Ford Transit - 2014 Fuse Box Diagram

Ford Transit - 2014 Fuse Box Diagram

FUSE BOX LOCATIONS
Right-hand drive
Left-hand drive
Pre-fuse box
A
Standard relay box
B
Passenger compartment
junction box
C
Engine compartment junction
box
D
Pre-fuse box
Driver seat
Standard relay box
114
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Passenger junction box
Note:
When refitting, make sure you hear
a click when engaging both clips.
Engine junction box
For item location: See
Maintenance
(page 127).
115
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by properly trained
technicians.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses,
are a push fit.
FUSE SPECIFICATION CHART
Pre-fuse box
116
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Starter motor and alternator
grey
350
1
Passenger junction box power supply - start
relevant / Passenger junction box KL15 for
Start-Stop
yellow
60
2
Engine junction box power supply - non-start
relevant
blue
100
3
Heated front screen right-hand side
green
40
4
Standard relay box power supply - non-start
relevant
blue
100
5
Heated front screen left-hand side
green
40
6
Passenger junction box power supply - non-
start relevant
yellow
60
7
Customer connection point
yellow
60
8
Customer connection point
yellow
60
9
Customer connection point
yellow
60
10
Circuits switched
Relay
Second battery disconnect switch
R1
117
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Engine junction box
Circuits protected
Colour
Ampere
rating
Fuse
Engine cooling fan
yellow
60
11
Trailer tow and trailer tow module power
supply (KL30)
pink
30
12
ABS and ESP pump
green
40
13
Not used
-
-
14
Glow plugs
yellow
60
15
Ignition relay (KL15 #3
yellow
60
16
Starter enable
pink
30
17
Ignition feed (KL15) to Passenger junction
box (vehicles without Start-Stop)
green
40
18
Not used (vehicles with Start-Stop)
-
-
18
Not used
-
-
19
ABS, ESP, steering angle sensor, YAW sensor
supply (KL30)
red
10
20
ABS and ESP valves and control unit
natural
25
21
Not used
-
-
22
118
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Not used
-
-
23
Fuel pump (without fuel-fired heater)
tan
5
24
Fuel pump (with fuel-fired heater)
yellow
20
24
Not used
-
-
25
PCM Power
blue
15
26
Fuel pump (with fuel-fired heater)
tan
5
27
T-MAF sensor
tan
5
28
Vaporiser glow plug monitoring
tan
5
29
Sonic purge valve
7.5
30
VAP pump/UEGO
blue
15
31
Vaporiser glow plug
yellow
20
32
Reversing lamps
red
10
33
Trailer KL15 Power supply
yellow
20
34
Not used
-
-
35
Air conditioning clutch
red
10
36
Not used
-
-
37
Circuits switched
Relay
Glow plugs
R2
Trailer tow (KL15)
R3
Starter enable
R4
Power feed (KL15 #4)
R5
Power feed (KL15 #3)
R6
Fuel pump
R7
119
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Circuits switched
Relay
Vaporiser glow plug
R8
Not used
R9
Air conditioning clutch solenoid
R10
Standard relay box
Circuits protected
Colour
Ampere
rating
Fuse
Rear window wiper
yellow
20
38
Front and rear air conditioning control
red
10
39
Not used
tan
5
40
Tachograph
tan
5
41
120
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Headlamp levelling, master light switch
(KL15)
tan
5
42
Heated front seats
yellow
20
43
Horn
yellow
20
44
Auxiliary power point front
yellow
20
45
Heated door mirrors, if CAT 1 fitted
red
10
46
Cigar lighter
yellow
20
47
Relay coils supply, power mirrors
tan
5
48
Auxiliary power point rear
yellow
20
49
Main beam left-hand side
red
10
50
Main beam right-hand side
red
10
51
Dipped beam left-hand side
red
10
52
Dipped beam right-hand side
red
10
53
Pre-fuse for dipped beam, main beam,
daytime running lamps, tachograph, fuel-fired
booster heater blower
pink
30
54
Heater blower motor
green
40
55
Power windows
yellow
20
56
Rear heater blower motor
pink
30
57
Front wiper motor
pink
30
58
Heated rear window, heated door mirrors
pink
30
59
Not used
-
-
60
Ignition relay (KL15 #1)
yellow
60
61
Ignition relay (KL15 #2)
yellow
60
62
121
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Circuits switched
Relay
Headlamp dip beam
R11
Heated door mirrors (if CAT 1 alarm is fitted), power outlet
(if CAT 1 alarm is not fitted)
R12
Headlamp main beam
R13
Horn
R14
Daytime running lamps
R15
Programmable fuel fired heater
R16
Heated rear windows and heated door mirrors (or heated
rear window left-hand side if Cat 1 alarm is fitted)
R17
Heated rear window right-hand side if Cat 1 alarm is fitted
R18
Power feed (KL15 #2)
R19
PJB KL15 (Start-Stop only)
R20
Power feed (KL15 #1)
R21
Heated windscreen right-hand side
R22
Windscreen wiper high and low function
R23
Rear window wiper
R24
Windscreen wiper on and off function
R25
Heated windscreen left-hand side
R26
122
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Passenger junction box
Circuits protected
Colour
Ampere
rating
Fuse
Rear parking aid, rain sensor
tan
5
63
Acceleration pedal demand sensor
grey
2
64
Brake lamp switch
blue
15
65
Instrument cluster, PATS supply, tachograph,
instrument panel switch illumination
tan
5
66
Washer pump
blue
15
67
Restraints control module
red
10
68
Exterior lamp switch (KL15)
yellow
20
69
Battery backed sounder
yellow
20
70
Exterior lamp switch (KL30)
tan
5
71
Battery saver supply, OBDII (KL30)
red
10
72
Radio, navigation unit and phone supply
blue
15
73
123
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Circuits protected
Colour
Ampere
rating
Fuse
Instrument cluster, fuel-fired booster heater
timer, remote keyless entry supply, interior
motion sensor (KL30)
tan
5
74
Side lamps right-hand side
brown
7.5
75
Side lamps left-hand side
brown
7.5
76
Ignition switch supply, battery disconnect
switch coils supply
tan
5
77
Central locking
blue
15
78
Number plate lamp, side markers
brown
7.5
79
Front fog lamps
blue
15
80
Rear fog lamps
red
10
81
Audio and instrument cluster ignition feed
violet
3
82
Auxiliary fuses
Location
Circuits protected
Colour
Ampere
rating
Fuse
Left-hand side
footwell
Trailer tow module
red
10
83
Below the
engine
compartment
junction box
DPF glow plug sensing
brown
7.5
84
124
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Fuses
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 134).
A
Engine oil filler cap
*
. See
Engine Oil Check
(page 132).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 134).
C
Battery positive connection (for connecting booster cables). See
Vehicle
battery
(page 141).
D
Engine coolant reservoir. See
Engine Coolant Check
(page 133).
E
Washer fluid reservoir. See
Washer Fluid Check
(page 135).
F
Engine junction box. See
Fuses
(page 114).
G
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 134).
H
Engine oil dipstick
*
. See
Engine Oil Check
(page 132).
I
*
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 2.2L DURATORQ-TDCI (PUMA)
DIESEL
129
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Maintenance
Fuel filter water trap (left-hand drive). See
Draining the Fuel Filter Water
Trap
(page 134).
A
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 134).
A
Engine oil filler cap
*
. See
Engine Oil Check
(page 132).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 134).
C
Fuel filter water trap (right-hand drive). See
Draining the Fuel Filter Water
Trap
(page 134).
C
Engine coolant reservoir. See
Engine Coolant Check
(page 133).
D
Washer fluid reservoir. See
Washer Fluid Check
(page 135).
E
Engine junction box. See
Fuses
(page 114).
F
Battery positive connection (for connecting booster cables). See
Vehicle
battery
(page 141).
G
Engine oil dipstick
* **
. See
Engine Oil Check
(page 132).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 134).
I
*
The filler caps and the engine oil dipstick are coloured for easy identification.
**
The dipstick will be in one of the two locations indicated.
130
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Maintenance
Engine junction box. See
Changing a Fuse
(page 116).
H
Battery positive connection (for connecting booster cables). See
Jump-Starting the Vehicle
(page 141).
I
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 134).
J
*
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE OIL DIPSTICK - 2.3L
DURATEC-HE (MI4)
MIN
A
MAX
B
ENGINE OIL DIPSTICK - 2.2L
DURATORQ-TDCI (PUMA)
DIESEL
MIN
A
MAX
B
ENGINE OIL DIPSTICK - 2.4L
DURATORQ-TDCI (PUMA)
DIESEL/3.2L DURATORQ-TDCI
(PUMA) DIESEL
MIN
A
MAX
B
ENGINE OIL CHECK
CAUTION
Do not use oil additives or other
engine treatments. Under certain
conditions, they could damage the
engine.
Note:
The oil consumption of new engines
reaches its normal level after approximately
5000 kilometres (3000 miles).
132
Transit (TT9) Vehicles Built From: 26-09-2011, Vehicles Built Up To: 31-12-2013
Maintenance
WARNINGS
Do not use the power points for
operating a cigar lighter element.
Do not insert objects other than an
accessory plug into the power points.
Run the engine for full capacity use of the
power points.
Note:
Do not use the power points over the
vehicle capacity of 12 volt DC 180 watt or a
fuse may blow.
Note:
Do not hang any accessory from the
accessory plug.
Note:
Always keep the power point caps
closed when not in use.
Note:
Incorrect use of the power points can
cause damage not covered by the vehicle
warranty.
To prevent the battery from running out of
charge:
Do not use the power points for longer
than necessary when the engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is
parked for extended periods.
Note:
The power points will turn off after
30 minutes if the ignition is switched on and
the engine is not running.
Auxiliary Power Point Locations
WARNING
You must close the instrument panel
storage compartment lid before
driving your vehicle.
1.
Press the button to open the
instrument panel storage
compartment lid.
A.
Auxiliary power point.
B.
Device cable outlet recesses.
Auxiliary Power Points may be found:
Inside the instrument panel storage
compartment.
Inside the floor console storage
compartment.
Inside the cargo area.
AC Power Point
WARNING
Do not use any extension cord with
the AC power point, since it will
defeat the safety protection design
provided by the cap and twist tab. Doing
so may cause the power point to overload
due to powering multiple devices that can
reach beyond the 150 watt load limit and
could result in fire or personal injury.
89
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Auxiliary Power Points
FUSE BOX LOCATIONS
Engine Compartment Fuse Box
For item location: See
Under Hood
Overview
(page 154).
Passenger Compartment Fuse Box
This is located behind the removable trim
panel.
Pre-fuse Box
This is located under the driver's seat.
Body Control Module Fuse Box
This is located behind the removable trim
panel.
141
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
FUSE SPECIFICATION CHART
Engine Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Selective Catalytic Reduction.
10A
F1
Selective Catalytic Reduction.
15A
F2
Selective Catalytic Reduction.
15A
F3
Selective Catalytic Reduction.
10A
F4
142
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits protected
Fuse rating
Fuse
Diesel particulate filter vaporizer.
3A
F5
Glow plug monitor.
Anti-lock brake system.
3A
F6
Stability assist.
Ignition.
Powertrain control module.
7.5A
F7
Cooling fan.
20A
F8
Left-hand windshield wiper.
30A
F9
Right-hand windshield wiper.
30A
F10
Air conditioning clutch.
10A
F11
Diesel particulate filter vaporizer glow plug.
20A
F12
Not used.
-
F13
Selective Catalytic Reduction - ignition.
3A
F14
Not used.
-
F15
Not used.
-
F16
Not used.
-
F17
Anti-lock brake system.
40A
F18
Stability assist pump.
Starter solenoid.
30A
F19
Glow plugs.
60A
F20
Ignition relay 3.
60A
F21
Not used.
-
F22
Not used.
-
F22
Not used.
-
F23
Fuel injection pump.
7.5A
F24
Not used.
-
F25
Not used.
-
F26
Not used.
-
F27
143
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits protected
Fuse rating
Fuse
Not used.
-
F28
Not used.
-
F29
Cooling fan 1.
40A
F30
Cooling fan 2.
40A
F31
Windshield dual wiper motors.
60A
F32
Start-Stop auxiliary water pump.
20A
F33
Not used.
-
F34
Powertrain control system supply.
15A
F35
Sensor NOXI 2.
15A
F36
Volume Control Valve.
7.5A
F37
Mass air flow sensor.
7.5A
F38
Diesel pump vaporizer.
15A
F39
Circuits switched
Relay
Ignition.
R1
Starter motor.
R2
Rear window wiper.
R3
Not used.
R4
Cooling fan.
R5
Windshield wiper - on and off.
R6
Windshield wiper - low and high speed.
R7
Not used.
R8
Not used.
R9
Air conditioning clutch.
R10
Fuel vaporizer system glow plug.
R11
Fuel injection pump.
R12
All-wheel drive pump.
R13
144
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits switched
Relay
Econetic.
R14
Low and high speed cooling fan.
R15
Selective Catalytic Reduction.
R16
Powertrain control module.
R17
High speed cooling fan.
R18
Passenger Compartment Fuse panel
Circuits protected
Fuse rating
Fuse
Airbag module.
10A
F1
Heated rear window.
20A
F2
Heated exterior mirrors.
10A
F3
Not used.
-
F4
Not used.
-
F5
Tachograph.
5A
F6
Battery sensor.
10A
F7
145
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits protected
Fuse rating
Fuse
AC power outlet socket.
40A
F8
Not used.
-
F9
Driver power seat.
30A
F10
Passenger power seat.
30A
F11
Power step.
30A
F12
Not used.
-
F13
Tracking and blocking control module.
5A
F14
Powertrain control module battery relay.
40A
F15
Powertrain control module power relay.
40A
F16
Not used.
-
F17
Anti-lock brake system valves.
30A
F18
Stability assist valves.
Tachograph.
5A
F19
Heated exterior mirror relay.
5A
F20
Heated windshield relay.
Not used.
-
F21
Passenger compartment fuse panel.
15A
F22
Air conditioning control module.
7.5A
F23
Headlamp leveling.
5A
F24
Interior lighting.
7.5A
F25
Heated exterior mirrors.
10A
F26
Heated front seats.
20A
F27
Cornering lamps.
20A
F28
Rear parking aid camera.
10A
F29
Lane keeping system.
Electro mirror.
Adaptive cruise control.
5A
F30
Not used.
-
F31
146
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits protected
Fuse rating
Fuse
Interior lighting.
10A
F32
All wheel drive module.
20A
F33
Rear window wiper.
20A
F34
Power folding mirrors.
5A
F35
Horn.
20A
F36
SYNC module.
7.5A
F37
Blower motor.
5A
F38
Horn relay.
Windshield wiper relay.
Remote keyless entry.
7.5A
F39
Battery.
Power windows.
Rear heating, ventilation and air conditioning.
Front blower motor.
40A
F40
Rear blower motor.
40A
F41
Heated rear window.
30A
F42
Trailer socket.
30A
F43
Auxiliary power points.
60A
F44
Not used.
-
F45
Power windows.
30A
F46
Cigar lighter socket.
20A
F47
Rear auxiliary power points.
20A
F48
Front auxiliary power points.
20A
F49
Ignition relay 1.
60A
F50
Ignition relay 2.
60A
F51
Left-hand heated windshield element.
40A
F52
Right-hand heated windshield element.
40A
F53
147
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits switched
Relay
Fuel fired booster heater.
R1
Auxiliary power points.
R2
Not used.
R3
Ignition 2.
R4
Power windows.
R5
Ignition 1.
R6
Horn.
R7
Not used.
R8
Front blower motor.
R9
Rear blower motor.
R10
Heated rear window.
R11
Heated exterior mirrors.
Left-hand heated windshield element.
R12
Right-hand heated windshield element.
R13
Pre-fuse Box
148
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits protected
Fuse rating
Fuse
Engine compartment fuse box.
470A
F1
Starter motor.
Alternator.
Passenger compartment fuse panel.
100A
F2
Body control module fuse box.
Powertrain control module.
40A
F3
Anti-lock brake system.
Passenger compartment fuse panel.
200A
F4
Passenger compartment fuse panel.
100A
F5
Cabin heater.
80A
F6
Heated windshield.
80A
F7
Engine junction box.
100A
F8
Passenger compartment fuse panel.
100A
F9
Passenger compartment fuse panel supply.
60A
F10
Passenger compartment fuse panel supply.
60A
F11
Auxiliary power point 1.
60A
F12
Auxiliary power point 2.
60A
F13
Auxiliary power point 3.
60A
F14
149
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Body Control Module Fuse Box
Circuits protected
Fuse rating
Fuse
Central locking system 2.
15A
F1
Central locking system 1.
15A
F2
Ignition switch.
15A
F3
Parking assist control module.
5A
F4
Rain sensor module.
5A
F5
Windshield washer pump.
15A
F6
Exterior mirrors.
7.5A
F7
150
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Circuits protected
Fuse rating
Fuse
Front fog lamps.
15A
F8
Right-hand high beam.
10A
F9
Left-hand high beam.
10A
F10
Right-hand exterior lamps.
25A
F11
Left-hand side lamps.
Battery backup sounder.
20A
F12
Anti-theft alarm horn.
On-board diagnostic.
15A
F13
Battery saver.
Turn signal indicator.
25A
F14
Left-hand exterior lamps.
25A
F15
Right-hand side lamp.
Central high mounted brake lamp.
Audio unit.
20A
F16
Navigation unit.
Instrument panel cluster.
7.5A
F17
Heater control.
Headlamp switch module.
10A
F18
Steering wheel module.
Front control/display interface module.
5A
F19
Ignition passive anti-theft system.
5A
F20
Accessory relay.
3A
F21
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by an authorized dealer.
Switch the ignition and all electrical
equipment off before attempting to
change a fuse.
WARNINGS
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
151
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
If electrical components in your vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
152
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Fuses
Washer fluid reservoir
*
. See
Washer Fluid Check
(page 158).
A
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 157).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 157).
C
Engine junction box. See
Fuses
(page 141).
D
Engine coolant reservoir. See
Engine Coolant Check
(page 157).
E
Battery positive connection (for connecting booster cables). See
Jump Starting
the Vehicle
(page 138).
F
Engine oil dipstick
*
. See
Engine Oil Check
(page 156).
G
Engine oil filler cap. See
Engine Oil Check
(page 156).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 158).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
UNDER HOOD OVERVIEW - AWD/RWD
Windshield washer reservoir
*
. See
Washer Fluid Check
(page 158).
A
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 157).
B
155
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Maintenance
Engine oil dipstick
*
. See
Engine Oil Check
(page 156).
C
Engine oil filler cap. See
Engine Oil Check
(page 156).
D
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 157).
E
Engine coolant reservoir. See
Engine Coolant Check
(page 157).
F
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 158).
G
Battery positive connection (for connecting booster cables). See
Jump Starting
the Vehicle
(page 138).
H
Engine compartment fuse box. See
Fuses
(page 141).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
ENGINE OIL DIPSTICK
Minimum
A
Maximum
B
ENGINE OIL CHECK
1.
Make sure that your vehicle is on level
ground.
2.
Switch off the engine and wait 10
minutes for the oil to drain into the oil
pan.
3.
Remove the dipstick and wipe it with
a clean, lint free cloth. Replace the
dipstick and remove it again to check
the oil level.
If the oil level is at the minimum mark, add
oil immediately. See
Technical
Specifications
(page 170).
Note:
Check the oil level before starting the
engine.
Note:
Make sure that the oil level is
between the minimum and the maximum
marks.
Note:
Do not use oil additives or other
engine treatments. Under certain conditions,
they could damage the engine.
Note:
The oil consumption of new engines
reaches its normal level after approximately
3000 mi (5,000 km).
Adding Engine Oil
WARNINGS
Only add oil when the engine is cold.
If the engine is hot, wait 10 minutes
for the engine to cool down.
Do not remove the filler cap when
the engine is running.
1.
Remove the engine oil filler cap.
2.
Add engine oil that meets Ford
specifications. See
Technical
Specifications
(page 170).
3.
Replace the engine oil filler cap. Turn
it until you feel a strong resistance.
156
Transit (TTG) Vehicles Built From: 06-01-2014, Vehicles Built Up To: 31-12-2014, CG3612en enGBR, Edition date: 12/2013
Maintenance