Saturn Aura Hybrid - 2009 Fuse Box Diagram

Saturn Aura Hybrid - 2009 Fuse Box Diagram

Vehicle Symbols
The vehicle has components and labels that use
symbols instead of text. Symbols are shown along with
the text describing the operation or information
relating to a specific component, control, message,
gage, or indicator.
M
:
This symbol is shown when you need to see your
owner manual for additional instructions or information.
*
:
This symbol is shown when you need to see a
service manual for additional instructions or information.
Vehicle Symbol Chart
Here are some additional symbols that may be found on
the vehicle and what they mean. For more information
on the symbol, refer to the index.
9
:
Airbag Readiness Light
#
:
Air Conditioning
!
:
Antilock Brake System (ABS)
g
:
Audio Steering Wheel Controls or OnStar
®
$
:
Brake System Warning Light
"
:
Charging System
I
:
Cruise Control
B
:
Engine Coolant Temperature
O
:
Exterior Lamps
#
:
Fog Lamps
.
:
Fuel Gage
+
:
Fuses
i
:
Headlamp High/Low-Beam Changer
j
:
LATCH System Child Restraints
*
:
Malfunction Indicator Lamp
:
:
Oil Pressure
}
:
Power
/
:
Remote Vehicle Start
>
:
Safety Belt Reminders
7
:
Tire Pressure Monitor
F
:
Traction Control
M
:
Windshield Washer Fluid
iv
If the engine still does not start, and the key appears
to be not damaged, try another ignition key. At this time,
you may also want to check the fuse. See
Fuses on
page 5-83
. If the engine still does not start with the other
key, your vehicle needs service. If your vehicle does start,
the first key may be faulty. See your dealer/retailer who
can service the PASS-Key
®
III+ to have a new key made.
In an emergency, contact Roadside Assistance.
See
Roadside Assistance Program on page 7-7
.
It may be possible for the PASS-Key
®
III+ decoder to
“learn” the transponder value of a new or replacement
key. Up to 10 keys may be programmed for the vehicle.
The following procedure is for programming additional
keys only. If all the currently programmed keys are
lost or do not operate, you must see your dealer/retailer
or a locksmith who can service PASS-Key
®
III+ to
have keys made and programmed to the system.
See your dealer/retailer or a locksmith who can service
PASS-Key
®
III+ to get a new key blank that is cut
exactly as the ignition key that operates the system.
To program the new key:
1. Verify that the new key has a
1
stamped on it.
2. Insert the already programmed key in the ignition
and start the engine. If the engine will not start,
see your dealer/retailer for service.
3. After the engine has started, turn the key to
LOCK/OFF, and remove the key.
4. Insert the key to be programmed and turn it to the
ON/RUN position within five seconds of the original
key being turned to the LOCK/OFF position.
The security light will turn off once the key has
been programmed.
5. Repeat Steps 1 through 4 if additional keys are to
be programmed.
If you are ever driving and the security light comes on
and stays on, you may be able to restart your engine if
you turn it off. Your PASS-Key
®
III+ system, however,
is not working properly and must be serviced by
your dealer/retailer. Your vehicle is not protected by the
PASS-Key
®
III+ system at this time.
If the PASS-Key
®
III+ key is lost or damaged, see your
dealer/retailer or a locksmith who can service
PASS-Key
®
III+ to have a new key made.
Do not leave the key or device that disarms or
deactivates the theft deterrent system in the vehicle.
2-20
Turn Signal/Multifunction Lever
The lever on the left side of the steering column
includes the following:
G
:
Turn and Lane-Change Signals
5 3
:
Headlamp High/Low-Beam Changer
O
:
Exterior Lamp Control
Flash-to-Pass.
Information for these features is on the pages following.
Turn and Lane-Change Signals
An arrow on the instrument
panel cluster flashes in the
direction of the turn or
lane change.
Move the lever all the way up or down to signal a turn.
Raise or lower the lever until the arrow starts to flash
to signal a lane change. Hold it there until lane change
is complete.
The lever returns to its starting position when it is
released.
If after signaling a turn or lane change the arrows flash
rapidly or do not come on, a signal bulb could be
burned out.
Have the bulbs replaced. If the bulb is not burned out,
check the fuse. See
Fuses on page 5-83
.
3-7
Accessory Power Outlet(s)
Accessory power outlets can be used to connect
auxiliary electrical equipment, such as a cellular
telephone.
There are two accessory power outlets. One accessory
power outlet is inside the center storage console and
the other is located on the center storage console below
the climate controls.
To use an outlet, lift the protective cap. When not in
use, always cover the outlet with the protective cap.
The accessory power outlet is operational at all times.
Notice:
Leaving electrical equipment plugged in for
an extended period of time while the vehicle is off
will drain the battery. Power is always supplied
to the outlets. Always unplug electrical equipment
when not in use and do not plug in equipment
that exceeds the maximum 20 ampere rating.
Certain electrical accessories may not be compatible
with the accessory power outlet and could result
in blown vehicle or adapter fuses. If you experience a
problem, see your retailer for additional information
on the accessory power outlet.
Notice:
Adding any electrical equipment to your
vehicle can damage it or keep other components
from working as they should. The repairs would not
be covered by your warranty. Do not use equipment
exceeding maximum amperage rating of 20 amperes.
Check with your dealer/retailer before adding
electrical equipment.
When adding electrical equipment, be sure to follow the
proper installation instructions included with the
equipment.
Notice:
Improper use of the power outlet can cause
damage not covered by the warranty. Do not hang
any type of accessory or accessory bracket from the
plug because the power outlets are designed for
accessory power plugs only.
3-18
Dinghy Towing
When dinghy towing, the vehicle should be run at the
beginning of each day and at each RV fuel stop for about
five minutes. This will ensure proper lubrication of
transmission components.
To dinghy tow the vehicle from the front with all
four wheels on the ground:
1. Position the vehicle to tow and then secure it to the
towing vehicle.
2. Shift the transmission to P (Park) and turn the
ignition to LOCK/OFF.
3. Set the parking brake.
4. To prevent the battery from draining while the
vehicle is being towed, remove the following
fuse from the instrument panel fuse block:
(IGN SENSOR). See
Instrument Panel Fuse Block
on page 5-83
for more information.
5. Turn the ignition to ACC/ACCESSORY.
6. Shift the transmission to N (Neutral).
7. Release the parking brake.
Remember to reinstall the IGN SENSOR fuse once the
destination has been reached.
Notice:
If 65 mph (105 km/h) is exceeded while
towing the vehicle, it could be damaged. Never
exceed 65 mph (105 km/h) while towing the vehicle.
4-29
A. Engine Air Cleaner/Filter. See
Engine Air
Cleaner/Filter on page 5-20
.
B. Cooling Fans (Out of view). See
Cooling System on
page 5-22
.
C. Engine Oil Dipstick. See “Checking Engine Oil”
under
Engine Oil on page 5-15
.
D. Engine Oil Fill Cap. See “When to Add Engine Oil”
under
Engine Oil on page 5-15
.
E. Engine Coolant Surge Tank. See
Engine Coolant on
page 5-23
.
F. Brake Master Cylinder Reservoir. See “Brake Fluid”
under
Brakes on page 5-31
.
G. Battery (Out of view). See
Battery on page 5-32
.
H. Engine Compartment Fuse Block. See
Engine
Compartment Fuse Block on page 5-86
.
I. Windshield Washer Fluid Reservoir. See “Adding
Washer Fluid” under
Windshield Washer Fluid
on page 5-30
.
Engine Oil
Checking Engine Oil
It is a good idea to check the engine oil every time you
get fuel. In order to get an accurate reading, the oil
must be warm and the vehicle must be on level ground.
The engine oil dipstick handle is a yellow loop. See
Engine Compartment Overview on page 5-14
for
the location of the engine oil dipstick.
1. Turn off the engine and give the oil several minutes
to drain back into the oil pan. If you do not do this,
the oil dipstick might not show the actual level.
2. Pull the dipstick and clean it with a paper towel or
cloth, then push it back in all the way. Remove it
again, keeping the tip down and check the level.
5-15
Electrical System
Intermediate Voltage Devices and
Wiring
{
CAUTION:
Exposure to intermediate voltage can cause shock
and burns. The intermediate voltage systems in
the vehicle can only be serviced by technicians
with special training.
Intermediate voltage devices are identified by
labels. Do not remove, open, take apart, or modify
these devices. Intermediate voltage cable or wiring
has blue covering. Do not probe, tamper with, cut,
or modify intermediate voltage cable or wiring.
Add-On Electrical Equipment
Notice:
Do not add anything electrical to the
vehicle unless you check with your dealer/retailer
first. Some electrical equipment can damage
the vehicle and the damage would not be covered
by the vehicle’s warranty. Some add-on electrical
equipment can keep other components from
working as they should.
Add-on equipment can drain the vehicle battery, even if
the vehicle is not operating.
The vehicle has an airbag system. Before attempting to
add anything electrical to the vehicle, see
Servicing
Your Airbag-Equipped Vehicle on page 1-70
.
Windshield Wiper Fuses
The windshield wiper motor is protected by an internal
circuit breaker and a fuse. If the motor overheats due to
heavy snow, etc., the wiper will stop until the motor
cools. If the overload is caused by some electrical
problem, have it fixed.
5-82
Power Windows and Other Power
Options
Fuses in the fuse block protect the power windows.
When the current load is too heavy, the fuse opens
protecting the circuit until the problem is fixed.
Fuses
The wiring circuits in your vehicle are protected from
short circuits by a combination of fuses, circuit breakers
and fusible links. This greatly reduces the chance of
damage caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure to
replace a bad fuse with a new one of the identical
size and rating.
There are three fuse blocks in your vehicle: one in the
center of the instrument panel, one in the engine
compartment and one in the trunk.
There is a fuse puller located on the instrument panel
fuse block. It can be used to easily remove fuses
from the fuse block.
Instrument Panel Fuse Block
The instrument panel fuse block is located on the
passenger side of the vehicle, on the lower portion of
the instrument panel near the floor.
Remove the panel cover to access the fuse block, then
remove the fuse block cover to access the fuses.
5-83
Your vehicle might not have all the fuses and features listed.
5-84
Fuses
Usage
POWER
MIRRORS
Power Mirrors
EPS
Electronic Power Steering
RUN/CRANK
Cruise Control Switch, Passenger
Airbag Status Indicator
HVAC
BLOWER HIGH
Heating Ventilation Air Conditioning
Blower - High Speed Relay
CLUSTER/
THEFT
Instrument Panel Cluster, Theft
Deterrent System
ONSTAR
OnStar
®
NOT
INSTALLED
Not Used
AIRBAG (IGN)
Airbag (Ignition)
HVAC
CTRL (BATT)
Heating Ventilation Air Conditioning
Control Diagnostic Link Connector
(Battery)
PEDAL
Not Used
Fuses
Usage
WIPER SW
Windshield Wiper/Washer Switch
IGN SENSOR
Ignition Switch
STRG WHL
ILLUM
Steering Wheel Illumination
NOT
INSTALLED
Not Used
RADIO
Audio System
INTERIOR
LIGHTS
Interior Lamps
NOT
INSTALLED
Not Used
POWER
WINDOWS
Power Windows
HVAC
CTRL (IGN)
Heating Ventilation Air Conditioning
Control (Ignition)
HVAC
BLOWER
Heating Ventilation Air Conditioning
Blower Switch
DOOR LOCK
Door Locks
5-85
Fuses
Usage
ROOF/HEAT
SEAT
Sunroof, Heated Seat
NOT
INSTALLED
Not Used
NOT
INSTALLED
Not Used
AIRBAG
(BATT)
Airbag (Battery)
SPARE FUSE
HOLDER
Spare Fuse Holder
SPARE FUSE
HOLDER
Spare Fuse Holder
SPARE FUSE
HOLDER
Spare Fuse Holder
SPARE FUSE
HOLDER
Spare Fuse Holder
FUSE PULLER
Fuse Puller
Engine Compartment Fuse Block
The engine compartment fuse block is located on the
driver side of the engine compartment, near the battery.
The vehicle might not have all the fuses and features
listed.
Notice:
Spilling liquid on any electrical components
on the vehicle may damage it. Always keep the
covers on any electrical component.
5-86
Fuses
Usage
1
Air Conditioner Clutch
2
Electronic Throttle Control
3
Belt Alternator Starter (BAS) IGN
Fuses
Usage
4
Transmission, Transmission Control
Module Ignition 1
5
Belt Alternator Starter (BAS) Pumps
5-87
Fuses
Usage
6
Emission
7
Left Headlamp Low-Beam
8
Horn
9
Right Headlamp Low-Beam
11
Left Headlamp High-Beam
12
Right Headlamp High-Beam
13
Engine Control Module BATT
14
Windshield Wiper
15
Antilock Brake System (ABS)
(IGN 1)
16
Engine Control Module (IGN 1)
17
Cooling Fan 1
18
Cooling Fan 2
19
Run Relay, Heating, Ventilation, Air
Conditioning Blower
20
Body Control Module 1
21
Body Control Module Run/Crank
22
Rear Electrical Center 1
23
Rear Electrical Center 2
24
Antilock Brake System (ABS)
25
Body Control Module 2
Fuses
Usage
26
Starter
41
Electric Power Steering
42
Transmission Control Module
Battery
43
Ignition Module
44
Injectors
46
Daytime Running Lamps
47
Center High-Mounted Stoplamps
50
Driver Power Window
51
Belt Alternator Starter (BAS) BATT
52
Transmission Pump Motor
54
Battery Voltage Sense
55
Antilock Brake System (Battery)
Relays
Usage
28
Cooling Fan 1
29
Cooling Fan Series/Parallel
30
Cooling Fan 2
31
Starter
32
Run/Crank, Ignition
33
Powertrain
5-88
Relays
Usage
34
Air Conditioning Clutch
35
High-Beam Headlamp
37
Horn
38
Low-Beam Headlamp
39
Windshield Wiper 1
40
Windshield Wiper 2
48
Daytime Running Lamps (DRL)
49
Stoplamps
53
Transmission Pump Motor
Diodes
Usage
27
Wiper
Rear Compartment Fuse Block
The rear compartment fuse block is located in the trunk
of the vehicle. Access the fuse block through the
trunk panel on the driver side of the rear cargo area.
5-89
Fuses
Usage
1
Passenger Seat Controls
2
Driver Seat Controls
3
Not Used
4
Not Used
Fuses
Usage
5
Emission 2, Canister Vent Solenoid
6
Park Lamps, Instrument Panel
Dimming
7
Not Used
5-90
Fuses
Usage
8
Not Used
9
Not Used
10
Sunroof Controls
11
Not Used
12
Not Used
13
Audio Amplifier
14
Heated Seat Controls
15
Not Used
16
Remote Keyless Entry (RKE)
System, XM™ Satellite
Radio, UGDO
17
Back-up Lamps
18
Not Used
19
Not Used
20
Auxiliary Power Outlets
21
Not Used
22
Trunk Release
23
Rear Defog
Fuses
Usage
24
Heated Mirrors
25
Fuel Pump
Relays
Usage
26
Rear Window Defogger
27
Park Lamps
28
Not Used
29
Not Used
30
Not Used
31
Not Used
32
Not Used
33
Back-up Lamps
34
Not Used
35
Not Used
36
Trunk Release
37
Fuel Pump
38 (Diode)
Cargo Lamp
5-91