Polaris RZR EPS - 2010 Fuse Box Diagram

Polaris RZR EPS - 2010 Fuse Box Diagram

85
MAINTENANCE
Fuses
If the engine stops or will not start, if the power steering stops working
(if equipped), or if you experience other electrical failures, a fuse may
need replacement. Locate and correct any short circuits that may have
caused the blown fuse, then replace the fuse.
The fuse box is located above the
power steering unit. One spare 20 amp
fuse is provided in the fuse box.
1.
Remove the fuse box cover.
2.
Remove the suspect fuse from the
fuse panel. If the fuse is blown,
install a new fuse with the same
amperage rating.
3.
Reinstall the fuse box cover.
Tip:
The 120 ohm resistor (if equipped) is
used by your Polaris dealer for power
steering diagnostics.
Spark Plugs
Spark Plug Gap/Torque
NOTICE:
Using non-recommended spark plugs can result in serious engine
damage. Always use Polaris-recommended spark plugs. Refer to the
specifications section beginning on page 120.
Spark plug condition is indicative of engine operation. The spark plug
firing end condition should be read after the engine is warmed up and
the vehicle is driven at higher speeds. Immediately check the spark plug
for correct color. See page 86.
CAUTION!
A hot exhaust system and engine can cause burns. Wear
protective gloves when removing a spark plug for inspection.
Fuse
Feature Supported
15A
Accessories, 12V Power Receptacle
15A
Electronic Fuel Injection
15A
Engine Control Module
15A
Lights
20A
Main Fuse - Ignition, Instrument Cluster
30A
Power Steering (if equipped)
Electrode Gap
New Plug Torque
Used Plug Torque
.035" (.9 mm)
18 ft. lbs.
(24 Nm)
18 ft. lbs.
(24 Nm)
129
WARRANTY
WARRANTY COVERAGE AND EXCLUSIONS:
LIMITATIONS OF WARRANTIES AND REMEDIES
The Polaris limited warranty excludes any failures that are not caused by a defect in
material or workmanship. This warranty does not cover accidental damage, normal wear
and tear, abuse or improper handling. This warranty also does not cover any vehicle that
has been altered structurally, modified, neglected, improperly maintained, used for rac-
ing, or used for purposes other than for which it was manufactured, or for any damages
which occur during trailer transit or as a result of unauthorized service or the use of
unauthorized parts. In addition, this warranty does not cover physical damage to paint or
finish, stress cracks, tearing or puncturing of upholstery material, corrosion, or defects in
parts, components or the vehicle due to fire, explosions or any other cause beyond
Polaris' control.
Warranty does not apply to parts exposed to friction surfaces, stresses, environmental
conditions and/or contamination for which they were not designed or not intended,
including but not limited to the following items:
Warranty applies to the product only and does not allow for coverage of personal loss.
Some items are considered "consumable," meaning they are considered part of normal
maintenance or part of completing an effective repair. The following items are excluded
from warranty coverage in the event of a warranty claim:
Wheels and tires
Finished and unfinished surfaces
Suspension components
Carburetor/Throttle body components
Brake components
Engine components
Seat components
Drive belts
Clutches and components
Hydraulic components
Steering components
Circuit breakers/Fuses
Batteries
Electronic components
Light bulbs/Sealed beam lamps
Spark Plugs
Lubricants such as oil, grease, etc.
Filters
Batteries (unless defective)
Fuel
Cosmetic damage/repair
Sealants
Coolants
Hotel fees
Meals
Towing charges
Shipping/ handling fees
Mileage
Product pick-up/delivery
Rentals/Loss of product use
Loss of vacation/personal
time