Ford S-MAX - 2012 Fuse Box Diagram

Ford S-MAX - 2012 Fuse Box Diagram

3.
Install a new battery (3.3V type
CR1-3N) with the
+
facing upwards.
4.
Re-assemble the remote control.
Programming the transmitter
Further transmitters may be used with the
remote system, please consult your dealer.
Up to a maximum of 3 separate remote
controls may be added. When adding extra
transmitters these must be programmed
separately.
Note:
The heater must be switched off
during programming.
Note:
The programming procedure may be
repeated as often as is required. The oldest
programmed transmitter will be deleted
each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
Specification Chart
(page 222).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater (depending
on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
The fuel operated heater aids in warming
the engine and the vehicle interior on
vehicles with a diesel engine. It is switched
on or off automatically depending on the
outside air temperature and the coolant
temperature, unless you have deactivated
it. When the fuel operated heater is
operating,
Aux. Heater on
is displayed in
the information display. See
Information
Displays
(page 89).
To deactivate the fuel operated heater:
E70499
1.
Press the right arrow button on the
steering wheel to enter the main menu.
2.
Highlight
Setup
with the up and down
arrow buttons and press the right arrow
button.
3.
Highlight
Aux. Heater
and press the
OK
button to toggle the heater on and
off. A cross appears in the box when
the heater is activated.
4.
Press the left arrow button to exit the
menu. Hold the left arrow button
pressed to return to the trip computer
display.
124
Climate Control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Pinch the retaining clips to release the
cover.
E72590
2. Remove the cover.
3. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
4. Lower the fuse box cover and pull it
towards you.
5. Install in the reverse order.
Rear fuse box
E72591
Release the catches and remove the cover.
220
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses,
are a push fit.
Note:
A fuse puller is located in the engine
compartment fuse box.
221
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Ampere rating
Fuse
Transmission control module (AWF21)
10
F1
Transmission control module (MPS6)
15
F1
Glow plug monitoring (diesel engines)
5
F2
222
Fuses
Circuits protected
Ampere rating
Fuse
Vaporiser glow plug monitoring (2.0L Duratorq-TDCi
Stage V and 2.2L Duratorq-TDCi Stage V)
5
F2
Engine cooling fan - twin fan (2.3L Duratec-HE and
2.2L Duratorq-TDCi automatic)
70
1
F3
Electric hydraulic power steering (EHPAS) (1.6L
EcoBoost SCTi and 2.0L Duratorq-TDCi)
80
1
F3
Glow plugs
60
F4
Engine cooling fan (1.6L Duratorq-TDCi, 2.0L Duratorq-
TDCi, 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi
manual, 2.0L Duratec-HE, 2.3L Duratec-HE and 2.0L
EcoBoost SCTi)
60
F5
Engine cooling fan - twin fan (1.6L EcoBoost SCTi)
70
F5
HEGO sensor (1.6L Duratorq-TDCi)
7.5
F6
HEGO sensor, CMS Sensor, Oxygen Sensor (engine
management)
10
F6
Vaporiser glow plug (2.0L Duratorq-TDCi Stage V and
2.2L Duratorq-TDCi Stage V)
20
F6
Relay coils
5
F7
Powertrain control module, fuel metering unit, MAF
sensor, fuel rail pressure control valve (engine
management)
10
F8
Powertrain control module (2.0L EcoBoost SCTi and
2.0L Duratorq-TDCi Stage V)
20
F8
Powertrain control module (1.6L EcoBoost SCTi, 1.6L
Duratorq-TDCi and 2.2L Duratorq-TDCi Stage V)
15
F8
MAF Sensor, Fuel Injectors (engine management)
10
F9
Fuel pump vaporiser (2.0L Duratorq-TDCi Stage V)
5
F9
MAF Sensor, EGR bypass Valve , Fuel pump vaporiser
(2.2L Duratorq-TDCi Stage V) (engine management)
7.5
F9
Degas valve, TMAF sensor, active grille shutter, bypass
valve, relay coil, auxiliary run on water pump (1.6L
EcoBoost SCTi)
7.5
F9
Engine control module (2.0L Duratorq-TDCi)
10
F10
223
Fuses
Circuits protected
Ampere rating
Fuse
Auxiliary run on, water pump (1.6L EcoBoost SCTi)
7.5
F10
PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic
Purge Valve, Swirl Control Valve, Variable Intake Valve,
EGR Valve, IVVT Oil Control Valve (engine manage-
ment). T.MAF sensor, variable exhaust timing valve,
active grille shutter, cannister purge valve. turbo control
valve, wastegate valve (engine management).
10
F11
Turbo control valve, MAF sensor, active grille shutter,
EGR valve, VCV valve (1.6L Duratorq-TDCi)
10
F11
MAF sensor, water in fuel sensor, active grille shutter,
inlet metering valve (2.0L Duratorq-TDCi Stage V)
5
F11
Fuel rail pressure, fuel metering unit, active grille
shutter (2.2L Duratorq-TDCi Stage V)
7.5
F11
Waste gate valve, variable intake timing valve, variable
exhaust timing valve, cannister purge valve, vacuum
solenoid valve (1.6L EcoBoost SCTi)
7.5
F11
Coil on Plug; Canister Purge Valve, Power Steering
Pressure Switch (engine management)
10
F12
EGR throttle, variable turbo control (2.0L Duratorq-
TDCi Stage V)
10
F12
Relay coils (2.0L Duratorq-TDCi, 2.2L Duratorq-TDCi
Stage V and 1.6L Duratorq-TDCi)
5
F12
Ignition coils (1.6L EcoBoost SCTi and 2.0L EcoBoost
SCTi)
15
F12
Air conditioning
15
F13
Diesel filter heater (2.0L Duratorq-TDCi, 2.0L Duratorq-
TDCi Stage V and 1.6L Duratorq-TDCi)
15
F14
HEGO sensors (2.2L Duratorq-TDCi Stage V)
10
F14
Starter relay
40
F15
Diesel auxiliary heater (PTC)
80
F16
Central fuse box supply A
60
F17
Central fuse box supply B
60
F18
Rear fuse box supply C
60
F19
224
Fuses
Circuits protected
Ampere rating
Fuse
Rear fuse box supply D
60
F20
VQM/non VQM: Cluster/Audio/AC/FLR
30
F21
Windscreen wiper module
30
F22
Heated rear window
25
F23
Headlamp washer
30
F24
ABS valves
30
F25
ABS pump
40
F26
Fuel fired heater
25
F27
Heater blower
40
F28
Not used
F29
ABS 30 feed
5
F30
Horn
15
F31
Fuel fired heater - remote control
5
F32
Light switch module, engine compartment fuse box
coils
5
F33
Heated windscreen (left-hand side)
40
F34
Heated windscreen (right-hand side)
40
F35
Rear wiper 15 feed
15
F36
Heated front washer jets/FLR + FSM KL15
7.5
F37
PCM/TCM/EHPAS 15 feed
10
F38
Adaptive front lighting system (AFS)
15
F39
Headlamp levelling / AFS module
5
F40
Instrument panel
20
F41
Cluster IP
5
F42
Audio/BVC module
15
F43
Automatic AC / Manual AC
5
F44
225
Fuses
Circuits protected
Ampere rating
Fuse
FLR (Start Stop)
5
F45
1
Fit a replacement with the same rating as the one you have removed.
Central fuse box
E124888
A
B
Left-hand drive
A
Right-hand drive
B
226
Fuses
Circuits protected
Ampere rating
Fuse
Steering wheel module
7.5
F1
Spare IP 30 Feed
5
F2
Interior lamps
10
F3
Engine immobiliser
5
F4
Adaptive cruise control (ACC)
7.5
F5
Rain sensor
5
F6
Cigar lighter
20
F7
Fuel filler flap unlock supply
10
F8
Windscreen washers - rear
15
F9
Windscreen washers - front
15
F10
Luggage compartment release supply
10
F11
Fuel filler flap lock supply
10
F12
Fuel pump
20
F13
Fuel pump (2.2L Duratorq-TDCi Stage V)
7.5
F13
Remote frequency receiver, Interior motion sensor
5
F14
Ignition switch
5
F15
Battery backup sounder (alarm system), OBD II
(board computer diagnostics)
5
F16
Steering wheel vibration actuator
5
F17
SRS (airbag) supply
10
F18
ABS, yaw rate sensor (ESP), electric parking brake
(EPB), accelerator pedal supply
7.5
F19
Electronic feed, electronic fuse, Auto-dimming mirror,
lane departure warning
7.5
F20
Spare IP 30 Feed
15
F21
Brake lamp switch
5
F22
Sunroof
20
F23
Spare IP 30 Feed
5
F24
227
Fuses
Rear fuse box
E75526
Circuits protected
Ampere rating
Fuse
Door module (left-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA1
Door module (right-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA2
Door module (left-hand rear) (window up/down)
25
FA3
228
Fuses
Circuits protected
Ampere rating
Fuse
Door module (right-hand rear) (window up/down)
25
FA4
Rear locking (without rear door modules)
10
FA5
Auxiliary power socket
15
FA6
Relay coils
5
FA7
Keyless vehicle module
20
FA8
Relay coils VQM (Start Stop)
5
FA9
Not used
-
FA10
Accessories, trailer module
20
FA11
Electric driver's seat
30
FA12
Sunblind system
15
FB1
Suspension module
15
FB2
Heated driver's seat
15
FB3
Heated front passenger seat
15
FB4
Not used
FB5
Rear climate control
10
FB6
Not used
FB7
Parking aid, BLIS
5
FB8
Electric front passenger seat
30
FB9
Anti-theft alarm horn
10
FB10
Not used
FB11
Not used
FB12
Electric rear quarter windows
7.5
FC1
Electric parking brake (EPB)
30
FC2
Electric parking brake (EPB)
30
FC3
Rear air conditioning
10
FC4
Keyless vehicle
20
FC5
Rear air conditioning blower
20
FC6
229
Fuses
Circuits protected
Ampere rating
Fuse
Seat memory function module
5
FC7
Rear seat entertainment/CD Changer
7.5
FC8
Audio amplifier
20
FC9
Sony audiophile
10
FC10
Not used
FC11
Not used
FC12
230
Fuses
UNDER BONNET OVERVIEW - 1.6L ECOBOOST SCTI (SIGMA)
E132430
A
J
I
G
F
H
B
C
D
E
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
C
Battery. See
Vehicle battery
(page 251).
D
Engine compartment fuse box. See
Fuses
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 245).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 244).
H
235
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 245).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 244).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.0L DURATEC-HE (MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
C
Battery. See
Jump-Starting the Vehicle
(page 251).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 222).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 245).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 244).
H
236
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 245).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 244).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.0L ECOBOOST SCTI (MI4)
A
C
G
H
J
I
F
D
E
B
E124921
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
C
Battery. See
Jump-Starting the Vehicle
(page 251).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 222).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 245).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 244).
H
237
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 245).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 244).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.3L DURATEC-HE (MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
C
Battery. See
Jump-Starting the Vehicle
(page 251).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 222).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 245).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 244).
H
238
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 245).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 244).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 1.6L DURATORQ-TDCI (DV) DIESEL
A
J
I
G
F
H
B
C
D
E
E135199
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
C
Battery. See
Vehicle battery
(page 251).
D
Engine compartment fuse box. See
Fuses
(page 220).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 245).
G
239
Maintenance
A
C
G
H
J
I
F
D
E
B
E124913
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 245).
C
Battery. See
Jump-Starting the Vehicle
(page 251).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 222).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 245).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 244).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 245).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 244).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
241
Maintenance
UNDER BONNET OVERVIEW - 2.2L DURATORQ-TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
Brake and clutch fluid reservoir (right-hand drive):
See
Brake and Clutch Fluid
Check
(page 245).
A
Engine oil filler cap
1
:
See
Engine Oil Check
(page 244).
B
Brake and clutch fluid reservoir (left-hand drive):
See
Brake and Clutch Fluid
Check
(page 245).
C
Battery:
See
Vehicle battery
(page 251).
D
Engine compartment fuse box:
See
Fuses
(page 220).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir:
See
Washer Fluid Check
(page 245).
G
Engine oil dipstick
1
:
See
Engine Oil Check
(page 244).
H
Power steering fluid reservoir:
See
Power Steering Fluid Check
(page 245).
I
Engine coolant reservoir:
See
Engine Coolant Check
(page 244).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
242
Maintenance