Toyota Urban Cruiser - 2012 Fuse Box Diagram

Toyota Urban Cruiser - 2012 Fuse Box Diagram

362
URBAN CRUISER_OM_OM52C63E_(EE)
4-3. Do-it-yourself maintenance
Do-it-yourself service precautions
If you perform maintenance yourself, be sure to follow the correct
procedures as given in these sections.
Items
Parts and tools
Battery condition
(
P. 380)
• Warm water
• Baking soda
• Grease
• Conventional wrench
(for terminal clamp bolts)
Engine coolant level
(
P. 377)
• Toyota Super Long Life Coolant
or similar high quality ethylene
glycol based non-silicate, non-
amine, non-nitrite and non-borate
coolant with long-life hybrid
organic acid technology. Toyota
Super Long Life Coolant is pre-
mixed with 50% coolant and 50%
deionized water.
• Funnel (used only for adding cool-
ant)
Engine oil level

P. 372)
• Toyota Genuine Motor Oil or
equivalent
• Rag or paper towel, funnel
(used only for adding oil)
Fuses
(
P. 402)
Fuse with same amperage rating
as original
370
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Engine compartment
Gasoline engine
Washer fluid tank (
P. 386)
Engine oil filler cap
(
P. 373)
Battery
(
P. 380)
Fuse box
(
P. 402)
Engine coolant reservoir
(
P. 377)
Radiator
(
P. 379)
Condenser
(
P. 379)
Electric cooling fan
Engine oil level dipstick
(
P. 372)
371
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
Diesel engine
Engine oil filler cap
(
P. 373)
Fuel filter
(
P. 497)
Battery
(
P. 380)
Fuse box
(
P. 402)
Intercooler
(
P. 379)
Electric cooling fan
Condenser
(
P. 379)
Radiator
(
P. 379)
Engine oil level dipstick
(
P. 372)
Engine coolant reservoir
(
P. 377)
Washer fluid tank (
P. 386)
Fuse box (if equipped)
(
P. 402)
402
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Checking and replacing fuses
If any of the electrical components do not operate, a fuse may have
blown. If this happens, check and replace the fuses as necessary.
Vehicles without smart entry & start system
Turn the engine switch to the “LOCK” position.
Vehicles with smart entry & start system
Turn the “ENGINE START STOP” switch OFF.
The fuses are located in the following places. To check the
fuses, follow the instructions below.
Engine compartment
Type A
Push the tab in and lift the lid
off.
Type B (if equipped)
Push the tab in and lift the lid
off.
STEP
1
STEP
2
405
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
Passenger’s side instrument panel (type B)
Open the glove box. Slide off
the damper.
Push in each side of the glove
box to disconnect the claws.
After a system failure, see “Fuse layout and amperage rat-
ings” (
P. 408) for details about which fuse to check.
STEP
3
406
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Remove the fuse with the pull-
out tool.
Check if the fuse has blown.
Type A
Normal fuse
Blown fuse
Replace it with one of an
appropriate amperage rating.
The amperage rating can be
found on the fuse box lid.
Type B
Normal fuse
Blown fuse
Replace it with one of an
appropriate amperage rating.
The amperage rating can be
found on the fuse box lid.
STEP
4
STEP
5
1
2
ITY42C012
1
2
ITY42C013
407
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
Type C
Normal fuse
Blown fuse
Contact any authorized Toyota
dealer or repairer, or another
duly qualified and equipped
professional.
Type D
Normal fuse
Blown fuse
Contact any authorized Toyota
dealer or repairer, or another
duly qualified and equipped
professional.
1
2
ITY42C014
1
2
ITY42C015
408
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Fuse layout and amperage ratings
Engine compartment (type A)
Fuse
Ampere
Circuit
1
AM2
15 A
Starting system, multi-port fuel
injection system/sequential multi-
port fuel injection system, Stop &
Start system, smart entry & start
system
2
HORN
10 A
Horn
3
EFI
*
1, 2, 3, 4
20 A
Multi-port fuel injection system/
sequential multi-port fuel injection
system
ECD
*
5, 6, 7, 8
30 A
4
SPARE
30 A
Spare fuse
5
SPARE
15 A
Spare fuse
6
SPARE
10 A
Spare fuse
7
HTR SUB2
*
3
40 A
Air conditioning system
HTR SUB1
*
7
50 A
8
EPS
50 A
Electric power steering
409
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
Fuse
Ampere
Circuit
9
ABS1/VSC1
50 A
ABS, VSC
10
HTR
40 A
Air conditioning system
11
RDI
30 A
Electric cooling fan
12
HTR SUB1
*
3
30 A
Air conditioning system
HTR SUB2
*
7
13
H-LP CLN/PWR
HTR
*
5
30 A
Air conditioning system
HTR SUB3
*
7
14
FR DEF
20 A
No circuit
15
ABS2/VSC2
30 A
ABS, VSC
16
H-LP MAIN
30 A
“H-LP HI LH”, “H-LP HI RH”, “H-LP
RH/H-LP LO RH”, “H-LP LH/H-LP
LO LH” fuses
17
ST
30 A
Starting system
18
S-LOCK
20 A
Smart entry & start system
19
DOME
15 A
Interior light, personal lights, lug-
gage compartment light, smart
entry & start system, wireless
remote control, audio system
20
ECU-B
7.5 A
Daytime running light system,
power windows, power door lock
system, smart entry & start system,
gauges and meters, air condition-
ing system, VSC, Active Torque
Control 4WD system, Stop & Start
system
410
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
*
1
: Gasoline engine (vehicles with a Stop & Start system)
*
2
: Gasoline engine (vehicles without a Stop & Start system)
*
3
: Gasoline engine (vehicles with PTC heater)
*
4
:
Gasoline engine (vehicles without PTC heater)
*
5
: Diesel engine (vehicles with power heater)
*
6
: Diesel engine (vehicles without power heater)
*
7
: Diesel engine (vehicles with PTC heater)
*
8
: Diesel engine (vehicles without PTC heater)
Fuse
Ampere
Circuit
21
ALT-S
*
1, 2, 3, 4
7.5 A
Charging system, fuel system
F/PMP
*
5, 6, 7, 8
30 A
22
ETCS
10 A
Electronic throttle control system
23
HAZ
10 A
Turn signal lights, emergency
flashers
24
BBC
*
1
40 A
Stop & Start system
AMT
*
5, 6, 7, 8
50 A
No circuit
25
H-LP RH/H-LP
LO RH
10 A
Right-hand headlight
26
H-LP LH/H-LP
LO LH
10 A
Left-hand headlight
27
EFI2
*
1, 2, 3, 4
10 A
Multi-port fuel injection system/
sequential multi-port fuel injection
system
ECD2
*
5, 6, 7, 8
28
ECD3
*
5, 6, 7, 8
7.5 A
Multi-port fuel injection system/
sequential multi-port fuel injection
system
411
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
Engine compartment (type B)
Fuse
Ampere
Circuit
1
ATF PMP
10 A
No circuit
2
HTR W/P
10 A
No circuit
3
H-LP HI RH
10 A
Right-hand headlight
4
H-LP HI LH
10 A
Left-hand headlight
412
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Under the instrument panel (type A)
Fuse name
Ampere
Circuit
1
TAIL
*
1
10 A
Front position lights, tail lights,
license plate lights, manual head-
light leveling dial, multi-port fuel
injection system/sequential multi-
port fuel injection system, instru-
ment cluster lights
PANEL2
*
2
7.5 A
2
PANEL1
*
2
7.5 A
Switch illuminations, instrument
cluster lights, steering switches,
Stop & Start system, gauges and
meters
3
A/C
7.5 A
Air conditioning system, rear win-
dow defogger, power heater
413
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
Fuse name
Ampere
Circuit
4
D DOOR
20 A
Power windows
5
RL DOOR
20 A
Power windows (rear left)
6
RR DOOR
20 A
Power windows (rear right)
7
CIG
15 A
Cigarette lighter
8
ACC
7.5 A
Power door lock system, outside
rear view mirrors, audio system
9
ID/UP / MIR
HTR
10 A
Outside rear view mirror defoggers
10
AM1 NO2
*
3
7.5 A
No circuit
11
RR FOG
7.5 A
Rear fog light
12
IGN
7.5 A
Multi-port fuel injection system/
sequential multi-port fuel injection
system, SRS airbag system, smart
entry & start system, Stop & Start
system
13
MET
7.5 A
Gauges and meters
14
P S-HTR
15 A
Seat heater
15
D S-HTR
15 A
Seat heater
16
WIP
20 A
Windshield wipers
17
RR WIP
15 A
Rear window wiper
18
WSH
15 A
Windshield washers, rear window
washer
414
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Fuse name
Ampere
Circuit
19
ECU-IG
10 A
Daytime running light system, ABS,
electric power steering, power win-
dows, power door lock system,
VSC, Active Torque Control 4WD
system, smart entry & start system,
Stop & Start system, electric cool-
ing fan
20
GAUGE
10 A
Charging system, turn signal lights,
emergency flashers, back-up
lights, air conditioning system, rear
window defogger, gauges and
meters
21
OBD2
7.5 A
On-board diagnosis system
22
STOP
10 A
Stop lights, high mounted stop-
light, multi-port fuel injection sys-
tem/sequential multi-port fuel
injection system, ABS, VSC
23
D/L
25 A
Power door lock system, double
locking system
24
FR FOG
15 A
Front fog lights
25
4WD
7.5 A
Active Torque Control 4WD system
415
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
*
1
: Vehicles with daytime running light system
*
2
: Vehicles without daytime running light system
*
3
: Vehicles with smart entry & start system
Fuse name
Ampere
Circuit
26
TAIL
*
2
10 A
Front position lights, tail lights,
license plate lights, manual head-
light leveling dial, multi-port fuel
injection system/sequential multi-
port fuel injection system, instru-
ment cluster lights
27
AM1
25 A
Multi-port fuel injection system/
sequential multi-port fuel injection
system, “ACC”, “CIG” fuses
416
4-3. Do-it-yourself maintenance
URBAN CRUISER_OM_OM52C63E_(EE)
Under the instrument panel (type B)
*
1
: Left-hand drive vehicles
*
2
: Right-hand drive vehicles
*
3
: Vehicles without smart entry & start system
Fuse name
Ampere
Circuit
1
POWER
30 A
Power windows
2
DEF
30 A
Rear window defogger
3
WIP-S
*
1
7.5 A
Power management
4
ACC2
*
1, 3
7.5 A
No circuit
5
WIP-S
*
2
7.5 A
Power management
6
ACC2
*
2, 3
7.5 A
No circuit
417
4-3. Do-it-yourself maintenance
4
Maintenance and care
URBAN CRUISER_OM_OM52C63E_(EE)
After a fuse is replaced
If the lights do not turn on even after the fuse has been replaced, a bulb
may need replacement. (
P. 418)
If the replaced fuse blows again, have the vehicle inspected by any
authorized Toyota dealer or repairer, or another duly qualified and
equipped professional.
If there is an overload in the circuits
The fuses are designed to blow, protecting the wiring harness from damage.
CAUTION
To prevent system breakdowns and vehicle fire
Observe the following precautions.
Failing to do so may cause damage, and possibly a fire or injury.
Never use a fuse of a higher amperage rating than indicated, or use any
other object in place of a fuse.
Always use a genuine Toyota fuse or equivalent.
Never replace a fuse with a wire, even as a temporary fix.
This can cause extensive damage or even fire.
Do not modify the fuse or the fuse box.
NOTICE
Before replacing fuses
Have the cause of electrical overload determined and repaired by any autho-
rized Toyota dealer or repairer, or another duly qualified and equipped pro-
fessional, as soon as possible.