Ford Mondeo - 2010 Fuse Box Diagram

Ford Mondeo - 2010 Fuse Box Diagram

The LED on the transmitter flashes orange
for about 5 seconds. This indicates that
the signal was not transmitted. The
transmitter batteries are discharged and
should be changed as soon as possible.
Changing the remote control
battery
Make sure that you dispose of old
batteries in an environmentally friendly
way. Seek advice from your local authority
regarding recycling.
E114361
2
1
1.
Insert a screwdriver or other suitable
tool into the slot on the back of the
remote control, and unscrew the
compartment cover.
CAUTION
Do not touch the battery contacts or
the printed circuit board with the
screwdriver.
2.
Carefully prise out the battery.
3.
Install a new battery (3.3V type
CR1-3N) with the
+
facing upwards.
4.
Re-assemble the remote control.
Programming the transmitter
Further transmitters may be used with the
remote system, please consult your
dealer. Up to a maximum of 3 separate
remote controls may be added. When
adding extra transmitters these must be
programmed separately.
Note:
The heater must be switched off
during programming.
Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 176).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
ELECTRIC SUNROOF
E78054
111
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
E72589
1.
Loosen the screws.
E72590
2.
Turn the knob through 90 degrees
and release the fuse box from the
retaining bracket.
3.
Lower the fuse box and pull it towards
you.
E72622
4.
Remove the cover to gain access to
the fuses (vehicles with a cooled glove
box).
5.
Install in the reverse order.
173
Fuses
Rear fuse box - 4-door and 5-
door
1
E87481
1.
Remove the cover.
2
E87482
2.
Remove the relevant fuse box cover.
Rear fuse box - Estate
1
2
E87479
1.
Release the catches.
2.
Remove the cover.
3
3
3
E87480
3.
Remove the relevant fuse box cover.
174
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
175
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Colour
Ampere
rating
Fuse
Transmission control module
red
10
F1
Glow plug monitoring (diesel engines)
tan
5
F2
176
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Engine cooling fan - twin fan (2.3L Duratec-
HE)
brown
70
1
F3
Electric hydraulic power steering (EHPAS)
(2.0L Duratorq-TDCi)
clear
80
1
F3
Glow plugs
yellow
60
F4
Engine cooling fan
yellow
60
F5
HEGO sensors 1 (engine management),
variable valve timing (engine management),
CMS sensor, Oxygen sensor
red
10
F6
Relay coils
tan
5
F7
Powertrain control module
red
10
F8
MAF Sensor, Swirl Control Valve , Fuel
Injectors, CCV PTC Heater, Variable Intake
Valve, Variable Exhaust Valve (engine
management)
red
10
F9
Engine control module
red
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor,
Sonic Purge Valve, Swirl Control Valve, Vari-
able Intake Valve, EGR Valve, IVVT Oil Control
Valve (engine management)
red
10
F11
EGR Throttle, Variable Turbo Control Valve,
Coil on Plug; Canister Purge Valve, Power
Steering Pressure Switch (engine manage-
ment)
red
10
F12
Air conditioning relay
blue
15
F13
Diesel filter heater
blue
15
F14
Starter relay
orange
40
F15
Diesel auxiliary heater (PTC)
clear
80
F16
Central fuse box supply A
yellow
60
F17
Central fuse box supply B
yellow
60
F18
Rear fuse box supply C
yellow
60
F19
Rear fuse box supply D
yellow
60
F20
177
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Not used
F21
Windscreen wiper module
green
30
F22
Heated rear window
clear
25
1
F23
Headlamp washer
green
30
F24
ABS valves
green
30
F25
ABS pump
orange
40
F26
Fuel fired heater
green
30
F27
Heater blower
orange
40
F28
Not used
F29
Not used
F30
Horn
blue
15
F31
Fuel fired heater - remote control
tan
5
F32
Light switch module, engine compartment
fuse box coils
tan
5
F33
Heated windscreen (left-hand side)
orange
40
F34
Heated windscreen (right-hand side)
orange
40
F35
ABS
tan
5
F36
Heated front washer jets
red
10
F37
Adaptive cruise control (ACC)
tan
5
F38
Adaptive front lighting system (AFS)
blue
15
F39
Not used
F40
Instrument panel
yellow
20
F41
Engine control module, transmission control
module, electric hydraulic power steering
(EHPAS) 15 feed
red
10
F42
Headlamp levelling, adaptive front lighting
system (AFS)
tan
5
F43
Not used
-
-
F44
178
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Rear window wiper
blue
15
F45
1
Fit a replacement with the same rating as the one you have removed.
Central fuse box
E75527
Circuits protected
Colour
Ampere
rating
Fuse
Rain sensor
tan
5
F1
SRS (airbag) supply
red
10
F2
Yaw rate sensor (ESP), accelerator pedal
supply
brown
7.5
F3
179
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Electronic feed, electronic fuse
brown
7.5
F4
Not used
-
-
F5
Audio system (including voice control)
blue
15
F6
Steering wheel module
brown
7.5
F7
Instrument cluster
tan
5
F8
Main beam
blue
15
F9
Power sunroof
yellow
20
F10
Reversing lamps
brown
7.5
F11
Not used
F12
Front fog lamp
blue
15
F13
Windscreen washers
blue
15
F14
Adaptive cruise control (ACC)
red
10
F15
Not used
F16
Interior lamps
red
10
F17
Engine immobiliser
tan
5
F18
Cigar lighter
blue
15
F19
Not used
F20
Remote frequency receiver, Interior motion
sensor
tan
5
F21
Fuel pump
yellow
20
F22
Fuel pump (2.2L Duratorq)
brown
7.5
F22
Not used
F23
Ignition switch
tan
5
F24
Fuel filler flap
red
10
F25
Battery backup sounder (alarm system),
OBD II (board computer diagnostics)
tan
5
F26
Steering column unit, climate control module
tan
5
F27
180
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Brake lamp switch
tan
5
F28
Rear fuse box
4-door and 5-door
E87483
181
Fuses
Estate
E75526
Circuits protected
Colour
Ampere
rating
Fuse
Door module (left-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA1
182
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Door module (right-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA2
Door module (left-hand rear) (window up/
down)
clear
25
FA3
Door module (right-hand rear) (window up/
down)
clear
25
FA4
Rear locking (without rear door modules)
red
10
FA5
Auxiliary power socket
blue
15
FA6
Relay coils
tan
5
FA7
Steering column lock
yellow
20
FA8
Not used
FA9
Electric driver's seat
green
30
FA10
Accessories, trailer module
yellow
20
FA11
Not used
FA12
Parking aid module
tan
5
FB1
Suspension module
blue
15
FB2
Heated driver's seat
blue
15
FB3
Heated front passenger seat
blue
15
FB4
Left-hand rear heated seat
blue
15
FB5
Not used
-
-
FB6
Right-hand rear heated seat
blue
15
FB7
Not used
FB8
Electric front passenger seat
green
30
FB9
Anti-theft alarm horn
red
10
FB10
Not used
FB11
Not used
FB12
Not used
-
-
FC1
183
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Not used
-
-
FC2
Not used
-
-
FC3
Not used
-
-
FC4
CD changer, rear seat entertainment system
brown
7.5
FC5
Not used
-
-
FC6
Seat memory function module
tan
5
FC7
Keyless entry
yellow
20
FC8
Not used
FC9
Not used
FC10
Not used
FC11
Not used
FC12
184
Fuses
ENGINE COMPARTMENT OVERVIEW - 1.6L DURATEC-16V
TI-VCT (SIGMA)
A
C
G
J
F
D
E
B
H
I
E87714
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
. See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 198).
C
Battery. See
Vehicle battery
(page 204).
D
Engine compartment fuse box. See
Fuses
(page 173).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 199).
G
Engine oil dipstick
1
. See
Engine oil check
(page 197).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
198).
I
Engine coolant reservoir. See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
189
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
. See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 198).
C
Battery. See
Using booster cables
(page 204).
D
Engine compartment fuse box. See
Fuse specification chart
(page 176).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 199).
G
Engine oil dipstick
1
. See
Engine oil check
(page 197).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
198).
I
Engine coolant reservoir. See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
190
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
. See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 198).
C
Battery. See
Using booster cables
(page 204).
D
Engine compartment fuse box. See
Fuse specification chart
(page 176).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 199).
G
Engine oil dipstick
1
. See
Engine oil check
(page 197).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
198).
I
Engine coolant reservoir. See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
191
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.5L DURATEC (VI5)
A
C
G
J
I
F
D
E
B
H
E73232
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
. See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 198).
C
Battery. See
Using booster cables
(page 204).
D
Engine compartment fuse box. See
Fuse specification chart
(page 176).
E
Screen washer fluid reservoir. See
Washer fluid check
(page 199).
F
Air cleaner. No maintenance necessary.
G
Engine oil dipstick
1
. See
Engine oil check
(page 197).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
198).
I
Engine coolant reservoir. See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
192
Maintenance
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL
A
C
G
J
I
F
D
E
B
H
E73233
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
. See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 198).
C
Battery. See
Using booster cables
(page 204).
D
Engine compartment fuse box. See
Fuse specification chart
(page 176).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 199).
G
Engine oil dipstick
1
. See
Engine oil check
(page 197).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
198).
I
Engine coolant reservoir. See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
193
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
I
F
D
E
B
H
E73234
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
. See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 198).
C
Battery. See
Using booster cables
(page 204).
D
Engine compartment fuse box. See
Fuse specification chart
(page 176).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 199).
G
Engine oil dipstick
1
. See
Engine oil check
(page 197).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
198).
I
Engine coolant reservoir. See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
194
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 198).
A
Engine oil filler cap
1
: See
Engine oil check
(page 197).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 198).
C
Battery: See
Vehicle battery
(page 204).
D
Engine compartment fuse box: See
Fuses
(page 173).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 199).
G
Engine oil dipstick
1
: See
Engine oil check
(page 197).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
198).
I
Engine coolant reservoir: See
Engine coolant check
(page 197).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
195
Maintenance
Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 186).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater
(depending on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
The fuel operated heater aids in warming
the engine and the vehicle interior on
vehicles with a diesel engine. It is switched
on or off automatically depending on the
outside air temperature and the coolant
temperature, unless you have deactivated
it. When the fuel operated heater is
operating,
Aux. Heater on
is displayed
in the information display. See
Information displays
(page 78).
To deactivate the fuel operated heater:
E70499
1.
Press the right arrow button on the
steering wheel to enter the main
menu.
2.
Highlight
Setup
with the up and down
arrow buttons and press the right
arrow button.
3.
Highlight
Aux. Heater
and press the
OK
button to toggle the heater on and
off. A cross appears in the box when
the heater is activated.
4.
Press the left arrow button to exit the
menu. Hold the left arrow button
pressed to return to the trip computer
display.
Diesel auxiliary heater
(depending on country)
The diesel auxiliary heater (PTC electrical
heater) aids in warming the vehicle interior
on vehicles with a diesel engine. It is
switched on or off automatically
depending on the outside air temperature,
the coolant temperature and the
alternator load.
110
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Loosen the screws.
E72590
2. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
3. Lower the fuse box and pull it towards
you.
Vehicles built up to: 07-02-2010
E72622
4. Remove the cover to gain access to
the fuses (vehicles with a cooled glove
box).
All vehicles
5. Install in the reverse order.
174
Fuses
Rear fuse box - 4-door and 5-
door
1
E87481
1.
Remove the cover.
2
E87482
2.
Remove the relevant fuse box cover.
Rear fuse box - Estate
1
2
E87479
1.
Release the catches.
2.
Remove the cover.
3
3
3
E87480
3.
Remove the relevant fuse box cover.
175
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
176
Fuses
FUSE SPECIFICATION CHART - VEHICLES BUILT UP TO: 07-
02-2010
Engine compartment fuse box
E75525
Circuits protected
Colour
Ampere
rating
Fuse
Transmission control module
red
10
F1
Glow plug monitoring (diesel engines)
tan
5
F2
177
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Engine cooling fan - twin fan (2.3L Duratec-
HE)
brown
70
1
F3
Electric hydraulic power steering (EHPAS)
(2.0L Duratorq-TDCi)
clear
80
1
F3
Glow plugs
yellow
60
F4
Engine cooling fan
yellow
60
F5
HEGO sensors 1 (engine management),
variable valve timing (engine management),
CMS sensor, Oxygen sensor
red
10
F6
Relay coils
tan
5
F7
Powertrain control module
red
10
F8
MAF Sensor, Swirl Control Valve , Fuel
Injectors, CCV PTC Heater, Variable Intake
Valve, Variable Exhaust Valve (engine
management)
red
10
F9
Engine control module
red
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor,
Sonic Purge Valve, Swirl Control Valve, Vari-
able Intake Valve, EGR Valve, IVVT Oil Control
Valve (engine management)
red
10
F11
EGR Throttle, Variable Turbo Control Valve,
Coil on Plug; Canister Purge Valve, Power
Steering Pressure Switch (engine manage-
ment)
red
10
F12
Air conditioning relay
blue
15
F13
Diesel filter heater
blue
15
F14
Starter relay
orange
40
F15
Diesel auxiliary heater (PTC)
clear
80
F16
Central fuse box supply A
yellow
60
F17
Central fuse box supply B
yellow
60
F18
Rear fuse box supply C
yellow
60
F19
Rear fuse box supply D
yellow
60
F20
178
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Not used
F21
Windscreen wiper module
green
30
F22
Heated rear window
clear
25
1
F23
Headlamp washer
green
30
F24
ABS valves
green
30
F25
ABS pump
orange
40
F26
Fuel fired heater
green
30
F27
Heater blower
orange
40
F28
Not used
F29
Not used
F30
Horn
blue
15
F31
Fuel fired heater - remote control
tan
5
F32
Light switch module, engine compartment
fuse box coils
tan
5
F33
Heated windscreen (left-hand side)
orange
40
F34
Heated windscreen (right-hand side)
orange
40
F35
ABS
tan
5
F36
Heated front washer jets
red
10
F37
Adaptive cruise control (ACC)
tan
5
F38
Adaptive front lighting system (AFS)
blue
15
F39
Not used
F40
Instrument panel
yellow
20
F41
Engine control module, transmission control
module, electric hydraulic power steering
(EHPAS) 15 feed
red
10
F42
Headlamp levelling, adaptive front lighting
system (AFS)
tan
5
F43
Not used
-
-
F44
179
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Rear window wiper
blue
15
F45
1
Fit a replacement with the same rating as the one you have removed.
Central fuse box
E75527
Circuits protected
Colour
Ampere
rating
Fuse
Rain sensor
tan
5
F1
SRS (airbag) supply
red
10
F2
Yaw rate sensor (ESP), accelerator pedal
supply
brown
7.5
F3
180
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Electronic feed, electronic fuse
brown
7.5
F4
Not used
-
-
F5
Audio system (including voice control)
blue
15
F6
Steering wheel module
brown
7.5
F7
Instrument cluster
tan
5
F8
Main beam
blue
15
F9
Power sunroof
yellow
20
F10
Reversing lamps
brown
7.5
F11
Not used
F12
Front fog lamp
blue
15
F13
Windscreen washers
blue
15
F14
Adaptive cruise control (ACC)
red
10
F15
Not used
F16
Interior lamps
red
10
F17
Engine immobiliser
tan
5
F18
Cigar lighter
blue
15
F19
Not used
F20
Remote frequency receiver, Interior motion
sensor
tan
5
F21
Fuel pump
yellow
20
F22
Fuel pump (2.2L Duratorq)
brown
7.5
F22
Not used
F23
Ignition switch
tan
5
F24
Fuel filler flap
red
10
F25
Battery backup sounder (alarm system),
OBD II (board computer diagnostics)
tan
5
F26
Steering column unit, climate control module
tan
5
F27
181
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Brake lamp switch
tan
5
F28
Rear fuse box
4-door and 5-door
E87483
182
Fuses
Estate
E75526
Circuits protected
Colour
Ampere
rating
Fuse
Door module (left-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA1
183
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Door module (right-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA2
Door module (left-hand rear) (window up/
down)
clear
25
FA3
Door module (right-hand rear) (window up/
down)
clear
25
FA4
Rear locking (without rear door modules)
red
10
FA5
Auxiliary power socket
blue
15
FA6
Relay coils
tan
5
FA7
Steering column lock
yellow
20
FA8
Not used
FA9
Electric driver's seat
green
30
FA10
Accessories, trailer module
yellow
20
FA11
Not used
FA12
Parking aid module
tan
5
FB1
Suspension module
blue
15
FB2
Heated driver's seat
blue
15
FB3
Heated front passenger seat
blue
15
FB4
Left-hand rear heated seat
blue
15
FB5
Not used
-
-
FB6
Right-hand rear heated seat
blue
15
FB7
Not used
FB8
Electric front passenger seat
green
30
FB9
Anti-theft alarm horn
red
10
FB10
Not used
FB11
Not used
FB12
Not used
-
-
FC1
184
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Not used
-
-
FC2
Not used
-
-
FC3
Not used
-
-
FC4
CD changer, rear seat entertainment system
brown
7.5
FC5
Not used
-
-
FC6
Seat memory function module
tan
5
FC7
Keyless entry
yellow
20
FC8
Not used
FC9
Not used
FC10
Not used
FC11
Not used
FC12
185
Fuses
FUSE SPECIFICATION CHART - VEHICLES BUILT FROM: 08-
02-2010
Engine compartment fuse box
E75525
Circuits protected
Colour
Ampere
rating
Fuse
Transmission control module (AWF21)
red
10
F1
Transmission control module (MPS6)
blue
15
F1
186
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Glow plug monitoring (diesel engines)
tan
5
F2
Vaporiser glow plug monitoring (DW10c)
tan
5
F2
Engine cooling fan - twin fan (2.3L Duratec-
HE)
brown
70
1
F3
Electric hydraulic power steering (EHPAS)
(2.0L Duratorq-TDCi)
clear
80
1
F3
Glow plugs
yellow
60
F4
Engine cooling fan
yellow
60
F5
HEGO sensors 1 (engine management),
variable valve timing (engine management),
CMS sensor, Oxygen sensor
red
10
F6
Vaporiser glow plug
yellow
20
F6
Relay coils
tan
5
F7
Powertrain control module
red
10
F8
Powertrain control module (2.0L EcoBoost
SCTi, 2.0L Duratorq TDCi - DW10c)
yellow
20
F8
MAF Sensor, Swirl Control Valve , Fuel
Injectors, CCV PTC Heater, Variable Intake
Valve, Variable Exhaust Valve (engine
management)
red
10
F9
Fuel pump vaporiser (2.0L Duratorq TDCi -
DW10c)
tan
5
F9
Engine control module
red
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor,
Sonic Purge Valve, Swirl Control Valve, Vari-
able Intake Valve, EGR Valve, IVVT Oil Control
Valve (engine management)
red
10
F11
MAF sensor, Water in Fuel Sensor (DW10c)
tan
5
F11
Ignition coils (2.0L EcoBoost SCTi)
blue
15
F12
187
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
EGR Throttle, Variable Turbo Control Valve,
Coil on Plug; Canister Purge Valve, Power
Steering Pressure Switch (engine manage-
ment)
red
10
F12
Relay coils (DW10c)
tan
5
F12
Air conditioning relay
blue
15
F13
Diesel filter heater
blue
15
F14
Brake vacuum pump
yellow
20
F14
Starter relay
orange
40
F15
Diesel auxiliary heater (PTC)
clear
80
F16
Central fuse box supply A
yellow
60
F17
Central fuse box supply B
yellow
60
F18
Rear fuse box supply C
yellow
60
F19
Rear fuse box supply D
yellow
60
F20
Not used
F21
Windscreen wiper module
green
30
F22
Heated rear window
clear
25
1
F23
Headlamp washer
green
30
F24
ABS valves
green
30
F25
ABS pump
orange
40
F26
Fuel fired heater
green
30
F27
Heater blower
orange
40
F28
Not used
F29
Not used
F30
Horn
blue
15
F31
Fuel fired heater - remote control
tan
5
F32
Light switch module, engine compartment
fuse box coils
tan
5
F33
188
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Heated windscreen (left-hand side)
orange
40
F34
Heated windscreen (right-hand side)
orange
40
F35
ABS
tan
5
F36
Heated front washer jets
red
10
F37
Adaptive cruise control (ACC)
tan
5
F38
Adaptive front lighting system (AFS)
blue
15
F39
Not used
F40
Instrument panel
yellow
20
F41
Engine control module, transmission control
module, electric hydraulic power steering
(EHPAS) 15 feed
red
10
F42
Headlamp levelling, adaptive front lighting
system (AFS)
tan
5
F43
Not used
-
-
F44
Rear window wiper
blue
15
F45
1
Fit a replacement with the same rating as the one you have removed.
189
Fuses
Central fuse box
E124888
Circuits protected
Colour
Ampere
rating
Fuse
Steering wheel module
brown
7.5
F1
Instrument cluster
tan
5
F2
Interior lamps
red
10
F3
Engine immobiliser
tan
5
F4
190
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Adaptive cruise control (ACC)
brown
7.5
F5
Rain sensor
tan
5
F6
Cigar lighter
blue
15
F7
Fuel filler flap unlock supply
red
10
F8
Windscreen washers - rear
blue
15
F9
Windscreen washers - front
blue
15
F10
Luggage compartment release supply
red
10
F11
Fuel filler flap lock supply
red
10
F12
Fuel pump
yellow
20
F13
Fuel pump (2.2L Duratorq)
brown
7.5
F13
Remote frequency receiver, Interior motion
sensor
tan
5
F14
Ignition switch
tan
5
F15
Battery backup sounder (alarm system),
OBD II (board computer diagnostics)
tan
5
F16
Not used
tan
5
F17
SRS (airbag) supply
red
10
F18
ABS, yaw rate sensor (ESP), electric parking
brake (EPB), accelerator pedal supply
brown
7.5
F19
Electronic feed, electronic fuse
brown
7.5
F20
Audio system (including voice control)
blue
15
F21
Brake lamp switch
tan
5
F22
Sunroof
yellow
20
F23
Steering column unit, climate control module
tan
5
F24
191
Fuses
Rear fuse box
4-door and 5-door
E87483
192
Fuses
Estate
E75526
Circuits protected
Colour
Ampere
rating
Fuse
Door module (left-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA1
193
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Door module (right-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA2
Door module (left-hand rear) (window up/
down)
clear
25
FA3
Door module (right-hand rear) (window up/
down)
clear
25
FA4
Rear locking (without rear door modules)
red
10
FA5
Auxiliary power socket
blue
15
FA6
Relay coils
tan
5
FA7
Keyless vehicle module
yellow
20
FA8
Not used
FA9
Electric driver's seat
green
30
FA10
Accessories, trailer module
yellow
20
FA11
Not used
FA12
Parking aid module
tan
5
FB1
Suspension module
blue
15
FB2
Heated driver's seat
blue
15
FB3
Heated front passenger seat
blue
15
FB4
Left-hand rear heated seat
blue
15
FB5
Not used
-
-
FB6
Right-hand rear heated seat
blue
15
FB7
Not used
FB8
Electric front passenger seat
green
30
FB9
Anti-theft alarm horn
red
10
FB10
Not used
FB11
Not used
FB12
Not used
-
-
FC1
194
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Not used
-
-
FC2
Not used
-
-
FC3
Not used
-
-
FC4
CD changer, rear seat entertainment system
brown
7.5
FC5
Not used
-
-
FC6
Seat memory function module
tan
5
FC7
Keyless entry
yellow
20
FC8
Not used
FC9
Not used
FC10
Not used
FC11
Not used
FC12
195
Fuses
ENGINE COMPARTMENT OVERVIEW - 1.6L DURATEC-16V
TI-VCT (SIGMA)
A
C
G
J
F
D
E
B
H
I
E87714
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Vehicle battery
(page 217).
D
Engine compartment fuse box. See
Fuses
(page 174).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
200
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Using booster cables
(page 217).
D
Engine compartment fuse box. See
Fuse specification chart
(page 177).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
201
Maintenance
ENGINECOMPARTMENTOVERVIEW-2.0LECOBOOSTSCTI
(MI4)
A
C
G
H
J
I
F
D
E
B
E124921
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Using booster cables
(page 217).
D
Engine compartment fuse box. See
Fuse specification chart
(page 186).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
202
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Using booster cables
(page 217).
D
Engine compartment fuse box. See
Fuse specification chart
(page 177).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
203
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.5L DURATEC (VI5)
A
C
G
J
I
F
D
E
B
H
E73232
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Using booster cables
(page 217).
D
Engine compartment fuse box. See
Fuse specification chart
(page 177).
E
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
F
Air cleaner. No maintenance necessary.
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
204
Maintenance
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL
A
C
G
J
I
F
D
E
B
H
E73233
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Using booster cables
(page 217).
D
Engine compartment fuse box. See
Fuse specification chart
(page 177).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
205
Maintenance
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
. See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 211).
C
Battery. See
Using booster cables
(page 217).
D
Engine compartment fuse box. See
Fuse specification chart
(page 186).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
. See
Engine oil check
(page 210).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
211).
I
Engine coolant reservoir. See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
207
Maintenance
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 211).
A
Engine oil filler cap
1
: See
Engine oil check
(page 210).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 211).
C
Battery: See
Vehicle battery
(page 217).
D
Engine compartment fuse box: See
Fuses
(page 174).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 211).
G
Engine oil dipstick
1
: See
Engine oil check
(page 210).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
211).
I
Engine coolant reservoir: See
Engine coolant check
(page 210).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE OIL DIPSTICK - 1.6L
DURATEC-16V TI-VCT
(SIGMA)
E95540
B
A
MIN
A
MAX
B
ENGINEOILDIPSTICK-2.0L
DURATEC-HE (MI4)/2.3L
DURATEC-HE (MI4)
E92036
A
B
MIN
A
MAX
B
208
Maintenance