Lincoln Aviator - 2005 Fuse Box Diagram

Lincoln Aviator - 2005 Fuse Box Diagram

Do not let children play with the moon roof or leave children
unattended in the vehicle. They may seriously hurt themselves.
CLOCK
Press the right control to increase
the time displayed.
Press the left control to decrease
the time displayed.
AUXILIARY POWER POINT (IF EQUIPPED)
Power outlets are designed for accessory plugs only. Do not hang
any type of accessory or accessory bracket from the plug.
Improper use of the power outlet can cause damage not covered
by your warranty.
The auxiliary power point is located
inside the center console.
Do not plug optional electrical
accessories into the cigarette lighter.
Use the power point.
Do not use the power point for
operating the cigarette lighter
element.
The maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse can supply a maximum of 240 Watts, a
15A fuse can supply a maximum of 180 Watts and a 10A fuse can supply
a maximum of 120 Watts. Exceeding these limits will result in a blown
fuse.
Always keep the power point caps closed when not being used.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Driver Controls
124
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag
supplemental restraint system (SRS) is provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
The National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 10 inches (25 cm)
between an occupant
s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the
Body
Builders Layout Book
for instructions about the appropriate
installation of additional equipment.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Seating and Safety Restraints
202
The RCM (restraints control module) monitors its own internal circuits
and the supplemental air bag electrical system wiring (including the
impact sensors, the system wiring, the air bag system readiness light, the
air bag back up power and the air bag ignitors).
Safety Canopy
´
system
Do not place objects or
mount equipment on or
near the headliner at the siderail
that may come into contact with a
deploying Safety Canopy
±
. Failure
to follow these instructions may
increase the risk of personal injury
in the event of a collision.
Do not lean your head on the door. The Safety Canopy
±
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
±
. See your Ford or Lincoln
Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
±
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
±
.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Seating and Safety Restraints
205
2. Locate the access panel on the
driver side of the floor console.
Using a screwdriver (or equivalent),
pry the access panel off the floor
console.
3. Using the screwdriver (or
equivalent), push the white plastic
override mechanism (located behind
the bracket) toward the roof of the
vehicle as shown in the illustration.
4. Move the gearshift lever back to N (Neutral) (two places from P
[Park]).
5. Start the vehicle and release the parking brake.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Driving
277
The fuel pump shut-off switch is
located in the passenger
s foot well,
by the kick panel.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
294
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below the
instrument panel on the driver
s
side.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
295
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
30A
Moonroof motor, Driver seat
switch, Driver seat lumbar
2
10A
VAPS module, Memory seat
module, Body security module,
Tire Pressure Monitor System
(TPMS), SecuriLock
±
LED
3
20A
Radio, Navigation module
4
5A
Front wiper module
5
15A
Flasher relay (turn/hazards)
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
296
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
6
5A
Electronic Hidden Antenna
Module (EHAM) (antenna
amplifier), Radio, Moonroof motor,
Driver window motor, Navigation
module and microphone
7
15A
Heated mirrors, DEATC module
8
5A
Daytime Running Lamps (DRL)
module, Heated PCV valve
9
10A
Back-up lamps (DTRS),
Electrochromatic mirror
10
10A
Heated backlight relay coil,
Climate seat modules, Auxiliary
A/C temperature blend/mode
actuator, A/C clutch relay contact
11
20A
Not used (spare)
12
15A
Restraints module
13
10A
Brake shift interlock
14
5A
Not used (spare)
15
5A
Instrument cluster, Rear wiper
module, TPMS
16
15A
OBD II
17
15A
Delayed accessory relay coil,
Battery saver relay coil and
contact
18
5A
Not used (spare)
19
15A
Washer pump
20
5A
Shifter, Clock, Power mirror
switch, DVD
21
10A
Brake pressure switch (ABS),
RSC switch, Flasher relay
22
10A
ABS/RSC module
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
297
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
23
7.5A
Liftgate release relay coil and
contact
24
30A
Subwoofer, Navigation amp
25
5A
Trailer tow battery charge relay
coil
26
5A
SecuriLock
±
transceiver
27
5A
Rear park assist, VAPS module
28
5A
Radio, Navigation
29
10A
DTRS, Feed to Fuse 28
30
5A
Instrument cluster, Compass
module, Auxiliary A/C relay coil
The relays are located on the reverse side of the passenger compartment
fuse panel. To access the relays, you must remove the fuse panel.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
298
Fuse/Relay Location
Description
Relay 1
Flasher relay
Relay 2
Heated backlight relay
Relay 3
Delayed accessory relay
Relay 4
Open
Relay 5
Battery saver relay
Relay 6
Open
Relay 7
Open
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle
s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
299
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
* Mini Fuses ** Cartridge Fuses
1
60A**
Power Junction Box (PJB)
2
30A**
Door locks (BSM)
3
20A**
Cigar lighter
4
40A**
Heated backlight/mirrors
5
40A**
Anti-lock Brake System
(ABS)/Roll Stability Control
(RSC) module (pump)
6
60A**
Delayed accessory
7
20A**
Daytime Running Lamps (DRL)
module
8
20A**
Electric cooling fan
9
20A**
Headlamp switch
10
30A**
ABS/RSC module (valves)
11
40A**
PTEC relay contacts
12
50A**
Ignition/Starter relay
13
40A**
Trailer tow relays
14
15A*
Brake lamp feed
15
10A*
Keep alive power
(PTEC/cluster/DEATC), Courtesy
lights
16
20A*
Power point #3
17
20A*
Rear wiper module
18
20A*
4x4 module
19
30A**
Driver window motor
20
30A**
Electric trailer brake module
21
30A**
Memory seat module
22
20A**
Main exterior lamps (low beam
headlamps, high beam headlamps,
fog lamps)
23
30A**
Ignition switch
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
300
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
* Mini Fuses ** Cartridge Fuses
24
20A*
Horn relay
25
20A*
Power point #1
26
20A*
Fuel pump relay contacts
27
20A*
Trailer tow relays
28
20A*
Power point #2
29
60A**
PJB
30
30A**
Front wiper module
31
30A**
Climate-controlled seats modules
32
30A**
Passenger seat switch
33
30A**
Auxiliary blower motor
34
20A**
Right HID relay
35
20A**
Left HID relay
36
40A**
Blower motor
37
15A*
A/C clutch relay, TXV,
Transmission, Speed control
38
15A*
HEGO, VMV, Canister vent,
IMCC-LSRC, EGR module
39
15A*
Injectors, Idle air control
40
15A*
PTEC, Mass Air Flow (MAF)
sensor, Fuel pump relay
41
25A*
Coil on plug, PTEC diode/relay
42
10A*
Right low beam (halogen)
43
10A*
Left low beam (halogen)
44
2A*
Heated PCV valve (w/DRL only)
45
2A*
Brake Pressure Switch
46
20A*
High beams/Fog lamps
47
Horn relay
48
Fuel pump relay
49
High beam relay
50
Fog lamp relay
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
301
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
* Mini Fuses ** Cartridge Fuses
51
Not used
52
A/C clutch relay
53
Trailer tow right turn relay
54
Trailer tow left turn relay
55
Blower motor relay
56
Starter motor relay
57
PTEC relay
58
Ignition relay
59
Not used
60
PCM diode
61
A/C clutch diode
62
30A circuit
breaker
Power windows, Moonroof, Audio
(delayed accessory)
Auxiliary relay box
The relay box is located on the front
right fender well underneath the
speed control module.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
302
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 1
HID relay (
1
²
2
ISO)
Relay 2
HID relay (
1
²
2
ISO)
Relay 3
Open
Relay 4
EDF relay (Full ISO)
Rear relay box
The relay box is located on the rear passenger side quarter trim panel.
See your dealer or a certified technician for service of this relay box.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
303
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 1
Liftgate release solenoid
Relay 2
Open
Relay 3
Open
Relay 4
Trailer tow back-up lamps
Relay 5
Open
Relay 6
Open
Relay 7
Trailer tow battery charge
Relay 8
Trailer tow park lamps
Relay 9
Open
Relay 10
Open
Diode 11
Open
Diode 12
Open
JUMP STARTING YOUR VEHICLE
The gases around the battery can explode if exposed to flames,
sparks, or lit cigarettes. An explosion could result in injury or
vehicle damage.
Batteries contain sulfuric acid which can burn skin, eyes and
clothing, if contacted.
Do not attempt to push-start your vehicle. Automatic
transmissions do not have push-start capability; doing so may
damage the catalytic converter.
Preparing your vehicle
When the battery is disconnected or a new battery is installed, the
transmission must relearn its shift strategy. As a result, the transmission
may have firm and/or soft shifts. This operation is considered normal and
will not affect function or durability of the transmission. Over time, the
adaptive learning process will fully update transmission operation.
1.
Use only a 12
volt supply to start your vehicle.
2. Do not disconnect the battery of the disabled vehicle as this could
damage the vehicle
s electrical system.
REVIEW COPY
2005 Aviator f/k/a Navigator LS
(231)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
304
The maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse can supply a maximum of 240 Watts, a
15A fuse can supply a maximum of 180 Watts and a 10A fuse can supply
a maximum of 120 Watts. Exceeding these limits will result in a blown
fuse.
Always keep the power point caps closed when not being used.
An auxiliary power point is located
on the lower rear side of the center
console. The power point is
accessible from the rear seats.
Another auxiliary power point is
located on the right rear quarter
panel. The power point is accessible
from the liftgate.
POWER WINDOWS
Do not leave children unattended in the vehicle and do not let
children play with the power windows. They may seriously injure
themselves.
When closing the power windows, you should verify they are free
of obstructions and ensure that children and/or pets are not in
the proximity of the window openings.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Driver Controls
125
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag
supplemental restraint system (SRS) is provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
The National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 10 inches (25 cm)
between an occupant
s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln/Mercury dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the
Body
Builders Layout Book
for instructions about the appropriate
installation of additional equipment.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Seating and Safety Restraints
202
The RCM (restraints control module) monitors its own internal circuits
and the supplemental air bag electrical system wiring (including the
impact sensors, the system wiring, the air bag system readiness light, the
air bag back up power and the air bag ignitors).
Safety Canopy
´
system
Do not place objects or
mount equipment on or
near the headliner at the siderail
that may come into contact with a
deploying Safety Canopy
³
. Failure
to follow these instructions may
increase the risk of personal injury
in the event of a collision.
Do not lean your head on the door. The Safety Canopy
³
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
³
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
³
. See your Ford or
Lincoln/Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
³
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
³
.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Seating and Safety Restraints
205
3. Using the screwdriver (or
equivalent), push the white plastic
override mechanism (located behind
the bracket) toward the roof of the
vehicle as shown in the illustration.
4. Move the gearshift lever back to N (Neutral) (two places from P [Park]).
5. Start the vehicle and release the parking brake.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Driving
276
The fuel pump shut-off switch is
located in the passenger
s foot well,
by the kick panel.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
292
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below the
instrument panel on the driver
s
side.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
293
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
30A
Moonroof motor, Driver seat switch,
Driver seat lumbar
2
10A
VAPS module, Memory seat module,
Body security module, Tire Pressure
Monitor System (TPMS), SecuriLock
³
LED
3
20A
Radio, Navigation module
4
5A
Front wiper module
5
15A
Flasher relay (turn/hazards)
6
5A
Electronic Hidden Antenna Module
(EHAM) (antenna amplifier), Radio,
Moonroof motor, Driver window motor,
Navigation module and microphone
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
294
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
7
15A
Heated mirrors, DEATC module
8
5A
Daytime Running Lamps (DRL)
module, Heated PCV valve
9
10A
Back-up lamps (DTRS),
Electrochromatic mirror
10
10A
Heated backlight relay coil, Climate
seat modules, Auxiliary A/C
temperature blend/mode actuator, A/C
clutch relay contact
11
20A
Not used (spare)
12
15A
Restraints module
13
10A
Brake shift interlock
14
5A
Not used (spare)
15
5A
Instrument cluster, Rear wiper module,
TPMS
16
15A
OBD II
17
15A
Delayed accessory relay coil, Battery
saver relay coil and contact
18
5A
Not used (spare)
19
15A
Washer pump
20
5A
Shifter, Clock, Power mirror switch, DVD
21
10A
Brake pressure switch (ABS), RSC
switch, Flasher relay
22
10A
ABS/RSC module
23
7.5A
Liftgate release relay coil and contact
24
30A
Subwoofer, Navigation amp
25
5A
Trailer tow battery charge relay coil
26
5A
SecuriLock
³
transceiver
27
5A
Rear park assist, VAPS module
28
5A
Radio, Navigation
29
10A
DTRS, Feed to Fuse 28
30
5A
Instrument cluster, Compass module,
Auxiliary A/C relay coil
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
295
The relays are located on the reverse side of the passenger compartment
fuse panel. To access the relays, you must remove the fuse panel.
Fuse/Relay Location
Description
Relay 1
Flasher relay
Relay 2
Heated backlight relay
Relay 3
Delayed accessory relay
Relay 4
Open
Relay 5
Battery saver relay
Relay 6
Open
Relay 7
Open
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle
s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
296
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
* Mini Fuses ** Cartridge Fuses
1
60A**
Power Junction Box (PJB)
2
30A**
Door locks (BSM)
3
20A**
Cigar lighter
4
40A**
Heated backlight/mirrors
5
40A**
Anti-lock Brake System
(ABS)/Roll Stability Control
(RSC) module (pump)
6
60A**
Delayed accessory
7
20A**
Daytime Running Lamps (DRL)
module
8
20A**
Electric cooling fan
9
20A**
Headlamp switch
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
297
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
* Mini Fuses ** Cartridge Fuses
10
30A**
ABS/RSC module (valves)
11
40A**
PTEC relay contacts
12
50A**
Ignition/Starter relay
13
40A**
Trailer tow relays
14
15A*
Brake lamp feed
15
10A*
Keep alive power
(PTEC/cluster/DEATC), Courtesy
lights
16
20A*
Power point #3
17
20A*
Rear wiper module
18
20A*
4x4 module
19
30A**
Driver window motor
20
30A**
Electric trailer brake module
21
30A**
Memory seat module
22
20A**
Main exterior lamps (low beam
headlamps, high beam headlamps,
fog lamps)
23
30A**
Ignition switch
24
20A*
Horn relay
25
20A*
Power point #1
26
20A*
Fuel pump relay contacts
27
20A*
Trailer tow relays
28
20A*
Power point #2
29
60A**
PJB
30
30A**
Front wiper module
31
30A**
Climate-controlled seats modules
32
30A**
Passenger seat switch
33
30A**
Auxiliary blower motor
34
20A**
Right HID relay
35
20A**
Left HID relay
36
40A**
Blower motor
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
298
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
* Mini Fuses ** Cartridge Fuses
37
15A*
A/C clutch relay, TXV,
Transmission, Speed control
38
15A*
HEGO, VMV, Canister vent,
IMCC-LSRC, EGR module
39
15A*
Injectors, Idle air control
40
15A*
PTEC, Mass Air Flow (MAF)
sensor, Fuel pump relay
41
25A*
Coil on plug, PTEC diode/relay
42
10A*
Right low beam (halogen)
43
10A*
Left low beam (halogen)
44
2A*
Heated PCV valve (w/DRL only)
45
Not used
46
20A*
High beams/Fog lamps
47
Horn relay
48
Fuel pump relay
49
High beam relay
50
Fog lamp relay
51
Not used
52
A/C clutch relay
53
Trailer tow right turn relay
54
Trailer tow left turn relay
55
Blower motor relay
56
Starter motor relay
57
PTEC relay
58
Ignition relay
59
Not used
60
PCM diode
61
A/C clutch diode
62
30A circuit
breaker
Power windows, Moonroof, Audio
(delayed accessory)
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
299
Auxiliary relay box
The relay box is located on the front
right fender well underneath the
speed control module.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 1
HID relay (
1
²
2
ISO)
Relay 2
HID relay (
1
²
2
ISO)
Relay 3
Open
Relay 4
EDF relay (Full ISO)
Rear relay box
The relay box is located on the rear passenger side quarter trim panel.
See your dealer or a certified technician for service of this relay box.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
300
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 1
Liftgate release solenoid
Relay 2
Open
Relay 3
Open
Relay 4
Trailer tow back-up lamps
Relay 5
Open
Relay 6
Open
Relay 7
Trailer tow battery charge
Relay 8
Trailer tow park lamps
Relay 9
Open
Relay 10
Open
Diode 11
Open
Diode 12
Open
JUMP STARTING YOUR VEHICLE
The gases around the battery can explode if exposed to flames,
sparks, or lit cigarettes. An explosion could result in injury or
vehicle damage.
Batteries contain sulfuric acid which can burn skin, eyes and
clothing, if contacted.
2005 Aviator f/k/a Navigator LS
(231)
Owners Guide (post-2002-fmt)
USA_English
(fus)
Roadside Emergencies
301