Saturn Ion - 2007 Fuse Box Diagram

Saturn Ion - 2007 Fuse Box Diagram

During normal
operation, the security
light will go off
approximately
three seconds after the
key is turned to the
RUN ignition position.
If the engine stalls and the security light flashes,
wait until the light stops flashing before trying
to restart the engine. Remember to release
the key from START as soon as the engine
starts.
If the engine is running and the security light
comes on, you will be able to restart the engine
if you turn the engine off. However, your Passlock
®
system is not working properly and must be
serviced by your retailer. Your vehicle is not
protected by Passlock
®
at this time. You may
also want to check the fuses, see
Fuses
and Circuit Breakers on page 375
. See your
retailer for service.
Starting and Operating
Your Vehicle
New Vehicle Break-In
Notice:
Your vehicle does not need an
elaborate break-in. But it will perform better in
the long run if you follow these guidelines:
Do not drive at any one constant speed,
fast or slow, for the first 500 miles
(805 km). Do not make full-throttle starts.
Do not exceed 5,000 engine rpm. Avoid
downshifting to brake, or slow, the vehicle.
Avoid making hard stops for the first
200 miles (322 km) or so. During this time
your new brake linings are not yet broken
in. Hard stops with new linings can mean
premature wear and earlier replacement.
Follow this breaking-in guideline every time
you get new brake linings.
Do not tow a trailer during the first
1,000 miles (1 600 km). See
Towing a Trailer
on page 259
for the trailer towing capabilities
of your vehicle and more information.
Following break-in, engine speed and load can
be gradually increased.
104
Turn and Lane-Change Signals
The turn signal has two upward (for right) and
two downward (for left) positions. These positions
allow you to signal a turn or a lane change.
To signal a turn, move the lever all the way up or
down. When the turn is finished, the lever will
return automatically.
An arrow on the
instrument panel cluster
will flash in the
direction of the turn or
lane change.
To signal a lane change, just raise or lower the
lever until the arrow starts to flash. Hold it
there until you complete your lane change. The
lever will return by itself when you release it.
As you signal a turn or a lane change, if the
arrows flash rapidly, a signal bulb may be burned
out and other drivers will not see your turn
signal.
If a bulb is burned out, replace it to help avoid an
accident. If the arrows do not go on at all when you
signal a turn, check the fuse, see
Fuses and Circuit
Breakers on page 375
and for burned-out bulbs.
Turn Signal On Chime
If the turn signal is left on for about 1 mile
(1.6 km), a chime will sound to let you know you
left the turn signal on.
144
To use the outlet, remove the cover. When not in
use, always cover the outlet with the protective cap.
Notice:
Leaving electrical equipment on for
extended periods will drain the battery.
Always turn off electrical equipment when not
in use and do not plug in equipment that
exceeds the maximum 15 ampere rating.
Certain electrical accessories may not be
compatible with the accessory power outlet and
could result in blown vehicle or adapter fuses.
If you experience a problem, see your retailer for
additional information on the accessory
power outlet.
Notice:
Adding any electrical equipment to
your vehicle may damage it or keep other
components from working as they should.
The repairs would not be covered by your
warranty. Check with your retailer before
adding electrical equipment.
Notice:
Improper use of the power outlet can
cause damage not covered by your warranty.
Do not hang any type of accessory or
accessory bracket from the plug because the
power outlets are designed for accessory
power plugs only.
Ashtray(s) and Cigarette Lighter
Your vehicle may have an ashtray and cigarette
lighter. To use the lighter, just push it in all the way
and let go. When it is ready for use, it will pop
back out by itself.
Notice:
Holding a cigarette lighter in while it
is heating will not allow the lighter to back
away from the heating element when it is hot.
Damage from overheating may occur to the
lighter or heating element, or a fuse could be
blown. Do not hold a cigarette lighter in
while it is heating. Do not use equipment
exceeding maximum amperage rating of
15 amperes.
To remove the ashtray, lift it straight up. To
reinstall it, press the ashtray down firmly until it is
fully seated.
Notice:
If you put papers, pins, or other
flammable items in the ashtray, hot cigarettes
or other smoking materials could ignite
them and possibly damage your vehicle.
Never put flammable items in the ashtray.
154
The oil light may also come on when the ignition
is on but the engine is not running, the light
will come on as a test to show you it is working,
but the light will go out when you turn the
ignition to START. If it does not come on with the
ignition on, you may have a problem with the
fuse or bulb. Have it fixed right away.
{
CAUTION:
Do not keep driving if the oil pressure is
low. If you do, your engine can become so
hot that it catches fire. You or others could
be burned. Check your oil as soon as
possible and have your vehicle serviced.
Notice:
Lack of proper engine oil maintenance
may damage the engine. The repairs would
not be covered by your warranty. Always follow
the maintenance schedule in this manual for
changing engine oil.
Passlock
®
Warning Light
Your vehicle has a
Passlock
®
theft-deterrent system.
With this system, the
security light will flash as
you open the door if your
ignition is off.
For more information, see
Passlock
®
on page 103
.
Reduced Engine Power Light
This light will come on
briefly when you start
the engine.
This light, along with the service engine soon light
will be displayed when a noticeable reduction in
the vehicle’s performance may occur. Stop the
vehicle and turn off the ignition. Wait for
10 seconds and restart your vehicle. This may
correct the condition.
178
Dinghy Towing (All Transaxles)
Notice:
Dolly towing or dinghy towing your
vehicle may cause damage because of reduced
ground clearance. Always tow your vehicle
using the dolly towing or dinghy towing
procedure listed in this section or put your
vehicle on a flatbed truck.
To tow your vehicle from the front with all four
wheels on the ground, do the following:
1. Set the parking brake.
2. Turn the ignition key to ACC (Accessory) to
unlock the steering wheel.
3. Shift your transaxle to NEUTRAL.
4. Release the parking brake.
To prevent battery rundown on long trips, remove
the IP BATT 2 fuse (#41) from the engine
compartment fuse block. See
Engine Compartment
Fuse Block on page 378
for more information.
Once you have reached your destination, be sure
to replace this fuse back into its original location.
Notice:
If you exceed 65 mph (105 km/h) while
towing your vehicle, it could be damaged.
Never exceed 65 mph (105 km/h) while towing
your vehicle.
Notice:
Towing your vehicle from the rear
could damage it. Also, repairs would not
be covered by the warranty. Never have your
vehicle towed from the rear.
Notice:
Don’t tow a vehicle with the front
drive wheels on the ground if one of the front
tires is a compact spare tire. Towing with
two different tire sizes on the front of the
vehicle can cause severe damage to the
transaxle.
257
A. Engine Air Cleaner/Filter. See
Engine Air
Cleaner/Filter on page 290
.
B. Engine Oil Dipstick (Out of View). See
“Checking Engine Oil” under
Engine Oil on
page 283
.
C. Engine Oil Fill Cap. See “When to Add Engine
Oil” under
Engine Oil on page 283
.
D. Electric Engine Cooling Fan (Out of View).
See
Cooling System on page 300
.
E. Brake Master Cylinder Reservoir. See “Brake
Fluid” under
Brakes on page 308
and
Hydraulic
Clutch on page 293
.
F. Engine Compartment Fuse Block. See
Engine
Compartment Fuse Block on page 378
.
G. Remote Positive (+) Terminal. See
Jump
Starting on page 312
.
H. Engine Coolant Surge Tank. See
Engine
Coolant on page 293
.
I. Windshield Washer Fluid Reservoir. See
“Adding Washer Fluid” under
Windshield
Washer Fluid on page 307
.
281
A. Engine Oil Dipstick. See “Checking Engine Oil”
under
Engine Oil on page 283
.
B. Electric Engine Cooling Fan. See
Cooling
System on page 300
.
C. Engine Oil Fill Cap. See “When to Add Engine
Oil” under
Engine Oil on page 283
.
D. Intercooler System Pressure Cap. See
Engine
Coolant on page 293
.
E. Brake Master Cylinder Reservoir. See “Brake
Fluid” under
Brakes on page 308
and
Hydraulic
Clutch on page 293
.
F. Engine Air Cleaner/Filter. See
Engine Air
Cleaner/Filter on page 290
.
G. Engine Compartment Fuse Block. See
Engine
Compartment Fuse Block on page 378
.
H. Remote Positive (+) Terminal. See
Jump
Starting on page 312
.
I. Engine Coolant Surge Tank. See
Coolant
Surge Tank Pressure Cap on page 297
.
J. Windshield Washer Fluid Reservoir. See
“Adding Washer Fluid” under
Windshield
Washer Fluid on page 307
.
Engine Oil
Checking Engine Oil
It is a good idea to check the engine oil every time
you get fuel. In order to get an accurate reading,
the oil must be warm and the vehicle must be
on level ground.
The engine oil dipstick handle is a yellow loop.
See
Engine Compartment Overview on page 280
for the location of the engine oil dipstick.
1. Turn off the engine and give the oil several
minutes to drain back into the oil pan. If you
do not do this, the oil dipstick might not
show the actual level.
2. Pull out the dipstick, clean it with a paper
towel or cloth and then push it back in all
the way.
3. Pull out the dipstick again, keeping the tip
down, and check the level.
283
4. Open the hoods and locate the positive (+)
and negative (
) terminal locations on each
vehicle.
You will not need to access your battery for
jump starting. Your vehicle has a remote
positive (+) and a remote negative (
) jump
starting terminal.
The remote positive (+) terminal is located on
the engine compartment fuse block, under a
red cap. See
Engine Compartment Overview
on page 280
for more information on location.
The remote negative (
) ground terminal is a
bolt located under the metal frame that
supports the radiator. It is at the front of the
engine compartment, on the driver’s side
of the vehicle, and is marked with a label that
says GND (
).
{
CAUTION:
An electric fan can start up even when the
engine is not running and can injure you.
Keep hands, clothing and tools away from
any underhood electric fan.
{
CAUTION:
Using a match near a battery can cause
battery gas to explode. People have been
hurt doing this, and some have been
blinded. Use a flashlight if you need
more light.
Be sure the battery has enough water.
You do not need to add water to the
battery installed in your new vehicle. But
if a battery has filler caps, be sure the
right amount of fluid is there. If it is low,
add water to take care of that first. If you
do not, explosive gas could be present.
Battery fluid contains acid that can burn
you. Do not get it on you. If you
accidentally get it in your eyes or on your
skin, flush the place with water and get
medical help immediately.
314
Electrical System
Add-On Electrical Equipment
Notice:
Do not add anything electrical to your
vehicle unless you check with your retailer
first. Some electrical equipment can damage
your vehicle and the damage would not
be covered by your warranty. Some add-on
electrical equipment can keep other
components from working as they should.
Your vehicle has an airbag system. Before
attempting to add anything electrical to your
vehicle, see
Servicing Your Airbag-Equipped
Vehicle on page 82
.
Windshield Wiper Fuses
The windshield wiper motor is protected by a
circuit breaker and a fuse. If the motor overheats
due to heavy snow or ice, the wiper will stop
until the motor cools. If the overload is caused by
some electrical problem, have it fixed.
Power Windows and Other
Power Options
Circuit breakers in the fuse panel protect the
power windows and other power accessories.
When the current load is too heavy, the circuit
breaker opens and closes, protecting the circuit
until the problem is fixed.
Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected
from short circuits by a combination of fuses.
This greatly reduces the chance of fires caused by
electrical problems.
Look at the silver-colored band inside the fuse.
If the band is broken or melted, replace the fuse.
Be sure you replace a bad fuse with a new
one of the identical size and rating.
375
Floor Console Fuse Block
Some fuses are in a fuse block on the driver’s
side of the floor console. To remove the floor
console cover, move the driver’s seat back as far
as it will go, and pull the floor console cover,
starting near the front of the vehicle, away from
the floor console.
Then remove the fuse block cover to access
the fuses.
Fuses
Usage
FUEL PUMP
Fuel Pump Relay
BCM ELECT
Ignition Switch, Body Control
Module (BCM)
BCM (PWR)
Entry Control, Trunk Release
DASH
Instrument Panel, Dimming Switch
LIGHTER
Cigar Lighter
PARK
Headlamp Switch
CLUSTER
Instrument Panel Cluster
PWR
WINDOWS
Power Window Switches
376
Fuses
Usage
STOP
Stoplamp (Brake) Switch
HVAC
Climate Control
CRUISE
Cruise Control Module, Clutch
Start Switch
AIR BAG
Airbags, Sensing and Diagnostic
Module (SDM)
WIPER SW
Windshield Wipers and Washers,
Transaxle Shift Lock Control Switch
RADIO
(BATT1)
Radio Receiver, Entertainment
Memory
ONSTAR
Entertainment, Mobile
Communications, OnStar
®
RADIO (ACC)
Radio Receiver, Entertainment
IGN SW
Ignition Switch
EPS
Cruise Control Switches, EPS Unit
PWR OUTLET
Auxiliary Power Outlet
SUN ROOF
Power Sunroof, OnStar Mirror
Relay
Usage
ALC/PARK
RELAY
OnStar
®
, Radio, Instrument Panel
Cluster, Body Control Module
(Entry Control), Cigar Lighter,
Headlamp Switch, License Lamp
FUEL PUMP
RELAY
Fuel Pump
ACC RELAY
Power Windows, Sunroof, Radio,
Wiper/Washer Switch, Accessory
Power Outlet
RUN RELAY
Climate Control (HVAC Blower,
Control Heads)
377
Engine Compartment Fuse Block
The engine compartment fuse block is located in
the engine compartment on the driver’s side
of the vehicle. See
Engine Compartment Overview
on page 280
for more information on location.
2.2L L4 Engine
Fuses
Usage
1
Engine Control Module, Transaxle
Control Module
2
Not Used
Fuses
Usage
3
Not Used
4
Passenger’s Side Headlamp
5
Air Conditioning
6
Not Used
7
Not Used
8
Anti-lock Brake System, Traction
Control Module
9
Engine Control Module, Electronic
Throttle Control
10
Canister Purge Solenoid, Mass
Airflow Sensor, Low Coolant
Switch, Oxygen Sensors, Air Pump
Relay Coil
11
Electric Ignition Control Module,
Charging System, Neutral Stop
Back-Up Switch
12
Not Used
13
Transaxle, Engine Control
Module (ECM)
14
Transaxle Control Module, Neutral
Stop Back-Up
15
PRNDL, Back-up Switch
16
Fuel Injectors (Cylinder 1, 2, 3, 4)
17
Fog Lamps
18
Driver’s Side Headlamp
19
Windshield Wiper
378
Fuses
Usage
20
Horn
21
Entertainment, Premium Radio
Amplifier
22
Anti-lock Brake System, Traction
Control Module
23
Rear Defogger
38
Starter/Ignition
39
Body Control Module 1
40
Anti-lock Brake System, Traction
Control Module
41
Body Control Module 2
42
Not Used
43
Electric Power Steering
44
Air Pump Relay Fuse
45
Cooling Fan
46
Crank
47
Body Control Module 1A
48
Body Control Module (IGN 3)
Relays
Usage
24
Air Conditioning Clutch
25
Horn
26
Fog Lamps
27
Air Solenoid
28
Run, Crank (IGN1)
29
Powertrain
30
Engine Cooling Fan
31
Engine Control Module
32
Wiper System 1
33
Wiper System 2
34
Rear Window Defogger
Diodes
Usage
35
§
Air Conditioning Diode
36
§
Not Used
37
§
Wiper Diode
Miscellaneous
Usage
49
Fuse Puller
379
2.0L L4 Supercharged Engine
Fuses
Usage
1
Engine Control Module
2
Not Used
3
Not Used
4
Passenger’s Side Headlamp
Fuses
Usage
5
Air Conditioning
6
Not Used
7
Not Used
8
Anti-lock Brake System
9
Engine Control Module, Electronic
Throttle Control
10
Canister Purge Solenoid, Mass
Airflow Sensor, Low Coolant Switch,
Oxygen Sensors
11
Electric Ignition Control Module,
Charging System, Neutral Safety
Stop Back-Up Switch
12
Not Used
13
Engine Control Module
14
Boost
15
Back-up Switch
16
Fuel Injectors
17
Fog Lamps
18
Driver’s Side Headlamp
380
Fuses
Usage
19
Windshield Wiper
20
Horn
21
Entertainment, Premium Radio
Amplifier
22
Anti-lock Brake System
23
Rear Defogger
38
Starter/Ignition
39
Body Control Module 1
40
Anti-lock Brake System
41
Body Control Module 2
42
Not Used
43
Electric Power Steering
44
Cooling Fan 2
45
Cooling Fan 1
46
Crank
47
Body Control Module 1A
48
Body Control Module (IGN 3)
Relays
Usage
24
Air Conditioning Clutch
25
Horn
26
Fog Lamps
27
Intercooler Pump
28
Run, Crank (IGN1)
29
Powertrain
30
Engine Cooling Fan 1
31
Engine Control Module
32
Wiper System 1
33
Wiper System 2
34
Rear Window Defogger
Diodes
Usage
35
§
Air Conditioning Diode
36
§
Not Used
37
§
Wiper Diode
Miscellaneous
Usage
49
Fuse Puller
381
2.4L LE5 Engine
Fuses
Usage
1
Engine Control Module, Transaxle
Control Module
2
Not Used
3
Not Used
4
Passenger’s Side Headlamp
5
Air Conditioning
Fuses
Usage
6
Not Used
7
Not Used
8
Anti-lock Brake System, Traction
Control Module
9
Engine Control Module, Electronic
Throttle Control
10
Canister Purge Solenoid, Mass
Airflow Sensor, Low Coolant Switch,
Oxygen Sensors
11
Electric Ignition Control Module,
Charging System, Neutral Stop
Back-Up Switch
12
Not Used
13
Transaxle 2, Engine Control
Module (ECM)
14
Transaxle Control Module, Neutral
Stop Back-Up
15
PRNDL, Back-up Switch
16
Fuel Injectors (Cylinder 1, 2, 3, 4)
17
Fog Lamps
18
Driver’s Side Headlamp
19
Windshield Wiper
382
Fuses
Usage
20
Horn
21
Entertainment, Premium
Radio Amplifier
22
Anti-lock Brake System, Traction
Control Module
23
Rear Defogger
38
Starter/Ignition
39
Body Control Module 1
40
Anti-lock Brake System, Traction
Control Module
41
Body Control Module 2
42
Not Used
43
Electric Power Steering
44
Cooling Fan 2
45
Cooling Fan
46
Crank
47
Body Control Module 1A
48
Body Control Module (IGN 3)
Relays
Usage
24
Air Conditioning Clutch
25
Horn
26
Fog Lamps
27
Not Used
28
Run, Crank (IGN 1)
29
Powertrain
30
Engine Cooling Fan
31
Engine Control Module
32
Wiper System 1
33
Wiper System 2
34
Rear Window Defogger
Diodes
Usage
35
§
Air Conditioning Diode
36
§
Not Used
37
§
Wiper Diode
Miscellaneous
Usage
49
Fuse Puller
383