Polaris Universal GEM - 2012 Fuse Box Diagram

Polaris Universal GEM - 2012 Fuse Box Diagram

33
FEATURES AND CONTROLS
Console
Headlight Switch
Press the top of the headlight switch to turn the headlights
and taillights on. Press the bottom of the switch to turn the
lights off.
Electrical Components
Electrical wiring, circuit boards and components are
located under and behind the upper and lower console.
NOTICE:
Liquids can damage electrical components and the
circuit board. Handle liquids with care. Do not spray
water directly into the upper or lower console.
Electrical Access Panel
(Fuses/Main Disconnect Switch)
Optional Accessory Switches
ON
OFF
37
FEATURES AND CONTROLS
Console
Windshield Wiper
Push the turn signal lever toward the console and release it to
turn the windshield wipers on. Push the lever toward the con-
sole again to activate the washer momentarily (if equipped, see
page 86). Pull the lever toward the steering wheel to turn the
wiper off.
If the wiper fails to work, check for a blown fuse at the fuse
block. See page 104.
CAUTION!
A worn or damaged wiper blade could impair operator vision and result in an accident. A
worn wiper blade could also damage windshield glass. Always replace worn or damaged wiper blades
promptly.
Wiper OFF
Wiper ON
52
FEATURES AND CONTROLS
Console
Main Disconnect Switch
WARNING!
The main disconnect switch will disable
the vehicle by disconnecting the battery pack from the
motor. It does not disable the battery pack. HIGH
VOLTAGE will be present at the battery terminals.
HIGH BATTERY VOLTAGE IS ALWAYS PRESENT.
DO NOT TOUCH THE BATTERY TERMINALS.
The main disconnect switch is located inside the
fuse access panel on the lower console. The
main disconnect switch must be turned on for
operation and for charging.
Main Disconnect
Switch
Fuses
Access Panel
87
FEATURES AND CONTROLS
Accessory Outlet (Option)
The optional accessory outlet is located on the lower con-
sole, to the right of the fuse access panel. This outlet will
accept a standard automotive 12-volt accessory and is
intended for moderately powered accessories, such as a
cellular phone. It will not operate large current items, such
as cigarette lighters.
The fuse for the power outlet plug is located in the fuse
block under the access panel in the center of the lower con-
sole. Always use fuses with the same type and rating.
NOTICE:
Do not plug in devices requiring power exceeding 25 watts. Damage to the vehicle electrical
system may occur or an accessory fuse may blow.
104
MAINTENANCE
Fuse Replacement
NOTICE:
Always disconnect the main disconnect switch
before servicing or unplugging any electrical
components. See page 52.
If you experience electrical failures not related to
the batteries, a fuse may need replacement. Locate
and correct any short circuits that may have caused
the blown fuse, then replace the fuse. See your
authorized GEM dealer if you suspect a relay or
diode needs replacement.
The fuse block is located inside the fuse access panel on the lower console. To open the
access panel, insert the ignition key in the lock and turn it counter-clockwise 1/4 turn.
Fuse Block
Access Panel
105
MAINTENANCE
Fuse Replacement
NOTICE:
Always install fuses with the recommended amperage to avoid damage to the electrical
system.
Tip:
See the label attached to the inside of the fuse access panel for the function and amp rating of
each fuse. The spare and heater coil fuses are used for accessories.
Fuse Recommendations
Fuse Application
Fuse Size
Heater Coil (fuse used for accessory)
30 amp
Turn Signals / Brake Lamps
10 amp
Windshield Wiper
Accessories
Radio
Tail Lamp/Headlamps / Horn / License Plate
Lamp
Heater
Radio / Public Address System
Odometer Switch
1 amp
Spare
Heater Coil
72V System
30A
10A
10A
10A
10A
10A
1A
10A
10A
10A
1A
1A
Turn Signals
Brake Lamps
Wiper
Accessories
Display
Radio
Tail/Headlamps
Horn
License P. Lamp
Heater
Radio / PA
Odometer Switch
Display
Fuse Label