Toyota Yaris Hatchback - 2008 Fuse Box Diagram

Toyota Yaris Hatchback - 2008 Fuse Box Diagram

217
3-5. Other interior features
3
Interior features
Power outlet
The power outlet can be used when
The engine switch is in the ACC or ON position.
NOTICE
To avoid damaging the power outlet
Close the power outlet lid when the power outlet is not in use.
Foreign objects or liquids that enter the power outlet may cause a short cir-
cuit.
To prevent the fuse from being blown
Do not use an accessory that uses more than 12 V 10 A.
To prevent the battery from being discharged
Do not use the power outlet longer than necessary when the engine is not
running.
The power outlet can be used for 12 V accessories that run on less
than 10 A.
233
4
Maintenance and care
4-3. Do-it-yourself maintenance
Do-it-yourself service precautions
If you perform maintenance yourself, be sure to follow the correct
procedures as given in these sections.
Items
Parts and tools
Battery condition
(
P. 247)
• Warm water
• Baking soda
• Grease
• Conventional wrench
(for terminal clamp bolts)
Brake fluid level
(
P. 246)
• FMVSS No.116 DOT 3 or SAE
J1703 brake fluid
• Rag or paper towel
Engine coolant level
(
P. 244)
• “Toyota Super Long Life Coolant”
or similar high quality ethylene
glycol based non-silicate, non-
amine, non-nitrite and non-borate
coolant with long-life hybrid
organic acid technology.
Except Canada:
“Toyota Super Long Life Coolant”
is pre-mixed with 50% coolant
and 50% deionized water.
Canada:
“Toyota Super Long Life Coolant”
is pre-mixed with 55% coolant
and 45% deionized water.
• Funnel (used only for adding
engine coolant)
Engine oil level
(→
P. 240)
• Toyota Genuine Motor Oil or
equivalent
• Rag or paper towel
• Funnel (used only for adding oil)
Fuses
(
P. 269)
Fuse with same amperage rating
as original
239
4-3. Do-it-yourself maintenance
4
Maintenance and care
Engine compartment
Washer fluid tank (
P. 250)
Engine oil filler cap
(
P. 240)
Engine oil level dipstick
(
P. 240)
Radiator cap
Battery
(
P. 247)
Brake fluid reservoir
(
P. 246)
Fuse box
(
P. 269)
Condenser
(
P. 246)
Electric cooling fan
Engine coolant reservoir
(
P. 244)
Radiator
(
P. 246)
269
4-3. Do-it-yourself maintenance
4
Maintenance and care
Checking and replacing fuses
If any of the electrical components do not operate, a fuse may have
blown. If this happens, check and replace the fuses as necessary.
Turn the engine switch off.
The fuses are located in the following places. To check the
fuses, follow the instructions below.
Engine compartment
Type A
1.Push the tab in and lift the
cover off.
2.Remove the cover.
271
4-3. Do-it-yourself maintenance
4
Maintenance and care
Type B
Remove the lid.
After a system failure, see “Fuse layout and amperage
ratings” (
P. 273) for details about which fuse to check.
Remove the fuse with the pull-
out tool.
272
4-3. Do-it-yourself maintenance
Check if the fuse has blown.
Type A
Normal fuse
Blown fuse
Replace it with one of an
appropriate amperage rating.
The amperage rating can be
found on the fuse box lid.
Type B
Normal fuse
Blown fuse
Replace it with one of an
appropriate amperage rating.
The amperage rating can be
found on the fuse box lid
Type C
Normal fuse
Blown fuse
Contact your Toyota dealer.
273
4-3. Do-it-yourself maintenance
4
Maintenance and care
Fuse layout and amperage ratings
Engine compartment (type A)
Fuse
Ampere
Circuit
1
ALT
120 A
Charging system, HTR SUB2,
EPS, ABS1/VSC1, HTR, ABS2/
VSC2, HTR SUB1,RDI, DEF, FR
FOG, OBD2, D/L, POWER, RR
DOOR, RL DOOR, STOP and AM1
2
MAIN
60 A
EFI, HORN, AM2, ALT-S, DOME,
ST, ECU-B, ETCS, HAZ, H-LP LH/
H-LP LO LH and H-LP RH/H-LP
LO RH fuses
274
4-3. Do-it-yourself maintenance
Engine compartment (type B)
Fuse
Ampere
Circuit
1
AM2
15 A
Starting system, multiport fuel
injection system/sequential multi-
port fuel injection system
2
HORN
10 A
Horn
3
EFI
20 A
Multiport fuel injection system/
sequential multiport fuel injection
system
4
SPARE
30 A
Spare fuse
5
SPARE
15 A
Spare fuse
6
SPARE
10 A
Spare fuse
7
FR DEF
20 A
No circuit
8
ABS2/VSC2
30 A
Anti-lock brake system
9
H-LP MAIN
30 A
No circuit
10
ST
30 A
Starting system
11
S-LOCK
20 A
No circuit
12
DOME
15 A
Interior light, personal lights, theft
deterrent system, audio system,
wireless remote control system
275
4-3. Do-it-yourself maintenance
4
Maintenance and care
13
ECU-B
7.5 A
Engine immobilizer system, day-
time running light system, front
passenger occupant classification
system, power windows, door lock
system, theft deterrent system,
meter and gauge
14
ALT-S
7.5 A
Charging system
15
ETCS
10 A
Multiport fuel injection system/
sequential multiport fuel injection
system, electronic throttle control
system
16
HAZ
10 A
Turn signal lights, emergency
flashers
17
H-LP RH/H-LP
LO RH
10 A
Right-hand headlight
18
H-LP LH/H-LP
LO LH
10 A
Left-hand headlight
19
EFI2
10 A
Multiport fuel injection system/
sequential multiport fuel injection
system
20
HTR SUB2
40 A
Air conditioning system
21
EPS
50 A
Electric power steering system
22
ABS1/VSC1
50 A
Anti-lock brake system
23
HTR
40 A
Air conditioning system
24
RDI
30 A
Electric cooling fan
25
HTR SUB1
30 A
Air conditioning system
26
H-LP CLN/PWR
HTR
30 A
No circuit
27
AMT
50 A
No circuit
Fuse
Ampere
Circuit
276
4-3. Do-it-yourself maintenance
Under the instrument panel (type A)
Fuse
Ampere
Circuit
1
ACC2
7.5 A
Shift lock system
2
DEF
30 A
Rear window defogger
3
POWER
30 A
Power windows
277
4-3. Do-it-yourself maintenance
4
Maintenance and care
Under the instrument panel (type B)
Fuse
Ampere
Circuit
1
TAIL
10 A
Side marker lights, parking lights
tail lights, license plate lights, multi-
port fuel injection system/sequen-
tial multiport fuel injection system
2
PANEL 1
7.5 A
Illuminations, instrument panel light
control, meter and gauge
3
A/C
7.5 A
Rear window defogger, air condi-
tioning system
4
D DOOR
20 A
No circuit
5
RL DOOR
20 A
Rear passenger’s power window
(left side)
6
RR DOOR
20 A
Rear passenger’s power window
(right side)
7
CIG
15 A
Power outlet
8
ACC
7.5 A
Door lock system, outside rear
view mirrors, audio system
9
ID/UP/MIR HTR
10 A
Multiport fuel injection system/
sequential multiport fuel injection
system
278
4-3. Do-it-yourself maintenance
10
IGN
7.5 A
Multiport fuel injection system/
sequential multiport fuel injection
system, engine immobilizer sys-
tem, SRS airbag system, front pas-
senger occupant classification
system
11
MET
7.5 A
Meter and gauge
12
WIP
25 A
Windshield wiper
13
RR WIP
15 A
Rear wiper
14
WSH
15 A
Windshield washer
15
ECU-IG
10 A
Daytime running light system, anti-
lock brake system, electric power
steering system, power windows,
door lock system, theft deterrent
system, electric cooling fan
16
GAUGE
10 A
Charging system, turn signal lights,
emergency flashers, buck-up
lights, instrument panel light con-
trol, shift lock system, rear window
defogger, air conditioning system,
automatic transmission system
17
OBD2
7.5 A
On-board diagnosis system
18
STOP
10 A
Stop lights, high mounted stop-
light, multiport fuel injection sys-
tem/sequential multiport fuel injec-
tion system, shift lock system, anti-
lock brake system
19
D/L
25 A
Door lock system
20
FR FOG
15 A
Front fog lights
21
AM1
25 A
Multiport fuel injection system/
sequential multiport fuel injection
system
Fuse
Ampere
Circuit
279
4-3. Do-it-yourself maintenance
4
Maintenance and care
After a fuse is replaced
If the lights do not turn on even after the fuse has been replaced, a bulb
may need replacement. (
P. 280)
If the replaced fuse blows again, have the vehicle inspected by your
Toyota dealer.
If there is an overload in the circuits
The fuses are designed to blow before the entire wiring harness is damaged.
CAUTION
To prevent system breakdowns and vehicle fire
Observe the following precautions.
Failing to do so may cause damage, and possibly a fire or injury.
Never use a fuse of a higher amperage rating than indicated, or use any
other object in place of a fuse.
Always use a genuine Toyota fuse or equivalent.
Never replace a fuse with a wire, even as a temporary fix.
This can cause extensive damage or even fire.
Do not modify the fuse or the fuse box.
NOTICE
Before replacing fuses
Have the cause of electrical overload determined and repaired by your
Toyota dealer as soon as possible.
217
3-5. Other interior features
3
Interior features
Power outlet
The power outlet can be used when
The engine switch is in the ACC or ON position.
NOTICE
To avoid damaging the power outlet
Close the power outlet lid when the power outlet is not in use.
Foreign objects or liquids that enter the power outlet may cause a short cir-
cuit.
To prevent the fuse from being blown
Do not use an accessory that uses more than 12 V 10 A.
To prevent the battery from being discharged
Do not use the power outlet longer than necessary when the engine is not
running.
The power outlet can be used for 12 V accessories that run on less
than 10 A.
233
4
Maintenance and care
4-3. Do-it-yourself maintenance
Do-it-yourself service precautions
If you perform maintenance yourself, be sure to follow the correct
procedures as given in these sections.
Items
Parts and tools
Battery condition
(
P. 247)
• Warm water
• Baking soda
• Grease
• Conventional wrench
(for terminal clamp bolts)
Brake fluid level
(
P. 246)
• FMVSS No.116 DOT 3 or SAE
J1703 brake fluid
• Rag or paper towel
Engine coolant level
(
P. 244)
• “Toyota Super Long Life Coolant”
or similar high quality ethylene
glycol based non-silicate, non-
amine, non-nitrite and non-borate
coolant with long-life hybrid
organic acid technology.
Except Canada:
“Toyota Super Long Life Coolant”
is pre-mixed with 50% coolant
and 50% deionized water.
Canada:
“Toyota Super Long Life Coolant”
is pre-mixed with 55% coolant
and 45% deionized water.
• Funnel (used only for adding
engine coolant)
Engine oil level
(→
P. 240)
• Toyota Genuine Motor Oil or
equivalent
• Rag or paper towel
• Funnel (used only for adding oil)
Fuses
(
P. 269)
Fuse with same amperage rating
as original
239
4-3. Do-it-yourself maintenance
4
Maintenance and care
Engine compartment
Washer fluid tank (
P. 250)
Engine oil filler cap
(
P. 240)
Engine oil level dipstick
(
P. 240)
Radiator cap
Battery
(
P. 247)
Brake fluid reservoir
(
P. 246)
Fuse box
(
P. 269)
Condenser
(
P. 246)
Electric cooling fan
Engine coolant reservoir
(
P. 244)
Radiator
(
P. 246)
269
4-3. Do-it-yourself maintenance
4
Maintenance and care
Checking and replacing fuses
If any of the electrical components do not operate, a fuse may have
blown. If this happens, check and replace the fuses as necessary.
Turn the engine switch off.
The fuses are located in the following places. To check the
fuses, follow the instructions below.
Engine compartment
Type A
1.Push the tab in and lift the
cover off.
2.Remove the cover.
271
4-3. Do-it-yourself maintenance
4
Maintenance and care
Type B
Remove the lid.
After a system failure, see “Fuse layout and amperage
ratings” (
P. 273) for details about which fuse to check.
Remove the fuse with the pull-
out tool.
272
4-3. Do-it-yourself maintenance
Check if the fuse has blown.
Type A
Normal fuse
Blown fuse
Replace it with one of an
appropriate amperage rating.
The amperage rating can be
found on the fuse box lid.
Type B
Normal fuse
Blown fuse
Replace it with one of an
appropriate amperage rating.
The amperage rating can be
found on the fuse box lid
Type C
Normal fuse
Blown fuse
Contact your Toyota dealer.
273
4-3. Do-it-yourself maintenance
4
Maintenance and care
Fuse layout and amperage ratings
Engine compartment (type A)
Fuse
Ampere
Circuit
1
ALT
120 A
Charging system, HTR SUB2,
EPS, ABS1/VSC1, HTR, ABS2/
VSC2, HTR SUB1,RDI, DEF, FR
FOG, OBD2, D/L, POWER, RR
DOOR, RL DOOR, STOP and AM1
2
MAIN
60 A
EFI, HORN, AM2, ALT-S, DOME,
ST, ECU-B, ETCS, HAZ, H-LP LH/
H-LP LO LH and H-LP RH/H-LP
LO RH fuses
274
4-3. Do-it-yourself maintenance
Engine compartment (type B)
Fuse
Ampere
Circuit
1
AM2
15 A
Starting system, multiport fuel
injection system/sequential multi-
port fuel injection system
2
HORN
10 A
Horn
3
EFI
20 A
Multiport fuel injection system/
sequential multiport fuel injection
system
4
SPARE
30 A
Spare fuse
5
SPARE
15 A
Spare fuse
6
SPARE
10 A
Spare fuse
7
FR DEF
20 A
No circuit
8
ABS2/VSC2
30 A
Anti-lock brake system
9
H-LP MAIN
30 A
No circuit
10
ST
30 A
Starting system
11
S-LOCK
20 A
No circuit
12
DOME
15 A
Interior light, personal lights, theft
deterrent system, audio system,
wireless remote control system
275
4-3. Do-it-yourself maintenance
4
Maintenance and care
13
ECU-B
7.5 A
Engine immobilizer system, day-
time running light system, front
passenger occupant classification
system, power windows, door lock
system, theft deterrent system,
meter and gauge
14
ALT-S
7.5 A
Charging system
15
ETCS
10 A
Multiport fuel injection system/
sequential multiport fuel injection
system, electronic throttle control
system
16
HAZ
10 A
Turn signal lights, emergency
flashers
17
H-LP RH/H-LP
LO RH
10 A
Right-hand headlight
18
H-LP LH/H-LP
LO LH
10 A
Left-hand headlight
19
EFI2
10 A
Multiport fuel injection system/
sequential multiport fuel injection
system
20
HTR SUB2
40 A
Air conditioning system
21
EPS
50 A
Electric power steering system
22
ABS1/VSC1
50 A
Anti-lock brake system
23
HTR
40 A
Air conditioning system
24
RDI
30 A
Electric cooling fan
25
HTR SUB1
30 A
Air conditioning system
26
H-LP CLN/PWR
HTR
30 A
No circuit
27
AMT
50 A
No circuit
Fuse
Ampere
Circuit
276
4-3. Do-it-yourself maintenance
Under the instrument panel (type A)
Fuse
Ampere
Circuit
1
ACC2
7.5 A
Shift lock system
2
DEF
30 A
Rear window defogger
3
POWER
30 A
Power windows
277
4-3. Do-it-yourself maintenance
4
Maintenance and care
Under the instrument panel (type B)
Fuse
Ampere
Circuit
1
TAIL
10 A
Side marker lights, parking lights
tail lights, license plate lights, multi-
port fuel injection system/sequen-
tial multiport fuel injection system
2
PANEL 1
7.5 A
Illuminations, instrument panel light
control, meter and gauge
3
A/C
7.5 A
Rear window defogger, air condi-
tioning system
4
D DOOR
20 A
No circuit
5
RL DOOR
20 A
Rear passenger’s power window
(left side)
6
RR DOOR
20 A
Rear passenger’s power window
(right side)
7
CIG
15 A
Power outlet
8
ACC
7.5 A
Door lock system, outside rear
view mirrors, audio system
9
ID/UP/MIR HTR
10 A
Multiport fuel injection system/
sequential multiport fuel injection
system
278
4-3. Do-it-yourself maintenance
10
IGN
7.5 A
Multiport fuel injection system/
sequential multiport fuel injection
system, engine immobilizer sys-
tem, SRS airbag system, front pas-
senger occupant classification
system
11
MET
7.5 A
Meter and gauge
12
WIP
25 A
Windshield wiper
13
RR WIP
15 A
Rear wiper
14
WSH
15 A
Windshield washer
15
ECU-IG
10 A
Daytime running light system, anti-
lock brake system, electric power
steering system, power windows,
door lock system, theft deterrent
system, electric cooling fan
16
GAUGE
10 A
Charging system, turn signal lights,
emergency flashers, buck-up
lights, instrument panel light con-
trol, shift lock system, rear window
defogger, air conditioning system,
automatic transmission system
17
OBD2
7.5 A
On-board diagnosis system
18
STOP
10 A
Stop lights, high mounted stop-
light, multiport fuel injection sys-
tem/sequential multiport fuel
injection system, shift lock system,
anti-lock brake system
19
D/L
25 A
Door lock system
20
FR FOG
15 A
Front fog lights
21
AM1
25 A
Multiport fuel injection system/
sequential multiport fuel injection
system
Fuse
Ampere
Circuit
279
4-3. Do-it-yourself maintenance
4
Maintenance and care
After a fuse is replaced
If the lights do not turn on even after the fuse has been replaced, a bulb
may need replacement. (
P. 280)
If the replaced fuse blows again, have the vehicle inspected by your Toy-
ota dealer.
If there is an overload in the circuits
The fuses are designed to blow before the entire wiring harness is damaged.
CAUTION
To prevent system breakdowns and vehicle fire
Observe the following precautions.
Failing to do so may cause damage, and possibly a fire or injury.
Never use a fuse of a higher amperage rating than indicated, or use any
other object in place of a fuse.
Always use a genuine Toyota fuse or equivalent.
Never replace a fuse with a wire, even as a temporary fix.
This can cause extensive damage or even fire.
Do not modify the fuse or the fuse box.
NOTICE
Before replacing fuses
Have the cause of electrical overload determined and repaired by your Toy-
ota dealer as soon as possible.
5
When trouble arises
323
5-2. Steps to take in an emergency
If the engine will not start
If the engine still does not start after following the correct starting
procedure (
P. 119) or releasing the steering lock (
P. 121), confirm
the following points.
The engine will not start even when the starter motor oper-
ates normally.
One of the following may be the cause of the problem.
There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle.
The engine may be flooded.
Try to restart the engine once more following correct starting
procedures. (
P. 119)
Vehicles with engine immobilizer system: There may be a
malfunction in the engine immobilizer system.
(
P. 70)
The starter motor turns over slowly, the interior lights and
headlights are dim, or the horn does not sound or sounds at
a low volume.
One of the following may be the cause of the problem.
The battery may be discharged. (
P. 327)
The battery terminal connections may be loose or corroded.
The starter motor does not turn over
The engine starting system may be malfunctioning due to an
electrical problem such as an open circuit or a blown fuse. How-
ever, a interim measure is available to start the engine.
(
P. 324)
WARRANTY
WARRANTY
This warranty also does not cover the following:
NORMAL SOUND, VIBRATION AND DETERIORATION
Conditions related to normal noise, wear, vibration, deterioration,
discolouration, distortion, deformation and fading.
MAINTENANCE EXPENSE
Normal maintenance services such as: engine tune-ups, lubrication, cleaning
and polishing, replacement of coolant, filters, spark plugs, fuses, remote key/
key fob batteries, worn wiper blades, brake pads/linings and clutch linings.
VEHICLES WITH ALTERED ODOMETER READING
Failure of a vehicle on which the odometer has been altered or changed so
that the actual kilometres driven cannot be determined.
SALVAGE OR WRITTEN-OFF VEHICLES
The new vehicle warranty no longer applies on any Toyota vehicle which is
designated at any time as salvaged, scrapped, junked, totalled or written off.
INCIDENTAL DAMAGES
Incidental or consequential damages associated with a vehicle failure. Such
damages include but are not limited to inconvenience, the cost of
transportation (unless expressly provided in this warranty), telephone calls
and lodging, the loss of personal or commercial property, and the loss of
pay or revenue.
TIRES
Tires originally installed on a new 2008 model year Toyota vehicle are
warranted by the respective tire manufacturer. Refer to the tire pamphlet
provided with your Toyota vehicle. If an original tire on your Toyota
vehicle has a defect during the term of the tire manufacturer warranty,
please contact your authorized Toyota dealer for assistance.
Any implied warranty of merchantability or fitness for a particular purpose
applicable to this vehicle, where permitted by law, is limited in duration to
the duration of this written warranty. The performance of repairs and
needed adjustments is the exclusive remedy under this written warranty or
any implied warranty. Toyota shall not be liable for incidental or
consequential damages by reasons of this written warranty or any implied
warranty.
The provision of the above written warranties is in addition to any statutory
warranties or other rights or remedies as may otherwise exist at law.
Toyota does not authorize any person or corporation to assume for it any
obligation or liability or make any representation in respect of the Toyota
New Vehicle Warranty.
13
Toyota New Vehicle Warranty