Ford Galaxy - 2010 Fuse Box Diagram

Ford Galaxy - 2010 Fuse Box Diagram

The LED on the transmitter flashes orange
for about 5 seconds. This indicates that
the signal was not transmitted. The
transmitter batteries are discharged and
should be changed as soon as possible.
Changing the remote control
battery
Make sure that you dispose of old
batteries in an environmentally friendly
way. Seek advice from your local authority
regarding recycling.
E114361
2
1
1.
Insert a screwdriver or other suitable
tool into the slot on the back of the
remote control, and unscrew the
compartment cover.
CAUTION
Do not touch the battery contacts or
the printed circuit board with the
screwdriver.
2.
Carefully prise out the battery.
3.
Install a new battery (3.3V type
CR1-3N) with the
+
facing upwards.
4.
Re-assemble the remote control.
Programming the transmitter
Further transmitters may be used with the
remote system, please consult your
dealer. Up to a maximum of 3 separate
remote controls may be added. When
adding extra transmitters these must be
programmed separately.
Note:
The heater must be switched off
during programming.
Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 194).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
117
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
E72589
1.
Loosen the screws.
E72590
2.
Turn the knob through 90 degrees
and release the fuse box from the
retaining bracket.
3.
Lower the fuse box and pull it towards
you.
E72622
4.
Remove the cover to gain access to
the fuses (vehicles with a cooled glove
box).
5.
Install in the reverse order.
192
Fuses
Rear fuse box
E72591
Release the catches and remove the
cover.
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
193
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Colour
Ampere
rating
Fuse
Transmission control module
red
10
F1
Glow plug monitoring (diesel engines)
tan
5
F2
194
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Engine cooling fan - twin fan (2.3L Duratec-
HE)
brown
70
1
F3
Electric hydraulic power steering (EHPAS)
(2.0L Duratorq-TDCi)
clear
80
1
F3
Glow plugs
yellow
60
F4
Engine cooling fan
yellow
60
F5
HEGO sensor (engine management), CMS
Sensor, Oxygen Sensor
red
10
F6
Relay coils
tan
5
F7
Powertrain control module
red
10
F8
MAF Sensor, Swirl Control Valve , Fuel
Injectors, CCV PTC Heater, Variable Intake
valve, Variable Exhaust Valve (engine
management)
red
10
F9
Engine control module
red
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor,
Sonic Purge Valve, Swirl Control Valve, Vari-
able Intake Valve, EGR Valve, IVVT Oil Control
Valve (engine management)
red
10
F11
Powertrain control module (2.2L Duratec-
HE and 2.3L Duratec-HE)
red
10
F11
EGR Throttle, Variable Turbo Control Valve,
Coil on Plug; Canister Purge Valve, Power
Steering Pressure Switch (engine manage-
ment)
red
10
F12
Glow plug relay, air conditioning (AC) clutch
relay(2.2L Duratorq-TDCi)
red
10
F12
Air conditioning relay
blue
15
F13
Diesel filter heater, fuel metering unit (2.2L
Duratorq-TDCi)
blue
15
F14
Starter relay
orange
40
F15
Diesel auxiliary heater (PTC)
clear
80
F16
195
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Central fuse box supply A
yellow
60
F17
Central fuse box supply B
yellow
60
F18
Rear fuse box supply C
yellow
60
F19
Rear fuse box supply D
yellow
60
F20
Not used
F21
Windscreen wiper module
green
30
F22
Heated rear window
clear
25
1
F23
Headlamp washer
green
30
F24
ABS valves
green
30
F25
ABS pump
orange
40
F26
Fuel fired heater
green
30
F27
Heater blower
orange
40
F28
Not used
F29
Not used
F30
Horn
blue
15
F31
Fuel fired heater - remote control
tan
5
F32
Light switch module, engine compartment
fuse box coils
tan
5
F33
Heated windscreen (left-hand side)
orange
40
F34
Heated windscreen (right-hand side)
orange
40
F35
ABS
tan
5
F36
Heated front washer jets
red
10
F37
Adaptive cruise control (ACC)
tan
5
F38
Adaptive front lighting system (AFS)
blue
15
F39
Not used
F40
Instrument panel
yellow
20
F41
196
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Engine control module, transmission control
module, electric hydraulic power steering
(EHPAS) (2.0L Duratorq-TDCi)
red
10
F42
Headlamp levelling, adaptive front lighting
system (AFS)
tan
5
F43
Not used
-
-
F44
Rear window wiper
blue
15
F45
1
Fit a replacement with the same rating as the one you have removed.
Central fuse box
E75527
197
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Rain sensor
tan
5
F1
SRS (airbag) supply
red
10
F2
ABS, yaw rate sensor (ESP), electric parking
brake (EPB), accelerator pedal supply
brown
7.5
F3
Electronic feed, electronic fuse
brown
7.5
F4
Not used
-
-
F5
Audio system (including voice control)
blue
15
F6
Steering wheel module
brown
7.5
F7
Instrument cluster
tan
5
F8
Main beam
blue
15
F9
Not used
-
-
F10
Reversing lamps
brown
7.5
F11
Not used
F12
Front fog lamp
blue
15
F13
Windscreen washers
blue
15
F14
Adaptive cruise control (ACC)
red
10
F15
Not used
F16
Interior lamps
red
10
F17
Engine immobiliser
tan
5
F18
Cigar lighter
blue
15
F19
Not used
F20
Remote frequency receiver, Interior motion
sensor
tan
5
F21
Fuel pump
yellow
20
F22
Fuel pump (2.2L Duratorq)
brown
7.5
F22
Not used
F23
Ignition switch
tan
5
F24
198
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Fuel filler flap
red
10
F25
Battery backup sounder (alarm system),
OBD II (board computer diagnostics)
tan
5
F26
Steering column unit, climate control module
tan
5
F27
Brake lamp switch
tan
5
F28
199
Fuses
Rear fuse box
E75526
Circuits protected
Colour
Ampere
rating
Fuse
Door module (left-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA1
200
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Door module (right-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA2
Door module (left-hand rear) (window up/
down)
clear
25
FA3
Door module (right-hand rear) (window up/
down)
clear
25
FA4
Rear locking (without rear door modules)
red
10
FA5
Auxiliary power socket
blue
15
FA6
Relay coils
tan
5
FA7
Not used
FA8
Not used
FA9
Electric driver's seat
green
30
FA10
Accessories, trailer module
yellow
20
FA11
Not used
FA12
Parking aid module
tan
5
FB1
Suspension module
blue
15
FB2
Heated driver's seat
blue
15
FB3
Heated front passenger seat
blue
15
FB4
Not used
FB5
Rear climate control
red
10
FB6
Not used
FB7
Not used
FB8
Electric front passenger seat
green
30
FB9
Anti-theft alarm horn
red
10
FB10
Not used
FB11
Not used
FB12
Electric rear quarter windows
brown
7.5
FC1
201
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Electric parking brake (EPB)
green
30
FC2
Electric parking brake (EPB)
green
30
FC3
Rear air conditioning
red
10
FC4
CD changer, rear seat entertainment system
brown
7.5
FC5
Rear air conditioning blower
yellow
20
FC6
Seat memory function module
tan
5
FC7
Not used
FC8
Not used
FC9
Not used
FC10
Not used
FC11
Not used
FC12
202
Fuses
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 215).
A
Engine oil filler cap
1
. See
Engine oil check
(page 214).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 215).
C
Battery. See
Using booster cables
(page 220).
D
Engine compartment fuse box. See
Fuse specification chart
(page 194).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 215).
G
Engine oil dipstick
1
. See
Engine oil check
(page 214).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
215).
I
Engine coolant reservoir. See
Engine coolant check
(page 214).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
207
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 215).
A
Engine oil filler cap
1
. See
Engine oil check
(page 214).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 215).
C
Battery. See
Using booster cables
(page 220).
D
Engine compartment fuse box. See
Fuse specification chart
(page 194).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 215).
G
Engine oil dipstick
1
. See
Engine oil check
(page 214).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
215).
I
Engine coolant reservoir. See
Engine coolant check
(page 214).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
208
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.5L DURATEC (VI5)
A
C
G
J
I
F
D
E
B
H
E73232
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 215).
A
Engine oil filler cap
1
. See
Engine oil check
(page 214).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 215).
C
Battery. See
Using booster cables
(page 220).
D
Engine compartment fuse box. See
Fuse specification chart
(page 194).
E
Screen washer fluid reservoir. See
Washer fluid check
(page 215).
F
Air cleaner. No maintenance necessary.
G
Engine oil dipstick
1
. See
Engine oil check
(page 214).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
215).
I
Engine coolant reservoir. See
Engine coolant check
(page 214).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
209
Maintenance
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL
A
C
G
J
I
F
D
E
B
H
E73233
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 215).
A
Engine oil filler cap
1
. See
Engine oil check
(page 214).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 215).
C
Battery. See
Using booster cables
(page 220).
D
Engine compartment fuse box. See
Fuse specification chart
(page 194).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 215).
G
Engine oil dipstick
1
. See
Engine oil check
(page 214).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
215).
I
Engine coolant reservoir. See
Engine coolant check
(page 214).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
210
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
I
F
D
E
B
H
E73234
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 215).
A
Engine oil filler cap
1
. See
Engine oil check
(page 214).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 215).
C
Battery. See
Using booster cables
(page 220).
D
Engine compartment fuse box. See
Fuse specification chart
(page 194).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 215).
G
Engine oil dipstick
1
. See
Engine oil check
(page 214).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
215).
I
Engine coolant reservoir. See
Engine coolant check
(page 214).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
211
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 215).
A
Engine oil filler cap
1
: See
Engine oil check
(page 214).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 215).
C
Battery: See
Vehicle battery
(page 220).
D
Engine compartment fuse box: See
Fuses
(page 192).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 215).
G
Engine oil dipstick
1
: See
Engine oil check
(page 214).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
215).
I
Engine coolant reservoir: See
Engine coolant check
(page 214).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
212
Maintenance
Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 214).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater
(depending on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
The fuel operated heater aids in warming
the engine and the vehicle interior on
vehicles with a diesel engine. It is switched
on or off automatically depending on the
outside air temperature and the coolant
temperature, unless you have deactivated
it. When the fuel operated heater is
operating,
Aux. Heater on
is displayed
in the information display. See
Information displays
(page 94).
To deactivate the fuel operated heater:
E70499
1.
Press the right arrow button on the
steering wheel to enter the main
menu.
2.
Highlight
Setup
with the up and down
arrow buttons and press the right
arrow button.
3.
Highlight
Aux. Heater
and press the
OK
button to toggle the heater on and
off. A cross appears in the box when
the heater is activated.
4.
Press the left arrow button to exit the
menu. Hold the left arrow button
pressed to return to the trip computer
display.
Diesel auxiliary heater
(depending on country)
The diesel auxiliary heater (PTC electrical
heater) aids in warming the vehicle interior
on vehicles with a diesel engine. It is
switched on or off automatically
depending on the outside air temperature,
the coolant temperature and the
alternator load.
129
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Loosen the screws.
E72590
2. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
3. Lower the fuse box and pull it towards
you.
Vehicles built up to: 07-02-2010
E72622
4. Remove the cover to gain access to
the fuses (vehicles with a cooled glove
box).
All vehicles
5. Install in the reverse order.
212
Fuses
Rear fuse box
E72591
Release the catches and remove the
cover.
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
213
Fuses
FUSE SPECIFICATION CHART - VEHICLES BUILT UP TO: 07-
02-2010
Engine compartment fuse box
E75525
Circuits protected
Colour
Ampere
rating
Fuse
Transmission control module
red
10
F1
Glow plug monitoring (diesel engines)
tan
5
F2
214
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Engine cooling fan - twin fan (2.3L Duratec-
HE)
brown
70
1
F3
Electric hydraulic power steering (EHPAS)
(2.0L Duratorq-TDCi)
clear
80
1
F3
Glow plugs
yellow
60
F4
Engine cooling fan
yellow
60
F5
HEGO sensor (engine management), CMS
Sensor, Oxygen Sensor
red
10
F6
Relay coils
tan
5
F7
Powertrain control module
red
10
F8
MAF Sensor, Swirl Control Valve , Fuel
Injectors, CCV PTC Heater, Variable Intake
valve, Variable Exhaust Valve (engine
management)
red
10
F9
Engine control module
red
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor,
Sonic Purge Valve, Swirl Control Valve, Vari-
able Intake Valve, EGR Valve, IVVT Oil Control
Valve (engine management)
red
10
F11
Powertrain control module (2.2L Duratec-
HE and 2.3L Duratec-HE)
red
10
F11
EGR Throttle, Variable Turbo Control Valve,
Coil on Plug; Canister Purge Valve, Power
Steering Pressure Switch (engine manage-
ment)
red
10
F12
Glow plug relay, air conditioning (AC) clutch
relay(2.2L Duratorq-TDCi)
red
10
F12
Air conditioning relay
blue
15
F13
Diesel filter heater, fuel metering unit (2.2L
Duratorq-TDCi)
blue
15
F14
Starter relay
orange
40
F15
Diesel auxiliary heater (PTC)
clear
80
F16
215
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Central fuse box supply A
yellow
60
F17
Central fuse box supply B
yellow
60
F18
Rear fuse box supply C
yellow
60
F19
Rear fuse box supply D
yellow
60
F20
Not used
F21
Windscreen wiper module
green
30
F22
Heated rear window
clear
25
1
F23
Headlamp washer
green
30
F24
ABS valves
green
30
F25
ABS pump
orange
40
F26
Fuel fired heater
green
30
F27
Heater blower
orange
40
F28
Not used
F29
Not used
F30
Horn
blue
15
F31
Fuel fired heater - remote control
tan
5
F32
Light switch module, engine compartment
fuse box coils
tan
5
F33
Heated windscreen (left-hand side)
orange
40
F34
Heated windscreen (right-hand side)
orange
40
F35
ABS
tan
5
F36
Heated front washer jets
red
10
F37
Adaptive cruise control (ACC)
tan
5
F38
Adaptive front lighting system (AFS)
blue
15
F39
Not used
F40
Instrument panel
yellow
20
F41
216
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Engine control module, transmission control
module, electric hydraulic power steering
(EHPAS) (2.0L Duratorq-TDCi)
red
10
F42
Headlamp levelling, adaptive front lighting
system (AFS)
tan
5
F43
Not used
-
-
F44
Rear window wiper
blue
15
F45
1
Fit a replacement with the same rating as the one you have removed.
Central fuse box
E75527
217
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Rain sensor
tan
5
F1
SRS (airbag) supply
red
10
F2
ABS, yaw rate sensor (ESP), electric parking
brake (EPB), accelerator pedal supply
brown
7.5
F3
Electronic feed, electronic fuse
brown
7.5
F4
Not used
-
-
F5
Audio system (including voice control)
blue
15
F6
Steering wheel module
brown
7.5
F7
Instrument cluster
tan
5
F8
Main beam
blue
15
F9
Not used
-
-
F10
Reversing lamps
brown
7.5
F11
Not used
F12
Front fog lamp
blue
15
F13
Windscreen washers
blue
15
F14
Adaptive cruise control (ACC)
red
10
F15
Not used
F16
Interior lamps
red
10
F17
Engine immobiliser
tan
5
F18
Cigar lighter
blue
15
F19
Not used
F20
Remote frequency receiver, Interior motion
sensor
tan
5
F21
Fuel pump
yellow
20
F22
Fuel pump (2.2L Duratorq)
brown
7.5
F22
Not used
F23
Ignition switch
tan
5
F24
218
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Fuel filler flap
red
10
F25
Battery backup sounder (alarm system),
OBD II (board computer diagnostics)
tan
5
F26
Steering column unit, climate control module
tan
5
F27
Brake lamp switch
tan
5
F28
219
Fuses
Rear fuse box
E75526
Circuits protected
Colour
Ampere
rating
Fuse
Door module (left-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA1
220
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Door module (right-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA2
Door module (left-hand rear) (window up/
down)
clear
25
FA3
Door module (right-hand rear) (window up/
down)
clear
25
FA4
Rear locking (without rear door modules)
red
10
FA5
Auxiliary power socket
blue
15
FA6
Relay coils
tan
5
FA7
Not used
FA8
Not used
FA9
Electric driver's seat
green
30
FA10
Accessories, trailer module
yellow
20
FA11
Not used
FA12
Parking aid module
tan
5
FB1
Suspension module
blue
15
FB2
Heated driver's seat
blue
15
FB3
Heated front passenger seat
blue
15
FB4
Not used
FB5
Rear climate control
red
10
FB6
Not used
FB7
Not used
FB8
Electric front passenger seat
green
30
FB9
Anti-theft alarm horn
red
10
FB10
Not used
FB11
Not used
FB12
Electric rear quarter windows
brown
7.5
FC1
221
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Electric parking brake (EPB)
green
30
FC2
Electric parking brake (EPB)
green
30
FC3
Rear air conditioning
red
10
FC4
CD changer, rear seat entertainment system
brown
7.5
FC5
Rear air conditioning blower
yellow
20
FC6
Seat memory function module
tan
5
FC7
Not used
FC8
Not used
FC9
Not used
FC10
Not used
FC11
Not used
FC12
222
Fuses
FUSE SPECIFICATION CHART - VEHICLES BUILT FROM: 08-
02-2010
Engine compartment fuse box
E75525
Circuits protected
Colour
Ampere
rating
Fuse
Transmission control module (AWF21)
red
10
F1
Transmission control module (MPS6)
blue
15
F1
223
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Glow plug monitoring (diesel engines)
tan
5
F2
Vaporiser glow plug monitoring (DW10c)
tan
5
F2
Engine cooling fan - twin fan (2.3L Duratec-
HE)
brown
70
1
F3
Electric hydraulic power steering (EHPAS)
(2.0L Duratorq-TDCi)
clear
80
1
F3
Glow plugs
yellow
60
F4
Engine cooling fan
yellow
60
F5
HEGO sensor (engine management), CMS
Sensor, Oxygen Sensor
red
10
F6
Vaporiser glow plug
yellow
20
F6
Relay coils
tan
5
F7
Powertrain control module
red
10
F8
Powertrain control module (2.0L EcoBoost
SCTi; DW10c)
yellow
20
F8
MAF Sensor, Swirl Control Valve , Fuel
Injectors, CCV PTC Heater, Variable Intake
valve, Variable Exhaust Valve (engine
management)
red
10
F9
Fuel pump vaporiser (DW10c)
tan
5
F9
Engine control module
red
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor,
Sonic Purge Valve, Swirl Control Valve, Vari-
able Intake Valve, EGR Valve, IVVT Oil Control
Valve (engine management)
red
10
F11
Powertrain control module (2.2L Duratec-
HE and 2.3L Duratec-HE)
red
10
F11
MAF sensor, water in fuel sensor (DW10c)
tan
5
F11
EGR Throttle, Variable Turbo Control Valve,
Coil on Plug; Canister Purge Valve, Power
Steering Pressure Switch (engine manage-
ment)
red
10
F12
224
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Relay coils (DW10c)
tan
5
F12
air conditioning (AC) clutch relay(2.2L
Duratorq-TDCi)
red
10
F12
Ignition coils (2.0L EcoBoost SCTi)
blue
15
F12
Air conditioning relay
blue
15
F13
Diesel filter heater, fuel metering unit (2.2L
Duratorq-TDCi)
blue
15
F14
Brake vacuum pump (2.0L EcoBoost SCTi)
yellow
20
F14
Starter relay
orange
40
F15
Diesel auxiliary heater (PTC)
clear
80
F16
Central fuse box supply A
yellow
60
F17
Central fuse box supply B
yellow
60
F18
Rear fuse box supply C
yellow
60
F19
Rear fuse box supply D
yellow
60
F20
Not used
F21
Windscreen wiper module
green
30
F22
Heated rear window
clear
25
1
F23
Headlamp washer
green
30
F24
ABS valves
green
30
F25
ABS pump
orange
40
F26
Fuel fired heater
green
30
F27
Heater blower
orange
40
F28
Not used
F29
Not used
F30
Horn
blue
15
F31
Fuel fired heater - remote control
tan
5
F32
225
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Light switch module, engine compartment
fuse box coils
tan
5
F33
Heated windscreen (left-hand side)
orange
40
F34
Heated windscreen (right-hand side)
orange
40
F35
ABS
tan
5
F36
Heated front washer jets
red
10
F37
Adaptive cruise control (ACC)
tan
5
F38
Adaptive front lighting system (AFS)
blue
15
F39
Not used
F40
Instrument panel
yellow
20
F41
Engine control module, transmission control
module, electric hydraulic power steering
(EHPAS) (2.0L Duratorq-TDCi)
red
10
F42
Headlamp levelling, adaptive front lighting
system (AFS)
tan
5
F43
Not used
-
-
F44
Rear window wiper
blue
15
F45
1
Fit a replacement with the same rating as the one you have removed.
226
Fuses
Central fuse box
E124888
Circuits protected
Colour
Ampere
rating
Fuse
Steering wheel module
brown
7.5
F1
Instrument cluster
tan
5
F2
Interior lamps
red
10
F3
Engine immobiliser
tan
5
F4
227
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Adaptive cruise control (ACC)
brown
7.5
F5
Rain sensor
tan
5
F6
Cigar lighter
blue
15
F7
Fuel filler flap unlock supply
red
10
F8
Windscreen washers - rear
blue
15
F9
Windscreen washers - front
blue
15
F10
Luggage compartment release supply
red
10
F11
Fuel filler flap lock supply
red
10
F12
Fuel pump
yellow
20
F13
Fuel pump (2.2L Duratorq)
brown
7.5
F13
Remote frequency receiver, Interior motion
sensor
tan
5
F14
Ignition switch
tan
5
F15
Battery backup sounder (alarm system),
OBD II (board computer diagnostics)
tan
5
F16
Not used
tan
5
F17
SRS (airbag) supply
red
10
F18
ABS, yaw rate sensor (ESP), electric parking
brake (EPB), accelerator pedal supply
brown
7.5
F19
Electronic feed, electronic fuse
brown
7.5
F20
Audio system (including voice control)
blue
15
F21
Brake lamp switch
tan
5
F22
Sunroof
yellow
20
F23
Steering column unit, climate control module
tan
5
F24
228
Fuses
Rear fuse box
E75526
Circuits protected
Colour
Ampere
rating
Fuse
Door module (left-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA1
229
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Door module (right-hand front) (window up/
down, central locking, electric folding mirror,
heated mirror)
clear
25
FA2
Door module (left-hand rear) (window up/
down)
clear
25
FA3
Door module (right-hand rear) (window up/
down)
clear
25
FA4
Rear locking (without rear door modules)
red
10
FA5
Auxiliary power socket
blue
15
FA6
Relay coils
tan
5
FA7
Keyless vehicle module
yellow
20
FA8
Not used
FA9
Electric driver's seat
green
30
FA10
Accessories, trailer module
yellow
20
FA11
Not used
FA12
Parking aid module/Blind spot detection
system
tan
5
FB1
Suspension module
blue
15
FB2
Heated driver's seat
blue
15
FB3
Heated front passenger seat
blue
15
FB4
Not used
FB5
Rear climate control
red
10
FB6
Not used
FB7
Sun blind system
blue
15
FB8
Electric front passenger seat
green
30
FB9
Anti-theft alarm horn
red
10
FB10
Not used
FB11
Not used
FB12
230
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Electric rear quarter windows
brown
7.5
FC1
Electric parking brake (EPB)
green
30
FC2
Electric parking brake (EPB)
green
30
FC3
Rear air conditioning
red
10
FC4
CD changer, rear seat entertainment system
brown
7.5
FC5
Rear air conditioning blower
yellow
20
FC6
Seat memory function module
tan
5
FC7
Keyless vehicle module
yellow
20
FC8
Audio amplifier
yellow
20
FC9
Sony audiophile
red
10
FC10
Not used
FC11
Not used
FC12
231
Fuses
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
. See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 246).
C
Battery. See
Using booster cables
(page 252).
D
Engine compartment fuse box. See
Fuse specification chart
(page 214).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 246).
G
Engine oil dipstick
1
. See
Engine oil check
(page 244).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
246).
I
Engine coolant reservoir. See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
236
Maintenance
ENGINECOMPARTMENTOVERVIEW-2.0LECOBOOSTSCTI
(MI4)
A
C
G
H
J
I
F
D
E
B
E124921
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
. See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 246).
C
Battery. See
Using booster cables
(page 252).
D
Engine compartment fuse box. See
Fuse specification chart
(page 214).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 246).
G
Engine oil dipstick
1
. See
Engine oil check
(page 244).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
246).
I
Engine coolant reservoir. See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
237
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
. See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 246).
C
Battery. See
Using booster cables
(page 252).
D
Engine compartment fuse box. See
Fuse specification chart
(page 214).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 246).
G
Engine oil dipstick
1
. See
Engine oil check
(page 244).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
246).
I
Engine coolant reservoir. See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
238
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.5L DURATEC (VI5)
A
C
G
J
I
F
D
E
B
H
E73232
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
. See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 246).
C
Battery. See
Using booster cables
(page 252).
D
Engine compartment fuse box. See
Fuse specification chart
(page 214).
E
Screen washer fluid reservoir. See
Washer fluid check
(page 246).
F
Air cleaner. No maintenance necessary.
G
Engine oil dipstick
1
. See
Engine oil check
(page 244).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
246).
I
Engine coolant reservoir. See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
239
Maintenance
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL
A
C
G
J
I
F
D
E
B
H
E73233
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
. See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 246).
C
Battery. See
Using booster cables
(page 252).
D
Engine compartment fuse box. See
Fuse specification chart
(page 214).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 246).
G
Engine oil dipstick
1
. See
Engine oil check
(page 244).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
246).
I
Engine coolant reservoir. See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
240
Maintenance
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
. See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 246).
C
Battery. See
Using booster cables
(page 252).
D
Engine compartment fuse box. See
Fuse specification chart
(page 214).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 246).
G
Engine oil dipstick
1
. See
Engine oil check
(page 244).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
246).
I
Engine coolant reservoir. See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
242
Maintenance
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 246).
A
Engine oil filler cap
1
: See
Engine oil check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 246).
C
Battery: See
Vehicle battery
(page 252).
D
Engine compartment fuse box: See
Fuses
(page 212).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 246).
G
Engine oil dipstick
1
: See
Engine oil check
(page 244).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
246).
I
Engine coolant reservoir: See
Engine coolant check
(page 245).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINEOILDIPSTICK-2.0L
DURATEC-HE (MI4)/2.3L
DURATEC-HE (MI4)
E92036
A
B
MIN
A
MAX
B
ENGINEOILDIPSTICK-2.0L
ECOBOOST SCTI (MI4)
E124917
A
B
MIN
A
MAX
B
243
Maintenance
Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 221).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater
(depending on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
The fuel operated heater aids in warming
the engine and the vehicle interior on
vehicles with a diesel engine. It is switched
on or off automatically depending on the
outside air temperature and the coolant
temperature, unless you have deactivated
it. When the fuel operated heater is
operating,
Aux. Heater on
is displayed
in the information display. See
Information displays
(page 91).
To deactivate the fuel operated heater:
E70499
1.
Press the right arrow button on the
steering wheel to enter the main
menu.
2.
Highlight
Setup
with the up and down
arrow buttons and press the right
arrow button.
3.
Highlight
Aux. Heater
and press the
OK
button to toggle the heater on and
off. A cross appears in the box when
the heater is activated.
4.
Press the left arrow button to exit the
menu. Hold the left arrow button
pressed to return to the trip computer
display.
Diesel auxiliary heater
(depending on country)
The diesel auxiliary heater (PTC electrical
heater) aids in warming the vehicle interior
on vehicles with a diesel engine. It is
switched on or off automatically
depending on the outside air temperature,
the coolant temperature and the
alternator load.
127
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Loosen the screws.
E72590
2. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
3. Lower the fuse box and pull it towards
you.
4. Install in the reverse order.
Rear fuse box
E72591
Release the catches and remove the
cover.
219
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
220
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Ampere
rating
Fuse
Transmission control module (AWF21)
10
F1
Transmission control module (MPS6)
15
F1
221
Fuses
Circuits protected
Ampere
rating
Fuse
Glow plug monitoring (diesel engines)
5
F2
Vaporiser glow plug monitoring (2.0L and 2.2L
Duratorq-TDCi Stage V)
5
F2
Engine cooling fan - twin fan (2.3L Duratec-HE)
70
1
F3
Electric hydraulic power steering (EHPAS) (2.0L
Duratorq-TDCi)
80
1
F3
Glow plugs
60
F4
Engine cooling fan
60
F5
HEGO sensor (engine management), CMS Sensor,
Oxygen Sensor
10
F6
Vaporiser glow plug
20
F6
Relay coils
5
F7
Powertrain control module
10
F8
Powertrain control module (2.0L EcoBoost SCTi; 2.0L
Duratorq-TDCi Stage V)
20
F8
Powertrain control module (2.2L Duratorq-TDCi Stage
V)
15
F8
MAF Sensor, Swirl Control Valve , Fuel Injectors, CCV
PTC Heater, Variable Intake valve, Variable Exhaust
Valve (engine management)
10
F9
Fuel pump vaporiser (2.0L Duratorq-TDCi Stage V)
5
F9
MAF Sensor, EGR bypass Valve , Fuel pump vaporiser
(2.2L Duratorq-TDCi Stage V) (engine management)
7.5
F9
Engine control module
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic
Purge Valve, Swirl Control Valve, Variable Intake Valve,
EGR Valve, IVVT Oil Control Valve (engine manage-
ment)
10
F11
Powertrain control module (2.3L Duratec-HE)
10
F11
MAF sensor, water in fuel sensor (2.0L Duratorq-TDCi
Stage V), Active grille shutter
5
F11
222
Fuses
Circuits protected
Ampere
rating
Fuse
Fuel rail pressure, Fuel metering unit, Fuel pump
vaporiser, Active grille shutter (2.2L Duratorq-TDCi
Stage V) (engine management)
7.5
F11
EGR Throttle, Variable Turbo Control Valve, Coil on
Plug; Canister Purge Valve, Power Steering Pressure
Switch (engine management)
10
F12
Relay coils (2.0L and 2.2L Duratorq-TDCi Stage V)
5
F12
Ignition coils (2.0L EcoBoost SCTi)
15
F12
Air conditioning relay
15
F13
Diesel filter heater, fuel metering unit (2.0L Duratorq-
TDCi Stage V)
15
F14
Brake vacuum pump (2.0L EcoBoost SCTi)
20
F14
Hego sensor (2.2L Duratorq-TDCi Stage V)
10
F14
Starter relay
40
F15
Diesel auxiliary heater (PTC)
80
F16
Central fuse box supply A
60
F17
Central fuse box supply B
60
F18
Rear fuse box supply C
60
F19
Rear fuse box supply D
60
F20
Not used
F21
Windscreen wiper module
30
F22
Heated rear window
25
F23
Headlamp washer
30
F24
ABS valves
30
F25
ABS pump
40
F26
Fuel fired heater
30
F27
Heater blower
40
F28
Not used
F29
223
Fuses
Circuits protected
Ampere
rating
Fuse
Not used
F30
Horn
15
F31
Fuel fired heater - remote control
5
F32
Light switch module, engine compartment fuse box
coils
5
F33
Heated windscreen (left-hand side)
40
F34
Heated windscreen (right-hand side)
40
F35
ABS
5
F36
Heated front washer jets
10
F37
Adaptive cruise control (ACC)
5
F38
Adaptive front lighting system (AFS)
15
F39
Not used
F40
Instrument panel
20
F41
Engine control module, transmission control module,
electric hydraulic power steering (EHPAS)
10
F42
Headlamp levelling, adaptive front lighting system
(AFS)
5
F43
Not used
-
F44
Rear window wiper
15
F45
1
Fit a replacement with the same rating as the one you have removed.
224
Fuses
Central fuse box
E124888
A
B
Circuits protected
Ampere
rating
Fuse
Steering wheel module
7.5
F1
Instrument cluster
5
F2
Interior lamps
10
F3
Engine immobiliser
5
F4
Adaptive cruise control (ACC)
7.5
F5
Rain sensor
5
F6
225
Fuses
Circuits protected
Ampere
rating
Fuse
Cigar lighter
15
F7
Fuel filler flap unlock supply
10
F8
Windscreen washers - rear
15
F9
Windscreen washers - front
15
F10
Luggage compartment release supply
10
F11
Fuel filler flap lock supply
10
F12
Fuel pump
20
F13
Fuel pump (2.2L Duratorq-TDCi Stage V)
7.5
F13
Remote frequency receiver, Interior motion sensor
5
F14
Ignition switch
5
F15
Battery backup sounder (alarm system), OBD II
(board computer diagnostics)
5
F16
Steering wheel vibration actuator
5
F17
SRS (airbag) supply
10
F18
ABS, yaw rate sensor (ESP), electric parking brake
(EPB), accelerator pedal supply
7.5
F19
Electronic feed, electronic fuse, Auto-dimming mirror,
lane departure warning
7.5
F20
Audio system (including voice control)
15
F21
Brake lamp switch
5
F22
Sunroof
20
F23
Steering column unit, climate control module
5
F24
226
Fuses
Rear fuse box
E75526
Circuits protected
Ampere
rating
Fuse
Door module (left-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA1
Door module (right-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA2
Door module (left-hand rear) (window up/down)
25
FA3
227
Fuses
Circuits protected
Ampere
rating
Fuse
Door module (right-hand rear) (window up/down)
25
FA4
Rear locking (without rear door modules)
10
FA5
Auxiliary power socket
15
FA6
Relay coils
5
FA7
Keyless vehicle module
20
FA8
Not used
FA9
Electric driver's seat
30
FA10
Accessories, trailer module
20
FA11
Not used
FA12
Parking aid module/Blind spot detection system
5
FB1
Suspension module
15
FB2
Heated driver's seat
15
FB3
Heated front passenger seat
15
FB4
Not used
FB5
Rear climate control
10
FB6
Not used
FB7
Sun blind system
15
FB8
Electric front passenger seat
30
FB9
Anti-theft alarm horn
10
FB10
Not used
FB11
Not used
FB12
Electric rear quarter windows
7.5
FC1
Electric parking brake (EPB)
30
FC2
Electric parking brake (EPB)
30
FC3
Rear air conditioning
10
FC4
CD changer, rear seat entertainment system
7.5
FC5
228
Fuses
Circuits protected
Ampere
rating
Fuse
Rear air conditioning blower
20
FC6
Seat memory function module
5
FC7
Keyless vehicle module
20
FC8
Audio amplifier
20
FC9
Sony audiophile
10
FC10
Not used
FC11
Not used
FC12
229
Fuses
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 241).
A
Engine oil filler cap
1
. See
Engine oil check
(page 240).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 241).
C
Battery. See
Using booster cables
(page 246).
D
Engine compartment fuse box. See
Fuse specification chart
(page 221).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 242).
G
Engine oil dipstick
1
. See
Engine oil check
(page 240).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
241).
I
Engine coolant reservoir. See
Engine coolant check
(page 240).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
234
Maintenance
ENGINECOMPARTMENTOVERVIEW-2.0LECOBOOSTSCTI
(MI4)
A
C
G
H
J
I
F
D
E
B
E124921
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 241).
A
Engine oil filler cap
1
. See
Engine oil check
(page 240).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 241).
C
Battery. See
Using booster cables
(page 246).
D
Engine compartment fuse box. See
Fuse specification chart
(page 221).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 242).
G
Engine oil dipstick
1
. See
Engine oil check
(page 240).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
241).
I
Engine coolant reservoir. See
Engine coolant check
(page 240).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
235
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 241).
A
Engine oil filler cap
1
. See
Engine oil check
(page 240).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 241).
C
Battery. See
Using booster cables
(page 246).
D
Engine compartment fuse box. See
Fuse specification chart
(page 221).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 242).
G
Engine oil dipstick
1
. See
Engine oil check
(page 240).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
241).
I
Engine coolant reservoir. See
Engine coolant check
(page 240).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
236
Maintenance
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 241).
A
Engine oil filler cap
1
. See
Engine oil check
(page 240).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 241).
C
Battery. See
Using booster cables
(page 246).
D
Engine compartment fuse box. See
Fuse specification chart
(page 221).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 242).
G
Engine oil dipstick
1
. See
Engine oil check
(page 240).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
241).
I
Engine coolant reservoir. See
Engine coolant check
(page 240).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
238
Maintenance
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 241).
A
Engine oil filler cap
1
: See
Engine oil check
(page 240).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 241).
C
Battery: See
Vehicle battery
(page 246).
D
Engine compartment fuse box: See
Fuses
(page 219).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 242).
G
Engine oil dipstick
1
: See
Engine oil check
(page 240).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
241).
I
Engine coolant reservoir: See
Engine coolant check
(page 240).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINEOILDIPSTICK-2.0L
DURATEC-HE (MI4)/2.3L
DURATEC-HE (MI4)
E92036
A
B
MIN
A
MAX
B
ENGINEOILDIPSTICK-2.0L
ECOBOOST SCTI (MI4)
E124917
A
B
MIN
A
MAX
B
239
Maintenance
Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 220).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater
(depending on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
The fuel operated heater aids in warming
the engine and the vehicle interior on
vehicles with a diesel engine. It is switched
on or off automatically depending on the
outside air temperature and the coolant
temperature, unless you have deactivated
it. When the fuel operated heater is
operating,
Aux. Heater on
is displayed
in the information display. See
Information displays
(page 90).
To deactivate the fuel operated heater:
E70499
1.
Press the right arrow button on the
steering wheel to enter the main
menu.
2.
Highlight
Setup
with the up and down
arrow buttons and press the right
arrow button.
3.
Highlight
Aux. Heater
and press the
OK
button to toggle the heater on and
off. A cross appears in the box when
the heater is activated.
4.
Press the left arrow button to exit the
menu. Hold the left arrow button
pressed to return to the trip computer
display.
Diesel auxiliary heater
(depending on country)
The diesel auxiliary heater (PTC electrical
heater) aids in warming the vehicle interior
on vehicles with a diesel engine. It is
switched on or off automatically
depending on the outside air temperature,
the coolant temperature and the
alternator load.
126
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Pinch the retaining clips to release the
cover.
E72590
2. Remove the cover.
3. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
4. Lower the fuse box cover and pull it
towards you.
5. Install in the reverse order.
Rear fuse box
E72591
Release the catches and remove the
cover.
218
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
219
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Ampere
rating
Fuse
Transmission control module (AWF21)
10
F1
Transmission control module (MPS6)
15
F1
220
Fuses
Circuits protected
Ampere
rating
Fuse
Glow plug monitoring (diesel engines)
5
F2
Vaporiser glow plug monitoring (2.0L Duratorq-TDCi
and 2.2L Duratorq-TDCi Stage V)
5
F2
Engine cooling fan - twin fan (2.3L Duratec-HE)
70
1
F3
Electric hydraulic power steering (EHPAS) (1.6L
EcoBoost SCTi and 2.0L Duratorq-TDCi)
80
1
F3
Glow plugs
60
F4
Engine cooling fan
60
F5
Engine cooling fan (1.6L EcoBoost SCTi)
70
F5
HEGO sensor (engine management), CMS Sensor,
Oxygen Sensor
10
F6
Vaporiser glow plug
20
F6
Relay coils
5
F7
Powertrain control module
10
F8
Powertrain control module (2.0L EcoBoost SCTi and
2.0L Duratorq-TDCi Stage V)
20
F8
Powertrain control module (1.6L EcoBoost SCTi and
2.2L Duratorq-TDCi Stage V)
15
F8
MAF Sensor, Swirl Control Valve , Fuel Injectors, CCV
PTC Heater, Variable Intake valve, Variable Exhaust
Valve (engine management)
10
F9
Fuel pump vaporiser (2.0L Duratorq-TDCi Stage V)
5
F9
MAF Sensor, EGR bypass Valve , Fuel pump vaporiser
(2.2L Duratorq-TDCi Stage V) (engine management)
7.5
F9
Cannister purge valve, Degas valve, TMAF sensor
(1.6L EcoBoost SCTi)
7.5
F9
Engine control module
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic
Purge Valve, Swirl Control Valve, Variable Intake Valve,
EGR Valve, IVVT Oil Control Valve (engine manage-
ment)
10
F11
221
Fuses
Circuits protected
Ampere
rating
Fuse
Powertrain control module (2.3L Duratec-HE)
10
F11
MAF sensor, Water in Fuel Sensor, Active grille shutter
(2.0L Duratorq-TDCi Stage V)
5
F11
Fuel rail pressure, Fuel metering unit, Fuel pump
vaporiser, Active grille shutter (2.2L Duratorq-TDCi
Stage V) (engine management)
7.5
F11
Waste gate valve, Active grille shutter (1.6L EcoBoost
SCTi)
7.5
F11
EGR Throttle, Variable Turbo Control Valve, Coil on
Plug; Canister Purge Valve, Power Steering Pressure
Switch (engine management)
10
F12
Relay coils (2.0L Duratorq-TDCi and 2.2L Duratorq-
TDCi Stage V)
5
F12
Ignition coils (1.6L EcoBoost SCTi and 2.0L EcoBoost
SCTi)
15
F12
Air conditioning relay
15
F13
Diesel filter heater, fuel metering unit (2.0L Duratorq-
TDCi Stage V)
15
F14
Brake vacuum pump (2.0L EcoBoost SCTi)
20
F14
Hego sensor (2.2L Duratorq-TDCi Stage V)
10
F14
Starter relay
40
F15
Diesel auxiliary heater (PTC)
80
F16
Central fuse box supply A
60
F17
Central fuse box supply B
60
F18
Rear fuse box supply C
60
F19
Rear fuse box supply D
60
F20
Not used
F21
Windscreen wiper module
30
F22
Heated rear window
25
F23
Headlamp washer
30
F24
222
Fuses
Circuits protected
Ampere
rating
Fuse
ABS valves
30
F25
ABS pump
40
F26
Fuel fired heater
30
F27
Heater blower
40
F28
Not used
F29
Not used
F30
Horn
15
F31
Fuel fired heater - remote control
5
F32
Light switch module, engine compartment fuse box
coils
5
F33
Heated windscreen (left-hand side)
40
F34
Heated windscreen (right-hand side)
40
F35
ABS
5
F36
Heated front washer jets
10
F37
Adaptive cruise control (ACC)
5
F38
Adaptive front lighting system (AFS)
15
F39
Not used
F40
Instrument panel
20
F41
Engine control module, transmission control module,
electric hydraulic power steering (EHPAS)
10
F42
Headlamp levelling, adaptive front lighting system
(AFS)
5
F43
Not used
-
F44
Rear window wiper
15
F45
1
Fit a replacement with the same rating as the one you have removed.
223
Fuses
Central fuse box
E124888
A
B
Left-hand drive
A
Right-hand drive
B
Circuits protected
Ampere
rating
Fuse
Steering wheel module
7.5
F1
Instrument cluster
5
F2
Interior lamps
10
F3
Engine immobiliser
5
F4
224
Fuses
Circuits protected
Ampere
rating
Fuse
Adaptive cruise control (ACC)
7.5
F5
Rain sensor
5
F6
Cigar lighter
20
F7
Fuel filler flap unlock supply
10
F8
Windscreen washers - rear
15
F9
Windscreen washers - front
15
F10
Luggage compartment release supply
10
F11
Fuel filler flap lock supply
10
F12
Fuel pump
20
F13
Fuel pump (2.2L Duratorq-TDCi Stage V)
7.5
F13
Remote frequency receiver, Interior motion sensor
5
F14
Ignition switch
5
F15
Battery backup sounder (alarm system), OBD II
(board computer diagnostics)
5
F16
Steering wheel vibration actuator
5
F17
SRS (airbag) supply
10
F18
ABS, yaw rate sensor (ESP), electric parking brake
(EPB), accelerator pedal supply
7.5
F19
Electronic feed, electronic fuse, Auto-dimming mirror,
lane departure warning
7.5
F20
Audio system (including voice control)
15
F21
Brake lamp switch
5
F22
Sunroof
20
F23
Steering column unit, climate control module
5
F24
225
Fuses
Rear fuse box
E75526
Circuits protected
Ampere
rating
Fuse
Door module (left-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA1
Door module (right-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA2
Door module (left-hand rear) (window up/down)
25
FA3
226
Fuses
Circuits protected
Ampere
rating
Fuse
Door module (right-hand rear) (window up/down)
25
FA4
Rear locking (without rear door modules)
10
FA5
Auxiliary power socket
15
FA6
Relay coils
5
FA7
Keyless vehicle module
20
FA8
Not used
FA9
Electric driver's seat
30
FA10
Accessories, trailer module
20
FA11
Not used
FA12
Parking aid module/Blind spot detection system
5
FB1
Suspension module
15
FB2
Heated driver's seat
15
FB3
Heated front passenger seat
15
FB4
Not used
FB5
Rear climate control
10
FB6
Not used
FB7
Sun blind system
15
FB8
Electric front passenger seat
30
FB9
Anti-theft alarm horn
10
FB10
Not used
FB11
Not used
FB12
Electric rear quarter windows
7.5
FC1
Electric parking brake (EPB)
30
FC2
Electric parking brake (EPB)
30
FC3
Rear air conditioning
10
FC4
CD changer, rear seat entertainment system
7.5
FC5
227
Fuses
Circuits protected
Ampere
rating
Fuse
Rear air conditioning blower
20
FC6
Seat memory function module
5
FC7
Keyless vehicle module
20
FC8
Audio amplifier
20
FC9
Sony audiophile
10
FC10
Not used
FC11
Not used
FC12
228
Fuses
ENGINECOMPARTMENTOVERVIEW-1.6LECOBOOSTSCTI
(SIGMA)
E132430
A
J
I
G
F
H
B
C
D
E
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Vehicle battery
(page 250).
D
Engine compartment fuse box. See
Fuses
(page 218).
E
Air cleaner. No maintenance necessary.
F
233
Maintenance
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
234
Maintenance
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
236
Maintenance
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL
A
C
G
J
I
F
D
E
B
H
E73233
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
237
Maintenance
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
I
F
D
E
B
H
E73234
238
Maintenance
A
C
G
H
J
I
F
D
E
B
E124913
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
239
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
: See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 243).
C
Battery: See
Vehicle battery
(page 250).
D
Engine compartment fuse box: See
Fuses
(page 218).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
: See
Engine oil check
(page 242).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
244).
I
Engine coolant reservoir: See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
240
Maintenance