Polaris Sportsman 800 EFI - 2011 Fuse Box Diagram

Polaris Sportsman 800 EFI - 2011 Fuse Box Diagram

86
MAINTENANCE
Fuse Replacement
If the engine stops or will not
start, or if you experience other
electrical failures, a fuse may need
replacement. Locate and correct
any short circuits that may have
caused the blown fuse, then
replace the fuse. Spare fuses are
provided in a compartment on the
top of the access door.
1.
Remove the front box/rack.
2.
Remove the suspect fuse from
the fuse panel. If the fuse is
blown, install a new fuse with
the same amperage.
3.
Reinstall the front box/rack.
Fuse
Feature Supported
5A
Speedometer
15A
Electronic Fuel Injection
20A
(Main Fuse) Ignition, Lighting
20A
Accessories, 12V Power Receptacle
Fuse Panel
Fuses
5
or
6 15 20
20
113
TROUBLESHOOTING
Engine Doesn't Turn Over
Engine Turns Over, Fails to Start
Engine Backfires
Possible Cause
Solution
Tripped circuit breaker or blown fuse
Reset the breaker/Replace fuse
Low battery voltage
Recharge the battery to 12.8 VDC
Loose battery connections
Check all connections and tighten
Loose solenoid connections
Check all connections and tighten
Possible Cause
Solution
Out of fuel
Refuel, cycle key to ON position three
times for 5 seconds each, then start
Clogged fuel filter
Replace the filter
Water is present in fuel
Drain the fuel system and refuel
Old or non-recommended fuel
Replace with fresh recommended fuel
Fouled or defective spark plugs
Inspect plugs and replace if necessary
No spark to spark plug
Inspect plugs, verify stop switch is on
Water or fuel in crankcase
Immediately see your POLARIS dealer
Low battery voltage
Recharge the battery to 12.8 VDC
Mechanical failure
See your dealer
Possible Cause
Solution
Weak spark from spark plug
Inspect, clean and/or replace spark plugs
Incorrect spark plug gap or heat range
Set gap to specs or replace plugs
Old or non-recommended fuel
Replace with fresh recommended fuel
Incorrectly installed spark plug wires
See your dealer
Incorrect ignition timing
See your dealer
Mechanical failure
See your dealer
Loose ignition connections
Check all connections and tighten
Water present in fuel
Replace with fresh recommended fuel
121
WARRANTY
LIMITATIONS OF WARRANTIES AND REMEDIES
Warranty does not apply to parts exposed to friction surfaces, stresses, environmental
conditions and/or contamination for which they were not designed or not intended,
including but not limited to the following items:
Warranty applies to the product only and does not allow for coverage of personal loss.
Some items are considered “consumable,” meaning they are considered part of normal
maintenance or part of completing an effective repair. The following items are excluded
from warranty coverage in the event of a warranty claim:
This warranty also excludes failures resulting from improper lubrication; improper
engine timing; improper fuel; surface imperfections caused by external stress, heat, cold
or contamination; operator error or abuse; improper component alignment, tension,
adjustment or altitude compensation; failure due to snow, water, dirt or other foreign
substance ingestion/contamination; improper maintenance; modified components; use
of aftermarket components resulting in failure; unauthorized repairs; repairs made after
the warranty period expires or by an unauthorized repair center; use of the product in
competition or for commercial purposes. Warranty will not apply to any product which
has been damaged by abuse, accident, fire or any other casualty not determined a defect
of materials or workmanship.
Wheels and tires
Finished and unfinished surfaces
Suspension components
Carburetor/Throttle body components
Brake components
Engine components
Seat components
Drive belts
Clutches and components
Hydraulic components
Steering components
Circuit breakers/Fuses
Batteries
Electronic components
Light bulbs/Sealed beam lamps
Spark Plugs
Lubricants such as oil, grease, etc.
Filters
Batteries (unless defective)
Fuel
Cosmetic damage/repair
Sealants
Coolants
Hotel fees
Meals
Towing charges
Shipping/ handling fees
Mileage
Product pick-up/delivery
Rentals/Loss of product use
Loss of vacation/personal
time