Polaris Outlaw 525 S - 2009 Fuse Box Diagram

Polaris Outlaw 525 S - 2009 Fuse Box Diagram

39
Features and Controls
Main Key Switch
The main key switch must be in the RUN position to start the engine. See page 66 for starting
procedures.
Start Button
Press the start button to engage the starter. Always release the start button promptly when the
engine starts. If the starter fails to engage, replace the blown fuse or see your Polaris dealer.
Engine Stop Switch
Move the stop switch either left or right to the OFF
position to stop the engine quickly. The engine will
not start or run when the switch is off.
Both the main switch and the engine stop switch will
shut off all electrical power to the vehicle, including
lights.
OFF
OFF
RUN
176
Troubleshooting
Engine Doesn’t Turn Over
Engine Pings or Knocks
Possible Cause
Solution
Fuseable link
See Polaris dealer for replacement
Low battery voltage
Recharge battery to 12.8 VDC
Loose battery connections
Check all connections and tighten
Loose solenoid connections
Check all connections and tighten
Possible Cause
Solution
Poor quality or low octane fuel
Replace with recommended fuel
Incorrect ignition timing
See your Polaris dealer
Incorrect spark plug gap or heat range
Set gap to specs or replace plugs
184
Troubleshooting
Engine Overheats
Possible Cause
Solution
Debris lodged in radiator screen
Remove and clean the screen
Plugged radiator
Use a garden hose to flush any debris from the radia-
tor fins. NOTE: High pressure washers can deform the
radiator fins and reduce cooling efficiency.
Insufficient coolant
Check levels and fill as needed; check for leaks
Insufficient air flow due to slow operation
Operate at a faster speed to increase air flow
Excessive oil in system
Check oil level, maintain at recommended level
Cooling system has not been bled
Bleed the cooling system
Foam has formed in cooling system
Drain and replace coolant with recommended coolant
Bent cooling hose
Shorten or replace hose
Defective thermostat or thermoswitch
See your Polaris dealer
Blown fan fuse or defective fan
Replace fuse and check fan for proper operation or see
your Polaris dealer