004 Navigator
(nav)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
283