Polaris Sportsman 570 EPS - 2016 Fuse Box Diagram

Polaris Sportsman 570 EPS - 2016 Fuse Box Diagram

89
WINCH GUIDE
Winch Cable Care
For your safety, always replace POLARIS winch parts (including the
cable) with genuine POLARIS replacement parts available at your
authorized POLARIS dealer.
WARNING!
Use of worn or damaged cable could lead to sudden failure and
SEVERE INJURY.
1.
Always inspect your winch before each use. Inspect for worn or
loose parts including mounting hardware. Never use the winch if
any part needs repair or replacement.
2.
Always inspect your winch cable before each use. Inspect for worn
or kinked winch cable.
A.
A kinked winch cable made of
wire rope is shown at right. Even
after being “straightened out,”
this cable has already been
permanently and severely
damaged. Promptly discontinue
use of a winch cable in this
condition.
B.
A kinked winch cable made of
wire rope that has been
“straightened out” is shown at
right. Even though it may look
usable, the cable has been
permanently and severely damaged. It can no longer transmit the load
that it could prior to kinking. Promptly discontinue use of a winch cable
in this condition.
C.
A winch cable made of
synthetic rope should be
inspected for signs of fraying.
Replace the cable if fraying is
observed (shown at right).
Promptly discontinue use of a
winch cable in this condition.
D.
Also replace the winch cable if there are fused or melted fibers. Such
an area of the synthetic rope will be stiff and appear smooth or glazed.
Promptly discontinue use of a winch cable in this condition.
A
B
C
119
MAINTENANCE
Fuse Replacement
If the engine stops or will not
start, or if you experience other
electrical failures, a fuse may
need replacement. Locate and
correct any short circuits that
may have caused the blown
fuse, then replace the fuse.
Spare fuses are provided in a
compartment on the top of the
access door.
1.
Open the front box cover.
2.
Remove the access panel.
See page 109.
3.
Remove fuse box cover.
4.
Remove the suspect fuse
from the fuse panel. If the
fuse is blown, install a new
fuse with the same
amperage.
5.
Secure the fuse box cover
and access panel.
6.
Secure the front box cover.
Fuse Box
Label inside the
Fuse Box Cover
149
TROUBLESHOOTING
Engine Doesn't Turn Over
Engine Turns Over, Fails to Start
Engine Backfires
Possible Cause
Solution
Tripped circuit breaker or blown fuse
Reset the breaker/Replace fuse
Low battery voltage
Recharge the battery to 12.8 VDC
Loose battery connections
Check all connections and tighten
Loose solenoid connections
Check all connections and tighten
Possible Cause
Solution
Out of fuel
Refuel, cycle key to ON position three
times for 5 seconds each, then start
Clogged fuel filter
Your POLARIS dealer can assist.
Water is present in fuel
Drain the fuel system and refuel
Old or non-recommended fuel
Replace with fresh recommended fuel
Fouled or defective spark plugs
Inspect plugs and replace if necessary
No spark to spark plug
Inspect plugs, verify stop switch is on
Water or fuel in crankcase
Your POLARIS dealer can assist.
Low battery voltage
Recharge the battery to 12.8 VDC
Mechanical failure
Your POLARIS dealer can assist.
Possible Cause
Solution
Weak spark from spark plug
Inspect, clean and/or replace spark plugs
Incorrect spark plug gap or heat range
Set gap to specs or replace plugs
Old or non-recommended fuel
Replace with fresh recommended fuel
Incorrectly installed spark plug wires
Your POLARIS dealer can assist.
Incorrect ignition timing
Your POLARIS dealer can assist.
Mechanical failure
Your POLARIS dealer can assist.
Loose ignition connections
Check all connections and tighten
Water present in fuel
Replace with fresh recommended fuel
162
WARRANTY
Warranty Coverage And Exclusions:
Limitations Of Warranties And Remedies
This warranty excludes damages or failures caused by abuse, accident, fire, or any other
cause other than a defect in materials or workmanship and provides no coverage for
consumable components, general wear items, or any parts exposed to friction surfaces,
stresses, environmental conditions and/or contamination for which they were not
designed or not intended, including but not limited to the following items:
Lubricants and Fluids
1. Mixing oil brands or using non-recommended oil may cause engine damage. We
recommend the use of POLARIS engine oil.
2. Damage or failure resulting from the use of non-recommended lubricants or fluids is
not covered by this warranty.
This warranty provides no coverage for personal loss or expense, including mileage,
transportation costs, hotels, meals, shipping or handling fees, product pick-up or
delivery, replacement rentals, loss of product use, loss of profits, or loss of vacation or
personal time.
Wheels and tires
Finished and unfinished surfaces
Suspension components
Carburetor/Throttle body components
Brake components
Engine components
Seat components
Drive belts
Clutches and components
Hydraulic components and fluids
Steering components
Circuit breakers/Fuses
Batteries
Electronic components
Light bulbs/Sealed beam lamps
Spark plugs
Filters
Sealants
Lubricants
Coolants
Bushings
Bearings