Ford Galaxy - 2011 Fuse Box Diagram

Ford Galaxy - 2011 Fuse Box Diagram

Note:
The programming procedure may
be repeated as often as is required. The
oldest programmed transmitter will be
deleted each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
specification chart
(page 220).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater
(depending on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
The fuel operated heater aids in warming
the engine and the vehicle interior on
vehicles with a diesel engine. It is switched
on or off automatically depending on the
outside air temperature and the coolant
temperature, unless you have deactivated
it. When the fuel operated heater is
operating,
Aux. Heater on
is displayed
in the information display. See
Information displays
(page 90).
To deactivate the fuel operated heater:
E70499
1.
Press the right arrow button on the
steering wheel to enter the main
menu.
2.
Highlight
Setup
with the up and down
arrow buttons and press the right
arrow button.
3.
Highlight
Aux. Heater
and press the
OK
button to toggle the heater on and
off. A cross appears in the box when
the heater is activated.
4.
Press the left arrow button to exit the
menu. Hold the left arrow button
pressed to return to the trip computer
display.
Diesel auxiliary heater
(depending on country)
The diesel auxiliary heater (PTC electrical
heater) aids in warming the vehicle interior
on vehicles with a diesel engine. It is
switched on or off automatically
depending on the outside air temperature,
the coolant temperature and the
alternator load.
126
Climate control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Pinch the retaining clips to release the
cover.
E72590
2. Remove the cover.
3. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
4. Lower the fuse box cover and pull it
towards you.
5. Install in the reverse order.
Rear fuse box
E72591
Release the catches and remove the
cover.
218
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
219
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Ampere
rating
Fuse
Transmission control module (AWF21)
10
F1
Transmission control module (MPS6)
15
F1
220
Fuses
Circuits protected
Ampere
rating
Fuse
Glow plug monitoring (diesel engines)
5
F2
Vaporiser glow plug monitoring (2.0L Duratorq-TDCi
and 2.2L Duratorq-TDCi Stage V)
5
F2
Engine cooling fan - twin fan (2.3L Duratec-HE)
70
1
F3
Electric hydraulic power steering (EHPAS) (1.6L
EcoBoost SCTi and 2.0L Duratorq-TDCi)
80
1
F3
Glow plugs
60
F4
Engine cooling fan
60
F5
Engine cooling fan (1.6L EcoBoost SCTi)
70
F5
HEGO sensor (engine management), CMS Sensor,
Oxygen Sensor
10
F6
Vaporiser glow plug
20
F6
Relay coils
5
F7
Powertrain control module
10
F8
Powertrain control module (2.0L EcoBoost SCTi and
2.0L Duratorq-TDCi Stage V)
20
F8
Powertrain control module (1.6L EcoBoost SCTi and
2.2L Duratorq-TDCi Stage V)
15
F8
MAF Sensor, Swirl Control Valve , Fuel Injectors, CCV
PTC Heater, Variable Intake valve, Variable Exhaust
Valve (engine management)
10
F9
Fuel pump vaporiser (2.0L Duratorq-TDCi Stage V)
5
F9
MAF Sensor, EGR bypass Valve , Fuel pump vaporiser
(2.2L Duratorq-TDCi Stage V) (engine management)
7.5
F9
Cannister purge valve, Degas valve, TMAF sensor
(1.6L EcoBoost SCTi)
7.5
F9
Engine control module
10
F10
PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic
Purge Valve, Swirl Control Valve, Variable Intake Valve,
EGR Valve, IVVT Oil Control Valve (engine manage-
ment)
10
F11
221
Fuses
Circuits protected
Ampere
rating
Fuse
Powertrain control module (2.3L Duratec-HE)
10
F11
MAF sensor, Water in Fuel Sensor, Active grille shutter
(2.0L Duratorq-TDCi Stage V)
5
F11
Fuel rail pressure, Fuel metering unit, Fuel pump
vaporiser, Active grille shutter (2.2L Duratorq-TDCi
Stage V) (engine management)
7.5
F11
Waste gate valve, Active grille shutter (1.6L EcoBoost
SCTi)
7.5
F11
EGR Throttle, Variable Turbo Control Valve, Coil on
Plug; Canister Purge Valve, Power Steering Pressure
Switch (engine management)
10
F12
Relay coils (2.0L Duratorq-TDCi and 2.2L Duratorq-
TDCi Stage V)
5
F12
Ignition coils (1.6L EcoBoost SCTi and 2.0L EcoBoost
SCTi)
15
F12
Air conditioning relay
15
F13
Diesel filter heater, fuel metering unit (2.0L Duratorq-
TDCi Stage V)
15
F14
Brake vacuum pump (2.0L EcoBoost SCTi)
20
F14
Hego sensor (2.2L Duratorq-TDCi Stage V)
10
F14
Starter relay
40
F15
Diesel auxiliary heater (PTC)
80
F16
Central fuse box supply A
60
F17
Central fuse box supply B
60
F18
Rear fuse box supply C
60
F19
Rear fuse box supply D
60
F20
Not used
F21
Windscreen wiper module
30
F22
Heated rear window
25
F23
Headlamp washer
30
F24
222
Fuses
Circuits protected
Ampere
rating
Fuse
ABS valves
30
F25
ABS pump
40
F26
Fuel fired heater
30
F27
Heater blower
40
F28
Not used
F29
Not used
F30
Horn
15
F31
Fuel fired heater - remote control
5
F32
Light switch module, engine compartment fuse box
coils
5
F33
Heated windscreen (left-hand side)
40
F34
Heated windscreen (right-hand side)
40
F35
ABS
5
F36
Heated front washer jets
10
F37
Adaptive cruise control (ACC)
5
F38
Adaptive front lighting system (AFS)
15
F39
Not used
F40
Instrument panel
20
F41
Engine control module, transmission control module,
electric hydraulic power steering (EHPAS)
10
F42
Headlamp levelling, adaptive front lighting system
(AFS)
5
F43
Not used
-
F44
Rear window wiper
15
F45
1
Fit a replacement with the same rating as the one you have removed.
223
Fuses
Central fuse box
E124888
A
B
Left-hand drive
A
Right-hand drive
B
Circuits protected
Ampere
rating
Fuse
Steering wheel module
7.5
F1
Instrument cluster
5
F2
Interior lamps
10
F3
Engine immobiliser
5
F4
224
Fuses
Circuits protected
Ampere
rating
Fuse
Adaptive cruise control (ACC)
7.5
F5
Rain sensor
5
F6
Cigar lighter
20
F7
Fuel filler flap unlock supply
10
F8
Windscreen washers - rear
15
F9
Windscreen washers - front
15
F10
Luggage compartment release supply
10
F11
Fuel filler flap lock supply
10
F12
Fuel pump
20
F13
Fuel pump (2.2L Duratorq-TDCi Stage V)
7.5
F13
Remote frequency receiver, Interior motion sensor
5
F14
Ignition switch
5
F15
Battery backup sounder (alarm system), OBD II
(board computer diagnostics)
5
F16
Steering wheel vibration actuator
5
F17
SRS (airbag) supply
10
F18
ABS, yaw rate sensor (ESP), electric parking brake
(EPB), accelerator pedal supply
7.5
F19
Electronic feed, electronic fuse, Auto-dimming mirror,
lane departure warning
7.5
F20
Audio system (including voice control)
15
F21
Brake lamp switch
5
F22
Sunroof
20
F23
Steering column unit, climate control module
5
F24
225
Fuses
Rear fuse box
E75526
Circuits protected
Ampere
rating
Fuse
Door module (left-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA1
Door module (right-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA2
Door module (left-hand rear) (window up/down)
25
FA3
226
Fuses
Circuits protected
Ampere
rating
Fuse
Door module (right-hand rear) (window up/down)
25
FA4
Rear locking (without rear door modules)
10
FA5
Auxiliary power socket
15
FA6
Relay coils
5
FA7
Keyless vehicle module
20
FA8
Not used
FA9
Electric driver's seat
30
FA10
Accessories, trailer module
20
FA11
Not used
FA12
Parking aid module/Blind spot detection system
5
FB1
Suspension module
15
FB2
Heated driver's seat
15
FB3
Heated front passenger seat
15
FB4
Not used
FB5
Rear climate control
10
FB6
Not used
FB7
Sun blind system
15
FB8
Electric front passenger seat
30
FB9
Anti-theft alarm horn
10
FB10
Not used
FB11
Not used
FB12
Electric rear quarter windows
7.5
FC1
Electric parking brake (EPB)
30
FC2
Electric parking brake (EPB)
30
FC3
Rear air conditioning
10
FC4
CD changer, rear seat entertainment system
7.5
FC5
227
Fuses
Circuits protected
Ampere
rating
Fuse
Rear air conditioning blower
20
FC6
Seat memory function module
5
FC7
Keyless vehicle module
20
FC8
Audio amplifier
20
FC9
Sony audiophile
10
FC10
Not used
FC11
Not used
FC12
228
Fuses
ENGINECOMPARTMENTOVERVIEW-1.6LECOBOOSTSCTI
(SIGMA)
E132430
A
J
I
G
F
H
B
C
D
E
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Vehicle battery
(page 250).
D
Engine compartment fuse box. See
Fuses
(page 218).
E
Air cleaner. No maintenance necessary.
F
233
Maintenance
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATEC-HE
(MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
234
Maintenance
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.3L DURATEC-HE
(MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
236
Maintenance
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL
A
C
G
J
I
F
D
E
B
H
E73233
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
237
Maintenance
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
I
F
D
E
B
H
E73234
238
Maintenance
A
C
G
H
J
I
F
D
E
B
E124913
Brake and clutch fluid reservoir (right-hand drive). See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
. See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 243).
C
Battery. See
Using booster cables
(page 250).
D
Engine compartment fuse box. See
Fuse specification chart
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
. See
Engine oil check
(page 242).
H
Power steering fluid reservoir. See
Power steering fluid check
(page
244).
I
Engine coolant reservoir. See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
239
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.2L DURATORQ-
TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
Brake and clutch fluid reservoir (right-hand drive): See
Brake and clutch
fluid check
(page 243).
A
Engine oil filler cap
1
: See
Engine oil check
(page 242).
B
Brake and clutch fluid reservoir (left-hand drive): See
Brake and clutch
fluid check
(page 243).
C
Battery: See
Vehicle battery
(page 250).
D
Engine compartment fuse box: See
Fuses
(page 218).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir: See
Washer fluid check
(page 244).
G
Engine oil dipstick
1
: See
Engine oil check
(page 242).
H
Power steering fluid reservoir: See
Power steering fluid check
(page
244).
I
Engine coolant reservoir: See
Engine coolant check
(page 243).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
240
Maintenance