Pontiac Aztek - 2005 Fuse Box Diagram

Pontiac Aztek - 2005 Fuse Box Diagram

These are some examples of symbols that may be found on the vehicle:
v
PASS-Key
®
III Operation
Your vehicle is equipped
with the PASS-Key
®
III
(Personalized Automotive
Security System)
theft-deterrent system.
PASS-Key
®
III is a passive
theft deterrent system. This
means you don’t have to do
anything different to arm or
disarm the system. It works
when you insert or remove
the key from the ignition.
When the PASS-Key
®
III system senses that someone
is using the wrong key, it shuts down the vehicle’s
starter and fuel systems. The starter will not work and
fuel will stop being delivered to the engine. Anyone
using a trial-and-error method to start the vehicle will be
discouraged because of the high number of electrical
key codes.
If the engine does not start and the SECURITY message
comes on, when trying to start the vehicle, the key
may have a damaged transponder. Turn the ignition off
and try again. See
PASS-Key
®
III Security Message
on page 3-43
.
If the engine still does not start, and the key appears to
be undamaged, try another ignition key. At this time,
you may also want to check the fuse. See
Fuses
and Circuit Breakers on page 5-101
. If the engine still
does not start with the other key, your vehicle needs
service. If your vehicle does start, the first key may be
faulty. See your dealer who can service the
PASS-Key
®
III to have a new key made.
It is possible for the PASS-Key
®
III decoder to learn the
transponder value of a new or replacement key. Up
to 10 total keys may be programmed for the vehicle.
This procedure is for learning additional keys only.
If all the currently programmed keys are lost or do not
operate, you must see your dealer or a locksmith
who can service PASS-Key
®
III to have keys made
and programmed to the system.
See your dealer who can service PASS-Key
®
III to get a
new key blank that is a cut exactly as the ignition key
that operates the system.
2-17
Accessory Power Outlets
With accessory power outlets you can plug in electrical
equipment such as a cellular telephone or CB radio.
There is a single front power outlet located on the floor
console above the climate control system outlets.
There is one rear power outlet located in the rear of the
vehicle on the driver’s side.
To use the outlet, pull the cover down. When not using
it, cover the outlet with the protective cap.
Notice:
Leaving electrical equipment on for
extended periods will drain the battery. Always turn
off electrical equipment when not in use and do
not plug in equipment that exceeds the maximum
amperage rating.
Certain electrical accessories may not be compatible to
the accessory power outlet and could result in blown
vehicle or adapter fuses.
If you experience a problem, see your dealer for
additional information on accessory power outlets.
Notice:
Adding any electrical equipment to your
vehicle may damage it or keep other components
from working as they should. The repairs would not
be covered by your warranty. Check with your
dealer before adding electrical equipment.
When adding electrical equipment, be sure to follow the
proper installation instructions included with the
equipment.
Notice:
Improper use of the power outlet can cause
damage not covered by your warranty. Do not
hang any type of accessory or accessory bracket
from the plug because the power outlets are
designed for accessory power plugs only.
3-20
Ashtrays and Cigarette Lighter
If your vehicle has an ashtray and cigarette lighter,
they are located in the glove box.
The ashtray fits into the cupholders. The cigarette
lighter installs into the accessory power outlet in the
instrument panel switchbank.
To use the lighter, push it in all the way and let go.
When it’s ready, it will pop back out by itself.
Notice:
Holding a cigarette lighter in while it is
heating will not allow the lighter to back away from
the heating element when it is hot. Damage from
overheating may occur to the lighter or heating
element, or a fuse could be blown. Do not hold a
cigarette lighter in while it is heating. Do not
use anything other than the cigarette lighter in the
heating element.
Notice:
If you put papers or other flammable items
in the ashtray, hot cigarettes or other smoking
materials could ignite them and possibly damage
your vehicle. Never put flammable items in the
ashtray.
Climate Controls
Climate Control System
With this system you can control the heating, cooling,
and ventilation for everyone in the vehicle.
Operation
Turn the right knob clockwise or counterclockwise to
direct the airflow inside your vehicle.
To change the current mode, select one of the following:
H
(Vent):
This mode directs air to the instrument
panel outlets.
3-21
A. Underhood Fuse Block. See
Underhood Fuse Block
on page 5-104
.
B. Remote Positive (+) Terminal. See
Jump Starting
on page 5-39
.
C. Power Steering Fluid Reservoir. See
Power Steering
Fluid on page 5-34
.
D. Automatic Transaxle Fluid Dipstick. See “Checking
the Fluid Level” under
Automatic Transaxle Fluid
on page 5-20
.
E. Brake Master Cylinder. See “Brake Fluid” under
Brakes on page 5-36
.
F. Windshield Washer Fluid Reservoir. See “Adding
Washer Fluid” under
Windshield Washer Fluid
on page 5-35
.
G. Battery. See
Battery on page 5-38
.
H. Radiator Pressure Cap. See
Radiator Pressure Cap
on page 5-26
.
I. Engine Oil Fill Cap. See “When to Add Engine Oil”
under
Engine Oil on page 5-14
.
J. Engine Oil Dipstick. See “Checking Engine Oil”
under
Engine Oil on page 5-14
.
K. Engine Air Cleaner/Filter. See
Engine Air
Cleaner/Filter on page 5-19
.
L. Engine Coolant Recovery Tank. See
Cooling System
on page 5-28
.
5-13
2. Get the vehicles close enough so the jumper cables
can reach, but be sure the vehicles are not touching
each other. If they are, it could cause a ground
connection you do not want. You would not be able
to start your vehicle, and the bad grounding
could damage the electrical systems.
To avoid the possibility of the vehicles rolling, set
the parking brake firmly on both vehicles involved in
the jump starting procedure. Put an automatic
transaxle in PARK (P) or a manual transaxle
in NEUTRAL before setting the parking brake.
Notice:
If you leave your radio or other accessories
on during the jump starting procedure, they could
be damaged. The repairs would not be covered
by your warranty. Always turn off your radio and
other accessories when jump starting your vehicle.
3. Turn off the ignition on both vehicles. Unplug
unnecessary accessories plugged into the cigarette
lighter or the accessory power outlet(s). Turn off
the radios and all lamps that are not needed. This
will avoid sparks and help save both batteries.
And it could save the radio!
4. Open the hood on the other vehicle and locate the
positive (+) and negative (
) terminal locations on
that vehicle.
You will not need to access your battery for jump
starting. Your vehicle has a remote positive (+) jump
starting terminal for that purpose. The terminal is
located under a tethered cap at the front of the
underhood fuse and relay center. See
Engine
Compartment Overview on page 5-12
for more
information on location.
5-40
{
CAUTION:
Inflating something too much can make it
explode, and you or others could be injured.
Be sure to read the inflator instructions, and
inflate any object only to its recommended
pressure.
To use your accessory inflator system, do the following:
1. Turn the ignition to ACCESSORY or ON.
2. Attach the appropriate nozzle adapter, if required,
to the end of the hose that has the pressure gage.
3. Attach that end of the hose to the object you wish
to inflate.
4. Remove the protective cap covering the outlet.
5. Attach the other end of the hose to the outlet.
6. Press the accessory inflator switch. The light in the
switch will come on to show the system is working.
If the accessory inflator system does not turn on or the
light does not come on, the fuse may be blown or
installed incorrectly. See
Fuses and Circuit Breakers on
page 5-101
or see your dealer for service.
Your accessory inflator will automatically shut off after
about 10 minutes. The light in the switch will blink. After
about one minute you can use the system again. Press
the inflator switch and the indicator light will come on.
Notice:
If you run the accessory inflator longer than
30 minutes at a time, you could damage the
inflator. The repairs would not be covered by your
warranty. Run the inflator for short periods of
time only.
After running the accessory inflator for 30 minutes, wait at
least 10 minutes before restarting the accessory inflator.
To turn off the inflator, do the following:
1. Press the switch and detach the hose, first from the
inflated object, then from the outlet.
2. Put the protective cap back on.
3. Place the inflator kit tools in the pouch, and store in
the glove box.
To put the cover back on, line up the tabs at the back of
the cover and put it in place. Push down the tab to
secure the cover.
5-69
Electrical System
Add-On Electrical Equipment
Notice:
Don’t add anything electrical to your
vehicle unless you check with your dealer first.
Some electrical equipment can damage your vehicle
and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment can
keep other components from working as they
should.
Your vehicle has an airbag system. Before attempting to
add anything electrical to your vehicle, see
Servicing
Your Airbag-Equipped Vehicle on page 1-66
.
Headlamp Wiring
The headlamp wiring is protected by different fuses
located in the underhood fuse block. An electrical
overload may cause the lamps to go off and remain that
way. If this happens, replace the right fuse with one
of the same kind and amperage.
Windshield Wiper Fuses
The windshield wiper motor is protected by an internal
circuit breaker and a fuse. If the motor overheats due to
heavy snow, etc., the wiper will stop until the motor
cools. If the overload is caused by some electrical
problem, be sure to get it fixed.
Power Windows and Other Power
Options
Circuit breakers in the floor console fuse block protect
the power windows and other power accessories.
When the current load is too heavy, the circuit breaker
opens and closes, protecting the circuit until the
problem is fixed.
Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination of fuses, circuit breakers,
and fusible thermal links.
Look at the silver-colored L-Band inside the fuse.
If the L-Band is broken or melted, replace the fuse.
Be sure you replace a bad fuse with a new one of the
identical size and rating.
5-101
If you ever have a problem on the road and do not have
a spare fuse, you can borrow one that has the same
amperage. Just pick a feature of your vehicle that
you can get along without — like the radio or cigarette
lighter — and use its fuse, if it is the right amperage.
Replace it as soon as you can.
There are two fuse blocks in your vehicle: the floor
console fuse block and the underhood fuse block.
Floor Console Fuse Block
The floor console fuse
block is located to the
right of the shift lever.
Pull the door open to access the fuse block.
Fuse
Usage
1
Empty
2
Steering Wheel Radio Controls
3
Power Door Locks
4
Empty
5
Empty
6
Empty
7
Empty
8
Empty
9
Empty
10
Turn Signal and Hazard Lamp
Flashers
5-102
Fuse
Usage
11
Power Seats
12
Electronic Level Control (ELC)
Compressor
13
Liftgate and Endgate
14
Rear Auxiliary Power Outlet
15
Electronic Level Control (ELC)
Compressor Relay and Height
Sensor
16
Heated Mirrors
17
Power Mirrors
18
Ignition 1 Module
19
Turn Signal Switch
21
Rear Defogger
22
Air Bag Module
24
TCC Switch
25
Climate Control Blower Motor
26
Climate Control Mode and
Temperature Motors and
Head-Up Display
28
Empty
29
Windshield Wipers and Washer
30
Instrument Panel Cluster,
Body Control Module (BCM),
PASS-Key
®
III
31
Park Lock Ignition Key Solenoid
Fuse
Usage
32
Empty
34
Power Sunroof
35
Power Windows
36
Map Lamps, Courtesy Lamps and
Instrument Panel Lights
37
Radio
38
UQ3 Radio Amplifier
39
Head-Up Display
40
Hazard Flashers
41
Instrument Panel Cluster,
Climate Control, Security LED and
Remote Keyless Entry Module
42
PASS-Key
®
III
43
Accessory Diode
44
Body Control Module (BCM)
46
Advanced Occupant System Module
Relay
Usage
20
Rear Defogger Relay
23
Ignition Relay
27
Accessory Relay
33
Retained Accessory Power Relay
45
Back-Up Lamp
5-103
Underhood Fuse Block
This fuse block is located in the engine compartment on
the passenger’s side of the vehicle. See
Engine
Compartment Overview on page 5-12
for more
information on location.
The back-up lamp relay (A) is located behind and to the
left of the underhood fuse block.
To remove the cover, press the two tabs in and lift up
the cover.
Fuse
Usage
1
Fuel Pump
2
Air Conditioning Compressor Clutch
3
Horn
4
Engine Controls-Emissions and
Sensors
5
Power Control Module (PCM)-Battery
Power
5-104
Fuse
Usage
6
Anti-Lock Brakes (ABS) Control
Module
7
Transaxle Solenoids
9
Anti-lock Brake System (ABS)
Solenoid Valves
10
Oxygen Sensors-Emissions Control
11
Fuel Injectors
13
Engine Controls
14
Daytime Running Lamps (DRL)
15
Passenger’s Low-Beam Headlamp
17
Driver’s Low-Beam Headlamp
18
Driver’s High-Beam Headlamp
19
Ignition Switch Battery Power
20
Parking Lamps
23
Passenger’s High-Beam Headlamp
24
Vent Solenoids
25
DVD
Fuse
Usage
26
Front Fog Lamps
27
Ignition Relay, Neutral Start Switch,
Powertrain Control Module (PCM)
28
Body Control Module-Battery Power
29
S Band, Remote Digital Radio
Receiver
30
All-Wheel Drive (AWD) Module
31
Cruise Control
32
Front Power Outlets/Lights, OnStar
®
33
Automatic Transaxle Shift Lock
Control System
34
Starter Solenoid Battery Fuse
35
Anti-lock Brake System (ABS) Motor
38
Engine Cooling Fan 2
39
Engine Cooling Fan 1
40
Main Battery Fuse for Retained
Accessory Power Relay and
Accessory Relay
5-105
Fuse
Usage
41
Main Battery Fuse for Heated
Seats, Air
44
Main Battery Fuse for Power
Outlets, Level Control, Power Seats
and Mirrors and Body Computer
46
Main Battery Fuse for Climate
Control Blower and Ignition 3 Relay
47
Main Battery Fuse for Ignition
Switch, Radio, Heads-Up Display,
Remote Keyless Entry (RKE),
Instrument Cluster, Air Conditioning
and Body Computer
70
§
Diode for Air Conditioning
Compressor Clutch
Relay
Usage
49
Horn
50
Fuel Pump
51
Air Conditioning Clutch
52
Daytime Running Lamps (DRL)
53
Low-Beam Headlamps
54
Parking Lamps
55
High-Beam Headlamps
56
Fog Lamps
57
Starter Relay
58
Cooling Fan
59
Ignition 1 Relay
60
Cooling Fan 2
61
Cooling Fan 1
5-106