Lincoln MKZ - 2013 Fuse Box Diagram

Lincoln MKZ - 2013 Fuse Box Diagram

PRINCIPLE OF OPERATION
WARNINGS
Airbags DO NOT inflate slowly
or gently, and the risk of injury
from a deploying airbag is the greatest
close to the trim covering the airbag
module.
All occupants of your vehicle,
including the driver, should
always properly wear their safety
belts, even when an airbag
supplemental restraint system is
provided.
Always transport children 12
years old and under in the back
seat and always properly use
appropriate child restraints.
Never place your arm over the
airbag module as a deploying
airbag can result in serious arm
fractures or other injuries.
Airbags can kill or injure a child
in a child seat. NEVER place a
rear-facing child seat in front of an
active airbag. If you must use a
forward-facing child seat in the front
seat, move the seat all the way back.
Do not attempt to service, repair,
or modify the airbag
supplemental restraint systems or its
fuses. Contact your authorized dealer
as soon as possible.
Several airbag system
components get hot after
inflation. Do not touch them after
inflation.
WARNINGS
If the airbag has deployed, the
airbag will not function again
and must be replaced immediately. If
the airbag is not replaced, the
unrepaired area will increase the risk
of injury in a collision.
The airbags are a supplemental
restraint system and are designed to
work with the safety belts to help
protect the driver and right front
passenger from certain upper body
injuries. Airbags DO NOT inflate
slowly; there is a risk of injury from a
deploying airbag.
Note:
You will hear a loud bang and
see a cloud of harmless powdery
residue if an airbag deploys. This is
normal.
42
Supplementary Restraints System
After all occupants have adjusted
their seats and put on safety belts, it
s
very important that they continue to
sit properly. A properly seated
occupant sits upright, leaning against
the seat back, and centered on the
seat cushion, with their feet
comfortably extended on the floor.
Sitting improperly can increase the
chance of injury in a crash event. For
example, if an occupant slouches, lies
down, turns sideways, sits forward,
leans forward or sideways, or puts one
or both feet up, the chance of injury
during a crash is greatly increased.
The conditions listed above may
cause the weight of a properly seated
occupant to be incorrectly interpreted
by the front passenger sensing
system. The person in the front
passenger seat may appear heavier
or lighter due to the conditions
described in the list above.
To know if the front
passenger sensing system is
operating properly, See
Crash Sensors and Airbag
Indicator
(page 51).
DO NOT attempt to repair or service
the system; take your vehicle
immediately to an authorized dealer.
If it is necessary to modify an
advanced front airbag system to
accommodate a person with
disabilities, contact the Ford
Customer Relationship Center. See
Getting the Services You Need
(page 243).
SIDE AIRBAGS
WARNINGS
Do not place objects or mount
equipment on or near the airbag
cover, on the side of the seat backs
(of the front seats), or in front seat
areas that may come into contact
with a deploying airbag. Failure to
follow these instructions may increase
the risk of personal injury in the event
of a collision.
Do not use accessory seat
covers. The use of accessory
seat covers may prevent the
deployment of the side airbags and
increase the risk of injury in an
accident.
Do not lean your head on the
door. The side airbag could injure
you as it deploys from the side of the
seatback.
Do not attempt to service, repair,
or modify the airbag, its fuses or
the seat cover on a seat containing an
airbag. Contact your authorized dealer
as soon as possible.
If the side airbag has deployed,
the airbag will not function again.
The side airbag system (including the
seat) must be inspected and serviced
by an authorized dealer. If the airbag
is not replaced, the unrepaired area
will increase the risk of injury in a
collision.
48
Supplementary Restraints System
The side airbags are located on the
outboard side of the seat backs of the
front seats. In certain lateral collisions,
the airbag on the side affected by the
collision will be inflated. The airbag
was designed to inflate between the
door panel and occupant to further
enhance the protection provided
occupants in side impact collisions.
E152533
The system consists of the following:
A label or embossed side panel
indicating that side airbags are
fitted to your vehicle
Side airbags located inside the
driver and front passenger seat
backs
Front passenger sensing system
·Crash sensors and
monitoring system with
readiness indicator. See
Crash Sensors and Airbag
Indicator
(page 51).
Note:
The passenger sensing system
will deactivate the passenger
seat-mounted side airbag if it detects
an empty, unbuckled passenger seat.
The design and development of the
side airbag system included
recommended testing procedures
that were developed by a group of
automotive safety experts known as
the Side Airbag Technical Working
Group. These recommended testing
procedures help reduce the risk of
injuries related to the deployment of
side airbags.
SIDE CURTAIN AIRBAGS
WARNINGS
Do not place objects or mount
equipment on or near the
headliner at the siderail that may
come into contact with a deploying
side curtain airbag. Failure to follow
these instructions may increase the
risk of personal injury in the event of
a collision.
Do not lean your head on the
door. The side curtain airbag
could injure you as it deploys from the
headliner.
Do not attempt to service, repair,
or modify the side curtain
airbags, its fuses, the A, B, or C pillar
trim, or the headliner on a vehicle
containing side curtain airbags.
Contact your authorized dealer as
soon as possible.
All occupants of the vehicle
including the driver should
always wear their safety belts even
when an airbag SRS and side curtain
airbag is provided.
49
Supplementary Restraints System
12 Volt DC Power Point
WARNING
Do not plug optional electrical
accessories into the cigar lighter
socket (if equipped). Improper use of
the lighter can cause damage not
covered by your warranty, and can
result in fire or serious injury.
Note:
If used when the engine is not
running, the battery will discharge.
There may be insufficient power to
restart your engine.
Note:
Do not insert objects other than
an accessory plug into the power point.
This will damage the outlet and blow
the fuse.
Note:
Do not hang any type of
accessory or accessory bracket from
the plug.
Note:
Do not use the power point over
the vehicle capacity of 12 volt DC 180
watts or a fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Improper use of the power point
can cause damage not covered by your
warranty.
Note:
Always keep the power point
caps closed when not in use.
Run the engine for full capacity use of
the power point. To prevent the
battery from being discharged:
Do not use the power point longer
than necessary when the engine is
not running.
Do not leave devices plugged in
overnight or when the vehicle is
parked for extended periods.
Locations
Power points may be found:
in the front of the center console
inside the center console storage
bin
on the rear of the center console.
110 Volt AC Power Point
(If
Equipped)
WARNING
Do not keep electrical devices
plugged in the power point
whenever the device is not in use. Do
not use any extension cord with the
110 volt AC power point, since it will
defeat the safety protection design.
Doing so my cause the power point to
overload due to powering multiple
devices that can reach beyond the 150
watt load limit and could result in fire
or serious injury.
Note:
Keep the engine running to use
the power point.
147
Auxiliary Power Points
TOWING A TRAILER
WARNINGS
Do not exceed the GVWR or the
GAWR specified on the
certification label.
Towing trailers beyond the
maximum recommended gross
trailer weight exceeds the limit of the
vehicle and could result in engine
damage, transmission damage,
structural damage, loss of vehicle
control, vehicle rollover and personal
injury.
Note:
There may be electrical items
such as fuses or relays that can affect
trailer towing operation. See
Fuses
(page 251).
Weight, not volume designates your
vehicle's load capacity. You cannot
necessarily use all available space
when loading a vehicle.
Towing a trailer places an additional
load on your vehicle's engine,
transmission, axle, brakes, tires and
suspension. Inspect these
components periodically during, and
after, any towing operation.
Load Placement
To help minimize how trailer
movement affects the vehicle when
driving:
Load the heaviest items closest to
the trailer floor.
Load the heaviest items in the
center of the left and right side
trailer tires.
Load the heaviest items above the
trailer axles or just slightly forward
toward the trailer tongue. Do not
allow the final trailer tongue
weight to go above or below
10-15% of the loaded trailer
weight.
Select a tow bar with the correct
rise or drop. When both the loaded
vehicle and trailer are connected,
the trailer frame should be level,
or slightly angled down toward the
vehicle, when viewed from the
side.
When driving with a trailer or payload,
a slight takeoff vibration or shudder
may be present due to the increased
payload weight. Additional
information regarding proper trailer
loading and setting your vehicle up for
towing is located in another chapter
of this manual. See
Load Limit
(page
219). You can also find the information
in the
RV & Trailer Towing Guide
,
available at your authorized dealer.
RECOMMENDED TOWING
WEIGHTS
Note:
Do not exceed the trailer weight
for your vehicle configuration listed in
the chart below.
Note:
Be sure to take into
consideration trailer frontal area. Do
not exceed 20 feet
2
(1.86 meters
2
).
Note:
For high altitude operation,
reduce the gross combined weight by
2% per 1000 feet (300 meters)
starting at the 1000 foot (300 meter)
elevation point.
227
Towing
CHANGING A FUSE
Fuses
WARNING
Always replace a fuse with one
that has the specified amperage
rating. Using a fuse with a higher
amperage rating can cause severe
wire damage and could start a fire.
E142430
If electrical components in the vehicle
are not working, a fuse may have
blown. Blown fuses are identified by
a broken wire within the fuse. Check
the appropriate fuses before replacing
any electrical components.
Standard Fuse Amperage Rating and Color
Color
J-type fuses
M-type fuses
Dual micro
fuses
Micro fuses
Fuse rating
-
-
Tan
Tan
5A
-
-
Brown
Brown
7.5A
-
-
Red
Red
10A
-
Grey
Blue
Blue
15A
Blue
Light Blue
-
Yellow
20A
White
White
-
White
25A
Pink
Pink
-
Green
30A
Green
Green
-
-
40A
Red
-
-
-
50A
Yellow
-
-
-
60A
251
Fuses
FUSE SPECIFICATION
CHART
Power Distribution Box
WARNINGS
Always disconnect the battery
before servicing high-current
fuses.
To reduce risk of electrical shock,
always replace the cover to the
power distribution box before
reconnecting the battery or refilling
fluid reservoirs.
The power distribution box is in the
engine compartment. It has
high-current fuses that protect your
vehicle's main electrical systems from
overloads.
If you disconnect and reconnect the
battery, you will need to reset some
features. See
Changing the 12V
Battery
(page 277).
E144783
The high-current fuses are coded as
follows:
252
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Not used (spare)
25A
3
1
Starter relay
-
2
Autowipers
15A
1
3
Blower motor relay
-
4
Power point 3 - Back of console
20A
3
5
Not used
-
6
Powertrain control module - vehicle
power 1
20A
1
7
Powertrain control module - vehicle
power 2
20A
1
8
Powertrain control module relay
-
9
Power point 1 - driver front
20A
3
10
Powertrain control module - vehicle
power 4
15A
2
11
Powertrain control module - vehicle
power 3
15A
2
12
Powertrain control module - vehicle
power 5
10A
2
13
Powertrain control module - vehicle
power 6
10A
2
14
Run/start relay
-
15
Power point 2 - console
20A
3
16
Not used
-
17
Powertrain control module - keep
alive power
10A
1
18
253
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Electronic power assist steering
10A
1
19
Run/start lighting
10A
1
20
Run/start transmission control,
Transmission oil pump start/stop
15A
1
21
Air conditioner clutch solenoid
10A
1
22
Blind spot information system, Rear
view camera, Adaptive cruise control,
Heads-up display, Shifter
15A
1
23
Not used
-
24
Anti-lock brake system
10A
2
25
Powertrain control module
10A
2
26
Not used
-
27
Not used
-
28
Not used
-
29
Not used
-
30
Not used
-
31
Electronic fan #1 relay
-
32
Air conditioner clutch relay
-
33
Not used
-
34
Not used
-
35
Not used
-
36
Not used
-
37
Electronic fan #2 relay
-
38
Electronic fan #3 relay
-
39
254
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Fuel pump relay
-
40
Horn relay
-
41
Not used
-
42
Not used
-
43
Not used
-
44
Not used
-
45
Alternator
10A
2
46
Brake on/off switch
10A
2
47
Horn
20A
1
48
Mass air flow monitor
5A
1
49
Not used
-
50
Not used
-
51
Not used
-
52
Power seats
10A
1
53
Not used
-
54
Not used
-
55
1
Micro fuse
2
Dual micro fuse
3
M-type fuse
Power Distribution Box - Bottom
There are fuses located on the bottom
of the fuse box. To access the bottom
of the fuse box, do the following:
255
Fuses
E145983
1.
Release the two latches, located
on both sides of the fuse box.
2.
Raise the inboard side of the fuse
box from the cradle.
3.
Move the fuse box toward the
center of the engine compartment.
4.
Pivot the outboard side of the fuse
box to access the bottom side.
The high-current fuses are coded as
follows:
256
Fuses
E144949
Protected components
Fuse amp rating
Fuse or relay
number
Fuel pump feed
30A
1
56
Not used
-
57
Not used
-
58
500W electronic fan 3
30A
1
59
500W electronic fan 1
30A
1
60
Not used
-
61
Body control module 1
50A
2
62
500W electronic fan 2
20A
1
63
Not used
-
64
257
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Front heated seat
20A
1
65
Not used
-
66
Body control module 2
50A
2
67
Heated rear window
40A
1
68
Anti-lock brake system valves
30A
1
69
Passenger seat
30A
1
70
Not used
-
71
Panoramic roof #1
30A
1
72
Rear climate controlled seats
20A
1
73
Driver seat module
30A
1
74
Not used
-
75
Transmission oil pump #2 stop/start
20A
1
76
Front climate controlled seats
30A
1
77
Not used
-
78
Blower motor
40A
1
79
Power trunk
30A
1
80
Inverter
40A
1
81
Anti-lock brake system pump
60A
2
82
Wiper motor #1
25A
1
83
258
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Starter solenoid
30A
1
84
Panoramic roof #2
30A
1
85
1
M-type fuse
2
J-type fuse
Passenger Compartment Fuse
Panel
The fuse panel is under the instrument
panel to the left of the steering
column.
E145984
The fuses are coded as follows:
259
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Lighting (ambient, glovebox, vanity,
dome, trunk)
10A
1
1
Memory seats, Lumbar, Power mirror
7.5A
1
2
Driver door unlock
20A
1
3
Not used (spare)
5A
1
4
Subwoofer amplifier, THX amplifier
20A
1
5
Not used (spare)
10A
2
6
Not used (spare)
10A
2
7
Not used (spare)
10A
2
8
Not used (spare)
10A
2
9
Power trunk logic
5A
2
10
Not used (spare)
5A
2
11
Climate control, Gear shift
7.5A
2
12
Steering wheel column, Cluster,
Datalink logic
7.5A
2
13
Not used (spare)
10A
2
14
Datalink/Gateway module
10A
2
15
Not used (spare)
15A
1
16
Not used (spare)
5A
2
17
Ignition, Push button stop/start
5A
2
18
260
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Passenger airbag disabled indicator,
Transmission range
5A
2
19
Adaptive headlamps
5A
2
20
Humidity and in-car temperature, Rear
climate seats
5A
2
21
Occupant classification sensor
5A
2
22
Delayed accessory (power inverter
logic, moonroof logic)
10A
1
23
Central lock/unlock
30A
1
24
Driver's door (window, mirror)
30A
1
25
Front passenger's door (window,
mirror)
30A
1
26
Moonroof
30A
1
27
THX amplifier
20A
1
28
Rear driver side door (window)
30A
1
29
Rear passenger side door (window)
30A
1
30
Not used (spare)
15A
1
31
GPS, Voice control, Display, Adaptive
cruise control, Radio frequency
receiver
10A
1
32
Radio, Active noise control
20A
1
33
Run/start bus (fuse #19, 20, 21, 22, 35,
36, 37, circuit breaker)
30A
1
34
Restraints control module
5A
1
35
261
Fuses
Protected components
Fuse amp rating
Fuse or relay
number
Continuous control damping suspen-
sion, Auto-dimming rear view mirror
15A
1
36
All-wheel drive relay, Heated steering
wheel
15A
1
37
Rear window shade
30A
38
1
Micro fuse
2
Dual micro fuse
262
Fuses