Ford Transit Custom - 2014 Fuse Box Diagram

Ford Transit Custom - 2014 Fuse Box Diagram

WARNINGS
If used when the engine is not
running, the battery will lose charge.
There may be insufficient power to
restart the engine.
Do not plug optional electrical
accessories into the cigar lighter
socket. Incorrect use of the lighter
can cause damage not covered by your
warranty, and can result in fire or serious
injury.
Note:
Do not insert objects other than an
accessory plug into the power point. This
will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volt DC 10 amp or a
fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Note:
The power point will turn off after 30
minutes if the ignition is on without the
engine running. Keep the engine running or
cycle the ignition to keep the power point
on.
Run the engine for full capacity use of the
power point. To prevent the battery from
losing charge:
Do not use the power point longer than
necessary when the engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is
parked for extended periods.
Locations
Power points may be found:
on the instrument panel
inside the center console storage bin
on the D-pillar or rear trim.
AC Power Point
(If Equipped)
WARNING
Do not keep electrical devices
plugged in the power point whenever
the device is not in use. Do not use
any extension cord with the AC power
point, since it will defeat the safety
protection design provided by the cap and
twist tab. Doing so my cause the power
point to overload due to powering multiple
devices that can reach beyond the 150
watt load limit and could result in fire or
serious injury.
Note:
The power point will turn off after 30
minutes if the ignition is on without the
engine running. Keep the engine running or
cycle the ignition to keep the power point
on.
84
Tourneo Custom/Transit Custom (TTF)
Auxiliary Power Points
FUSE BOX LOCATIONS
Engine Compartment Fuse Box
For item location: See
Under Hood
Overview
(page 146).
Passenger Compartment Fuse Box
This is located behind the removable trim
panel.
Pre-fuse Box
This is located under the driver's seat.
Body Control Module Fuse Box
This is located behind the removable trim
panel.
134
Tourneo Custom/Transit Custom (TTF)
Fuses
FUSE SPECIFICATION CHART
Engine Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Not used
-
1
Not used
-
2
Not used
-
3
Not used
-
4
135
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits protected
Fuse rating
Fuse
Diesel particulate filter vaporizer, glow plug monitor
3 A
5
Anti-lock braking system, electronic stability program,
ignition
3 A
6
Powertrain control module ignition
7.5 A
7
Not used
-
8
Front wiper left-hand
30 A
9
Front wiper right-hand
30 A
10
Air conditioning clutch
10 A
11
Diesel particulate filter vaporizer, glow plug
20 A
12
Not used
-
13
Not used
-
14
Not used
-
15
Not used
-
16
Not used
-
17
Anti-lock braking system, electronic stability program
pump
40 A
18
Starter solenoid
30 A
19
Glow plugs
60 A
20
Ignition relay three
60 A
21
Not used
-
22
Not used
-
22
Anti-lock braking system, electronic stability program
valves
25 A
23
Diesel fuel pump
7.5 A
24
Not used
-
25
Not used
-
26
Not used
-
27
Not used
-
28
136
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits protected
Fuse rating
Fuse
Not used
-
29
Engine coolant fan (single fan)
60 A
30
Not used
-
31
Dual front wiper motors
60 A
32
Not used
-
33
Not used
-
34
Powertrain control system
15 A
35
Powertrain control system
7.5 A
36
Powertrain control system
7.5 A
37
Air conditioning clutch
7.5 A
38
Powertrain control system
15 A
39
Circuits switched
Relay
Ignition 3
R1
Starter
R2
Rear wiper
R3
Front wipers
R4
Not used
R5
Not used
R6
Not used
R7
Not used
R8
Not used
R9
Air conditioning clutch
R10
Vaporizer glow plug
R11
Fuel pump
R12
All-wheel drive pump
R13
Not used
R14
137
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits switched
Relay
Low speed cooling fan
R15
Not used
R16
Powertrain control module
R17
High speed cooling fan
R18
Passenger's Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Airbag module
10 A
1
Anti-lock braking system
5 A
2
Heated mirrors
10 A
3
Not used
-
4
Fuel fired heater
20 A
5
Tachograph
5 A
6
Not used
-
7
230V power outlet
40 A
8
138
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits protected
Fuse rating
Fuse
Not used
-
9
Power seat movement -
driver's
30 A
10
Power seat movement -
passenger's
30 A
11
Not used
-
12
Not used
-
13
Powertrain control module
battery positive
5 A
14
Powertrain control module
power relay
40 A
15
Power supply for
passenger's junction box
40 A
16
Not used
-
17
Not used
-
18
Ignition tachograph
5 A
19
Heated mirror, windshield
relay
5 A
20
Not used
-
21
Ignition non start related to
passenger's junction box
15 A
22
Front and rear air condi-
tioning control
7.5 A
23
Headlamp leveling
5 A
24
Not used
-
25
Not used
-
26
Heated seats
20 A
27
Not used
-
28
Rear view camera, lane
keeping system, electric
mirror
10 A
29
139
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits protected
Fuse rating
Fuse
Cornering lamp
20 A
30
Not used
-
31
Not used
-
32
Not used
-
33
Rear wiper
20 A
34
Power mirrors
5 A
35
Horn
20 A
36
Audio SYNC module
7.5 A
37
Front blower, Wiper, horn
relay
5 A
38
Remote keyless entry,
battery, power window log,
rear heating ventilation air
conditioning
7.5 A
39
Heater blower motor
40 A
40
Rear heater blower
40 A
41
Heated rear screen
30 A
42
Trailer B+ supply
30 A
43
Power points
60 A
44
Not used
-
45
Power windows
30 A
46
Cigar lighter
20 A
47
Power point rear
20 A
48
Power point front
20 A
49
Ignition relay 1
60 A
50
Ignition relay 2
60 A
51
Heated windshield left-hand
40 A
52
Heated windshield right-
hand
40 A
53
140
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits switched
Relay
Fuel fired heater
R1
Power points
R2
Not used
R3
Ignition 2
R4
Not used
R5
Ignition 1
R6
Horn
R7
Not used
R8
Heater blower
R9
Rear heater blower
R10
Heated rear windows , heated mirrors
R11
Heated windshield right-hand
R12
Heated windshield left-hand
R13
Pre-fuse Box
141
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits protected
Fuse rating
Fuse
Starter, alternator, feed engine junction box
470 A
1
Power supply for passenger's compartment fuse box and
body control module fuse box.
100 A
2
Not used
40 A
3
Passenger's fuse box non start related feed 1
200 A
4
Passenger's fuse box non start related feed 3
100 A
5
Electric cabin heater
80 A
6
Heated windshield
80 A
7
Power supply for engine junction box
100 A
8
Passenger's fuse box non start related feed 2
100 A
9
Body control module fuse box
60 A
10
Body control module fuse box
60 A
11
Customer connection 1 (optional)
60 A
12
Customer connection 2
60 A
13
Customer connection 3 (optional)
60 A
14
142
Tourneo Custom/Transit Custom (TTF)
Fuses
Body Control Module Fuse Box
Circuits protected
Fuse rating
Fuse
Central locking 1
15 A
1
Central locking 2
15 A
2
Ignition switch supply
15 A
3
Parking aid module
5 A
4
Rain sensing module
5 A
5
Washer pump supply
15 A
6
Mirror supply
7.5 A
7
143
Tourneo Custom/Transit Custom (TTF)
Fuses
Circuits protected
Fuse rating
Fuse
Fog lamp supply
15 A
8
High beam right supply
10 A
9
High beam left supply
10 A
10
Exterior lamp right
25 A
11
Battery backup sounder supply, security horn
20 A
12
On board diagnostics 2 supply, battery saver supply
15 A
13
Direction indicator supply, rear fog lamp supply, daytime
running lamp supply
25 A
14
Exterior lamp left
25 A
15
Radio, CD, navigation supply
20 A
16
Instrument cluster
7.5 A
17
Light switch module, steering wheel module supply
10 A
18
Audio system
5 A
19
Ignition passive anti-theft system supply
5 A
20
Radio and instrument cluster ignition accessory
3 A
21
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by an authorized dealer.
Switch the ignition and all electrical
equipment off before attempting to
change a fuse.
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
If electrical components in your vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
144
Tourneo Custom/Transit Custom (TTF)
Fuses
Washer fluid reservoir. See
Washer Fluid Check
(page 149).
A
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 148).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 148).
C
Engine junction box. See
Fuses
(page 134).
D
Engine coolant reservoir. See
Engine Coolant Check
(page 148).
E
Battery positive connection (for connecting booster cables). See
Jump-Starting the Vehicle
(page 131).
F
Engine oil dipstick
*
. See
Engine Oil Check
(page 147).
G
Engine oil filler cap. See
Engine Oil Check
(page 147).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 149).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
ENGINE OIL DIPSTICK
Minimum
A
Maximum
B
ENGINE OIL CHECK
1.
Make sure that your vehicle is on level
ground.
2.
Switch off the engine and wait 10
minutes for the oil to drain into the oil
pan.
3.
Remove the dipstick and wipe it with
a clean, lint free cloth. Replace the
dipstick and remove it again to check
the oil level.
If the oil level is at the minimum mark, add
oil immediately. See
Technical
Specifications
(page 161).
Note:
Check the oil level before starting the
engine.
Note:
Make sure that the oil level is
between the minimum and the maximum
marks.
Note:
Do not use oil additives or other
engine treatments. Under certain conditions,
they could damage the engine.
Note:
The oil consumption of new engines
reaches its normal level after approximately
3000 mi (5,000 km).
Adding Engine Oil
WARNINGS
Only add oil when the engine is cold.
If the engine is hot, wait 10 minutes
for the engine to cool down.
147
Tourneo Custom/Transit Custom (TTF)
Maintenance