Polaris Polaris LSV - 2011 Fuse Box Diagram

Polaris Polaris LSV - 2011 Fuse Box Diagram

25
FEATURES AND CONTROLS
Console
Battery Discharge Indicator
The battery discharge indicator
displays the amount of charge
removed (used) from fully
charged batteries.
When the
batteries are fully charged, the
right-most bar illuminates, indi-
cating 0% has been used. The
charge status indicator will be
solid green (see page 26). As
the batteries discharge, the bar
moves leftward.
Tip:
If batteries are not allowed to recharge fully (solid green light), the battery
discharge indicator may be inaccurate.
When the second bar from the left flashes, battery discharge is at 70%.
The batteries should be recharged as soon as possible.
Avoid discharging
the batteries more than 80%.
NOTICE:
If the two left-most bars begin to flash, battery damage may occur
with continued operation. Stop the vehicle and recharge the batteries.
Hour Meter
The hour meter records and displays the hours of actual vehicle move-
ment since manufacture.
Auxiliary 12-Volt Terminal Board
The 12-volt terminal board is located under the hood. It contains con-
stant 12-volt, switched 12-volt and ground terminals that can be used to
power auxiliary lights and accessories. The terminals are limited to 10
amps.
Never install any accessory that grounds to the vehicle chassis.
Auxiliary Outlets
The 12-volt receptacle can be used to power accessories, but is limited
to 10 amps (the terminal board and 12-volt outlet are fused together at
10 amps.
100% Remains (Full Charge)
50% Remains
70% Discharged
Recharge the batteries
50% Discharged
30%
66
MAINTENANCE
Brakes
Brake Inspection
1.
Check the brake system for
fluid leaks.
2.
Check the brake pedal for
excessive travel or a spongy
feel.
3.
Check the friction pads for
wear, damage and looseness.
4.
Inspect the brake disc spline
and pad wear surface for
excessive wear.
5.
Change pads when worn to
3/64" (1 mm).
Fuse Replacement
NOTICE:
Always disconnect the main power connector before servicing or
unplugging any electrical components. See page 36.
If you experience electrical failures not related to the batteries, a fuse
may need replacement. Locate and correct any short circuits that may
have caused the blown fuse, then replace the fuse. Spare fuses are
located in the fuse blocks. See your Polaris dealer if you suspect a relay
or diode needs replacement.
The
main fuse block
is located
under the hood on the driver’s
side. Always install fuses with
the recommended amperage to
avoid damage to the electrical
system.
The
relay and diode block
is
located near the main fuse
block.
The
48-volt fuse block
is located
behind the controller, under the
cargo box. Always install 48-
volt fuses in the 48-volt fuse
block.
3/64" (1mm)
Main Fuse Recommendations
Fuse Application
Fuse Size
Chassis
20 amp
14-Volt Charger
15 amp
Unswitched Power
10 amp
Lights
10 amp
Accessories
10 amp
48-Volt Charger
5 amp
Indicators
2 amp
48-Volt Fuse Recommendation
Fuse Application
Fuse Size
48-Volt Fuse Block
20 amp
87
WARRANTY
WARRANTY COVERAGE AND EXCLUSIONS:
LIMITATIONS OF WARRANTIES AND REMEDIES
The POLARIS limited warranty excludes any failures that are not caused by a defect in
material or workmanship. This warranty does not cover accidental damage, normal wear
and tear, abuse or improper handling. This warranty also does not cover any vehicle that
has been altered structurally, modified, neglected, improperly maintained, used for rac-
ing, or used for purposes other than for which it was manufactured, or for any damages
which occur during trailer transit or as a result of unauthorized service or the use of
unauthorized parts. In addition, this warranty does not cover physical damage to paint or
finish, stress cracks, tearing or puncturing of upholstery material, corrosion, or defects in
parts, components or the vehicle due to fire, explosions or any other cause beyond
POLARIS' control.
Warranty does not apply to parts exposed to friction surfaces, stresses, environmental
conditions and/or contamination for which they were not designed or not intended,
including but not limited to the following items:
Wheels and tires
Finished and unfinished surfaces
Suspension components
Carburetor/Throttle body components
Brake components
Engine components
Seat components
Drive belts
Clutches and components
Hydraulic components
Steering components
Circuit breakers/Fuses
Batteries
Electronic components
Light bulbs/Sealed beam lamps