Ford Kuga - 2012 Fuse Box Diagram

Ford Kuga - 2012 Fuse Box Diagram

12 Volt DC Power Point
WARNING
Do not plug optional electrical
accessories into the cigar lighter
socket. Incorrect use of the lighter
can cause damage not covered by your
warranty, and can result in fire or serious
injury.
Note:
Do not insert objects other than an
accessory plug into the power point. This
will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volts DC 180 watts or
a fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Run the engine for full capacity use of the
power point. To prevent the battery from
running out of charge:
Do not use the power point longer than
necessary when the engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is
parked for extended periods.
Location
Power points may be found:
on the center console
on the rear of the center console
in the luggage compartment.
AC Power Point
(If Equipped)
WARNING
Do not keep electrical devices
plugged in the power point whenever
the device is not in use. Do not use
any extension cord with the power point,
since it will defeat the safety protection
design. Doing so my cause the power point
to overload due to powering multiple
devices that can reach beyond the 150
watt load limit and could result in fire or
serious injury.
Note:
The power point will turn off when
the ignition is switched off or the battery
voltage drops below 11 volts.
Note:
Depending on the country for which
your vehicle was originally built, the voltage
supply will be either 110 volts or 230 volts.
The power point is used for powering
electrical devices that require up to 150
watt. It is located on the rear of the center
console.
When the indicator light, located on the
power point, is:
on
power point is working, ignition is
on and a device is plugged in.
off
power point is off, ignition is off
or no device is plugged in.
flashing
power point is in fault mode.
102
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Auxiliary Power Points
FUSE BOX LOCATIONS
Pre-Fuse Box
Your vehicle has a pre-fuse box located in
the engine compartment attached to the
positive battery post. This box contains
several high current fuses. If replacement
of these high current fuses is required, see
an authorized dealer.
Engine Compartment Fuse Box
WARNINGS
Always disconnect the battery before
servicing high current fuses.
WARNINGS
To reduce risk of electrical shock,
always replace the cover to the
engine compartment fuse box before
reconnecting the battery or refilling fluid
reservoirs.
The engine compartment fuse box has
high-current fuses that protect your
vehicle's main electrical systems from
overloads.
When you disconnect and reconnect the
battery, you will need to reset some
features. See
Changing the 12V Battery
(page 184).
Lift the release lever at the rear of the cover
to remove it.
Passenger Compartment Fuse Box
The fuse box is located below the glove
box.
168
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Luggage Compartment Fuse Box
The fuse box is located in the luggage
compartment behind the passenger side
wheel well. Remove the fuse panel cover
to gain access to the fuses.
FUSE SPECIFICATION CHART
Engine Compartment Fuse Box
169
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Not used
-
F1
Not used
-
F2
Not used
-
F3
Not used
-
F4
Not used
-
F5
Not used
-
F6
Anti-lock brake system, electronic stability program
40A**
F7
Electronic stability program
30A**
F8
Headlamp washer
20A**
F9
Heater blower motor
40A**
F10
Voltage quality module. body control module
30A**
F11
Powertrain control module
30A**
F12
Starter relay
30A**
F13
Heated windshield right-hand side
40A**
F14
Front cigar lighter, auxiliary power points
20A**
F15
Heated windshield left-hand side
40A**
F16
Auxiliary heater
20A**
F17
Not used
-
F18
Anti-lock brake system, electronic stability program
5A*
F19
Horn
15A*
F20
Stop light switch
5A*
F21
Battery monitor system
15A*
F22
Relay coils
5A*
F23
Lighting control
5A*
F24
Not used
-
F25
170
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Engine control relay coil feed (vehicles with a gasoline engine)
5A*
F26
Engine control relay coil feed (vehicles with a diesel engine),
transmission control (vehicles with a diesel engine)
15A*
F26
Air conditioning clutch
15A*
F27
Adaptive cruise control (vehicles with start-stop)
5A*
F28
Rear window defroster
25A*
F29
Not used
-
F30
Not used
-
F31
Engine control module
15A*
F32
Engine control module
10A*
F33
Engine control module
10A*
F34
Engine control module
15A*
F35
Active grill shutters
5A*
F36
Passenger airbag deactivation indicator feed
5A*
F37
Engine control module, transmission control module
5A*
F38
Headlamps, headlamp leveling
5A*
F39
Electronic power assist steering
5A*
F40
Body control module
20A*
F41
Rear window wiper
15A*
F42
Headlamps
15A*
F43
Adaptive cruise control (vehicles without start-stop)
5A*
F44
Heated washer nozzle
10A*
F45
Autowipers
40A**
F46
Not used
-
F47
Diesel vaporizer
15A*
F48
Not used
-
R1
171
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Horn
Micro relay
R2
Diesel vaporizer relay
Micro relay
R3
Not used
-
R4
Not used
-
R5
Not used
-
R6
Windshield defroster
Power relay
R7
Not used
-
R8
Headlamp washer
Micro relay
R9
Starter relay
Mini relay
R10
Air conditioning clutch
Micro relay
R11
Cooling fan
Power relay
R12
Heater blower
Mini relay
R13
Engine control relay
Mini relay
R14
Heated rear window
Power relay
R15
Ignition
Power relay
R16
*Mini fuses **Cartridge fuses
172
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Passenger Compartment Fuse Box
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Fuel pump
20A
56
Not used
-
57
Not used
-
58
Passive anti-theft transceiver
5A
59
173
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Interior lamp, driver door switch pack, glove box illumination,
overhead console switch bank
10A
60
Not used
-
61
Autowipers, auto-dimming mirror
5A
62
Adaptive cruise control (front sensing module)
10A
63
Not used
-
64
Liftgate release
10A
65
Not used
-
66
SYNC, multifunction display, global positioning system module
7.5A
67
Electric steering column lock
15A
68
Instrument cluster
5A
69
Not used
-
70
Heating control head (manual air conditioning), duel electronic
automatic temperature control
10A
71
Steering wheel module
7.5A
72
Data link connector, battery backup sounder
5A
73
High beam headlamps
15A
74
Fog lamps
15A
75
Reversing lamp
10A
76
Washer pump
20A
77
Ignition switch, start button
5A
78
Audio unit, navigation DVD player, touch screen, hazard warning
lamp switch, door lock switch
15A
79
Moonroof
20A
80
Radio frequency receiver, interior motion sensor
5A
81
Washer pump
20A
82
Central locking
20A
83
174
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Not used
-
84
Ignition switch
7.5A
85
Air bag module, occupant classification system, passenger air
bag deactivation indicator
10A
86
Not used
-
87
Not used
-
88
Not used
-
89
Luggage Compartment Fuse Box
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Hands-free liftgate
5A
F1
Keyless vehicle module
10A
F2
Keyless vehicle door handles
5A
F3
Door control unit front left
25A
F4
Door control unit front right
25A
F5
Door control unit rear left
25A
F6
175
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Door control unit rear right
25A
F7
Not used
-
F8
Driver's seat motor
25A
F9
Not used
-
F10
Rear ignition relay coil feed
5A
F11
Climate control (vehicles with start-stop)
10A
F12
Instrument cluster (vehicles with start-stop)
5A
F13
Information and entertainment display, SYNC, global positioning
system module (vehicles with start-stop)
7.5A
F14
Audio unit (vehicles with start-stop)
15A
F15
Not used
-
F16
Not used
-
F17
Not used
-
F18
Not used
-
F19
Not used
-
F20
Not used
-
F21
Not used
-
F22
Not used
-
F23
AC/DC auxiliary power points
30A
F24
Rear auxiliary power points
20A
F24
Power liftgate
25A
F25
Accessories, trailer tow module
40A
F26
Luggage compartment auxiliary power points
20A
F27
Not used
-
F28
Blind spot monitor, front camera sensor, adaptive cruise control,
rear view camera with park assist, voltage quality module ignition
signal
5A
F29
176
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
Protected Components
Fuse Amp
Rating
Fuse/
Relay
Number
Parking aid
5A
F30
Not used
-
F31
DC/AC auxiliary power point ignition signal
5A
F32
Not used
-
F33
Driver heated seat
20A
F34
Passenger heated seat
20A
F35
Not used
-
F36
Not used
-
F37
Not used
-
F38
Not used
-
F39
Not used
-
F40
Not used
-
F41
Not used
-
F42
Not used
-
F43
Not used
-
F44
Not used
-
F45
Blind spot monitor, front camera sensor, adaptive cruise control,
rear view camera with park assist (vehicles with start-stop)
10A
F46
Ignition switch
Power relay
R1
Not used
-
R2
Not used
-
R3
Not used
-
R4
Not used
-
R5
Not used
-
R6
177
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by an authorized dealer.
Switch the ignition and all electrical
equipment off before attempting to
change a fuse.
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
If electrical components in your vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
178
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Fuses
UNDER HOOD OVERVIEW - 1.6L ECOBOOST (132KW/180PS) -
SIGMA
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 184).
A
Brake fluid reservoir (right-hand drive)
*
: See
Brake Fluid Check
(page 184).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 183).
C
Engine oil dipstick
*
: See
Engine Oil Check
(page 183).
D
Brake fluid reservoir (left-hand drive)
*
: See
Brake Fluid Check
(page 184).
E
Battery: See
Changing the 12V Battery
(page 184).
F
Engine compartment fuse box: See
Fuses
(page 168).
G
Air cleaner: No maintenance necessary.
H
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 184).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
181
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Maintenance
UNDER HOOD OVERVIEW - 2.0L DURATORQ-TDCI (DW) DIESEL
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 184).
A
Brake fluid reservoir (right-hand drive)
*
: See
Brake Fluid Check
(page 184).
B
Brake fluid reservoir (left-hand drive)
*
: See
Brake Fluid Check
(page 184).
C
Battery: See
Changing the 12V Battery
(page 184).
D
Engine compartment fuse box: See
Fuses
(page 168).
E
Air cleaner: No maintenance necessary.
F
Engine oil dipstick
*
: See
Engine Oil Check
(page 183).
G
Engine oil filler cap
*
: See
Engine Oil Check
(page 183).
H
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 184).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
182
Kuga (CBS) Vehicles Built From: 05-07-2012, Vehicles Built Up To: 31-12-2013
Maintenance
FUSE BOX LOCATIONS
Engine compartment fuse box
E78332
Passenger compartment fuse box
1.
Remove the screws in the instrument
panel trim underneath the glove
compartment and lower the trim panel.
2.
Loosen the screws.
3.
Lower the fuse box and pull it towards
you.
Install in the reverse order.
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by properly trained
technicians.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses
are a push fit.
Note:
A fuse puller is located in the lid of
the engine compartment fuse box.
133
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E79716
19
6
7
8
10
9
12
11
14
13
16
15
29
36
28
34
35
33
22
25
32
5
4
3
2
1
20
17
18
24
21
30
31
23
26
27
Circuits protected
Ampere
rating
Fuse
Cooling fan
40
1
Power steering
80
2
Passenger junction box supply 1
60
3
Passenger junction box supply 2
60
4
PTC heater
80
5
Glow plugs (diesel only)
60
6
ESP pump
30
7
ESP valves
20
8
Powertrain control module
20
9
Climate control blower
30
10
Ignition switch
20
11
134
Fuses
Circuits protected
Ampere
rating
Fuse
Ignition relay 15l
40
12
Starter solenoid
20
13
Heated windscreen, right-hand side
40
14
Not used
-
15
Heated windscreen, left-hand side
40
16
Not used
-
17
Power converter
30
18
ESP module
10
19
Horn
15
20
Auxiliary heater
20
21
Power steering module
10
22
Headlamp washer
30
23
Diesel fuel heater
15
24
Ignition, relays
10
25
Automatic transmission
15
26
Air conditioning clutch
10
27
Glow plug monitoring (diesel only)
10
28
Dual zone climate control
10
29
Powertrain control module
3
30
Battery sensor smart charging
10
31
Injectors (petrol only)
10
32
Heated oxygen sensors (petrol only)
10
33
Ignition coils, valves
10
34
Powertrain control module, valves, solenoids
10
35
Powertrain control module
10
36
135
Fuses
Passenger compartment fuse box
100
101
102
103
104
138
139
140
141
142
143
105
111
117
123
130
132
133
129
134
135
136
137
131
106
112
118
124
109
115
121
127
110
116
122
128
107
113
119
125
108
114
120
126
E88709
Circuits protected
Ampere rating
Fuse
Electronic modules ignition
supply
10
100
Driver
s electric seat
20
101
Heater control, remote
control receiver
10
102
Lighting control battery
supply
10
103
Battery saver, interior lamps
10
104
Heated rear window
25
105
Keyless start
20
106
Instrument cluster battery
supply, on-board
diagnostics
10
107
Accessory to cluster (audio
and navigation unit)
7.5
108
Cigar lighter, rear auxiliary
power socket
20
109
136
Fuses
Circuits protected
Ampere rating
Fuse
Daytime running lamps igni-
tion supply to lighting
control switch
10
110
Fuel pump (diesel only)
5
111
Fuel pump (petrol only)
15
111
Audio modules battery
supply
15
112
Daytime running lamps
(parking lamps)
10
113
Instrument cluster ignition
supply, engine immobiliser
10
114
Lighting control ignition
supply
7.5
115
Fog lamps
20
116
Number plate lamps
7.5
117
Door module, left-hand rear
20
118
Luggage compartment
auxiliary power socket
15
119
Luggage compartment
auxiliary power socket
(vehicles with trailer tow
module)
25
119
Door module, right-hand
rear
20
120
Heated front seats
20
121
Airbag module
10
122
Heated exterior mirrors
7.5
123
Parking lamps, side lamps,
tail lamps (left-hand side)
7.5
124
Parking lamps, side lamps,
tail lamps (right-hand side)
7.5
125
Key free system
20
126
137
Fuses
Circuits protected
Ampere rating
Fuse
Not used
-
127
Not used
-
128
Windscreen wipers
20
129
AWD module
10
130
Rear window wiper
15
131
Brake lamps
15
132
Central locking relays,
passenger door module
25
133
Central locking relays, driver
door module
20
134
Daytime running lamps
20
135
Washer pump, heated
washer jets
15
136
Battery backup sounder
10
137
Powertrain control module,
accelerator pedal, auto-
matic transmission, keyless
module IGN monitor
10
138
Main beam right-hand side
10
139
Main beam left-hand side
10
140
Reversing lamp
10
141
Dipped beam, right-hand
side
15
142
Dipped beam, left-hand side
15
143
138
Fuses
Engine compartment fuse box:
See
Fuses
(page 133).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
:
See
Engine Oil Check
(page 146).
I
*
For easy identification, filler caps and the engine oil dipstick are marked in colour.
UNDER BONNET OVERVIEW - 2.0L DURATORQ-TDCI (DW) DIESEL
E78893
I
F
E
D
C
B
A
H
G
144
Maintenance
I
F
E
D
C
B
A
H
G
E125377
Screen washer fluid reservoir
*
:
See
Washer Fluid Check
(page 148).
A
Engine coolant reservoir
*
:
See
Engine Coolant Check
(page 147).
B
Brake and clutch fluid reservoir (right-hand drive)
*
:
See
Brake and Clutch
Fluid Check
(page 147).
C
Engine oil filler cap
*
:
See
Engine Oil Check
(page 146).
D
Brake and clutch fluid reservoir (left-hand drive)
*
:
See
Brake and Clutch Fluid
Check
(page 147).
E
Battery:
See
Vehicle battery
(page 153).
F
Engine compartment fuse box:
See
Fuses
(page 133).
G
145
Maintenance