Lincoln MKZ - 2009 Fuse Box Diagram

Lincoln MKZ - 2009 Fuse Box Diagram

CLOCK
Press the right (+) control to move
the time display forwards.
Press the left (-) control to move
the time display backwards.
AUXILIARY POWER POINT (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power point is located in the center console utility
compartment.
Do not use the power point for operating the cigarette lighter element (if
equipped).
To prevent the fuse from being blown, do not use the power point(s)
over the vehicle capacity of 12 VDC/180W. If the power point or cigar
lighter socket is not working, a fuse may have blown. Refer to
Fuses and
relays
in the
Roadside Emergencies
chapter for information on
checking and replacing fuses.
To have full capacity usage of your power point, the engine is required to
be running to avoid unintentional discharge of the battery. To prevent
the battery from being discharged:
do not use the power point longer than necessary when the engine is
not running,
do not leave battery chargers, video game adapters, computers and
other devices plugged in overnight or when the vehicle is parked for
extended periods.
Always keep the power point caps closed when not being used.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Driver Controls
55
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
WARNING:
Do not put anything on or over the airbag module.
Placing objects on or over the airbag inflation area may cause
those objects to be propelled by the airbag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint system (SRS) or its fuses. See your
authorized dealer.
WARNING:
Modifying or adding equipment to the front end of
the vehicle (including frame, bumper, front end body structure
and tow hooks) may affect the performance of the airbag system,
increasing the risk of injury. Do not modify the front end of the
vehicle.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Seating and Safety Restraints
127
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or
near the airbag cover on the side of the seatbacks of the front
seats or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. See your authorized dealer.
WARNING:
All occupants of the vehicle should always wear
their safety belts even when an airbag SRS is provided.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Seating and Safety Restraints
135
Side curtain airbag system
WARNING:
Do not place
objects or mount equipment
on or near the headliner at the
siderail that may come into
contact with a deploying side air
curtain. Failure to follow these
instructions may increase the risk
of personal injury in the event of a
collision.
WARNING:
Do not place objects or mount equipment on or
near the side air curtain cover.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the seat.
WARNING:
Do not attempt to service, repair, or modify the side
air curtain system, its fuses, the A, B, or C pillar trim, or the
headliner on a vehicle containing a side air curtain. See your
authorized dealer.
WARNING:
All occupants of the vehicle, including the driver,
should always wear their safety belts even when an inflatable
curtain is provided.
WARNING:
To reduce the risk of injury, do not obstruct or
place objects in the deployment zone of the inflatable curtain.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Seating and Safety Restraints
138
If the steering wanders or pulls, check for:
an improperly inflated tire
uneven tire wear
loose or worn suspension components
loose or worn steering components
improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal depressed:
1. Apply the parking brake, turn
ignition key to off, then remove the
key.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock release access hole
on the console.
3. Insert the screwdriver (or similar
tool) into the access hole and press
downward while pulling the
gearshift lever out of the P (Park)
position and into the N (Neutral)
position.
4. Remove the tool and reinstall the
protective cover.
5. Start the vehicle and release the
parking brake.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Driving
198
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
The fuel pump shut-off switch is
located in the front passenger
footwell area in the right upper
corner.
To reset the switch:
1. Turn the ignition to the off
position.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition to the on
position.
5. Wait a few seconds and return
the key to off position.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
212
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
213
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
1
10A
Backup lamps, Electrochromatic
mirror
2
20A
Horns
3
15A
Battery saver: Interior lamps,
Puddle lamps, Trunk lamp, Glove
box lamp, Rear power windows
4
15A
Parklamps, License plate lamps
5
Not used
6
Not used
7
Not used
8
30A
Rear window defroster
9
10A
Heated mirrors
10
30A
Starter coil, PCM
11
15A
High beams
12
7.5A
Delay accessories: Radio head units,
Moon roof, Front power windows,
Electrochromatic mirrors
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
214
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
13
7.5A
Cluster, Analog clock, Climate
control head units
14
15A
Washer pump
15
20A
Cigar lighter
16
15A
Door lock actuator, Decklid lock
solenoid
17
20A
Not used (Spare)
18
20A
Radio head units, OBDII connector
19
7.5A
Not used (Spare)
20
7.5A
Power mirrors, Satellite radio
module, All wheel drive
21
7.5A
Stop lamps, CHMSL
22
7.5A
Audio
23
7.5A
Wiper relay coil, Cluster logic
24
7.5A
OCS (Passenger’s seat), PAD
indicator
25
7.5A
RCM
26
7.5A
PATS Transceiver, Brake shift
interlock solenoid, Brake pedal
switch, Automatic transmission
module
27
7.5A
Cluster, Climate control head units
28
10A
ABS/Traction Control, Heated seats,
Compass, Reverse sensing system
C/B
30A Circuit
Breaker
Moon roof, Delayed accessory (SJB
fuse 12, rear power windows)
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
WARNING:
Always disconnect the battery before servicing high
current fuses.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
215
WARNING:
To reduce risk of electrical shock, always replace
the cover to the Power Distribution Box before reconnecting the
battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
1
60A***
SJB power feed (fuses 12, 13, 14,
15, 16, 17, 18, C/B)
2
60A***
SJB power feed (fuses 1, 2, 4, 10,
11)
3
40A**
Powertrain power, PCM relay coil
4
40A**
Blower motor
5
Not used
6
40A**
Rear window defroster, Heated
mirrors
7
Not used
8
40A**
ABS pump
45 46 47 48 49
50
51
52
53
55
56
54
57
58
41
42
43
44
23 24 25 26 27
28
29
30
31
32
33
34
35
13
1
2
8
9
10
11
12
18
19
20
21
22
3
4
5
6
7
14 15 16 17
36
37
38
39
40
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
216
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
9
20A**
Wipers
10
30A**
ABS Valves
11
30A**
Passenger heated/cooled seat
12
30A**
Driver heated/cooled seat
13
10A*
SYNC
14
15A*
Ignition switch
15
10A*
Memory module logic
16
15A*
Transmission
17
10A*
Alternator sense
18
Not used
19
40A**
Logic feed to SJB (solid state
devices)
20
20A**
THXII Amplifier #1
21
20A**
THXII Amplifier #2
22
20A**
Console power point
23
10A*
PCM KAM and canister vent
solenoid
24
15A*
Fog lamps
25
10A*
A/C Compressor clutch
26
15A*
LH HID Low beam
27
15A*
RH HID Low beam
28
80A***
Engine cooling fan
29
Not used
30
30A**
Fuel pump/injectors relay
31
30A**
Passenger power seat
32
30A**
Driver power seat
33
20A**
Moon roof
34
30A**
Driver Smart power window
35
30A**
Passenger Smart power window
36
1A*
PCM diode
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
217
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
37
1A*
One Touch Integrated Start
(OTIS) diode
38
Not used
39
Not used
40
Not used
41
Relay
Fog lamp relay
42
Relay
Wiper park relay
43
Relay
A/C clutch relay
44
Not used
45
Not used
46
15A*
Injectors
47
15A*
PCM class B
48
15A*
Coil on plug
49
15A*
PCM class C
50
Full ISO Relay
LH HID low beam relay
51
Full ISO Relay
RH HID low beam relay
52
Full ISO Relay
Blower relay
53
Not used
54
Full ISO Relay
Fuel pump/injectors relay
55
Full ISO Relay
Wiper RUN relay
56
Not used
57
Full ISO Relay
PCM relay
58
Not used
*Mini fuses **A1 fuses ***A3 fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Note:
The tire pressure monitoring system (TPMS) indicator light will
illuminate when the spare tire is in use. To restore the full functionality
of the monitoring system, all road wheels equipped with tire pressure
monitoring sensors must be mounted on the vehicle.
2009 MKZ
(378)
Owners Guide
USA
(fus)
Roadside Emergencies
218