If the engine stops or will not start, or if you experience other electrical
failures, a fuse may need replacement. Locate and correct any short cir-
cuits that may have caused the blown fuse, then replace the fuse.
The main fuse box is located under the dash, above the brake and throt-
tle pedals. Spare fuses are provided in the fuse box.
The power fuse box is located under the driver’s seat. Remove the
engine access panel to access the fuse box.
Lights: Headlights, Taillights
Accessory: Winch Switch, 12V Power Receptacle
Electronic Engine Control, Starting
Lights, Drive, Accessories
Main Fuse Box
Lift up on the two fuse box tabs.
Slide the fuse box slightly toward the
right side of the vehicle to disengage it
from the mount.
Remove the fuse box cover.
Remove the suspect fuse from the fuse
panel. If the fuse is blown, install a
new fuse with the same amperage rat-
Reinstall the fuse box cover. Reinstall
the fuse box over the mount and slide
it toward the left to engage the tabs. Be
sure the fuse box is securely mounted.
Step 3 - Cover removed
Step 1 - Lift tabs
WARRANTY COVERAGE AND EXCLUSIONS:
LIMITATIONS OF WARRANTIES AND REMEDIES
The POLARIS limited warranty excludes any failures that are not caused by a defect in
material or workmanship. This warranty does not cover accidental damage, normal wear
and tear, abuse or improper handling. This warranty also does not cover any vehicle that
has been altered structurally, modified, neglected, improperly maintained, used for rac-
ing, or used for purposes other than for which it was manufactured, or for any damages
which occur during trailer transit or as a result of unauthorized service or the use of
unauthorized parts. In addition, this warranty does not cover physical damage to paint or
finish, stress cracks, tearing or puncturing of upholstery material, corrosion, or defects in
parts, components or the vehicle due to fire, explosions or any other cause beyond
Warranty does not apply to parts exposed to friction surfaces, stresses, environmental
conditions and/or contamination for which they were not designed or not intended,
including but not limited to the following items:
Warranty applies to the product only and does not allow for coverage of personal loss.
Some items are considered “consumable,” meaning they are considered part of normal
maintenance or part of completing an effective repair. The following items are excluded
from warranty coverage in the event of a warranty claim:
Wheels and tires
Finished and unfinished surfaces
Carburetor/Throttle body components
Clutches and components
Light bulbs/Sealed beam lamps
Lubricants such as oil, grease, etc.
Batteries (unless defective)
Shipping/ handling fees
Rentals/Loss of product use
Loss of vacation/personal