Pontiac Sunfire - 2004 Fuse Box Diagram

Pontiac Sunfire - 2004 Fuse Box Diagram

The main components of your instrument panel are the following:
A. Fog Lamp Button. See “Fog Lamps” under
Exterior
Lamps on page 3-12
.
B. Instrument Panel Brightness Control. See
“Instrument Panel Brightness” under
Interior Lamps
on page 3-14
.
C. Enhanced Traction System Switch. See
Enhanced
Traction System (ETS) on page 4-10
.
D. Turn Signal/Multifunction Lever. See
Turn
Signal/Multifunction Lever on page 3-6
.
E. Instrument Panel Cluster. See
Instrument Panel
Cluster on page 3-22
.
F. Hazard Warning Flashers Switch. See
Hazard
Warning Flashers on page 3-4
.
G. Ignition Switch. See
Ignition Positions on page 2-18
.
H. Windshield Wiper/Washer Controls. See “Windshield
Wipers” and “Windshield Washers” under
Turn
Signal/Multifunction Lever on page 3-6
.
I. Audio System. See
Audio System(s) on page 3-37
.
J. Climate Controls and Rear Window Defogger.
See
Climate Control System on page 3-17
.
K. Fuse Panel. See “Instrument Panel Fuse Block”
under
Fuses and Circuit Breakers on page 5-85
.
L. Remote Trunk Release Button. See “Remote Trunk
Release” under
Trunk on page 2-11
.
M. Hood Release Lever. See
Hood Release on
page 5-10
.
N. Cupholder. See
Cupholder(s) on page 2-38
.
O. Parking Brake Lever. See
Parking Brake on
page 2-28
.
P. Shift Lever. See
Automatic Transaxle Operation on
page 2-23
and
Manual Transaxle Operation on
page 2-26
.
Q. Accessory Power Outlet. See
Accessory Power
Outlets on page 3-16
.
3-3
Turn Signal/Multifunction Lever
The lever on the left side of the steering column
includes the following:
Turn and Lane-Change Signals
Headlamp High/Low-Beam Changer
Flash-to-Pass
Cruise Control
For information on the exterior lamps, see
Exterior
Lamps on page 3-12
.
Turn and Lane-Change Signals
The turn signal has two upward (for right) and two
downward (for left) positions. These positions allow you
to signal a turn or a lane change.
To signal a turn, move the lever all the way up or down.
When the turn is finished, the lever will return
automatically.
An arrow on the instrument
panel cluster will flash in
the direction of the
turn or lane change.
To signal a lane change, just raise or lower the lever
until the arrow starts to flash. Hold it there until you
complete your lane change. The lever will return by itself
when you release it.
As you signal a turn or a lane change, if the arrows
flash rapidly, a signal bulb may be burned out and other
drivers will not see your turn signal. If a bulb is burned
out, replace it to help avoid an accident.
If the arrows do not go on at all when you signal a turn,
check the fuse. See
Fuses and Circuit Breakers on
page 5-85
.
3-6
Accessory Power Outlets
The accessory power outlet can be used to connect
electrical equipment such as a cellular phone or
CB radio.
The accessory power outlet is located on the lower
console on the passenger’s side.
To use the outlet, remove the cover. When not in use,
always cover the outlet with the protective cap.
Notice:
Leaving electrical equipment on for
extended periods will drain the battery. Always turn
off electrical equipment when not in use and do
not plug in equipment that exceeds the maximum
amperage rating.
Certain electrical accessories may not be compatible
with the accessory power outlet and could result
in blown vehicle or adapter fuses. If you experience a
problem, see your dealer for additional information
on the accessory power outlet.
Notice:
Adding any electrical equipment to your
vehicle may damage it or keep other components
from working as they should. The repairs would not
be covered by your warranty. Check with your
dealer before adding electrical equipment.
When adding electrical equipment, be sure to follow the
installation instructions included with the equipment.
Notice:
Improper use of the power outlet can cause
damage not covered by your warranty. Do not
hang any type of accessory or accessory bracket
from the plug because the power outlets are
designed for accessory power plugs only.
Ashtrays and Cigarette Lighter
Your vehicle may have an ashtray and cigarette lighter.
To use the lighter, just push it in all the way and let
go. When it’s ready, it will pop back out by itself.
Notice:
Holding a cigarette lighter in while it is
heating will not allow the lighter to back away from
the heating element when it is hot. Damage from
overheating may occur to the lighter or heating
element, or a fuse could be blown. Do not hold a
cigarette lighter in while it is heating.
To clean the center console ashtray, remove the entire
ashtray and empty it. The ashtray can be placed in
the rear cupholder for the rear seat passengers to use.
Notice:
If you put papers or other flammable
items in the ashtray, hot cigarettes or other smoking
materials could ignite them and possibly damage
your vehicle. Never put flammable items in the
ashtray.
3-16
The oil light could also come on in three other situations:
When the ignition is on but the engine is not running,
the light will come on as a test to show you it is
working, but the light will go out when you turn the
ignition to START. If it doesn’t come on with the
ignition on, you may have a problem with the fuse or
bulb. Have it fixed right away.
If you’re idling at a stop sign, the light may blink on
and then off.
If you make a hard stop, the light may come on for a
moment. This is normal.
{
CAUTION:
Do not keep driving if the oil pressure is low. If
you do, your engine can become so hot that it
catches fire. You or others could be burned.
Check your oil as soon as possible and have
your vehicle serviced.
Notice:
Lack of proper engine oil maintenance may
damage the engine. The repairs would not be covered
by your warranty. Always follow the maintenance
schedule in this manual for changing engine oil.
Passlock
®
Warning Light
This light will come on briefly when you turn the key
to START.
If the light flashes, the Passlock
®
system has entered a
tamper mode. If the vehicle fails to start, see
Passlock
®
on page 2-17
.
On vehicles equipped with the remote keyless entry
system, when the ignition is off and the security system
is armed, the light will flash to indicate that the
security system is active.
If the light comes on continuously while driving and
stays on, there may be a problem with the
Passlock
®
system. Your vehicle will not be protected by
Passlock
®
, and you should see your dealer.
United States
Canada
3-34
A. Coolant Surge Tank.
See
Cooling System on page 5-26
.
B. Engine Oil Dipstick.
See “Checking Engine Oil” under
Engine Oil on page 5-13
.
C. Engine Oil Fill Cap.
See “When to Add Engine Oil” under
Engine Oil on page 5-13
.
D. Brake Fluid Reservoir.
See “Brake Fluid” under
Brakes on page 5-34
.
E. Power Steering Fluid Reservoir.
See
Power Steering Fluid on page 5-32
.
F. Clutch Master Cylinder Reservoir
(If Equipped) (Not Shown).
See
Hydraulic Clutch on page 5-19
.
G. Battery. See
Battery on page 5-38
.
H. Engine Air Cleaner/Filter.
See
Engine Air Cleaner/Filter on page 5-17
.
I. Windshield Washer Fluid Reservoir.
See
Windshield Washer Fluid on page 5-33
.
J. Engine Compartment Fuse Block.
See “Engine Compartment Fuse Block” under
Fuses and Circuit Breakers on page 5-85
.
Engine Oil
If the oil pressure light
appears on the instrument
cluster, it means you
need to check your engine
oil level right away.
For more information, see
Oil Pressure Light on
page 3-33
.
You should check your engine oil level regularly; this is
an added reminder.
Checking Engine Oil
It is a good idea to check your engine oil every time you
get fuel. In order to get an accurate reading, the oil
must be warm and the vehicle must be on level ground.
The engine oil dipstick handle is a yellow loop. See
Engine Compartment Overview on page 5-12
for
the location of the engine oil dipstick.
Turn off the engine and give the oil several minutes
to drain back into the oil pan. If you don’t, the oil dipstick
might not show the actual level.
5-13
Instrument Panel Fuse Block
The instrument panel fuse
block is located on the
driver’s side end of
the instrument panel.
To open, push the tab on the access door to the left
and pull the door forward. There is a white fuse removal
tool located in the fuse block area. Make sure to
insert the tabs first when reinstalling the cover.
Fuses
Usage
TURN-B/U
Turn Signals, Back-Up Lamps
ERLS
Cruise Control, Engine Controls
BCM/CLU
Body Control Module,
Instrument Panel Cluster
PCM
Powertrain Control Module
IGN MDL
Ignition Module
F/P-INJ
Fuel Pump, Fuel Injectors
5-86
Fuses
Usage
AIR BG
Air Bag
CRUISE
Cruise Control Module/Switch
ABS
Anti-Lock Brake (Ignition)
APO
Accessory Power Outlet
RFA BATT
Remote Keyless Entry System
MIR/DLC
Power Mirror/Diagnostic
Link Connector
LT HDLP
Left Headlamp
RDO/INTLP
Radio, Interior Lamps, OnStar
®
RT HDLP
Right Headlamp
CLSTR
Instrument Panel Cluster
EXT LP
Exterior Lamps
CIG
Cigarette Lighter
FOG
Fog Lamps
HORN
Horn
Blank
Not Used
Blank
Not Used
Fuses
Usage
STOP/HZD
Stop Lamps, Hazard Lamps
Blank
Not Used
Blank
Not Used
RR DEFOG
Rear Window Defogger
PWR ACC
Power Door Locks
Blank
Not Used
Blank
Not Used
Blank
Not Used
O2HTR
O2 Sensor Heater
HVAC
Climate Control System
WIPER
Windshield Wiper
BCM
Body Control Module
AMPL
Audio Amplifier
PWR WDO
Power Windows, Sunroof
(Circuit Breaker)
RELAY DRL
Daytime Running Lamps (Relay)
Blank
Not Used
5-87
Engine Compartment Fuse Block
The engine compartment fuse block is located on the
driver’s side of the vehicle. Lift the cover to check
the fuses. See
Engine Compartment Overview on
page 5-12
for more information on location.
Fuses
Usage
IGN
Ignition Switch Circuits
BATT 1
Exterior lamps, Power Outlet,
Horn, Audio Amplifier
Fuses
Usage
BATT 2
Rear Defogger, Starter,
Power Locks, Stoplamps
ABS
Anti-Lock Brake System
COOLING FAN
Engine Cooling Fan
PCM/HVAC
Powertrain Control Module,
Heater and A/C Blower
CRNK
Starter
BLO
Heater and A/C Blower
PCM
Powertrain Control Module
A/C
A/C Compressor
A/C
A/C Compressor
FUEL PUMP
Fuel Pump
CRANK
Starter
COOLING FAN
Engine Cooling Fan
HEATER
BLOWER
Heater and A/C Blower
5-88