Kia Rio - 2005 Fuse Box Diagram

Kia Rio - 2005 Fuse Box Diagram

Knowing Your Vehicle
3-8
Windows
Manual Windows (If Equipped)
Use the window crank to open and close each window.
Power Windows (If Equipped)
The ignition switch must be in the ON position for
power windows to operate. Each door has a power
window switch that controls that door’s window.
However, the driver has a power window lock switch
which can cancel the operation of the three passenger
window switches.
NOTICE
To prevent the power window fuse from malfunc-
tioning and the power window system from being
damaged, do not open or close more than two
windows at the same time.
1S2106002
NOTICE
If you notice buffeting and pulsation (wind shock)
with either side window open, you should open
the opposite window slightly to reduce the condi-
tion.
Electrical Circuit Protection
Fuses
A vehicle’s electrical system is protected from
electrical overload damage by fuses.
This vehicle has two fuse panels, one located in the
driver’s side kick panel, the other in the engine
compartment near the battery. A fuse panel chart is
provided later in this section.
If any of your vehicle’s lights, accessories, or controls
do not work, check the appropriate circuit fuse. If a
fuse has blown, the element inside the fuse will be
melted.
Always replace a blown fuse with one of the same
rating.
If the replacement fuse blows out, this indicates an
electrical problem. Avoid using the system involved
and immediately consult an Authorized Kia Dealer.
Two kinds of fuses are used: standard for lower
amperage rating, and main for higher amperage
ratings.
6-7
Standard
Normal
Normal
Blown
Blown
Main fuse
AS2B06003
Fuse Replacement
If the electrical system does not work, first check the
driver’s side fuse panel.
1.
Turn the ignition switch and all other switches off.
2.
Pull the suspected fuse straight out. Use the
removal tool provided on the main fuse box in the
engine compartment. Refer to the fuse panel chart
on the fuse panel cover to identify the likely
problem fuse or electrical circuit.
3.
Check the removed fuse; replace if it is blown.
Spare fuses are provided in the passenger
compartment fuse panel, and in the engine
compartment fuse panel cover.
4.
Push in a new fuse of the same rating, and make
sure it fits tightly in the clips.
If it fits loosely, consult an Authorized Kia Dealer.
If you do not have a spare, use a fuse of the same
rating from a circuit you may not need for operating
the vehicle, such as the CIGAR or AUDIO fuse.
In Case Of An Emergency
6-8
WARNING -Fuse Replacement
Never replace a fuse with anything but
another fuse of the same type and rating.
A higher capacity fuse could cause damage
and possibly a fire.
Never install a wire in place of the proper
fuse - even as a temporary repair. It may
cause extensive wiring damage and possibly
a fire.
Do not use a screwdriver or any other metal
object to remove fuses because it may cause
a short circuit and damage the system.
1B3106003A
If the headlights or other electrical components do not
work and the fuses are OK, check the fuse box in the
engine compartment. If a fuse is blown, it must be
replaced.
1.
Turn the ignition switch and all other switches off.
2.
Remove the fuse box cover by unhooking the tab on
one end, and tilting the cover back toward the other
end.
3.
Check the fuses. If one is blown, replace it with a
new one of the same rating.
6-9
CAUTION
After checking the fuse box in the engine
compartment, make sure the cover is properly
reinstalled. An improperly installed cover could
allow water ingress and lead to electrical failures.
2FDA602
In Case Of An Emergency
6-10
Fuse Panel Description
Driver’s side kick panel
DESCRIPTION
FUSE
PROTECTED
RATING
COMPONENT
Drive’rs side kick panel
(A/BAG)
10A
Airbag
TURN LAMP
10A
Turn signal lamp
METER
10A
Meterset, Backup lamp,
Warning sound
ILLUMI
10A
Illumination
POWER SOCKET
15A
Trunk room lamp, Power socket
HAZARD
10A
Hazard lamp
STOP
15A
Stop lamp, ABS
TAIL(RH)
10A
Tail lamp
(Right-Rear/Left-Front),
Switch illumination
TAIL(LH)
10A
Tail lamp
(Left-Rear/Right-Front)
CIGAR
15A
Cigarette lighter
AUDIO
10A
Audio, Electric rearview mirror
WIPER(FRT)
15A
Wiper(front), Washer(front),
Sunroof
WIPER(RR)
15A
Wiper(Rear), Washer(Rear)
(WARMER)
15A
Seatwarmer
MIRROR DEF
10A
Mirror defroster
START
10A
Engine control unit,
ECAT unit
*(
):Optional
6-11
Engine compartment
DESCRIPTION
FUSE
PROTECTED
RATING
COMPONENT
Engine Compartment
(ABS)
15A
ABS
RR FOG
10A
Rear fog light (if equipped)
(F/FOG)
15A
Front fog light (if equipped)
MAIN
80A
Battery is not rechargeable
IG 1
30A
(It will be automatically
connect
ed to the secondary fuse.) CIGAR
10A,AUDIO 10A,IG COIL 15A,
TURN LAMP 10A,A/BAG 10A,
WIPER(RR) 15A,WIPER(FRT)
15A,RELAY 10A,START 10A
BLOWER
30A
Heater
COOLING
30A
Cooling
fan
(ABS 1)
30A
ABS
COND. FAN
20A
Condenser fan
HEAD-HI
15A
Head lamp high
HEAD-LOW
15A
Head lamp low
EMS
10A
Engine sensors
INJECTOR
15A
Injector,0
2
sensor
F/PUMP
10A
Fuel pump
ECU
10A
Engine control unit,ECAT
unit,
Main relay
RELAY
10A
Blower motor,Power window,
Rear window defroster,Head
lamp(Airbag equipped vehicle)
(HLLD)
10A
-
*(
):Optional
START
WINDOW
POWER
FUEL
PUMP
FRONT
FOG
A/CON
HEAD
LAMP
COOL.FAN
HORN
TNS
MAIN
IG 1
BLOWER
COOL ING
(ABS 1)
IG 2
COND.F
(
)
(
) (
)
(
)
(
)
COND.FAN
ROOM 15A
IG COIL
(ABS)
D/LOCK
BTN
P/WIN
(ABS 2)
RR DEF
HORN
TNS
RR FOG
(HLLD)
(F/FOG)
HEAD
S/ROOF
MAIN
RELAY
RELAY
ECU
F/PUMP
INJECT
EMS
HEAD
LOW
HEAD
HI
15A
15A
25A
30A
30A
30A
25A
10A
15A
10A
10A
80A
15A
25A
15A
25A
10A
10A
10A
15A
10A
15A
15A
MAIN
30A
30A
30A
30A
30A
20A
* USE THE DESIGNATED FUSE AND RELAY ONLY.
* REFER TO OWNER'S MANUAL FOR FUSE AND RELAY SERVICE.
* (
) : OPTION
In Case Of An Emergency
6-12
DESCRIPTION
FUSE
PROTECTED
RATING COMPONENT
Engine compartment (continued)
MAIN RELAY
25A
(It will be automatically connect
ed
to the secondary fuse.)
EMS 10A, INJECTOR 15A,
F/PUMP 10A, ECU 10A
S/ROOF
15A
Sunroof
HEAD
25A
(It will be automatically connect
ed to the secondary fuse.)
HEAD-HI 15A, HEAD-LOW
15A, FOG LAMP(RR) 10A
IG 2
30A
TNS
15A
(It will be automatically connect
ed to the secondary fuse.)
TAIL (LH) 10A, TAIL(RH) 10A
HORN
10A
Horn
RR DEF
25A
Rear window defroster
(ABS 2)
20A
ABS
P/WIN
30A
Power window
BTN
30A
(It will be automatically connect
ed to the secondary fuse.)
MEMORY/ROOM 10A,
STOP 15A, HAZARD 15A
D/LOCK
25A
Power door lock
IG COIL
15A
Ignition coil
ROOM
15A
Room LAMP, Audio,
Meterset, Warning sound
*(
): Optional
6-13
Memory Fuse (If Equipped)
Your vehicle is equipped with a “Memory Fuse” to
prevent battery discharge if the vehicle is parked for
prolonged periods without being operated. Use the
following procedures before parking the vehicle for a
prolonged period.
1. Turn off the engine.
2. Turn off the headlights and tail lights.
3. Open the main fuse box cover in the engine compartment
and pull up the “ROOM FUSE 15A” using the fuse
puller; push the fuse to the side. This will change the
MEMORY FUSE mode to prevent battery discharge.
FUEL
PUMP
FRONT
FOG
A/CON
HEAD
LAMP
COOL.FAN
HORN
TNS
MAIN
COND.F
(
) (
)
(
)
(
)
COND.FAN
ROOM 15A
IG COIL
(ABS)
(F/FOG)
HEAD
15A
15A
15A
25A
20A
* REFER TO OWNER'S MANUAL FOR FUSE AND RELAY SERVICE.
* (
) : OPTION
RIOMEMORY
CAUTION
If the memory fuse is pulled up from the fuse
box housing, the radio and dome light will not
operate. After reinstalling the “Memory Fuse”,
the radio “anti-theft”code (Optional) must be
entered again and the preset radio stations
must be reselected.
Even though the memory fuse is pulled up, the
battery can still be discharged by operation of
the headlights or other electrical devices.
Engine Compartment
7-13
Engine coolant reservoir
Radiator cap
Engine oil fill cap
Air cleaner
Auto transaxle fluid
dipstick (if equipped)
Brake/clutch
fluid reservoir
Engine oil dipstick
Windshield
washer
fluid
reservoir
Power steering
fluid reservoir
(if equipped)
Fuse box
Battery
2FDA604