Polaris RANGER EV LI-ION - 2016 Fuse Box Diagram

Polaris RANGER EV LI-ION - 2016 Fuse Box Diagram

21
FEATURES AND CONTROLS
Console
Key/Light Switch
Turn the key to the LIGHTS ON position to operate with
the lights on.
Turn the key to the LIGHTS OFF position to operate
with the lights off.
Turn the key to the OFF position to disable all electrical
circuits. The key can be removed from the switch at the
OFF position.
Auxiliary Outlet
The 12-volt receptacle can be used to power accessories, but is limited to 10 amps (the
terminal board and 12-volt outlet are fused together at 10 amps).
Key/Light
Switch
Drive Mode
Switch
Direction
Selector
AWD
Switch
12V Auxiliary
Outlet
7184005
RUN
RUN
31
FEATURES AND CONTROLS
Main Power Connector
NOTICE:
Damage to electrical connections and components will occur if they are unplugged before
the main power connector is disconnected. Always disconnect both the main power fuse
and the main power connector before servicing or unplugging any electrical components.
When disconnected, the main power
connector disconnects the battery pack
from all electrical components, with
the exception of the contactor.
Before servicing the vehicle, unplug
the main power fuse. This fuse is
located inside the right front wheel
well.
The main power connector is located
under the cargo box, behind the seats.
To disconnect, unplug the connector.
After servicing the vehicle, the main
power connector should be the last
connection to be made.
WARNING!
All battery and electrical
service must be performed only by an
authorized service facility. Your POLARIS
dealer can assist.
Main Power Connector
Main Power Fuse
51
WINCH GUIDE
Winch Cable Care
For your safety, always replace POLARIS winch parts (including the cable) with genuine
POLARIS replacement parts available at your authorized POLARIS dealer.
WARNING!
Use of worn or damaged cable could lead to sudden failure and SEVERE INJURY.
1.
Always inspect your winch before each use. Inspect for worn or loose parts including
mounting hardware. Never use the winch if any part needs repair or replacement.
2.
Always inspect your winch cable before each use. Inspect for worn or kinked winch
cable.
A.
A kinked winch cable made of wire rope is shown at
right. Even after being “straightened out,” this cable has
already been permanently and severely damaged.
Promptly discontinue use of a winch cable in this
condition.
B.
A kinked winch cable made of wire rope that has been
“straightened out” is shown at right. Even though it may
look usable, the cable has been permanently and
severely damaged. It can no longer transmit the load
that it could prior to kinking. Promptly discontinue use
of a winch cable in this condition.
C.
A winch cable made of synthetic rope should be
inspected for signs of fraying. Replace the cable if
fraying is observed (shown at right). Promptly
discontinue use of a winch cable in this condition.
D.
Also replace the winch cable if there are fused or
melted fibers. Such an area of the synthetic rope will
be stiff and appear smooth or glazed. Promptly
discontinue use of a winch cable in this condition.
A
B
C
72
WARRANTY
LIMITATIONS OF WARRANTIES AND REMEDIES
This warranty excludes damages or failures caused by abuse, accident, fire, or any other cause other than a defect
in materials or workmanship and provides no coverage for consumable components, general wear items, or any
parts exposed to friction surfaces, stresses, environmental conditions and/or contamination for which they were
not designed or not intended, including but not limited to the following items:
Lubricants and Fluids
1. Damage or failure resulting from the use of non-recommended lubricants or fluids is not covered by this
warranty.
This warranty provides no coverage for personal loss or expense, including mileage, transportation costs, hotels,
meals, shipping or handling fees, vehicle pick-up or delivery, replacement rentals, loss of vehicle use, loss of
profits, or loss of vacation or personal time.
The exclusive remedy for breach of this warranty shall be, at POLARIS MOTORCYCLES’s option, repair or
replacement of any defective materials, components, or products. THE REMEDIES SET FORTH IN THIS
WARRANTY ARE THE ONLY REMEDIES AVAILABLE TO ANY PERSON FOR BREACH OF THIS
WARRANTY. POLARIS SHALL HAVE NO LIABILITY TO ANY PERSON FOR INCIDENTAL,
CONSEQUENTIAL OR SPECIAL DAMAGES OF ANY DESCRIPTION, WHETHER ARISING OUT OF
EXPRESS OR IMPLIED WARRANTY OR ANY OTHER CONTRACT, NEGLIGENCE, OR OTHER TORT
OR OTHERWISE. THIS EXCLUSION OF CONSEQUENTIAL, INCIDENTAL, AND SPECIAL DAMAGES
IS INDEPENDENT FROM AND SHALL SURVIVE ANY FINDING THAT THE EXCLUSIVE REMEDY
FAILED OF ITS ESSENTIAL PURPOSE.
THE IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE IS EXCLUDED FROM THIS
LIMITED WARRANTY. ALL OTHER IMPLIED WARRANTIES (INCLUDING BUT NOT LIMITED TO
THE IMPLIED WARRANTY OF MERCHANTABILITY) ARE LIMITED IN DURATION TO THE ABOVE
SIX MONTH OR 3 YEAR, 5,000 MILE WARRANTY PERIOD. POLARIS DISCLAIMS ALL EXPRESS
WARRANTIES NOT STATED IN THIS WARRANTY. SOME STATES DO NOT PERMIT THE EXCLUSION
OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES OR ALLOW LIMITATIONS ON
THE DURATION OF IMPLIED WARRANTIES, SO THE ABOVE LIMITATIONS MAY NOT APPLY TO
YOU IF INCONSISTENT WITH CONTROLLING STATE LAW.
Wheels and tires
Finished and unfinished surfaces
Suspension components
Fuel Injectors/Throttle body components
Brake components
Hydraulic components and fluids
Seat components
Circuit breakers/Fuses
Clutches and components
Electronic components
Steering components
Sealants
Light bulbs/Sealed beam lamps
Bearings
Lubricants
Bushings