Ford Tourneo Custom - 2016 Fuse Box Diagram

Ford Tourneo Custom - 2016 Fuse Box Diagram

WARNINGS
If used when the engine is not
running, the battery will lose charge.
There may be insufficient power to
restart the engine.
Do not plug optional electrical
accessories into the cigar lighter
socket. Incorrect use of the lighter
can cause damage not covered by your
warranty, and can result in fire or serious
injury.
Note:
Do not insert objects other than an
accessory plug into the power point. This
will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volt DC 10 amp or a
fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Note:
The power point will turn off after 30
minutes if the ignition is on without the
engine running. Keep the engine running or
cycle the ignition to keep the power point
on.
Run the engine for full capacity use of the
power point. To prevent the battery from
losing charge:
Do not use the power point longer than
necessary when the engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is
parked for extended periods.
Locations
Power points may be found:
on the instrument panel
inside the center console storage bin
on the D-pillar or rear trim.
AC Power Point
(If Equipped)
WARNING
Do not keep electrical devices
plugged in the power point whenever
the device is not in use. Do not use
any extension cord with the AC power
point, since it will defeat the safety
protection design provided by the cap and
twist tab. Doing so my cause the power
point to overload due to powering multiple
devices that can reach beyond the 150
watt load limit and could result in fire or
serious injury.
Note:
The power point will turn off after 30
minutes if the ignition is on without the
engine running. Keep the engine running or
cycle the ignition to keep the power point
on.
91
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Auxiliary Power Points
FUSE BOX LOCATIONS
Engine Compartment Fuse Box
For item location: See
Under Hood
Overview
(page 154).
Passenger Compartment Fuse Box
This is located behind the removable trim
panel.
Pre-fuse Box
This is located under the driver's seat.
Body Control Module Fuse Box
This is located behind the removable trim
panel.
141
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
FUSE SPECIFICATION CHART
Engine Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Not used.
-
F1
Not used.
-
F2
Not used.
-
F3
Not used.
-
F4
142
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Powertrain control module.
3 A
F5
Anti-lock brake system module.
3 A
F6
Powertrain control module.
7.5 A
F7
Glow plug module.
Not used.
-
F8
Windshield wiper motor.
30 A
F9
Auxiliary windshield wiper motor.
30 A
F10
Air conditioning clutch.
10 A
F11
Glow plugs.
20 A
F12
Not used.
-
F13
Not used.
-
F14
Not used.
-
F15
Not used.
-
F16
Not used.
-
F17
Anti-lock brake system module.
40 A
F18
Starter relay.
30 A
F19
Glow plug module.
60 A
F20
Ignition relay.
60 A
F21
Not used
-
F22
Anti-lock brake system module.
25 A
F23
Fuel pump relay.
7.5 A
F24
Not used.
-
F25
Econetic coolant valve.
3 A
F26
Not used.
-
F27
Not used.
-
F28
Audio front control module.
-
F29
Low-speed and high-speed cooling fan.
60 A
F30
143
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Not used.
-
F31
Windshield wiper motor relay.
60 A
F32
Not used.
-
F33
Not used.
-
F34
Powertrain control module.
15 A
F35
Mass air flow sensor.
7.5 A
F36
Fuel metering valve.
7.5 A
F37
Air conditioning clutch relay.
7.5 A
F38
Low-speed and high-speed cooling fan.
15 A
F39
Glow plug relay.
Fuel vaporizer system fuel pump.
Heated oxygen sensor.
Econetic coolant valve relay.
Circuits switched
Relay
Ignition.
R1
Starter motor.
R2
Rear window wiper.
R3
Windshield wiper motor.
R4
Not used.
R5
Not used.
R6
Not used.
R7
Not used.
R8
Not used.
R9
Air conditioning clutch.
R10
Glow plugs.
R11
Fuel pump.
R12
Not used.
R13
144
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits switched
Relay
Econetic coolant valve.
R14
Low-speed cooling fan.
R15
Not used.
R16
Powertrain control module.
R17
High-speed cooling fan.
R18
Passenger Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Restraints control module.
10 A
F1
Not used.
-
F2
Exterior mirrors.
10 A
F3
Not used.
-
F4
Auxiliary heater control module.
20 A
F5
Tachograph.
5 A
F6
Not used.
-
F7
145
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Direct current (DC/AC) inverter
40 A
F8
Not used.
-
F9
Driver power seat.
30 A
F10
Not used.
-
F11
Not used.
-
F12
Not used.
-
F13
Powertrain control module relay.
5 A
F14
Powertrain control module relay.
40 A
F15
Battery control module.
40 A
F16
Not used.
-
F17
Not used.
-
F18
Tachograph.
5 A
F19
Heated windshield relay.
5 A
F20
Left-hand heated windshield relay.
right-hand heated windshield relay.
Direct current (DC/AC) inverter relay.
Customer access.
10 A
F21
Body control module.
15 A
F22
Fuel fired booster heater relay.
7.5 A
F23
Auxiliary blower motor relay.
Booster heater.
Blower motor.
Message center switch.
Headlamps.
5 A
F24
Interior lighting.
25 A
F25
Not used.
-
F26
Heated front seats.
20 A
F27
Adaptive front lighting module.
20 A
F28
Image processing module A.
10 A
F29
Image processing module B.
Auto-dimming interior mirror.
146
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Steering column control module.
Not used.
-
F30
Not used.
-
F31
Interior lamps.
10 A
F32
Not used.
-
F33
Rear window wiper relay.
20 A
F34
Rear window wiper motors.
Power folding mirrors.
5 A
F35
Driver door window.
Horn relay.
20 A
F36
SYNC module.
7.5 A
F37
Global positioning system module.
Rear window wiper.
5 A
F38
Horn relay.
Blower motor relay.
Auxiliary blower motor switch.
7.5 A
F39
Intrusion sensor.
Radio frequency receiver.
Blower motor relay.
40 A
F40
Auxiliary blower motor relay.
Rear heater blower
40 A
F41
Heated rear window relay.
30 A
F42
Trailer module.
30 A
F43
Trailer socket.
Auxiliary power point relay.
60 A
F44
Not used.
-
F45
Driver door window switch.
30 A
F46
Passenger door window switch.
Auxiliary power point.
20 A
F47
Rear auxiliary power points.
20 A
F48
Front auxiliary power points.
20 A
F49
147
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Ignition relay 1.
60 A
F50
Ignition relay 2.
60 A
F51
Left-hand heated windshield element.
40 A
F52
Right-hand heated windshield element.
40 A
F53
Circuits switched
Relay
Fuel fired booster heater
R1
Auxiliary power points.
R2
Not used.
R3
Ignition relay 2.
R4
Not used.
R5
Ignition relay 1.
R6
Horn.
R7
Not used.
R8
Blower motor.
R9
Auxiliary blower motor.
R10
Heated rear window.
R11
Right-hand heated windshield element.
R12
Left-hand heated windshield element.
R13
148
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Pre-fuse Box
Circuits protected
Fuse rating
Fuse
Alternator.
350 A
F1
Starter motor.
Battery junction box.
Auxiliary junction box.
100 A
F2
Not used.
-
F3
Auxiliary junction box.
200 A
F4
Auxiliary junction box.
100 A
F5
Electric booster heater.
80 A
F6
Auxiliary junction box.
80 A
F7
Battery junction box.
100 A
F8
Auxiliary junction box.
100 A
F9
Body control module 1.
60 A
F10
Body control module 2.
60 A
F11
Customer access.
60 A
F12
Not used.
-
F13
Customer access.
60 A
F14
149
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Body Control Module Fuse Box
Circuits protected
Fuse rating
Fuse
Not used.
-
F1
Driver door latch.
15 A
F2
Passenger door latch.
Liftgate latch.
Ignition switch.
15 A
F3
Auxiliary battery relay.
Parking aid module.
5 A
F4
Rain sensor module.
5 A
F5
Autolamp module.
150
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Windshield washer pump.
15 A
F6
Exterior mirrors.
7.5 A
F7
Front fog lamps.
15 A
F8
Right-hand headlamp.
10 A
F9
Left-hand headlamp.
10 A
F10
Right-hand rear lamps.
25 A
F11
Right-hand headlamp.
Left-hand headlamp.
Exterior mirrors.
Anti-theft alarm.
20 A
F12
Battery back-up sounder.
Data link connector.
15 A
F13
Auxiliary power point relay.
Interior lighting.
Headlamps.
25 A
F14
Exterior mirrors.
Right-hand headlamp.
25 A
F15
Left-hand headlamp.
Left-hand rear lamps.
Trailer module.
Audio control.
20 A
F16
Instrument cluster.
7.5 A
F17
Blower motor.
Headlamp switch.
10 A
F18
Front control/display interface module.
5 A
F19
Passive anti-theft system.
5 A
F20
Audio front control module.
3 A
F21
151
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by an authorized dealer.
Switch the ignition and all electrical
equipment off before attempting to
change a fuse.
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
If electrical components in your vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
152
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Fuses
Washer fluid reservoir. See
Washer Fluid Check
(page 158).
A
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 157).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 157).
C
Engine junction box. See
Fuses
(page 141).
D
Engine coolant reservoir. See
Engine Coolant Check
(page 156).
E
Battery positive connection (for connecting booster cables). See
Jump Starting
the Vehicle
(page 138).
F
Engine oil dipstick
*
. See
Engine Oil Check
(page 155).
G
Engine oil filler cap. See
Engine Oil Check
(page 155).
H
Power steering fluid reservoir. See
Power Steering Fluid Check
(page 157).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
ENGINE OIL DIPSTICK
Minimum
A
Maximum
B
ENGINE OIL CHECK
1.
Make sure that your vehicle is on level
ground.
2.
Check the oil level before starting the
engine, or switch the engine off and
wait 10 minutes for the oil to drain into
the oil pan.
3.
Remove the dipstick and wipe it with
a clean, lint free cloth. Replace the
dipstick and remove it again to check
the oil level.
If the oil level is at the minimum mark, add
oil immediately. See
Technical
Specifications
(page 169).
Note:
Make sure that the oil level is
between the minimum and the maximum
marks.
Note:
Do not use oil additives or other
engine treatments. Under certain conditions
they may cause engine damage.
Note:
The oil consumption of new engines
reaches its normal level after approximately
3,000 mi (5,000 km).
Adding Engine Oil
WARNINGS
Only add oil when the engine is cold.
If the engine is hot, wait 10 minutes
for the engine to cool down.
Do not remove the filler cap when
the engine is running.
155
Tourneo Custom/Transit Custom (TTF) Vehicles Built From: 12-01-2015, CG3577en enGBR, Edition date: 01/2015, First Printing
Maintenance