Polaris Slingshot SL - 2015 Fuse Box Diagram

Polaris Slingshot SL - 2015 Fuse Box Diagram

77
MAINTENANCE
Fuse Replacement
The fuse box is located under the hood near the brake fluid reservoir. The three main system
fuses are located in the battery compartment.
1.
Open the hood.
2.
Squeeze the fuse box cover tabs inward and remove the cover.
3.
Use the fuse puller provided in the tool kit to remove the spent fuse.
NOTICE:
Always use the recommended fuse to prevent electrical system damage. Refer to the label
on the fuse box cover.
4.
Install the new fuse.
5.
Reinstall the fuse box cover.
Fuse Box
Fuse Box Label
Tabs
83
TROUBLESHOOTING
Shifting Difficulties
Battery Charging Rate Low or Battery Discharges
Brake Noise / Poor Brake Performance
NOTE:
Contact your dealer if brake performance does not return after these inspections.
Anti-Lock Brake Light Remains Illuminated or Illuminates Intermittently
Possible Cause
Possible Remedy/Action
Hydraulic Clutch Fluid Contaminated
Flush hydraulic clutch fluid (see dealer).
Air In Hydraulic Clutch System
Bleed system (see dealer).
Clutch Slave Cylinder Bracket Loose
Inspect / tighten loose parts.
Hydraulic Clutch Fluid Leak
Inspect system for leaks (see dealer).
Clutch Damage
Replace clutch.
Possible Cause
Possible Remedy/Action
Loose/Corroded Charging Circuit
Connection
Check/clean battery cable connections. Check/clean
charging circuit connections. See dealer.
Accessory Load Exceeds Charge Rate
Use ACC position and limit accessory operation when
engine is off.
Improperly Wired Accessory (Current Draw)
See dealer to check charging system output and
current draw.
Battery discharges when vehicle not in use.
See dealer to check key OFF current draw.
Possible Cause
Possible Remedy/Action
Dust / Dirt On Brake Disc(s)
Clean disc.
Worn Pads Or Disc / Brake Disc Damage
Inspect pads.
Brake Fluid Level Low Or Fluid Contaminated
Inspect fluid level / fluid. See page 63.
Possible Cause
Possible Remedy/Action
Blown fuse
Check the fuses. See page 77.
Loose or damaged pulse ring
Inspect pulse ring for looseness or chipped teeth.
Debris lodged in components
Inspect wheel speed sensor and pulse ring for debris.
Damage caused by debris
Inspect wheel speed sensor for cracked housing.
Damaged components
See service manual or authorized dealer.
85
SPECIFICATIONS
SLINGSHOT / SLINGSHOT SL
Drive System
Final Drive Type
Right Angle Drive (37/16)
Carbon Fiber Reinforced Belt (62:39)
Transmission Type
5 Speed with Overdrive
Gear Shift Pattern
5-Speed H-Gate Pattern with Reverse Down-Right
Internal Gear Ratios
1st
3.753:1
2nd
2.258:1
3rd
1.512:1
4th
1.000:1
5th
0.729:1
Right Angle Drive Ratio
2.313:1
Final Drive Ratio
1.590:1
Clutch Type
Single Plate, Diaphragm Spring, Dry
Electrical
Alternator
140 Amp Maximum Output
Battery
12 Volt / 30 Amp Hour / 575 CCA
Lights
Center Headlights (USA)
High/Low H9 65W
Auxiliary Outer Lights (USA)
H3 55W
Headlights (Canada)
High/Low H3 55W
Turn Signals / Taillight / Brake Light
Non-Serviceable LED
License Plate Light
Non-Serviceable LED
Speedometer / Indicator Lights
Non-Serviceable LED
Fuses
/ Circuit Breakers
Ignition
10A Breaker
Headlight
30A Breaker
Gauges
5A
Radio
25A
Turn Signal / Horn
20A
Fuel Pump
10A
ECM
10A Breaker
Powertrain
20A Breaker
Fan
20A Breaker
Accessory
25A
ABS
25A
EPAS
30A
Chassis Main Fuse
50A
Engine Main Fuse
40A
ABS Motor Fuse
40A
87
WARRANTY
Limited Warranty
POLARIS Industries Inc., 2100 Highway 55, Medina, MN 55340 (POLARIS) gives a TWO YEAR LIMITED
WARRANTY on all components of your POLARIS vehicle against defects in material or workmanship. This
warranty covers parts and labor charges for repair or replacement of defective parts and begins on the date of
purchase by the original retail purchaser. This warranty is transferable to another owner during the warranty
period through an authorized POLARIS dealer, but any such transfer will not extend the original term of the
warranty. The duration of this warranty may vary by international region based upon local laws and regulations.
Registration
At the time of sale, the Warranty Registration Form must be completed by your dealer and submitted to
POLARIS within ten days of purchase. Upon receipt of this registration, POLARIS will record the registration for
warranty. No verification of registration will be sent to the purchaser as the copy of the Warranty Registration
Form will be your proof of warranty coverage. If you have not signed the original registration and received the
customer copy, please contact your dealer immediately. NO WARRANTY COVERAGE WILL BE ALLOWED
UNLESS YOUR VEHICLE IS REGISTERED WITH POLARIS. Initial dealer preparation and set-up of your
vehicle is very important in ensuring trouble-free operation. Purchasing a vehicle in the crate or without proper
dealer set-up will void your warranty coverage.
Warranty Coverage And Exclusions:
Limitations Of Warranties And Remedies
This POLARIS limited warranty excludes any failures that are not caused by a defect in material or
workmanship. THIS WARRANTY DOES NOT COVER CLAIMS OF DEFECTIVE DESIGN. This warranty
also does not cover acts of God, accidental damage, normal wear and tear, abuse or improper handling. This
warranty also does not cover any vehicle, component, or part that has been altered structurally, modified,
neglected, improperly maintained or used for racing, competition or purposes other than for which it was
designed.
This warranty excludes damages or failures resulting from: improper lubrication; improper engine timing;
improper fuel; surface imperfections caused by external stress, heat, cold or contamination; operator error or
abuse; improper component alignment, tension, adjustment or altitude compensation; snow, water, dirt or other
foreign substance ingestion/contamination; improper maintenance; modified components; use of aftermarket or
unapproved components, accessories, or attachments; unauthorized repairs; or repairs made after the warranty
period expires or by an unauthorized repair center.
This warranty excludes damages or failures caused by abuse, accident, fire, or any other cause other than a defect
in materials or workmanship and provides no coverage for consumable components, general wear items, or any
parts exposed to friction surfaces, stresses, environmental conditions and/or contamination for which they were
not designed or not intended, including but not limited to the following items:
Wheels and tires
Finished and unfinished surfaces
Suspension components
Fuel Injectors/Throttle body components
Brake components
Engine components
Seat components
Drive belts
Clutches and components
Hydraulic components and fluids
Steering components
Circuit breakers/Fuses
Batteries
Electronic components
Light bulbs/Sealed beam lamps
Spark plugs
Filters
Sealants
Lubricants
Coolants
Bushings
Bearings