Ford Mondeo - 2012 Fuse Box Diagram

Ford Mondeo - 2012 Fuse Box Diagram

The LED on the transmitter flashes green
or red for about two seconds. This
indicates the signal was not transmitted
correctly. Repeat the transmission.
The LED on the transmitter illuminates
orange for about two seconds before
showing green or red. This indicates the
transmitter batteries are weak and should
be changed.
The LED on the transmitter flashes orange
for about 5 seconds. This indicates that
the signal was not transmitted. The
transmitter batteries are discharged and
should be changed as soon as possible.
Changing the remote control
battery
Make sure that you dispose of old batteries
in an environmentally friendly way. Seek
advice from your local authority regarding
recycling.
E114361
2
1
1.
Insert a screwdriver or other suitable
tool into the slot on the back of the
remote control, and unscrew the
compartment cover.
CAUTION
Do not touch the battery contacts or
the printed circuit board with the
screwdriver.
2.
Carefully prise out the battery.
3.
Install a new battery (3.3V type
CR1-3N) with the
+
facing upwards.
4.
Re-assemble the remote control.
Programming the transmitter
Further transmitters may be used with the
remote system, please consult your dealer.
Up to a maximum of 3 separate remote
controls may be added. When adding extra
transmitters these must be programmed
separately.
Note:
The heater must be switched off
during programming.
Note:
The programming procedure may be
repeated as often as is required. The oldest
programmed transmitter will be deleted
each time.
1.
Install the battery in the new
transmitter.
2.
Turn off the power to the receiver by
removing fuse F32 from the engine
compartment fuse box. See
Fuse
Specification Chart
(page 195).
3.
Wait for at least 5 seconds.
4.
Reconnect power to the receiver by
replacing the fuse, and press the OFF
button on the new transmitter within
5 seconds until the LED light turns off.
5.
The new transmitter is now
programmed.
Fuel operated heater (depending
on country)
WARNING
The fuel operated heater must not
be operated at filling stations, near
sources of combustible vapours or
dust or in enclosed spaces.
115
Climate Control
FUSE BOX LOCATIONS
Engine compartment fuse box
E72588
Central fuse box
All vehicles
E72589
1. Pinch the retaining clips to release the
cover.
E72590
2. Remove the cover.
3. Turn the knob through 90 degrees and
release the fuse box from the retaining
bracket.
4. Lower the fuse box cover and pull it
towards you.
5. Install in the reverse order.
Rear fuse box - 4-door and 5-door
1
E87481
1.
Remove the cover.
193
Fuses
2
E87482
2.
Remove the relevant fuse box cover.
Rear fuse box - Estate
1
2
E87479
1.
Release the catches.
2.
Remove the cover.
3
3
3
E87480
3.
Remove the relevant fuse box cover.
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses,
are a push fit.
Note:
A fuse puller is located in the engine
compartment fuse box.
194
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E75525
Circuits protected
Ampere rating
Fuse
Transmission control module (AWF21)
10
F1
Transmission control module (MPS6)
15
F1
Glow plug monitoring (diesel engines)
5
F2
195
Fuses
Circuits protected
Ampere rating
Fuse
Vaporiser glow plug monitoring (2.0L Duratorq-TDCi
Stage V and 2.2L Duratorq-TDCi Stage V)
5
F2
Engine cooling fan - twin fan (2.3L Duratec-HE and
2.2L Duratorq-TDCi automatic)
70
1
F3
Electric hydraulic power steering (EHPAS) (1.6L
Duratec-16V Ti-VCT Stage V, 1.6L EcoBoost SCTi and
2.0L Duratorq-TDCi)
80
1
F3
Glow plugs
60
F4
Engine cooling fan (1.6L Duratorq-TDCi, 2.0L Duratorq-
TDCi, 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi
manual, 1.6L Duratec-16V Ti-VCT Stage V, 2.0L
Duratec-HE, 2.3L Duratec-HE, 2.0L EcoBoost SCTi)
60
F5
Engine cooling fan - twin fan (1.6L EcoBoost SCTi)
70
F5
HEGO sensor (1.6L Duratorq-TDCi)
7.5
F6
HEGO sensors 1, CMS sensor, Oxygen sensor (engine
management)
10
F6
Vaporiser glow plug (2.0L Duratorq-TDCi Stage V, 2.2L
Duratorq-TDCi Stage V)
20
F6
Relay coils
5
F7
Powertrain control module, Fuel metering unit, MAF
sensor, fuel rail pressure control valve (engine
management).
10
F8
Powertrain control module (2.0L EcoBoost SCTi and
2.0L Duratorq-TDCi Stage V)
20
F8
Powertrain control module (1.6L EcoBoost SCTi, 1.6L
Duratorq-TDCi and 2.2L Duratorq-TDCi Stage V)
15
F8
MAF Sensor, Fuel Injectors, Variable Intake Valve,
Variable Exhaust Valve, ignition coils (engine
management).
10
F9
Fuel pump vaporiser (2.0L Duratorq-TDCi Stage V)
5
F9
MAF Sensor, EGR bypass Valve , Fuel pump vaporiser
(2.2L Duratorq-TDCi Stage V) (engine management)
7.5
F9
196
Fuses
Circuits protected
Ampere rating
Fuse
Degas valve, TMAF sensor, active grille shutter, bypass
valve, relay coil, auxiliary run on, water pump (1.6L
EcoBoost SCTi).
7.5
F9
Engine control module (2.0L Duratorq-TDCi, 1.6L
Duratec-16V Ti-VCT Stage V)
10
F10
Auxiliary run on, water pump (1.6L EcoBoost SCTi)
7.5
F10
PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic
Purge Valve, Swirl Control Valve, Variable Intake Valve,
EGR Valve, IVVT Oil Control Valve (engine manage-
ment). T.MAF sensor, variable exhaust timing valve,
active grille shutter, cannister purge valve, turbo control
valve, waste gate valve (engine management).
10
F11
Turbo control valve, MAF sensor, active grille shutter,
EGR valve, VCV valve (1.6L Duratorq-TDCi)
10
F11
MAF sensor, Water in Fuel Sensor, Active grille shutter,
inlet metering valve (2.0L Duratorq-TDCi Stage V).
5
F11
Fuel rail pressure, fuel metering unit, fuel pump
vaporiser, active grille shutter (2.2L Duratorq-TDCi
Stage V)
7.5
F11
Waste gate valve, variable intake timing valve, variable
exhaust timing valve, cannister purge valve, vacuum
solenoid valve (1.6L EcoBoost SCTi).
7.5
F11
Ignition coils (1.6L EcoBoost SCTi and 2.0L EcoBoost
SCTi)
15
F12
Coil on Plug; Canister Purge Valve, Power Steering
Pressure Switch (engine management)
10
F12
EGR throttle, variable turbo control (2.0L Duratorq-
TDCi Stage V)
10
F12
Relay coils (2.0L Duratorq-TDCi Stage V, 2.2L
Duratorq-TDCi Stage V and 1.6L Duratorq-TDCi)
5
F12
Air conditioning
15
F13
Diesel filter heater (2.0L Duratorq-TDCi, 2.0L Duratorq-
TDCi Stage V and 1.6L Duratorq-TDCi)
15
F14
HEGO sensor (2.2L Duratorq-TDCi Stage V)
10
F14
Starter relay
40
F15
197
Fuses
Circuits protected
Ampere rating
Fuse
Diesel auxiliary heater (PTC)
80
F16
Central fuse box supply A
60
F17
Central fuse box supply B
60
F18
Rear fuse box supply C
60
F19
Rear fuse box supply D
60
F20
VQM/non VQM: Cluster/Audio/AC/FLR
30
F21
Windscreen wiper module
30
F22
Heated rear window
30
F23
Headlamp washer
30
F24
ABS valves
30
F25
ABS pump
40
F26
Fuel fired heater
25
F27
Heater blower
40
F28
Not used
F29
ABS 30 feed
5
F30
Horn
15
F31
Fuel fired heater - remote control
5
F32
Light switch module, engine compartment fuse box
coils
5
F33
Heated windscreen (left-hand side)
40
F34
Heated windscreen (right-hand side)
40
F35
Rear wiper 15 feed
15
F36
Heated front washer jets/FLR + FSM KL15
7.5
F37
PCM/TCM/EHPAS 15 feed
10
F38
Adaptive front lighting system (AFS)
15
F39
Headlamp levelling / AFS module
5
F40
Instrument panel
20
F41
198
Fuses
Circuits protected
Ampere rating
Fuse
Cluster IP
5
F42
Audio/BVC module
15
F43
Automatic AC / Manual AC
5
F44
FLR (Start Stop)
5
F45
1
Fit a replacement with the same rating as the one you have removed.
Central fuse box
E124888
A
B
199
Fuses
Left-hand drive
A
Right-hand drive
B
Circuits protected
Ampere rating
Fuse
Steering wheel module
7.5
F1
Spare IP 30 Feed
5
F2
Interior lamps
10
F3
Engine immobiliser
5
F4
Adaptive cruise control (ACC)
7.5
F5
Rain sensor
5
F6
Cigar lighter
20
F7
Fuel filler flap unlock supply
10
F8
Windscreen washers - rear
15
F9
Windscreen washers - front
15
F10
Luggage compartment release supply
10
F11
Fuel filler flap lock supply
10
F12
Fuel pump
20
F13
Fuel pump (2.2L Duratorq-TDCi Stage V)
7.5
F13
Remote frequency receiver, Interior motion sensor
5
F14
Ignition switch
5
F15
Battery backup sounder (alarm system), OBD II
(board computer diagnostics)
5
F16
Steering wheel vibration actuator
5
F17
SRS (airbag) supply
10
F18
ABS, yaw rate sensor (ESP), electric parking brake
(EPB), accelerator pedal supply
7.5
F19
Electronic feed, electronic fuse, Auto-dimming mirror,
lane departure warning
7.5
F20
Spare IP 30 Feed
15
F21
200
Fuses
Circuits protected
Ampere rating
Fuse
Brake lamp switch
5
F22
Sunroof
20
F23
Spare IP 30 Feed
5
F24
Rear fuse box
4-door and 5-door
E87483
201
Fuses
Estate
E75526
Circuits protected
Ampere rating
Fuse
Door module (left-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA1
Door module (right-hand front) (window up/down,
central locking, electric folding mirror, heated mirror)
25
FA2
Door module (left-hand rear) (window up/down)
25
FA3
202
Fuses
Circuits protected
Ampere rating
Fuse
Door module (right-hand rear) (window up/down)
25
FA4
Rear locking (without rear door modules)
10
FA5
Auxiliary power socket
15
FA6
Relay coils
5
FA7
Keyless vehicle module
20
FA8
Relay coils VQM (Start Stop)
5
FA9
Not used
-
FA10
Accessories, trailer module
20
FA11
Electric driver's seat
30
FA12
Not used
-
FB1
Suspension module
15
FB2
Heated driver's seat
15
FB3
Heated front passenger seat
15
FB4
Left-hand rear heated seat
15
FB5
Not used
-
FB6
Right-hand rear heated seat
15
FB7
Parking aid, BLIS
5
FB8
Electric front passenger seat
30
FB9
Anti-theft alarm horn
10
FB10
Not used
FB11
Not used
FB12
Not used
-
FC1
Not used
-
FC2
Not used
-
FC3
Not used
-
FC4
Keyless vehicle
20
FC5
Not used
-
FC6
203
Fuses
Circuits protected
Ampere rating
Fuse
Seat memory function module
5
FC7
Rear seat entertainment/CD Changer
7.5
FC8
Audio amplifier
20
FC9
Sony audio system
10
FC10
Not used
FC11
Not used
FC12
204
Fuses
UNDER BONNET OVERVIEW - 1.6L DURATEC-16V TI-VCT (SIGMA)
A
C
G
J
F
D
E
B
H
I
E87714
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Vehicle battery
(page 226).
D
Engine compartment fuse box. See
Fuses
(page 193).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 219).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
209
Maintenance
UNDER BONNET OVERVIEW - 1.6L ECOBOOST SCTI (SIGMA)
E132430
A
J
I
G
F
H
B
C
D
E
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Vehicle battery
(page 226).
D
Engine compartment fuse box. See
Fuses
(page 193).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 219).
H
210
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.0L DURATEC-HE (MI4)
A
C
G
J
F
D
E
B
H
I
E73231
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Jump-Starting the Vehicle
(page 226).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 195).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 219).
H
211
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.0L ECOBOOST SCTI (MI4)
A
C
G
H
J
I
F
D
E
B
E124921
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Jump-Starting the Vehicle
(page 226).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 195).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 219).
H
212
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.3L DURATEC-HE (MI4)
E81313
A
C
G
J
F
D
E
B
H
I
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Jump-Starting the Vehicle
(page 226).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 195).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 219).
H
213
Maintenance
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 1.6L DURATORQ-TDCI (DV) DIESEL
A
J
I
G
F
H
B
C
D
E
E135199
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Vehicle battery
(page 226).
D
Engine compartment fuse box. See
Fuses
(page 193).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
214
Maintenance
A
C
G
H
J
I
F
D
E
B
E124913
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
. See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 220).
C
Battery. See
Jump-Starting the Vehicle
(page 226).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 195).
E
Air cleaner. No maintenance necessary.
F
Screen washer fluid reservoir. See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
. See
Engine Oil Check
(page 219).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir. See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
216
Maintenance
UNDER BONNET OVERVIEW - 2.2L DURATORQ-TDCI (DW) DIESEL
A
C
G
J
F
D
E
B
H
I
E87715
Brake and clutch fluid reservoir (right-hand drive):
See
Brake and Clutch Fluid
Check
(page 220).
A
Engine oil filler cap
1
:
See
Engine Oil Check
(page 219).
B
Brake and clutch fluid reservoir (left-hand drive):
See
Brake and Clutch Fluid
Check
(page 220).
C
Battery:
See
Vehicle battery
(page 226).
D
Engine compartment fuse box:
See
Fuses
(page 193).
E
Air cleaner: No maintenance necessary.
F
Screen washer fluid reservoir:
See
Washer Fluid Check
(page 221).
G
Engine oil dipstick
1
:
See
Engine Oil Check
(page 219).
H
Power steering fluid reservoir:
See
Power Steering Fluid Check
(page 220).
I
Engine coolant reservoir:
See
Engine Coolant Check
(page 219).
J
1
The filler caps and the engine oil dipstick are coloured for easy identification.
217
Maintenance