Kia Borrego - 2011 Fuse Box Diagram

Kia Borrego - 2011 Fuse Box Diagram

Safety features of your vehicle
46
3
C040300AHM
Occupant detection system
Your vehicle is equipped with an occu-
pant detection system in the front pas-
senger's seat.
The occupant detection system is
designed to detect the presence of a
properly-seated front passenger and
determine if the passenger's front air bag
should be enabled (may inflate) or not.
The driver's front air bag is not affected
or controlled by the occupant detection
system.
WARNING
• If an air bag deploys, there may
be a loud noise followed by a fine
dust released in the vehicle.
These conditions are normal and
are not hazardous - the air bags
are packed in this fine powder.
The dust generated during air
bag deployment may cause skin
or eye irritation as well as aggra-
vate asthma for some persons.
Always wash all exposed skin
areas thoroughly with lukewarm
water and a mild soap after an
accident in which the air bags
were deployed.
The SRS can function only when
the ignition switch is in the ON
position. If the SRS air bag warn-
ing light does not illuminate, con-
tinuously remains on after illumi-
nating for about 6 seconds when
the ignition switch is turned to
the ON position, or after the
engine is started, or comes on
while driving, the SRS is not
working properly. If this occurs,
have your vehicle immediately
inspected by an authorized KIA
dealer.
(Continued)
(Continued)
Before you replace a fuse or dis-
connect a battery terminal, turn
the ignition switch to the LOCK
position and remove the ignition
key. Never remove or replace the
air bag related fuse(s) when the
ignition switch is in the ON posi-
tion. Failure to heed this warning
will cause the SRS air bag warn-
ing light to illuminate.
OHM038050N
Features of your vehicle
24
4
D080104AHM
Power window lock button
The driver can disable the power win-
dow switches on the passenger doors
by pressing the power window lock but-
ton located on the driver’s door to the
LOCK position (pressed).
When the power window lock button
is in the LOCK position (pressed),
the driver’s master control cannot
operate the passenger door power
windows.
CAUTION
• To prevent possible damage to
the power window system, do not
open or close two windows or
more at the same time. This will
also ensure the longevity of the
fuse.
• Never try to operate the main
switch on the driver's door and
the
individual
door
window
switch in the opposing directions
at the same time. If this is done,
the window will stop and cannot
be opened or closed.
WARNING -
Windows
• NEVER leave the ignition key in
the vehicle.
NEVER leave any child unattend-
ed in the vehicle.
Even very
young children may inadvertently
cause the vehicle to move, entan-
gle themselves in the windows,
or otherwise injure themselves or
others.
• Always double check to make
sure all arms, hands, head and
other obstructions are safely out
of the way before closing a win-
dow.
Do not allow children to play with
the power windows. Keep the dri-
ver’s door power window lock
button in the LOCK position
(pressed).
Serious injury can
result from unintentional window
operation by the child.
• Do not extend the any head or
arms outside the window while
driving.
OHM048018N
4 119
Features of your vehicle
D280600AEN
Digital clock
Whenever the battery terminals or relat-
ed fuses are disconnected, you must
reset the time.
When the ignition switch is in the ACC or
ON position, the clock buttons operate as
follows:
D280601AHM
Hour (1)
Pressing the H button will advance the
time displayed by one hour.
D280602AHM
Minute (2)
Pressing the M button will advance the
time displayed by one minute.
D280603AHM
Reset (3)
To clear away minutes, press the R but-
ton. Then the clock will be set precisely
on the hour.
For example, if the R button is pressed
while the time is between 9:01 and 9:29,
the display will reset to 9:00.
9:01 ~ 9:29 display changed to 9:00
9:30 ~ 9:59 display changed to 10:00
D280604AHM
Display conversion
To change the 12 hour format to the 24
hour format, press the R button until the
display blinks.
For example, if the R button is pressed
while the time is 10:15 p.m., the display
will change to 22:15.
OHM048137
OHM048136
Type A
Type B
WARNING
Do not adjust the clock while driv-
ing. You may lose your steering
control and cause an accident that
results in severe personal injury or
death.
5 11
Driving your vehicle
NOTICE
If the battery is weak or the smart key
does not work correctly, you can start
the engine by inserting the smart key
in the smart key holder. When you
pull out the smart key from the smart
key holder, press the smart key and
pull it out.
(Continued)
(Continued)
When the stop lamp fuse is blown, you
can't start the engine normally.
Replace the fuse with a new one. If it
is not possible, you can start the
engine by pressing the ENGINE
START/STOP button for 10 seconds
while it is in the ACC position. The
engine can start without depressing
the brake pedal. But for your safety
always depress the brake pedal before
starting the engine.
CAUTION
Do not press the ENGINE START/
STOP button for more than 10 sec-
onds except when the stop lamp
fuse is blown.
OHM058002
7
Engine compartment / 7-2
Maintenance services / 7-4
Owner maintenance / 7-5
Explanation of scheduled maintenance items / 7-11
Engine oil / 7-14
Engine coolant / 7-15
Brake fluid / 7-18
Power steering fluid / 7-19
Washer fluid / 7-20
Parking brake
/ 7-20
Air cleaner / 7-21
Climate control air filter / 7-21
Wiper blades / 7-22
Battery / 7-25
Tires and wheels / 7-28
Fuses / 7-42
Appearance care / 7-53
Emission control system / 7-67
Maintenance
Maintenance
2
7
ENGINE COMPARTMENT
G010000AHM-EU
OHM018005N
1. Engine coolant reservoir
2. Engine oil filler cap
3. Brake fluid reservoir
4. Air cleaner
5. Fuse box
6. Negative battery terminal
7. Positive battery terminal
8. Radiator cap
9. Engine oil dipstick
10. Power steering fluid reservoir
11. Windshield washer fluid reservoir
* The actual engine room in the vehicle may differ from the illustration.
3.8L
7 3
Maintenance
OHM018004N
1. Engine coolant reservoir
2. Engine oil filler cap
3. Brake fluid reservoir
4. Air cleaner
5. Fuse box
6. Negative battery terminal
7. Positive battery terminal
8. Radiator cap
9. Engine oil dipstick
10. Power steering fluid reservoir
11. Windshield washer fluid reservoir
4.6L
* The actual engine room in the vehicle may differ from the illustration.
Maintenance
42
7
FUSES
G210000AHM
A vehicle’s electrical system is protected
from electrical overload damage by
fuses.
This vehicle has 5 fuse panels, one locat-
ed in the driver’s side panel bolster, the
others in the engine compartment and
luggage compartment.
If any of your vehicle’s lights, acces-
sories, or controls do not work, check the
appropriate circuit fuse. If a fuse has
blown, the element inside the fuse will
melt.
If the electrical system does not work,
first check the driver’s side fuse panel.
Always replace a blown fuse with one of
the same rating.
If the replacement fuse blows, this indi-
cates an electrical problem. Avoid using
the system involved and immediately
consult an authorized KIA dealer.
Three kinds of fuses are used: blade type
for lower amperage rating, cartridge type,
and fusible link for higher amperage rat-
ings.
1VQA4037
Normal
Normal
Blade type
Cartridge type
Fusible link
Blown
Blown
Normal
Blown
WARNING
- Fuse replace-
ment
• Never replace a fuse with any-
thing but another fuse of the
same rating.
• A higher capacity fuse could
cause damage and possibly a
fire.
• Never install a wire or aluminum
foil instead of the proper fuse -
even as a temporary repair. It may
cause extensive wiring damage
and a possible fire.
CAUTION
Do not use a screwdriver or any
other metal object to remove fuses
because it may cause a short circuit
and damage the system.
7 43
Maintenance
G210100AHM
Inner panel fuse replacement
1. Turn the ignition switch and all other
switches off.
2. Open the fuse panel cover.
3. Pull the suspected fuse straight out.
Use the removal tool provided in the
main fuse box in the engine compart-
ment.
4. Check the removed fuse; replace it if it
is blown.
Spare fuses are provided in the instru-
ment panel fuse panel (or in the engine
compartment fuse panel).
5. Push in a new fuse of the same rating,
and make sure it fits tightly in the clips.
If it fits loosely, consult an authorized KIA
dealer.
If you do not have a spare, use a fuse of
the same rating from a circuit you may
not need for operating the vehicle, such
as the cigarette lighter fuse.
If the headlights or other electrical com-
ponents do not work and the fuses are
OK, check the fuse panel in the engine
compartment. If a fuse is blown, it must
be replaced.
OHM078022
OHM078021
OHM078057
Front
Rear
Maintenance
44
7
G210101AHM
Memory fuse (SHUNT connector)
Your vehicle is equipped with a memory
fuse (SHUNT connector) to prevent bat-
tery discharge if your vehicle is parked
without being operated for prolonged
periods. Use the following procedures
before parking the vehicle for prolonged
periods.
1. Turn off the engine.
2. Turn off the headlights and tail lights.
3. Open the driver’s side panel cover and
pull out the memory fuse (SHUNT
connector).
NOTICE
If the memory fuse is pulled out from
the fuse panel, the warning chime,
audio, clock and interior lamps, etc.,
will not operate. Some items must be
reset after
replacement. Refer
to
“Battery” in this section.
• Even though the memory fuse is
pulled out, the battery can still be dis-
charged by operation of the head-
lights or other electrical devices.
G210200AHM
Engine compartment fuse
replacement
1. Turn the ignition switch and all other
switches off.
2. Remove the fuse panel cover by
pressing the tab and pulling the cover
up.
OHM078023
OHM078024N
OHM078025N
7 45
Maintenance
3. Check the removed fuse; replace it if it
is blown. To remove or insert the fuse,
use the fuse puller in the engine com-
partment fuse panel.
4. Push in a new fuse of the same rating,
and make sure it fits tightly in the clips.
If it fits loosely, consult an authorized
KIA dealer.
G210201AUN
Main fuse
If the main fuse is blown, it must be
removed as follows:
1. Disconnect the negative battery cable.
2. Remove the nuts shown in the picture
above.
3. Replace the fuse with a new one of the
same rating.
4. Reinstall in the reverse order of
removal.
NOTICE
If the main fuse is blown, consult an
authorized KIA dealer.
CAUTION
After checking the fuse panel in the
engine
compartment,
securely
install the fuse panel cover. If not,
electrical failures may occur from
water contact.
OHM078026L
Maintenance
46
7
NOTICE
Not all fuse panel descriptions in this
manual may be applicable to your vehi-
cle. It is accurate at the time of printing.
When you inspect the fuse panel in your
vehicle, refer to the fuse panel label.
G210300BHM-EU
Fuse/relay panel description
Inside the fuse/relay panel covers, you can find the fuse/relay label describing fuse/relay name and capacity.
Inner fuse panel
Engine compartment fuse panel
OHM078027/OHM078043N/OHM078028N/OHM078029N
7 47
Maintenance
Inner fuse panel (Instrument panel)
Description
Fuse rating
Protected component
AUDIO
15A
Audio, Rear Monitor, RSE Control Box, DVD Player Can
MEMORY
7.5A
Front A/C Control Module, Rear A/C Control Module, Instrument Cluster (IND.), RF Receiver, FAM, RAM, Driver
Door Module, Assistant Door Module, Tilt & Telescopic Module, IMS Control Module
Front A/C Control Module, Incar Temperature Sensor, PDM, Multifunction Switch (Wiper/Washer),
IG2-1
7.5A
Driver/Passenger Seat Warmer Module, Front Blower Relay, Electro Chromic Mirror, Rear Blower Relay,
AC Inverter Switch, Trailer Relay, C/FAN HI/LOW Relay
IG2-2
7.5A
Rear A/C Control Module, Driver Door Module, FAM, Assistant Door Module, IMS Control Module,
Tilt & Telescopic Module
SMART KEY
7.5A
Start Stop Button Switch, PDM,Smart Key Control Module, Fob Holder
ROOM
7.5A
Electronic Chrome Mirror, Map Lamp, Vanity Lamp Switch LH/RH, Front/Rear A/C Control Module,
Center Room Lamp, Rear Room Lamp
KEY LOCK
7.5A
Sport Mode Switch, Ignition Lock Switch
ILLUMI
7.5A
IPM
RR S/WARMER
20A
Rear Seat Warmer Relay
FRT S/WARMER
20A
Driver Seat Warmer Module, Passenger Seat Warmer Module
SUNROOF
25A
Sunroof Module
TPMS
7.5A
Tire Pressure Monitoring Module, Data Link Connector, Multipurpose Check Connector
PEDAL
15A
Adjustable Pedal Relay
F/PWR OUTLET
15A
Front Power Outlet
S/TILT & TELE
20A
Tilt & Telescopic Module
PASS P/SEAT
20A
Passenger Power Seat Switch
DRIVER P/SEAT
30A
Driver Power Seat Switch, Lumbar Support Switch, IMS Control Module
ACC
7.5A
Audio, Front A/C Control Module, Rear monitor, RSE Control Box, Smart Key Control Module, DVD Player Can
Maintenance
48
7
Description
Fuse rating
Protected component
START
7.5A
Burglar Alarm Relay, Start Relay
AIR BAG IND.
7.5A
Instrument Cluster (Air Bag IND.)
ABS
7.5A
ABS Control Module, ESC Control Module, DBC Relay, Steering Angle Sensor, Crash Pad Switch LH,
Smart Key Control Module, Rear Parking Assist Control Module
Rheostat, Instrument Cluster (MICOM), Multifunction Switch (Cruise Remocon), Generator,
IGN 1
7.5A
Rear Parking Assist Buzzer, Rear Parking Assist Switch, Audio, PODS Module,
Tire Pressure Monitoring Module
ENG
7.5A
Multipurpose Check Connector, ECM, TCM, Front Wiper Motor, 4WD ECM, Stop Lamp Switch,
Free Running Differential Air Pump, Generator (G8BA)
AIR BAG
15A
SRS Control Module, Telltale Lamp
DDM
30A
Driver Door Module, Driver Safety Power Window Motor
ADM
30A
Assistant Door Module, Passenger Safety Power Window Motor
7 49
Maintenance
Inner fuse panel (Luggage compartment)
FUSE
Fuse rating
Circuit Protected
RR DEFOG
25A
RR Defog Relay, Rear Defogger (+)
T/G POWER LATCH
30A
Tail Gate Control Module
RR WIPER
15A
Rear Wiper Motor Relay (+), Rear Wiper Motor
DOOR LOCK
15A
Rear Door Lock Actuator LH/RH, Rear Door Lock/Unlock Relay
CTR P/OUT
15A
Console Power Outlet
RR P/OUT
15A
Rear Power Outlet
FUEL DR
15A
Fuel Door Relay, Fuel Filler Door Actuator
TRAILER3
15A
Tail Lamp Converter (Back up)
RR P/WIN-LH
20A
Rear Power Window Relay LH(UP/DH), Rear Power Window Motor LH
RR P/WIN-RH
20A
Rear Power Window Relay RH(UP/DH), Rear Power Window Motor RH(DN)
LUGGAGE
7.5A
Luggage Lamp
AMP
30A
AMP
TRAILER2
30A
Tail Lamp Converter (Tail)
Maintenance
50
7
Engine compartment main fuse panel
Description
Fuse rating
Protected component
FRT/RR WASHER
10A
Front/Rear Washer Motor Relay, Washer Motor
TRAILER 5
15A
Tail Lamp Converter (Turn/Stop)
STOP LAMP
20A
Stop Lamp Switch, DBC Relay
KEY SW 1
25A
Ignition Switch, PDM Relay Box (IG1 Relay , ACC Relay)
STOP SIGNAL
7.5A
ABS Control Module, ESC Control Module, ECM, Smart Key Control Module
A/C COMP
7.5A
A/C Comp Relay
FRT DEICER
15A
Front Deicer Relay
HORN
15A
Horn Relay
ECU 1
10A
ECM, Mass Air Flow Sensor, Immobilizer Module, A/C Comp Relay
O2 DN
10A
Oxygen Sensor #3,#4
ECU 2
15A
Oil Control Valve, ECM, Variable Intake Manifold Valve, Purge Control Solenoid Valve, Canister Close Valve
O2 UP
10A
Oxygen Sensor #1,#2
IGN COIL
20A
Ignition Coil #1~#8, Condenser #1,#2
INJECTOR
15A
ECM, Injector #1~#8, Camshaft Position Sensor #1 ~ #3 (G8BA)
P/TRAIN
7.5A
ECM, Main Relay, Relay Box(Burglar Horn Relay), Generator (G8BA)
FUEL PUMP
15A
Fuel Pump Relay, Fuel Sender & Fuel Pump Motor
ATM
15A
TCM
7 51
Maintenance
Description
Fuse rating
Protected component
ABS 2
40A
ABS Control Module
ABS 1
40A
ABS Control Module
PDM
20A
PDM
FRT WIPER
30A
Front Wiper ON Relay, Front Wiper HI/LO Relay
KEY SW 2
30A
Start Relay #1, Ignition Switch, PDM Relay Box (IG2 Relay)
RAM 1
50A
RAM(CTR P/OUT FUSE 15A, RR P/OUT FUSE 15A, FUEL DR FUSE 15A, RR P/WIN-LH FUSE 20A,
RR P/WIN-RH FUSE 20A, LUGGAGE FUSE 7.5A)
RAM 2
50A
RAM(RR DEFOG FUSE 25A, T/G POWER LATCH FUSIBLE LINK 30A, DOOR LOCK FUSE 15A,
RR WIPER FUSE 15A)
RAM 3
50A
RAM (AMP FUSIBLE LIMK 30A TRAILER 2 FUSIBLE LINK 30A)
IPM 1
50A
IPM (ILLUMI FUSE 7.5A, DDM FUSIBLE LINK 30A, FRT S/WARMER FUSE 20A, OBD-II FUSE 7.5A,
SUNROOF FUSE 25A, KEY LOCK FUSE 7.5A)
IPM 2
50A
IPM (ADM FUSIBLE LINK 30A, F/PWR OUTLET FUSE 15A, PEDAL FUSE 15A, S/TILT & TELE FUSE 20A)
IPM 3
50A
IPM (MEMORY FUSE 7.5A, DRIVER P/SEAT FUSE 30A, PASS P/SEAT FUSE 20A,
RR S/WARMER FUSE 20A, ROOM FUSE 7.5A, AUDIO FUSE 15A)
4WD
30A
4WD ECM
AC 110V
30A
AC inverter module
Maintenance
52
7
Engine compartment sub fuse panel
Description
Fuse rating
Protected component
C/FAN LOW
30A
C/Fan Low Relay
E/BRAKE
30A
Trailer Electric Brake
FRONT BLOWER
40A
Front Blower Relay
REAR BLOWER
30A
Rear Blower Relay
C/FAN HI
60A
C/Fan Hi Relay
TRAILER 1
30A
Trailer Relay