Lincoln Blackwood - 2002 Fuse Box Diagram

Lincoln Blackwood - 2002 Fuse Box Diagram

Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and tow hooks may affect the
performance of the air bag sensors increasing the risk of injury. Do not
modify the front end of the vehicle.
Additional equipment such as snowplow equipment may effect
the performance of the air bag sensors increasing the risk of
injury. Please refer to the Body Builders Layout Book for instructions
about the appropriate installation of additional equipment.
Removing the blocker beam without installing snow plow
attachment hardware may effect air bag deployment in a crash.
Do not operate the truck unless either the blocker beam or snow plow
attachment hardware is installed on the vehicle.
Seating and safety restraints
113
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle if the engine is not at normal operating
temperature or damage to the transmission may occur.
Do not rock the vehicle for more than a few minutes or damage
to the transmission and tires may occur or the engine may
overheat.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn off the ignition whenever you leave
your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving
136
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
NOTE:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
Roadside emergencies
150
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel cover.
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
25A
Radio, Amplifier, I/P fuse 31
2
5A
Powertrain Control Module (PCM),
Instrument Cluster, Electronic Automatic
Temperature Control (EATC), Overhead
Trip Computer Module (OTC), Navigation
Module, Clock
3
20A
Cigar Lighter, Data Link Connector
4
7.5A
Mirrors, Seats, Pedals, (memory)
FUSE1
12
22
2
13
23
6
17
27
7
18
28
8
19
29
9
30
20
31
21
11
10
RELAY
5
RELAY
4
RELAY
3
RELAY
2
RELAY
1
3
14
24
4
15
25
5
16
26
Roadside emergencies
151
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
5
15A
Speed Control Module, Reverse Lamp,
Reverse Sensing System (RSS), E/C Mirror,
Central Security Module, Navigation Module
6
5A
Cluster, Brake Shift Interlock Solenoid,
Generic Electronic Module (GEM), RSS, Air
Suspension, OTC, Compass, Automatic
Parking Brake Release
7
5A
Console Blower Relay
8
5A
E/C mirror, Navigation Module, Clock, GEM
9
Not Used
10
Not Used
11
30A
Front Washer Pump Relay, Wiper Run/Park
Relay, Wiper Hi/LO Relay, Windshield Wiper
Motor
12
15A
Air Suspension
13
20A
Stop Lamp Switch (Lamps), Turn/Hazard
Flasher, Trailer Brake, Radio Frequency
Interference Module (RFI)
14
15A
Battery Saver Relay, Interior Lamp Relay,
Accessory Delay Relay (Power Windows)
15
5A
Stop Lamp Switch, (Speed Control, Brake
Shift Interlock, Anti-lock Brake System
(ABS), PCM Module Inputs, Traction
Control, Air Suspension, Central Security
Module, GEM Module
16
20A
Headlamps (Hi Beams), Cluster (Hi Beam
Indicator)
17
10A
Heated Mirrors, Rear Defrost
18
5A
Instrument Illumination (Dimmer Switch
Power)
19
Not Used
20
5A
GEM, Power Tonneau Cover, Air Suspension,
Memory
Roadside emergencies
152
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
21
15A
Starter Relay, Fuse 20 of the Fuse Panel ,
Radio
22
10A
Air Bag Module
23
10A
Trailer Tow Battery Charge Relay,
Turn/Hazard Flasher, Rear Console Controls,
Climate Control Seats, Traction Control
Module
24
10A
I/P Fuse 7, EATC, Blower Relay
25
Not Used
26
10A
Right Side Low Beam Headlamp
27
5A
Fog lamp Relay and Fog lamp Indicator
28
10A
Left Side Low Beam Headlamp
29
5A
Autolamp Module, Transmission Overdrive
Control Switch, Central Security Module,
Power Tonneau
30
30A
Passive Anti Theft Transceiver, Instrument
Cluster, Ignition Coils, Powertrain Control
Module Relay
31
10A
CD Changer, Rear Console Controls
Relay 1
Interior Lamp Relay
Relay 2
Battery Saver Relay
Relay 3
Heated Grid Relay
Relay 4
One Touch Down Window Relay
Relay 5
Ignition Key Accessory Delay Relay
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Roadside emergencies
153
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
20A *
Power Point
2
30A*
Powertrain Control Module
3
30A*
Headlamps/Autolamps
4
20A*
Console Power Point
5
20A*
Trailer Tow Backup/Park Lamps
6
15A*
Parklamps/Autolamps, Passenger Fuse Panel
Feed Fuse #18
7
20A*
Horn
8
30A*
Power Door Locks
9
15A*
Fog Lamps, Power Tonneau
10
20A*
Fuel Pump
11
20A*
Alternator Field
Roadside emergencies
154
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
12
20A*
Rear Auxiliary Power Point
13
15A*
A/C Clutch
14
20A*
Box Power Point
15
Not Used
16
Not Used
17
10A*
Delayed ACC
18
15A*
Powertrain Control Module, Fuel Injectors,
Fuel Pump Relay, Idle Air Control, Mass Air
Flow Sensor
19
10A*
Trailer Tow Stop and Right Turn Lamp
20
10A*
Trailer Tow Stop and Left Turn Lamp
21
Not Used
22
Not Used
23
15A*
HEGO Sensor, Canister Vent, Automatic
Transmission, CMS Sensor
24
Not Used
101
30A**
Trailer Tow Battery Charge
102
50A**
Four Wheel Antilock Brake Module, Traction
Control
103
50A**
Junction Block Battery Feed
104
Not Used
105
40A**
Climate Control Front Blower
106
Not Used
107
30A**
Passenger Power Seat
108
30A**
Trailer Tow Electric Brake
109
50A**
Air Suspension
110
30A**
Climate Control Seats
111
40A**
Ignition Switch Battery Feed (Start and Run
Circuits)
112
30A**
Drivers Power Seat, Adjustable Pedals
113
40A**
Ignition Switch Battery Feed (Run and
Accessory Circuits)
Roadside emergencies
155
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
114
Not Used
115
Not Used
116
40A**
Heated Grid / Mirrors
117
Not Used
118
Not Used
201
Trailer Tow Park Lamp Relay
202
Front Wiper Run/Park Relay
203
Trailer Tow Backup Lamp Relay
204
A/C Clutch Relay
205
Not Used
206
Fog Lamp Relay
207
Front Washer Pump Relay
208
Not Used
209
Not Used
301
Fuel Pump Relay
302
Trailer Tow Battery Charge Relay
303
Wiper High / Low Relay
304
Powertrain Control Module Relay
401
Not Used
501
Powertrain Control Module Diode
502
A/C Compressor Diode
503
Auto Park Brake Diode
601
30A CB
Power Windows, Moonroof
602
50A**
Power Tonneau
*Mini fuses **Maxi fuses
Roadside emergencies
156
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and tow hooks may affect the
performance of the air bag sensors increasing the risk of injury. Do not
modify the front end of the vehicle.
Additional equipment such as snowplow equipment may effect
the performance of the air bag sensors increasing the risk of
injury. Please refer to the Body Builders Layout Book for instructions
about the appropriate installation of additional equipment.
Seating and safety restraints
112
Vehicles with a higher center of gravity such as utility and
four-wheel drive vehicles handle differently than vehicles with a
lower center of gravity. Utility and four-wheel drive vehicles are
not
designed for cornering at speeds as high as passenger cars any more
than low-slung sports cars are designed to perform satisfactorily under
off-road conditions. Avoid sharp turns, excessive speed and abrupt
maneuvers in these vehicles. Failure to drive cautiously could result in
an increased risk of vehicle rollover, personal injury and death.
Loaded vehicles, with a higher center of gravity, may handle
differently than unloaded vehicles. Extra precautions, such as
slower speeds and increased stopping distance, should be taken when
driving a heavily loaded vehicle.
Your vehicle has the capability to haul more cargo and people than most
passenger cars. Depending upon the type and placement of the load,
hauling people and cargo may raise the center of gravity of the vehicle.
Use extra caution while becoming familiar with your vehicle. Know the
capabilities and limitations of both you as a driver and your vehicle.
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless the brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF.
Apply the brake pedal and shift
to N (Neutral)
.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Driving
134
The fuel pump shut-off switch is
located in the passenger’s foot well,
by the kick panel.
Use the following procedure to reset
the fuel pump shut-off switch.
1. Turn the ignition to the OFF
position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset
the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON
position. Pause for a few seconds
and return the key to the OFF
position.
5. Make a further check for leaks in
the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside emergencies
148
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside emergencies
149
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
25A
Radio, Amplifier, I/P fuse 31
2
5A
Powertrain Control Module (PCM),
Instrument Cluster, Electronic Automatic
Temperature Control (EATC), Overhead
Trip Computer Module (OTC), Navigation
Module, Clock
3
20A
Cigar Lighter, Data Link Connector
4
7.5A
Mirrors, Seats, Pedals, (memory)
5
15A
Speed Control Module, Reverse Lamp,
Reverse Sensing System (RSS), E/C Mirror,
Central Security Module, Navigation Module
FUSE1
12
22
2
13
23
6
17
27
7
18
28
8
19
29
9
30
20
31
21
11
10
RELAY
5
RELAY
4
RELAY
3
RELAY
2
RELAY
1
3
14
24
4
15
25
5
16
26
Roadside emergencies
150
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
6
5A
Cluster, Brake Shift Interlock Solenoid,
Generic Electronic Module (GEM), RSS, Air
Suspension, OTC, Compass, Automatic
Parking Brake Release
7
5A
Console Blower Relay
8
5A
E/C mirror, Navigation Module, Clock, GEM
9
Not Used
10
Not Used
11
30A
Front Washer Pump Relay, Wiper Run/Park
Relay, Wiper Hi/LO Relay, Windshield Wiper
Motor
12
15A
Air Suspension
13
20A
Stop Lamp Switch (Lamps), Turn/Hazard
Flasher, Trailer Brake, Radio Frequency
Interference Module (RFI)
14
15A
Battery Saver Relay, Interior Lamp Relay,
Accessory Delay Relay (Power Windows)
15
5A
Stop Lamp Switch, (Speed Control, Brake
Shift Interlock, Anti-lock Brake System
(ABS), PCM Module Inputs, Traction
Control, Air Suspension, Central Security
Module, GEM Module
16
20A
Headlamps (Hi Beams), Cluster (Hi Beam
Indicator)
17
10A
Heated Mirrors, Rear Defrost
18
5A
Instrument Illumination (Dimmer Switch
Power)
19
Not Used
20
5A
GEM, Power Tonneau Cover, Air
Suspension, Memory
21
15A
Starter Relay, Fuse 20 of the Fuse Panel ,
Radio
Roadside emergencies
151
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
22
10A
Air Bag Module
23
10A
Trailer Tow Battery Charge Relay,
Turn/Hazard Flasher, Rear Console Controls,
Climate Control Seats, Traction Control
Module
24
10A
I/P Fuse 7, EATC, Blower Relay
25
Not Used
26
10A
Right Side Low Beam Headlamp
27
5A
Fog lamp Relay and Fog lamp Indicator
28
10A
Left Side Low Beam Headlamp
29
5A
Autolamp Module, Transmission Overdrive
Control Switch, Central Security Module,
Power Tonneau
30
30A
Passive Anti Theft Transceiver, Instrument
Cluster, Ignition Coils, Powertrain Control
Module Relay
31
10A
CD Changer, Rear Console Controls
Relay 1
Interior Lamp Relay
Relay 2
Battery Saver Relay
Relay 3
Heated Grid Relay
Relay 4
One Touch Down Window Relay
Relay 5
Ignition Key Accessory Delay Relay
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the power distribution box before
reconnecting the battery or refilling fluid reservoirs
Roadside emergencies
152
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
20A *
Power Point
2
30A*
Powertrain Control Module
3
30A*
Headlamps/Autolamps
4
20A*
Console Power Point
5
20A*
Trailer Tow Backup/Park Lamps
6
15A*
Parklamps/Autolamps, Passenger Fuse Panel
Feed Fuse #18
7
20A*
Horn
8
30A*
Power Door Locks
9
15A*
Fog Lamps, Power Tonneau
10
20A*
Fuel Pump
11
20A*
Alternator Field
12
20A*
Rear Auxiliary Power Point
13
15A*
A/C Clutch
14
20A*
Box Power Point
Roadside emergencies
153
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
15
Not Used
16
Not Used
17
10A*
Delayed ACC
18
15A*
Powertrain Control Module, Fuel Injectors,
Fuel Pump Relay, Idle Air Control, Mass Air
Flow Sensor
19
10A*
Trailer Tow Stop and Right Turn Lamp
20
10A*
Trailer Tow Stop and Left Turn Lamp
21
Not Used
22
Not Used
23
15A*
HEGO Sensor, Canister Vent, Automatic
Transmission, CMS Sensor
24
Not Used
101
30A**
Trailer Tow Battery Charge
102
50A**
Four Wheel Antilock Brake Module, Traction
Control
103
50A**
Junction Block Battery Feed
104
Not Used
105
40A**
Climate Control Front Blower
106
Not Used
107
30A**
Passenger Power Seat
108
30A**
Trailer Tow Electric Brake
109
50A**
Air Suspension
110
30A**
Climate Control Seats
111
40A**
Ignition Switch Battery Feed (Start and Run
Circuits)
112
30A**
Drivers Power Seat, Adjustable Pedals
113
40A**
Ignition Switch Battery Feed (Run and
Accessory Circuits)
114
Not Used
115
Not Used
116
40A**
Heated Grid / Mirrors
Roadside emergencies
154
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
117
Not Used
118
Not Used
201
Trailer Tow Park Lamp Relay
202
Front Wiper Run/Park Relay
203
Trailer Tow Backup Lamp Relay
204
A/C Clutch Relay
205
Not Used
206
Fog Lamp Relay
207
Front Washer Pump Relay
208
Not Used
209
Not Used
301
Fuel Pump Relay
302
Trailer Tow Battery Charge Relay
303
Wiper High / Low Relay
304
Powertrain Control Module Relay
401
Not Used
501
Powertrain Control Module Diode
502
A/C Compressor Diode
503
Auto Park Brake Diode
601
30A CB
Power Windows, Moonroof
602
50A**
Power Tonneau
*Mini fuses **Maxi fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Spare tire information
Your vehicle is equipped with a spare tire that may be used as a spare or
a regular tire. The spare is identical to the other tires on your vehicle.
Roadside emergencies
155